English dropdown-ico

Manual Desa TPNEA-A

36 pages 2.49 mb
Download

Go to site of 36

Summary
  • Desa TPNEA-A - page 1

    For more information, visit www .desatech.com W ARNING: If the information in this manual is not fol-           ? ...

  • Desa TPNEA-A - page 2

    www .desatech.com 56131-F 2 T AbLE OF CONTENTS Safety Information ............................................... 2 Dimensions .......................................................... 5 Pre-Installation Preparation ................................. 6 General V enting ................................................... 9 V enting Installation Inst ...

  • Desa TPNEA-A - page 3

    www .desatech.com 56131-F 3 Models (V)DVF36TPNEA/TPNPEA and (V)DVF36STEA/TSTPEA use a direct spark ignition with a 24 V AC control module. All models have HI/LO valve that controls the ame height. These units can be equipped with louvers for circulating or with panels for noncirculating operation. Fan Kit models DVFFBK and DVFFBKT are available ...

  • Desa TPNEA-A - page 4

    www .desatech.com 56131-F 4 W ARNING: Do not allow fans                          ? ...

  • Desa TPNEA-A - page 5

    www .desatech.com 56131-F 5 DIMENSIONS FRONT VIEW 30" (Opening) 25" 19 7 / 8 " (Opening) RIGHT SIDE 1 7 / 8 " 22 5 / 8 " 41 1 / 8 " 32" (Opening) 1 7 / 8 " 39 3 / 4 " 26 3 / 8 " 3" 1" 3 1 / 2 " 22 5 / 8 " 34 3 / 4 " 3" BACK VIEW TOP VIEW (Left Side) (Right Side) (Front) ...

  • Desa TPNEA-A - page 6

    www .desatech.com 56131-F 6 PRE-INST ALLA TION PREP ARA TION LOCA TION AND SP ACE REQUIREMENTS Determine the safest and most efcient location for your DESA direct-vent replace. Make sure that rafters and wall studs are not in the way of the venting system. Choose a location where the heat output is not affected by drafts, air conditioning duc ...

  • Desa TPNEA-A - page 7

    www .desatech.com 56131-F 7 0" 36" 2" Wall In Front Of Glass 36" Min. Perpendicular Wall 2" Min. From Opening Right Side Surround (0" Min.) Left Side Surround (0" Min.) TOP VIEW Figure 6 - Mantel Clearances for Peninsula and See-Thru Fireplaces (Peninsula Shown) 21" Min. 15" Min. 12" Min. 4" Mi ...

  • Desa TPNEA-A - page 8

    www .desatech.com 56131-F 8 PRE-INST ALLA TION PREP ARA TION Continued 39 3 / 4 " Min. 43 1 /4" 24" Figure 9 - Rough Opening for Installing See-Thru Fireplace 3" 1" Dia. Hole 3" 2" Dia. Hole 1" 2" Figure 10 - Hole Locations For Gas Line and Electric Wires for Peninsula and See-Thru Fireplaces Height Depe ...

  • Desa TPNEA-A - page 9

    www .desatech.com 56131-F 9 GENERAL VEN TIN G These models are approved for use with DESA 58 Series, rigid type direct vent pipe as supplied by DESA or with approved types of exible vent pipe (not supplied) when appropriate sized for an 8" outer and 5" inner diameter application. Y our replace is approved to be vented either through ...

  • Desa TPNEA-A - page 10

    www .desatech.com 56131-F 10 Fixed Closed Op en ab le Fixed Closed V V V V V V V V X X V X G G J F B B K N H I A N E L D B M A C B V V A G G B TERMINA TION CAP AIR SUPPL Y INLET GAS METER RESTRICTED AREA (TERMINA TION PROHIBITED) A = clearance above grade, veranda, porch, deck, or balcony [*12" (30.5 cm) minimum] B = clearance to window or doo ...

  • Desa TPNEA-A - page 11

    www .desatech.com 56131-F 1 1 VENT ING INST ALLA TION INSTRUCTIONS W ARNING: Read all instruc-              Failure to do so could result in ? ...

  • Desa TPNEA-A - page 12

    www .desatech.com 56131-F 12 VENT ING INST ALLA TION INSTRUCTIONS Continued For V erti cal T ermin ati on: Mea sure the dist ance from the replace ue outlet to the ceiling. Add the ceiling thickness, the vertical rise in an attic or second story , and allow for sufcient vent height above the roof line. Y ou may use one or two 90° elbows i ...

  • Desa TPNEA-A - page 13

    www .desatech.com 56131-F 13 VENT ING INST ALLA TION INSTRUCTIONS Continued 2. Rigid vent pipes and ttings have special twist-lock connections. Assemble the desired combination of pipe and elbows to the appli- ance adap tor with pipe seams orie nted towa rds the wall or oor . T wist-loc k Procedure: The female ends of the pipes and ttings ...

