-
Jotul GF 200 DV - page 1
WARNING: IF THE INFORMA TION IN THESE INSTR UC- TIONS ARE NO T FOLLOWED EXA CTL Y , A FIRE OR EXPLOSION MA Y RESUL T CAUSING PROP- ERTY D AMAGE, PERSONAL INJUR Y OR LOSS OF LIFE. FOR Y OUR SAFETY : DO NO T ST ORE OR USE GASOLINE OR OTHER FLAMMABLE V APORS AND LIQ UIDS IN THE VICINITY OF THIS OR ANY OTHER APPLIANCE. INST ALLA TION: INST ALLA TION AN ...
-
Jotul GF 200 DV - page 2
2 W elc ome to J ø tul... C ongratulations on the purchase of your new Jøtul GF 200 D V Lillehammer - a direct vented gas heater especially designed and approv ed f or installation in to a v ariety of configurations wher e close clear ance to combustibles is r equired. W e at Jøtul are glad you’ve made the decision to w arm your hearth with a ...
-
Jotul GF 200 DV - page 3
3 T able of Contents Specifica tions .................................................. 3 General Inf ormation ...................................... 5 Saf ety Information ......................................... 6 Hearth Protection Requirements ................ 6 Clear ance Requiremen ts ............................... 7 Mantel and T rim Clear an ...
-
Jotul GF 200 DV - page 4
4 Jøtul GF 200 D V Lillehammer Specifica tions Figur e 1. Dimensional V iews - GF 200 DV Lillehammer GF 200 DV Lillehammer Options • Fuel C onversion Kit - NG .............................. 155349 • Fuel C onversion Kit - LP ............................... 155350 • High Altitude C onv ersion Kit - NG ........... 154371 • High Altitude C on ...
-
Jotul GF 200 DV - page 5
5 DO NO T OPERA TE THE LILLEHAMMER GAS STO V E WITH THE GLASS FRONT REMO VED, CRACKED OR BR OKEN. REPLACEMENT OF THE GLASS SHOULD BE DONE BY A LICENSED OR QUALIFIED SERVICE PERSON. ONL Y REMOVE GLASS FOR ROUTINE SERVICE. ALWA Y S HANDLE GLASS CAREFULL Y . SEE THE MAINTENANCE CHAPTER FOR INSTRUCTIONS ON REPLA CING THE GLASS P ANEL. Gener al Informat ...
-
Jotul GF 200 DV - page 6
6 Loca ting the Stov e In selecting the location, the aesthetic and func- tional use of the appliance are primary concerns. Howev er , proper v enting systems and access to the fuel supply are also important issues. Due to the high surface temper atures of the Lillehammer , one must also consider the proximity of traffic wa ys , furniture, draperie ...
-
Jotul GF 200 DV - page 7
7 Clear ance to C ombustibles Minimum Stov e Clearance R ear 0” (0mm) Ceiling 17” (432mm) Corner 2” (51mm) Right Side 2” (51mm) Lef t Side *10” (255mm) * Necessary f or complete access to pull out required Ligh ting Instructions Plate. Minimum V ent Pipe Clearance Horizontal runs: Off the top of the pipe - 2” (26mm) Off the sides and bo ...
-
Jotul GF 200 DV - page 8
8 Install the Exhaust Restric tor Pla te 1. R emove the T op Pla te to access the Glass Panel. 2. R elease the Glass P anel latches and lift the panel str aigh t up of f of the fireb ox . 2. Ca refully r emo ve the L og Set pieces from the fir ebox. 2. Use a 1/4” nut driver to remo ve the two lower sheet metal screws located inside the firebox be ...
-
Jotul GF 200 DV - page 9
9 35 Ft. (10.67 m) 30 Ft. (9.14 m) 25 Ft. (7.62 m) 20 Ft. (6.10 m) 15 Ft. (4.57 m) 5 Ft. (1.52 m) 1 Ft. (.30 m) 10 Ft. (3.05 m) 10 Ft. (3.05 m) 5 Ft. (1.52 m) VERTICAL RUN HORIZONT AL RUN F igure 7 . Install the Air Inlet R estrictor Plate. Rear W all of F irebox Air Deflector R emove this screw only Air In take R estric tor Plate T able 1. V ertic ...
