English dropdown-ico

Manual Kohler KT17

16 pages 3.49 mb
Download

Go to site of 16

Summary
  • Kohler KT17 - page 1

    OWNE I / Y R S MAN UAL MODELS (17 hP) (19 hP) *with Full Pressure Lubrication operating and maintenance instructions Congratulations - You have selected a fine four-cycle, twin cylinder, air-cooled engine. Kohler designs long life strength and on-the-job durability into each engine.. . making a Kohler engine dependable.. .dependability vou can co ...

  • Kohler KT17 - page 2

    Safety Information For Your Safety! These precautions should be followed at all times. Failure to follow these precautions could result in iniurv to vourself and others, A WARNING ib Explosive Fuel can cause fires and severe burns. Stop engine before filling fuel tank. Explosive Fuel! Gasoline is extremely flammable and its vapors can explode if ig ...

  • Kohler KT17 - page 3

    Safety Information (Cont.) A WARNING Accidental Starts can cause severe injury or death. Disconnect and ground spark plug lead before servicing. Accidental Starts! Before servicing the engine or equipment, always disconnect the spark plug leads to prevent the engine from starting accidentally Ground the leads to prevent sparks that could cause fire ...

  • Kohler KT17 - page 4

    381 ug Control Ignition Panel Coil (Optional) / Choke Control (Optional) Throttle Control , (Optional) Dark ug Blower Housing Vluffler. Air Cleaner Oil Fill Breaker Points ‘ic S V / tarter Solenoid 3ptional) Air Intake Screen cod Fins 0i;Sump Starter Figure 1. Typical KT Engine. Oil Recommendations Using the proper type and weight of oil in t ...

  • Kohler KT17 - page 5

    Fuel Recommendations A WARNING: Explosive Fuel! Gasoline is extremely flammable and its vapors can explode if ignited. Store gasoline only in approved ‘containers, in well ventilated, unoccupied buildings, away from sparks or flames. Do not fill the fuel tank while the engine is hot or running, since spilled fuel could ignite if it comes in conta ...

  • Kohler KT17 - page 6

    Operating Instructions Also read the operating instructions of the equipment this engine powers. Pre-Start Checklist Check oil level. Add oil if low. Do not overfill. Check fuel level. Add fuel if low. Check cooling air intake areas and external surfaces of engine. Make sure they are clean and unobstructed. Check that the air cleaner components and ...

  • Kohler KT17 - page 7

    Operating Optional spark arrestor mufflers are available from your Kohler Engine Service Dealer. Check your local 1aw.s and statutes regarding engine spark arrestor muffler requirements. Angle of Operation This engine will operate continuously at angles up to 30’ in any direction. Check oil level to assure crankcase oil level is at the “F” ma ...

  • Kohler KT17 - page 8

    Check Oil Level The importance of checking and maintaining the proper oil level in the crankcase cannot be overemphasized. Check oil BEFORE EACH USE as follows: 1. Make sure the engine is stopped, level, and is cool so the oil has had time to drain into the sump. 2. To keep dirt, grass clippings, etc., out of the engine, clean the area around the o ...

  • Kohler KT17 - page 9

    Change Oil Filter Some engines are equipped with an oil filter. Replace the oil filter every other oil change, in accordance with the “Oil Change Intervals” table on page 8. Always use a genuine Kohler oil filter, Part No. 52 050 02, and replace as follows: 1 . 2. 3 . 4 . 5. 6 . 7. 8 . Drain the oil from the engine crankcase. Allow the oil filt ...

  • Kohler KT17 - page 10

    NOTE: Operating the engine with loose or damaged air cleaner components could allow unfiltered air into the engine causing premature wear and failure. 6. Reinstall element cover, seals, air cleaner cover and wing nuts. Tighten wing nuts l/2 to 1 full turn after nuts contacts cover. Do not over-tighten. r cleaner Service Precleaner 7. When ai necess ...

  • Kohler KT17 - page 11

    Ground Electrode 0.025 in. (0.65 mm) Gap Figure 8. Servicing Spark Plug. Battery Charging A WARNING: Explosive Gas! Batteries produce explosive hydrogen gas while being charged. To prevent a fire or explosion, charge batteries only in well ventilated areas. Keep sparks, open flames, and other sources of ignition a way from the battery at all times. ...

  • Kohler KT17 - page 12

    Kohler Adjustable Jet Low Idle 1 Main Fuel 1 1 KT17 1 1 turn 1 2-l/2 turns 1 1 KT19 1 1 turn I 2-l/2 turns 3. Start the engine and run at half throttle for 5 to IO 4. 5. 6 . minutes to warm up. The engine must be warm before making final settings (steps 4, 5, 6, and 7). Main Fuel Needle Setting: This adjustment is required for adjustable main jet c ...

  • Kohler KT17 - page 13

    Walbro Fixed Jet , Low Idle KT17 1 -l/4 turns KT19 l-1 /4 turns Walbro Adjustable Jet Low idle Main Fuel KT17 1-l /4 turns i-1/4 turns KT19 1-I /4 turns 1 turn 3. Start the engine and run at half throttle for five to ten minutes to warm up. The engine must be warm before making final settings. 4. Main Fuel Needle Setting: This adjustmenf is require ...

  • Kohler KT17 - page 14

    Troubleshooting When troubles occur, be sure to check the simple causes which, at first, may seem to obvious to be considered. For example, a starting problem could be caused by an empty fuel tank. Some common causes of engine troubles are listed in the following table. Do not attempt to service or replace major engine components, or any items that ...

  • Kohler KT17 - page 15

    Specifications Model: ............................................................................................. KT17 ............................ KT19 Bore: ................................................. inches (millimeters) ............. 3.12 (79.2) ................... 3.12 (79.2) Stroke. ................................................ inc ...

  • Kohler KT17 - page 16

    ENGINE DIVISION, KOHLER CO., KOHLER, WISCONSIN 53044 FOR SALES AND SERVICE INFORMATION IN U.S. AND CANADA, CALL l-800-544-2444 FORM NO.: TP-2107-C ISSUED: 4187 I REVISED: 12/95 I MAILED: I LITHO IN U.S.A. ...

Manufacturer Kohler Category Automobile Parts

Documents that we receive from a manufacturer of a Kohler KT17 can be divided into several groups. They are, among others:
- Kohler technical drawings
- KT17 manuals
- Kohler product data sheets
- information booklets
- or energy labels Kohler KT17
All of them are important, but the most important information from the point of view of use of the device are in the user manual Kohler KT17.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Kohler KT17, service manual, brief instructions and user manuals Kohler KT17. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Kohler KT17.

Similar manuals

A complete manual for the device Kohler KT17, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Kohler KT17 by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Kohler KT17.

A complete Kohler manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Kohler KT17 - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Kohler KT17, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Kohler KT17, that we can find in the current document
3. Tips how to use the basic functions of the device Kohler KT17 - which should help us in our first steps of using Kohler KT17
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Kohler KT17
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Kohler KT17 in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Kohler KT17?

Use the form below

If you did not solve your problem by using a manual Kohler KT17, ask a question using the form below. If a user had a similar problem with Kohler KT17 it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)