English dropdown-ico

Manual Chevrolet Chevrolet Camaro

22 pages 0.44 mb
Download

Go to site of 22

Summary
  • Chevrolet Chevrolet Camaro - page 1

     A /C -H EA T ER S Y ST EM - M A N U A L  2001 C he v r o l e t C a m a r o 2000-01 MANUAL A/C-HEATER SYSTEMS General Motors Chevrolet; Camaro Pontiac; Firebird * PLEASE READ THIS FIRST * WARNING: To avoid injury from accidental air bag deployment, read and carefully follow all SERVICE PRECAUTIONS and DISABLING & ACTIVATING AIR BAG SYSTEM ...

  • Chevrolet Chevrolet Camaro - page 2

    some of the air is recirculated through the A/C system. A/C Conditioned air is directed through dash registers. Bi-Level Conditioned air is directed through dash registers and floor outlets. A small amount of air is directed to defrost outlets. Vent Compressor does not operate in this setting. Outside air is delivered through dash registers. Heater ...

  • Chevrolet Chevrolet Camaro - page 3

    1) Remove right instrument panel sound insulator. Remove temperature control cable from heater housing. Move temperature control knob from full cold to full hot setting. If cable binds or pulley does not rotate freely, replace cable. Set temperature control knob to detent position halfway between full cold and full hot setting. 2) If control cable ...

  • Chevrolet Chevrolet Camaro - page 4

    NOTE: For additional trouble shooting information, see MANUAL A/C-HEATER SYSTEMS - TROUBLE SHOOTING article. BLOWER MOTOR 1) If blower does not operate, check HVAC fuse (20-amp) in instrument panel fuse block. If fuse is blown, check for short to ground in Brown wire between HVAC fuse (20-amp) and mode selector switch 3-pin connector terminal " ...

  • Chevrolet Chevrolet Camaro - page 5

    Ambient Temp. High Pressure Low Pressure F ( C) psi (kg/cm ) psi (kg/cm ) 70-80 (21-29) ( 1) ...... 115-190 (8.1-13.4) ........ 24-34 (1.7-2.4) 70-80 (21-29) ( 2) ...... 115-200 (8.1-14.1) ........ 25-37 (1.8-2.6) 80-90 (27-33) ( 1) ...... 140-215 (9.8-15.1) ........ 28-38 (2.0-2.7) 80-90 (27-33) ( 2) ..... 150-235 (10.5-16.5) ....... 30-40 (2.1-2. ...

  • Chevrolet Chevrolet Camaro - page 6

    A/C SYSTEM PERFORMANCE TEMPERATURE SPECIFICATIONS (2001 MODELS) Ambient Temp. F ( C) Center Vent Temp. F ( C) 70-80 (21-27) ( 1) ...................................... 38-48 (3-9) 70-80 (21-27) ( 2) ..................................... 40-55 (4-13) 80-90 (27-33) ( 1) ..................................... 38-55 (3-13) 80-90 (27-33) ( 2) ........... ...

  • Chevrolet Chevrolet Camaro - page 7

    relay harness connector terminal B2 (Dark Blue wire). If test light illuminates, go to next step. If test light does not illuminate, go to step 6). 5) Repair short to battery voltage in Dark Blue wire between blower motor relay harness connector terminal B2 and blower motor resistor harness connector terminal "C". After repair, go to step ...

  • Chevrolet Chevrolet Camaro - page 8

    14) Operate blower system to verify repair. If blower motor operates normally, repair is complete. If blower motor is still inoperative, return to step 2). BLOWER MOTOR INOPERATIVE IN HIGH SPEED 2000 Models 1) Perform DIAGNOSTIC SYSTEM TEST . Go to next step. 2) Set mode switch in VENT position. Set blower motor switch in highest speed position. Us ...

  • Chevrolet Chevrolet Camaro - page 9

    harness connector terminal B2 (Dark Blue wire) and C1 (Purple wire). Turn ignition switch to ON position. Set mode selector switch to VENT position. Place blower motor switch in low speed position. If blower motor operates, go to step 8). If blower motor does not operate, go to step 7). 5) Check for poor connection or connector damage at blower swi ...

  • Chevrolet Chevrolet Camaro - page 10

    position. If blower operates in any position, problem is intermittent. Check for poor connections. loose components or damaged wiring. Repair or replace as necessary. After repair, go to step 16). If blower motor does not operate in any speed position, go to next step. 3) Turn ignition switch to OFF position. Disconnect blower motor harness connect ...

  • Chevrolet Chevrolet Camaro - page 11

    switch in VENT position. Set blower motor switch in lowest speed position. Using test light connected to ground, probe blower motor resistor harness connector terminal "C" (Dark Blue wire). If test light illuminates, go to next step. If test light does not illuminate, go to step 4). 3) Using test light connected to ground, probe blower mo ...