-
Jotul GF 200 DV - page 10
10 Co-linear Hearthmount Installa tion The Jøtul GF 200 D V Lillehammer may be v ented through a masonry fireplace using Simpson Dura- V ent Chimney Liner Conv ersion Kit 923GK. When installed in the manner described below , this system can impro ve the performance of the appliance in cold climate situations, as well as simplif y the vent installa ...
-
Jotul GF 200 DV - page 11
11 Masonr y or Pre fabricated Chimne y Co nv ersion The GF200 DV Lillehammer is approv ed for use with Simpson Dura-v ent Chimney Kit #934 in a masonry chimney or a pr efabrica ted solid fuel listed chimney . These installation requirements must be followed: 1. In masonry chimney , a fireclay liner or listed steel liner , must be pr esent the entir ...
-
Jotul GF 200 DV - page 12
12 Horiz ontal V enting (Horizontal T ermination) • The maximum horizon tal run made directly off the rear of the stove into a standard horiz ontal cap (#984 or #985) must be no more than a 9” section of Simpson Dur a-ven t (#907B). See F igure 12-1. • The maximum horizon tal run made directly off the r ear of the stove into a 14” snorkel c ...
-
Jotul GF 200 DV - page 13
13 W all Shield Installation When horiz ontally v enting direc tly of f the rear of the stove, install the decorativ e W all Shield #129349, (included in the stove), to c over the top of the venting hole in the w all. See Figure 14. 1. R emov e the top four 1/4” he x head screw from the rear shroud of the stov e. 2. Align the holes in the wall sh ...
-
Jotul GF 200 DV - page 14
14 V ent T ermination Requirements Figure 15. V ent T erminal Clear ances - National Fuel Gas Code A = Clear ance abov e grade, veranda, porch , deck, or balcony : *12 inches (30 cm) minimum. B = Clear ance to window or door that may be opened: 9 inches (23 cm) minimum. W e r ec ommend 12 inches to help preven t condensation. C = Clearance to perma ...
-
Jotul GF 200 DV - page 15
15 T ools Required: • 1/4” Nut driver • 7/16” and 1/2” open end wrench • T orx T -20 or slotted screwdriv er . Fuel Co nversion Kit C ontents: • 1 regulator tower labeled for Propane • 3 regulator tower screws • 1 burner orifice (#48 for NG, 3/64 for LPG) • 1 pilot orifice (#51 for NG, #30 for LPG) • Label A - to be completed ...
-
Jotul GF 200 DV - page 16
16 Gas C on version Procedure See F igur e 29, page 25 for parts identification. 1. T urn off gas supply to the stove. 2 . Remov e the stov e T op Plate (3). 3. R emove the Fr ont Panel. Using a 10mm open- end wrench, loosen the two bolts holding the Fr ont Panel (1) to the side panels (2). (Note: Y ou do not hav e to remo ve these bolts.) Pull the ...
-
Jotul GF 200 DV - page 17
17 C onnec t the Gas Supply The gas supply line connection is made to the valve just inside the left r ear leg. The gas supply line should be 3/8" npt with a 1/2" diameter supply , or the appr opriate siz e to pro vide sufficien t gas pres- sure to the v alve r egardless of the input setting. The use of Flexible Gas Appliance C onnectors ...
-
Jotul GF 200 DV - page 18
18 Leak T est: • Mix a 50-50 solution of water and dish soap. • Light appliance- see lighting instruc tions on page 21 of this manual or on the stove’ s rating plate. • Brush or spray all joints and connections with the soapy w ater solution. If bubbles appear at an y c onnection or seam or a gas odor is detected immediately turn gas contro ...
