-
Weber 3400 - page 1
W ARNING: Do not try to light this appliance without reading "Lighting" instructions section of this manual. THIS GAS APPLIANCE IS DESIGNED FOR OUTDOOR USE ONL Y . NO TICE TO INST ALLER: These instructions must be left with the o wner and the owner should keep them f or future use. FOR Y OUR SAFETY If y ou smell gas: 1. Shut off gas to th ...
-
Weber 3400 - page 2
W ARNINGS ■ Do not store a spare or disconnected LP tank under or near this barbecue . ■ Improper assemb ly ma y be dang er ous. Please carefully f ollow the assembl y instructions in this manual. ■ After a period of storage, and/or nonuse, the W eber Gas Barbecue should be chec ked f or gas leaks and burner obstructions bef ore using. See in ...
-
Weber 3400 - page 3
3 W ARRANTY Weber-Stephen Products Co. (W eber) hereby warrants to the ORIGINAL PURCHASER of this Weber Gas Barbecue that it will be free of defects in material and workmanship from the date of purchase as follows: Aluminum Castings, 10 years, Recycled Work Surfaces, 10 years Stainless Steel Flavorizer Bars, 5 years Cooking Grates , 3 years, All Re ...
-
Weber 3400 - page 4
© 1995 Weber . W eber , , Flavorizer and Crossover are registered U.S. trademarks; Platinum, Perma-Mount, Gas Catcher , FlameCheck, Steam-N-Chips, Spider Stopper , and W arm-Up are U.S. trademarks of Weber-Stephen Products Co., 200 East Daniels Road, Palatine, IL 60067-6266. U.S.A. Genesis Gas Barbecues are covered under the following patent nos.: ...
-
Weber 3400 - page 5
5 General Instructions Your Weber Gas Barbecue is a portable outdoor cooking appliance. With the Weber Gas Barbecue you can grill, barbecue, roast and bake with results that are difficult to duplicate with indoor kitchen appliances. The closed lid and Flavorizer Bars produce that "outdoor" flavor in the food. The Weber Gas Barbecue is por ...
-
Weber 3400 - page 6
6 Lighting Note - The following are general lighting instructions for the Weber Gas Barbecue, the illustrations shown may not be of your model. Summary lighting instructions are on the control panel. Crosso ver Ignition System Note - The Crossover Ignition System ignites the Front burner with a spark from the igniter electrode inside the Gas Catche ...
-
Weber 3400 - page 7
7 4) Turn the tank on by turning the tank valve counterclockwise. 5) Strike a match and put the flame into the matchlight hole in the front of the cooking box. WARNING: Do not lean over open barbecue. Keep your face and body at least one foot away from the matchlight hole when lighting the barbecue. 6) Push Front burner control knob down and turn t ...
-
Weber 3400 - page 8
8 Lighting the side burner For models with a range-style side burner The side burner has a separate ignition system from the main cooking box. Lighting only the side burner. Figure 3. 1) Open the side burner lid. 2) Check that the fuel scale reads more than “E”. 3) Check that the side burner valve is OFF (push down and turn clockwise), and all ...
-
Weber 3400 - page 9
9 Using the swing table For models with the swing table / slide bar assembly To raise table: Lift table up and engage slide in locked position. Figure 5. To lower table: Pull support rod up to disengage slide lock, and lower table. Figure 5. WARNING: If swing table end bracket is in any way cracked or damaged, do not use swing table . Call our Cust ...
-
Weber 3400 - page 10
10 Cooking The Weber Gas Barbecue should not be moved when operating or hot. You can adjust the FRONT, CENTER and BACK burners as desired. The control settings High (H), Medium (M), Low (L), or Off (O) are described in your cookbook. The cookbook uses these notations to describe the settings of the FRONT, CENTER, and BACK burners. For example, to s ...
-
Weber 3400 - page 11
11 Refilling the LP tank We suggest that you refill before the fuel scale indicator reaches “E.” Note - If you run out of fuel, check the indicator setting and/or adjust the fuel scale indicator setting with the scale setting wing nut while the tank is empty so you do not run out again. Removal of the LP tank 1) Close tank valve (turn clockwise ...
-
Weber 3400 - page 12
12 d) Mix soap and water. e) Open the tank valve. Figure 10. f) Check for leaks by wetting the fitting with the soap and water solution and watching for bubbles. If bubbles form or if a bubble grows there is a leak. If there is a leak turn off the gas, tighten the fitting, turn the gas back on and recheck with the soap and water solution. If leak d ...
-
Weber 3400 - page 13
13 Safe handling tips f or LP Gas ■ Liquid Propane (LP) gas is a petroleum product as are gasoline and natural gas. LP gas is a gas at regular temperatures and pressures. Under moderate pressure, inside a tank, LP gas is a liquid. As the pressure is released the liquid readily vaporizes and becomes gas. ■ LP gas has an odor similar to natural g ...
-
Weber 3400 - page 14
14 Problem Burners burn with a yellow or orange flame, in conjunction with the smell of gas. Burner does not light, or flame is low in HIGH position. Experiencing flare-ups: CAUTION: Do not line the bottom tray with aluminum foil. Burner flame pattern is erratic. Flame is low when burner is on HIGH. Flames do not run the whole length of the burner ...
-
Weber 3400 - page 15
15 Problem Side burner does not light. Flame is low in HIGH position. Flame is very yellow in conjunction with the smell of gas, OR Burner makes popping noise in conjunction with the smell of gas. Push button ignition does not work. Check Is gas supply off? Is fuel hose bent or kinked? Inspect the Weber Spider Stopper Guard for possible obstruction ...
-
Weber 3400 - page 16
16 WARNING: If there is a leak at connections a, b or c, retighten the fitting with a wrench and recheck for leaks with soap and water solution. If a leak persists after retightening the fitting, turn OFF the gas . DO NOT OPERATE THE BARBECUE. Contact your dealer. d) Side burner hose to side burner connection. Figure 14 (d). e) Valves to manifold c ...
-
Weber 3400 - page 17
17 17 Check: a) Hose to manifold connections. Figure 15 (a). b) Regulator to tank connection. Figure 15 (b). WARNING: If there is a leak at connections a or b, retighten the fitting with a wrench and recheck for leaks with soap and water solution. If a leak persists after retightening the fitting, turn OFF the gas . DO NOT OPERATE THE BARBECUE. Con ...
-
Weber 3400 - page 18
18 18 General Maintenance W eber Spider Stopper Guards Your Weber Gas Barbecue, as well as any outdoor gas appliance, is a target for spiders and other insects. They can nest in the venturi section of the burner tubes. This blocks the normal gas flow, and can cause the gas to flow back out of the air shutter. Figure 16. This could result in a fire ...
-
Weber 3400 - page 19
19 19 g) Lift and twist the burner assembly slightly, to separate the crossover tube from the burners. Figure 24. Remove the burners from the cooking box. h) To reinstall burners, reverse steps c) through g). i) Reinstall the Spider Stopper Guards. Slightly rotate the Spider Stopper Guards so that the seams are in line with the Venturi fins. There ...
-
Weber 3400 - page 20
20 20 Crosso ver Ignition System Operations If the Crossover Ignition System fails to ignite the Front burner, light the Front burner with a match. If the Front burner lights with a match, then check the Crossover Ignition System. ■ Check that both the white and black ignition wires are attached properly. Figure 26. ■ Check that the Crossover I ...
Do you have a question concerning Weber 3400?
Use the form below
If you did not solve your problem by using a manual Weber 3400, ask a question using the form below. If a user had a similar problem with Weber 3400 it is likely that he will want to share the way to solve it.