  • Chevrolet Chevrolet Camaro - page 12

    1) Perform DIAGNOSTIC SYSTEM TEST . Go to next step. 2) Turn ignition switch to ON position. Set mode switch to VENT position. Turn blower switch to each speed position. If blower motor operates normally, go to next step. If blower motor malfunctions, go to step 4). 3) Place blower motor switch at maximum speed position. Place mode switch in each p ...

  • Chevrolet Chevrolet Camaro - page 13

    14) Check Light Green wire between A/C-heater control panel harness connector C2 terminal "B" and blower motor switch harness connector C1 terminal "E" located at A/C-heater control panel for open or high resistance. Repair Light Green wire as necessary. After repair, go to step 24). If wire is okay, go to step 18). 15) Check fo ...

  • Chevrolet Chevrolet Camaro - page 14

    Removal (5.7L Engine) Disconnect negative battery cable. Discharge A/C system, using approved refrigerant recovery/recycling equipment. Raise and support vehicle. Remove serpentine drive belt and tensioner. Remove compressor and condenser hose bolt. Disconnect compressor and condenser hose assembly. Discard seal. Disconnect transmission oil cooler ...

  • Chevrolet Chevrolet Camaro - page 15

    2) Raise and support vehicle. Remove compressor and condenser hose assembly fitting at condenser. Discard "O" ring. Lower vehicle. Remove accumulator tube. Remove radiator air upper baffle from condenser. Remove condenser. 3) To install, reverse removal procedure. Lightly coat "O" rings with mineral-base refrigerant oil. Evacuat ...

  • Chevrolet Chevrolet Camaro - page 16

    Fig. 3: Exploded View Of A/C-Heater Assembly Courtesy of General Motors Corp. Installation 1) To install, reverse removal procedure. Transfer condensate ...

  • Chevrolet Chevrolet Camaro - page 17

    screen to new evaporator. Using appropriate adhesive, install NEW evaporator core gasket in same position as original. Slide new evaporator to right until full seated in A/C-heater case. 2) Apply sealer (not epoxy) between evaporator and evaporator upper and lower case. Using epoxy, glue perforated section of heater and A/C evaporator case to A/C-h ...

  • Chevrolet Chevrolet Camaro - page 18

    ring, as this will cause it to expand. Insert short screen end of orifice tube first. Evacuate, charge, and leak test A/C system. TORQUE SPECIFICATIONS TORQUE SPECIFICATIONS Application Ft. Lbs. (N.m) Accumulator Hose Fitting At Evaporator ..................... 28 (38) Accumulator Tube Bolt ...................................... 10 (14) Compressor ...

  • Chevrolet Chevrolet Camaro - page 19

    Fig. 4: Manual A/C-Heater System Wiring Diagram (2000 Camaro & Firebird With 3.8L Engine) ...

  • Chevrolet Chevrolet Camaro - page 20

    Fig. 5: Manual A/C-Heater System Wiring Diagram (2000 Camaro & Firebird With 5.7L Engine) ...

  • Chevrolet Chevrolet Camaro - page 21

    Fig. 6: Manual A/C-Heater System Wiring Diagram (2001 Camaro & Firebird With 3.8L Engine) ...

  • Chevrolet Chevrolet Camaro - page 22

    Fig. 7: Manual A/C-Heater System Wiring Diagram (2001 Camaro & Firebird With 5.7L Engine) A00063334 ...

Manufacturer Chevrolet Category Air Conditioner

Documents that we receive from a manufacturer of a Chevrolet Chevrolet Camaro can be divided into several groups. They are, among others:
- Chevrolet technical drawings
- Camaro manuals
- Chevrolet product data sheets
- information booklets
- or energy labels Chevrolet Chevrolet Camaro
All of them are important, but the most important information from the point of view of use of the device are in the user manual Chevrolet Chevrolet Camaro.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Chevrolet Chevrolet Camaro, service manual, brief instructions and user manuals Chevrolet Chevrolet Camaro. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Chevrolet Chevrolet Camaro.

Similar manuals

A complete manual for the device Chevrolet Chevrolet Camaro, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Chevrolet Chevrolet Camaro by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Chevrolet Chevrolet Camaro.

A complete Chevrolet manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Chevrolet Chevrolet Camaro - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Chevrolet Chevrolet Camaro, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Chevrolet Chevrolet Camaro, that we can find in the current document
3. Tips how to use the basic functions of the device Chevrolet Chevrolet Camaro - which should help us in our first steps of using Chevrolet Chevrolet Camaro
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Chevrolet Chevrolet Camaro
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Chevrolet Chevrolet Camaro in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Chevrolet Chevrolet Camaro?

Use the form below

If you did not solve your problem by using a manual Chevrolet Chevrolet Camaro, ask a question using the form below. If a user had a similar problem with Chevrolet Chevrolet Camaro it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)