English dropdown-ico

Manual Carrier 58PAV

12 pages 0.19 mb
Download

Go to site of 12

Summary
  • Carrier 58PAV - page 1

    58PAV, 58RAV Induced-Combustion Furnaces Service and Maintenance Instructions For Sizes 045-155, Series 131 NOTE: Read the entire instruction manual before performing any service or maintenance. This symbol → indicates a change since the last issue. Index Page SAFETY CONSIDERATIONS ..................................................1-2 ELECTROSTAT ...

  • Carrier 58PAV - page 2

    The ability to properly perform maintenance on this equip- ment requires certain expertise, mechanical skills, tools, and equipment. If you do not possess these, do not attempt to perform any maintenance on this equipment other than those procedures recommended in the User’s Manual. FAILURE TO FOLLOW THIS WARNING COULD RESULT IN POSSIBLE DAMAGE T ...

  • Carrier 58PAV - page 3

    Never operate unit without a filter or with filter access door removed. A failure to follow this warning could result in fire, personal injury, or death. 1. Downflow/Horizontal Each furnace requires 2 filters which are installed in the return-air duct. (See Fig. 4 and 5.) To remove filters for cleaning or replacement, proceed as follows: a. Disconn ...

  • Carrier 58PAV - page 4

    9. Loosen setscrew holding blower wheel on motor shaft. 10. Remove bolts holding motor mount to blower housing and slide motor and mount out of housing. Disconnect ground wire attached to blower housing before removing motor. 11. Lubricate motor (when oil ports are provided). a. Remove dust caps or plugs from oil ports located at each end of motor. ...

  • Carrier 58PAV - page 5

    8. Clean cells using field-provided small wire brush, steel spring cable, reversible electric drill, and vacuum cleaner. a. Assemble wire brush and steel spring cable. (1.) Use 48 in. of 1/4-in. diameter high-grade steel spring cable (commonly known as drain clean-out or Roto- Rooter cable). (2.) Use 1/4-in. diameter wire brush (commonly known as 2 ...

  • Carrier 58PAV - page 6

    ELECTRICAL CONTROLS AND WIRING There may be more than 1 electrical supply to the unit. Check accessories and cooling unit for additional electrical supplies. The electrical ground and polarity for 115-v wiring must be maintained properly. Refer to Fig. 10 for field wiring information and to Fig. 12 for unit wiring information. NOTE: If the polarity ...

  • Carrier 58PAV - page 7

    Fig. 10—Heating and Cooling Application Wiring Diagram A78461 115-VOLT FIELD- SUPPLIED FUSED DISCONNECT AUXILIARY J-BOX CONTROL BOX 24-VOLT TERMINAL BLOCK TWO-WIRE HEATING- ONLY FOUR WIRE FIELD-SUPPLIED FUSED DISCONNECT CONDENSING UNIT TWO WIRE FURNACE R G C W R G Y GND GND FIELD 24-VOLT WIRING FIEL ...

  • Carrier 58PAV - page 8

    → Fig. 12—Unit Wiring Diagram A94074 PCB BLO WER OFF DELAY SELE C TION C HART 90 SEC 135 SEC 180 SEC 225 SEC GVR HI/LO R E LAY SEC-1 SEC-2 PL 1 3 2 1 6 5 4 987 LED TEST/TWIN BLOW ER OFF D E LAY G R Y W C HUM H S IR IDR B L W R BLO WER SPE ED SELE C T F U 1 C O OL HEAT L2 PL3 PL 2 VAC 120 L1 P R1 1 2 1 2 3 PR2 2 4 VA C - 3A F U SE SPA R E-2 SPA ...

  • Carrier 58PAV - page 9

    Fig. 13—Service Label A93297 - Stuck gas valve relay on control or miswire to gas valve circuit. - Stuck-open gas valve or leaky gas valve. - Obstructed pressure tubing.- Defective pressure switch (stuck closed). - Short circuit in secondary voltage (24V) wiring. - Proper vent sizing and conde ...

  • Carrier 58PAV - page 10

    Close door switch and go to start. Is circuit breaker closed? Is red LED status light on? Is red LED status light blinking rapidly without a pause? Is door switch closed? Is there 115v going to switch? Replace control board. Replace door switch. Is red LED status light blinking ON/OFF slowly with a combination of short and long flashes? ...

  • Carrier 58PAV - page 11

    11 NO PREVIOUS FAULT - Faults are erased after 48 hrs or whenever power (115V or 24V) is interrupted. Run system through a heating or cooling cycle to recheck system. 12 BLOWER ON AFTER POWER UP (115V OR 24V) - Normal  operation. Blower will run for 90 sec when furnace power is interrupted during a call for heat and R- ...

  • Carrier 58PAV - page 12

    Copyright 1994 CARRIER Corp. • 7310 W. Morris St. • Indianapolis, IN 46231 58pr9sm Manufacturer reserves the right to discontinue, or change at any time, specifications or designs without notice and without incurring obligations. Book 1 4 Tab 6a 8a PC 101 Catalog No. 535-835 Printed in U.S.A. Form 58P,R-9SM Pg 12 9-94 Replaces: 58P,R-8SM ...

Manufacturer Carrier Category Furnace

Documents that we receive from a manufacturer of a Carrier 58PAV can be divided into several groups. They are, among others:
- Carrier technical drawings
- 58PAV manuals
- Carrier product data sheets
- information booklets
- or energy labels Carrier 58PAV
All of them are important, but the most important information from the point of view of use of the device are in the user manual Carrier 58PAV.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Carrier 58PAV, service manual, brief instructions and user manuals Carrier 58PAV. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Carrier 58PAV.

Similar manuals

A complete manual for the device Carrier 58PAV, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Carrier 58PAV by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Carrier 58PAV.

A complete Carrier manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Carrier 58PAV - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Carrier 58PAV, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Carrier 58PAV, that we can find in the current document
3. Tips how to use the basic functions of the device Carrier 58PAV - which should help us in our first steps of using Carrier 58PAV
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Carrier 58PAV
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Carrier 58PAV in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Carrier 58PAV?

Use the form below

If you did not solve your problem by using a manual Carrier 58PAV, ask a question using the form below. If a user had a similar problem with Carrier 58PAV it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)