English dropdown-ico

Manual Desa VSGF36PTA

40 pages 2.03 mb
Download

Go to site of 40

Summary
  • Desa VSGF36PTA - page 1

    For more information, visit www .desatech.com W ARNING: If the information in this manual is not fol- lowed exactly , a fire or explosion may result causing property damage, personal injury or loss of life. — Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance. — WHA T TO DO IF YOU ...

  • Desa VSGF36PTA - page 2

    www .desatech.com 1 16746-01A 2 W ARNING: Improper installation, adjustment, altera- tion, service or maintenance can cause injury or prop- erty damage. Refer to this manual for correct installation and operational procedures. For assistance or addi- tional information consult a qualified installer , service agency or the gas supplier . W ARNING: ...

  • Desa VSGF36PTA - page 3

    www .desatech.com 1 16746-01A 3 SAFETY INFORMA TION W ARNING: This product con- ta ins an d/o r gen er ate s c hem ical s known to the state of California to cause cancer or birth defects or other reproductive harm. IMPORT ANT : Read this owner’s manual carefully and compl etely b e f o r e t r y i n g t o a s s e m b l e , operate or service thi ...

  • Desa VSGF36PTA - page 4

    www .desatech.com 1 16746-01A 4 1. This appliance is only for use with the type of gas indica ted on the rating plate. Thi s appli ance is not convertible for use with other gases. 2. Do not place propane/LP supply tank(s) in- side any structure. Locate propane/LP supply tank(s) outdoors (propane/LP units only). 3. If you smell gas • shut off gas ...

  • Desa VSGF36PTA - page 5

    www .desatech.com 1 16746-01A 5 Optional Remote Control PRODUCT IDENTIFICA TION Figure 1 - Log Base Assembly (VSGF36NRA Shown) Log Set Base Assembly Front Burner Piezo Ignitor Rear Burner T op Louver Assembly Fireplace Hood Bottom Louver Assembly Screen Assembly T op Outer Casing Figu re 2 - F irep lace (VS GF36N RA Shown ) UNP ACKING CAUTION: Do n ...

  • Desa VSGF36PTA - page 6

    www .desatech.com 1 16746-01A 6 LOCA TING FIREBO X PLANNING Plan where you will install the firebox. This will save time and money later when you install the firebox. Before installation, consider the following: 1. Where the firebox will be located. Allow for wall and ceiling clearances (see Installation Clear - ances, page 10). 2. Everything ne ...

  • Desa VSGF36PTA - page 7

    www .desatech.com 1 16746-01A 7 AIR FOR COMB USTION AND VENTILA TION W ARNING: This firebox shall not be installed in a confined space or unusually tight con - struction unless provisions are provided for adequate combus- tion and ventilation air . Read the following instructions to insure pro per f resh air for this and other fuel-bu rning ap pl ...

  • Desa VSGF36PTA - page 8

    www .desatech.com 1 16746-01A 8 AIR FOR COMB USTION AND VENTILA TION Continued DETERMINING FRESH-AIR FLOW FOR HEA TER LOCA TION Determining if Y ou Have a Confined or Unconfined Space Use this work sheet to determine if you have a confined or unconfined space. Space: Includes the room in which you will install heater plus any adjoining rooms wi ...

  • Desa VSGF36PTA - page 9

    www .desatech.com 1 16746-01A 9 VENTILA TION AIR V entilation Air From Inside Building This fresh air would come from an adjoining un - confined space. When ventilating to an adjoining unconfined space, you must provide two perma- nent openings: one within 12" of the ceiling and one within 12" of the floor on the wall connecting the tw ...

  • Desa VSGF36PTA - page 10

    www .desatech.com 1 16746-01A 10 CAUTION: This fireplace cre- ates warm air currents. These currents move heat to wall sur - faces next to fireplace. Installing fireplace next to vinyl or cloth wall coverings or operating heater where impurities (such as, but not limited, to tobacco smoke , arom atic candles, clean- ing flui ds, oil or kerosene ...