  • Desa TPNEA-A - page 14

    www .desatech.com 56131-F 14 VENT ING INST ALLA TION INSTRUCTIONS Continued       For vinyl sidin g, stucco, or wood exteriors, a siding standoff must be installed between the vent cap and exterior wall. The siding standoff prevents ex ce ssi ve heat from dam agi ng sidi ...

  • Desa TPNEA-A - page 15

    www .desatech.com 56131-F 15   Fi gu re s 22 and 23 sho w dif feren t con gur atio ns for venting with horizontal termination. Each gure includes a chart with vertical minimum/maxi mum and horizontal maximum dimensions which must be met ...

  • Desa TPNEA-A - page 16

    www .desatech.com 56131-F 16 VENT ING INST ALLA TION INSTRUCTIONS Continued Figure 26 - Installing Firestop If area above is a living space, install restop below framed hole. If area above is an attic, install restop above framed hole. Note: Pay special attention to these installa- tion instructions for required clearances (air space) to comb ...

  • Desa TPNEA-A - page 17

    www .desatech.com 56131-F 17 VENT ING INST ALLA TION INSTRUCTIONS Continued 5. Pla ce th e as hing ov er th e pip e se ction (s) extending through the roof. Apply a bead of silicone or roof sealer to the bottom ange of ashing and secure the base of the ashing to the roof and framing with roong nails. Be sure roong material overlap ...

  • Desa TPNEA-A - page 18

    www .desatech.com 56131-F 18    V ertical (V) Horizontal (H 1 ) + Horizontal (H 2 ) 5' min. 2' max. 6' min. 4' max. 7' min. 6' max. 8' min. 8' max. 20' max. 8' max. Figure 29 - V ertical Rigid V enting Conguration Us ...

  • Desa TPNEA-A - page 19

    www .desatech.com 56131-F 19 VENT ING INST ALLA TION INSTRUCTIONS Continued Figure 32 - V ertical Rigid V enting Conguration With No Horizontal Run    V = 40' max. P ARTS LIST FOR DESA VENTING        ? ...

  • Desa TPNEA-A - page 20

    www .desatech.com 56131-F 20 VENT ING INST ALLA TION INSTRUCTIONS Continued   P A58-712 Adjustable 7"-12" Section Double W all Pipe, Galvanized FP A58-6 6" Dura V ent Collar to FMI Pipe Adaptor E58-45 45° Elbow, Galvanized E58-90 90° Elbow, Galvanized FSE58-45 45° Starter Elbow (D ...

  • Desa TPNEA-A - page 21

    www .desatech.com 56131-F 21 INST ALLA TION W ALL SWITCH INST ALLA TION Si nce th e VDV F3 6TP NE A/T ST EA seri es use s a 24 V AC curr ent supp lied from a tran sfor mer moun ted on the ignitio n module and is prewired for easy conn ecti on to a wall swit ch (see Figu re 34). The (V)D VF36 TPNA /TST A models use a self gen er - ated milliv olt cu ...

  • Desa TPNEA-A - page 22

    www .desatech.com 56131-F 22 INST ALLA TION Continued Y ou may test the blower for operation by turning the control knob clockwise just until it clicks on which is the full on position. Adjust the fan speed to the lowest setting (this should be no more than 1/4 of a turn clockwise). FRONT O F F P I L O T O N L O H I P I L O T E A 16AI 7 TPTH TP TH ...

  • Desa TPNEA-A - page 23

    www .desatech.com 56131-F 23 O F F P I L O T O N L O H I P I L O T E A 16AI 7 TPTH TP TH Gas V alve T o Thermopoile Extension Cord Outlet Box White Red Figure 40 - Installing Remote Receiver (SKYTECH Model) Optional Fan Kit Plug Receiver Pull to Remove Insulation T ab Battery Cover 12 V olt Battery Figure 41 - Installing Battery in Hand- Held Remot ...

  • Desa TPNEA-A - page 24

    www .desatech.com 56131-F 24 2. Prepare incoming gas line and check with local codes regarding the use of teon tape. Complete your gas line installation by con- necting incoming gas line with exible gas line. Secure tightly with a wrench, but DO NOT OVER TIGHTEN.       ...

  • Desa TPNEA-A - page 25

    www .desatech.com 56131-F 25 4. Figure 47 shows the log set. Logs “A” have the knot at the end of the log. Logs “B” have the knot at the middle of the log. T wigs “C” have the shape of a “Y”. T wigs “D” have the shap e of bent twigs . T wig “E” is a stra ight twig which is placed across the top of Logs “B”. 5. Figure 48 ...