-
Jotul GF 200 DV - page 19
19 Dera ting Procedure: T o derate this unit, install the appropria te orifice as shown in the High Altitude char t. 1. Remov e the two ¼” hex head screw that holds the burner tube/log support to the bottom of the stove. 2. R emove the burner tube/log support to e xpose the main burner orifice. 3. R emove the air deflector shield around the main ...
-
Jotul GF 200 DV - page 20
20 Install the Log Set The Lillehammer is equipped with a one piece log set and is packaged in bubble wrap inside the firebox. The log set must be removed fr om the pack aging and arr anged in the unit prior to start up of the gas stove. Do not handle the log set with your bar e hands. Alw a ys wear gloves to pr e ve nt skin irritation from the cer ...
-
Jotul GF 200 DV - page 21
21 1 (25mm) 3/8 (8mm) Min. 1/8 (3mm) Min. Ignitor Thermopile Thermocouple Checking the System 1. Purging the Gas Line: When ligh ting the appli- ance f or the first time it will take a few mo- ments to clear the gas line of air . Once this purge is complete, the appliance will opera te as described in the lighting instructions loca ted on ...
-
Jotul GF 200 DV - page 22
22 3. Burner Adjustment: The Lillehammer is equipped with a v ariable gas c ontrol v alve. that provides easy adjustment of the flame height appearance and hea t output . T o adjust the flame between the H I and LOW setting, rotate the HI / LO W knob, located in the cen ter of the valve f ace. Flame height will adjust appro ximately 1.0” to 1.5? ...
-
Jotul GF 200 DV - page 23
23 W ith proper care and main tenance, your Jøtul gas stov e will pro vide you with many y ears of service. If you experience any pr oblems with Jøtul GF 200 D V , c on tact y our authorized Jøtul dealer f or assistance. Fill out the Main tenance R ecord f orm on the next page and k eep it up to date. It will provide useful inf ormation of servi ...
-
Jotul GF 200 DV - page 24
24 Maintenance Rec ord Jøtul GF 200 Lillehammer Direct V ent Stov e Model: Serial Number: __________________________ Date of P ur chase: _______________________ Dealer: _________________________________ Addr ess: _______________________________ _________________________________ Phone: _________________________________ T ype of Fuel: Natural Gas __ ...
-
Jotul GF 200 DV - page 25
25 3 21 Illustra ted Pa r ts List GF 200 DV Lillehammer 39 40 Figure 29. 12A 20 2 24 23 22 19 4 12 11 10 13 36 C A B 37 38 D 41 43 42 1 35 5 34 15 17 18 16 14 27 26 20 2 33 28 25 29 30 31 32 ...
-
Jotul GF 200 DV - page 26
26 10 Glass Frame 12931692 11 Glass Gasket (7/16” tadpole) 129124 12 Glass Clip 129135 Glass Frame Assembly 154337 12A Latch K eeper 129149 13 Glass 129113 14 Log Set 129122 * Embers 129123 15 Burner T ube 129331 16 Air Divider 129320 17 Air Deflector 129109 18 Burner Orifice Holder Shield 129329 19 E xhaust Baffle 129310 20 Side Heat Shield 1293 ...
-
Jotul GF 200 DV - page 27
27 7. Push in gas con trol knob slightly and turn counter clockwise to “PI LO T” . 8. Push in contr ol knob all the way and hold in. Immediately ligh t the pilot by triggering the spark ignitor (push the red button repeatedly) until pilot lights. Continue to hold the c ontrol knob in for about one minute after the pilot ligh ts. R elease knob a ...
-
Jotul GF 200 DV - page 28
Jøtul ASA P .O . Box 1411 N-1602 Fr edrik stad, Norway Jøtul Nor th America 400 Riverside Stre et Portland, ME 04104 137743 1.03 Stoves and fir eplaces must be installed to c onf orm to local and na tional building regulations. In preparing to install this appliance, it is important that all instructions issued with the unit are carefully r ead a ...
Do you have a question concerning Jotul GF 200 DV?
Use the form below
If you did not solve your problem by using a manual Jotul GF 200 DV, ask a question using the form below. If a user had a similar problem with Jotul GF 200 DV it is likely that he will want to share the way to solve it.