  • Desa VSGF36PTA - page 11

    www .desatech.com 1 16746-01A 1 1 INST ALLA TION Continued Mantel Clearances for Built-In Installation If placing custom mantel abov e built-i n firebox, you mus t meet the minim um allow able clea ranc e betw een man tel shel f and top of firebox op enin g sh ow n in Fig ure 7. Th es e ar e th e mi ni mum al low ab le mant el clearan ces for a s ...

  • Desa VSGF36PTA - page 12

    www .desatech.com 1 16746-01A 12 Rough Opening Dimensions for Built-in Installation Front Width (Inside to Depth Model Inside) Height (Minimum) 36" 41 1 / 2 " 40 1 / 2 " 20 3 / 4 " 1. Fr am e in rou gh op en in g. The fire box fra mi ng sh oul d be co nst ruc ted of 2 x 4 lu mb er or hea vie r. Us e di me nsi ons in Tab le 1 an ...

  • Desa VSGF36PTA - page 13

    www .desatech.com 1 16746-01A 13 INST ALLA TION Continued INST ALLING FIREBOX USING OPTIONAL ACCESSORY MANTELS W ARN ING : A q ual ified s er vic e person must install firebox. Fol- low all local codes. This firebox may be installed using the corner or cab inet mant el with heart h base acces sori es again st a wall in your home. A trim kit is i ...

  • Desa VSGF36PTA - page 14

    www .desatech.com 1 16746-01A 14 INST ALLA TION Continued W ARNING: Never connect natural gas fireplace to private (non-utility) gas wells . This gas is commonly known as wellhead gas. Installation Items Needed Before installing fireplace, make sure you have the items listed below . • exte rnal regulator for propane/LP unit only (supplied by in ...

  • Desa VSGF36PTA - page 15

    www .desatech.com 1 16746-01A 15 Note: If adding the G8007 series brick liner acces- sory , install it now . Follow instructions in G8007 accessory kit. CAUTION: Do not pick up log base assembly by burner . This could damage burner . Only handle base by grates. 3. Route gas line (provided by installer) from equipment shutoff valve to fireplace. Ro ...

  • Desa VSGF36PTA - page 16

    www .desatech.com 1 16746-01A 16 CHECKING GAS CONNECTIONS WARNING: Test all gas pip- ing and connections, inter nal and external to unit, for leaks after insta lling or servicing. Cor- rect all leaks at once. WARNING: Never use an open flame to check for a leak. Apply a noncorrosive leak detection fluid to all joints. Bubbles forming show a leak. ...

  • Desa VSGF36PTA - page 17

    www .desatech.com 1 16746-01A 17 INST ALLA TION Continued INST ALLING LOGS (MODELS VSGF36NT A, VSGF36PT A, VSGF36NRA AND VSGF36PRA) W ARNING: Failure to posi- tion the parts in accordance with these diagrams or failure to use only parts specifically approved wit h this hea ter may result in property damage or per son al i nju ry. CAUTION: Do not r ...

  • Desa VSGF36PTA - page 18

    www .desatech.com 1 16746-01A 18 INST ALLA TION Continued INST ALLING FIREPLACE HOOD AND SCREEN 1. Loosen screws inside top edge of firebox. Slide notches in hood over screws and tighten screws (see Figure 25). 2. Install fireplace screen by slipping notches of fireplace screen over screws on front of fireplace (see Figure 26). Figure 25 - Hood ...

  • Desa VSGF36PTA - page 19

    www .desatech.com 1 16746-01A 19 OPERA TING FIREPLACE THERMOST A T MODELS FOR YOUR SAFETY READ BEFORE LIGHTING W ARNING: If you do not fol- low these instructions exactly , a fire or explosion may result causing property damage, per - sonal injury or loss of life. A. This appliance has a pilot which must be lighted by hand. When lighting the pilot ...