  • Desa TPNEA-A - page 26

    www .desatech.com 56131-F 26 Figure 52 - Correct Pilot Flame Pattern 1/8" (0.3cm) 3/8" - 1/2" (.95cm-1.3cm) 1/2" (12.7 mm) 3/4" (19 mm) Edge of Burner T op of Burner Figure 53 - Correct Ignitor Location (Side V iew) b URNER FLAME ADjUSTMENT The air shutter, located at the bas e of the main burner (see Figure 54), h as been ...

  • Desa TPNEA-A - page 27

    www .desatech.com 56131-F 27 b URNER FLAME ADjUSTMENT Continued Figure 56 - Burner Removal 4. Slide burner forward off orice and turn to one side to clear opening in hearth pan. Be careful not to bend or damage pilot or ignitor element. 5 . T o reinstall burner, follow reverse steps ma kin g su re a ir s hut ter on b urn er t ube is completely s ...

  • Desa TPNEA-A - page 28

    www .desatech.com 56131-F 28 OPERA TING FIREPLACE MILLIV OL T FOR YOUR SAFETY  W ARNING: If you do not fol- low these instructions exactly ,         ...

  • Desa TPNEA-A - page 29

    www .desatech.com 56131-F 29 D. Do not use this appliance if any part has been under water . Immediately call a qualied service technician to inspect the appliance and to replace any part of the control system and any gas control which has been under water . LIGHTING INSTRUCTIONS 1. ST OP ! Rea d the saf et y inf or ma ti on begin- ning on page ...

  • Desa TPNEA-A - page 30

    www .desatech.com 56131-F 30 OPERA TING FIREPLACE Continued D. Do not use this appliance if any part has been under water . Immediately call a qualied service technician to inspect the appliance and to replace any part of the control system and any gas control which has been under water . LIGHTING INSTRUCTIONS 1. S TO P! Re ad th e s a fe ty in ...

  • Desa TPNEA-A - page 31

    www .desatech.com 56131-F 31 TROUbLESHOO TING             ? ...

  • Desa TPNEA-A - page 32

    www .desatech.com 56131-F 32 REMEDY 1. Replace ignitor if wire is prop- erly connected and you have no spark 2. Us in g a ma tc h, l igh t pil ot . If pi- lo t lig ht s tur n off pi lot a nd pu sh pie zo aga in. If pilot light s, an im pr op er gas /a ir m ix tu re cau se im pr op er li ght ing and a l ong er pu rg e pe ri od is rec om me nd ed . I ...

  • Desa TPNEA-A - page 33

    www .desatech.com 56131-F 33 TROUbLESHOO TING Continued REMEDY 1. Check electrical connections and replace wall switch 1. Clean and adjust main burner 2 . Adjust ignitor location for maximum ame impingement on sensor 3. Have vent inspected for block- age or damage  1. Wa l l s w i t c h w i r e s d e f e ...

  • Desa TPNEA-A - page 34

    www .desatech.com 56131-F 34 RECEIVER AND HAND-HELD   For millivolt models. Allows the gas log heater to be turned on and off by using a hand-held remote control.    Natural - 27272  ...

  • Desa TPNEA-A - page 35

    www .desatech.com 56131-F 35        ? ...

  • Desa TPNEA-A - page 36

    2701 Industrial Drive P .O. Box 90004 Bowling Green, KY 42102-9004 www .desatech.com NOT A UPC 56131 Rev . F 03/06 WARRANTy INFORMA TION KEEP THIS WARRANTy Model Serial No. Date Purchased Always specify model and serial numbers when communicating with the factory . W e reserve the right to amend these specications at any time without notice. The ...

Manufacturer Desa Category Indoor Fireplace

Documents that we receive from a manufacturer of a Desa TPNEA-A can be divided into several groups. They are, among others:
- Desa technical drawings
- TPNEA-A manuals
- Desa product data sheets
- information booklets
- or energy labels Desa TPNEA-A
All of them are important, but the most important information from the point of view of use of the device are in the user manual Desa TPNEA-A.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Desa TPNEA-A, service manual, brief instructions and user manuals Desa TPNEA-A. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Desa TPNEA-A.

Similar manuals

A complete manual for the device Desa TPNEA-A, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Desa TPNEA-A by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Desa TPNEA-A.

A complete Desa manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Desa TPNEA-A - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Desa TPNEA-A, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Desa TPNEA-A, that we can find in the current document
3. Tips how to use the basic functions of the device Desa TPNEA-A - which should help us in our first steps of using Desa TPNEA-A
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Desa TPNEA-A
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Desa TPNEA-A in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Desa TPNEA-A?

Use the form below

If you did not solve your problem by using a manual Desa TPNEA-A, ask a question using the form below. If a user had a similar problem with Desa TPNEA-A it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)