  • Desa VSGF36PTA - page 20

    www .desatech.com 1 16746-01A 20 OPERA TING FIREPLACE Continued Note: If pilot does not stay lit, contact a qualified service person or gas supplier for repairs. Until repairs are made, light pilot with match. T o light pilot with match, see Manual Lighting Procedure . 7. Keep cont ro l knob pr esse d in for 30 second s afte r lighti ng pilot. Aft ...

  • Desa VSGF36PTA - page 21

    www .desatech.com 1 16746-01A 21 OPERA TING FIREPLACE Continued C. Use only your hand to push in or turn the gas contr ol knob. Never use tools. If the knob will not push in or turn by hand, donʼt try to repair it, call a qualified service tech- nician or gas supplier . Force or attempted repair may result in a fire or explosion. D. Do not use t ...

  • Desa VSGF36PTA - page 22

    www .desatech.com 1 16746-01A 22 OPERA TING FIREPLACE Continued WA RN ING : Mak e su re t he se- l ec to r s wi tc h is i n t h e O FF p os it io n wh en yo u ar e a way fr om ho me fo r lo ng per iod s of ti me . He ate r wi ll c om e o n a u to ma ti ca ll y wi th s el e c- to r s wit ch in the ON po sit ion . Figure 31 - Pilot (Propane/LP) Pilot ...

  • Desa VSGF36PTA - page 23

    www .desatech.com 1 16746-01A 23 OPERA TING FIREPLACE Continued Figure 32 - Setting the Selector Switch, Control Knob and Flame Adjustment Knob for Hand-Held Remote Operation O F F P I L O T L O I H REMOTE OFF ON O N Selector Switch in Remote Position (Optional Hand- Held Remote Control) Flame Adjustment Knob Control Knob in On Position ON/OFF SERI ...

  • Desa VSGF36PTA - page 24

    www .desatech.com 1 16746-01A 24 OPERA TING FIREPLACE Continued 2. The receiver continuously receives signals from the hand-held remote to control the roo m tempera ture . If the hand-held remot e is misplaced, obstructed or for any r eason cannot transmi t to the receiv er , the rec eiver will shut off the fireplace after 8 minutes. Key Pad Lock ...

  • Desa VSGF36PTA - page 25

    www .desatech.com 1 16746-01A 25 CLEANING AND MAINTENANCE W ARNING: T urn off fireplace and let cool before cleaning. CAUTION: Y ou must keep control areas, burner and cir- culating air passageways of fireplace clean. I nspect these areas of fireplace before each use. Have fireplace inspected yearly by a qualified service p er s on . Fi r e pl ...

  • Desa VSGF36PTA - page 26

    www .desatech.com 1 16746-01A 26 WIRING DIAGRAM Not e: For prope r operat ion of optio nal acce ssor ies , the wires from the thermopile to the control must be connected exactly as shown. Thermopile SPECIFICA TIONS Models VSGF36NT A and VSGF36NRA Btu (V ariable) 33,000/21,500 T ype Gas Natural Gas Ignition Piezo Pressure Manifold 3.5" W .C. In ...

  • Desa VSGF36PTA - page 27

    www .desatech.com 1 16746-01A 27 POSSIBLE CAUSE 1 . Ignitor electrode not con - nected to ignitor cable 2. Ignitor cable pinched or wet 3. Piezo ignitor nut is loose 4. Broken ignitor cable 5. Bad piezo ignitor 6. Ignitor electrode broken 7. Ignitor electrode positioned wrong 1. G as sup ply tur ne d off or equi p - ment shu toff val ve c lose d 2. ...

  • Desa VSGF36PTA - page 28

    www .desatech.com 1 16746-01A 28 TROUBLESHOO TING Continued POSSIBLE CAUSE 1. Co nt rol k nob n o t fu ll y pr es se d in 2. Control knob not pressed in long enough 3. Equipment shutoff valve not fully open 4. Pilot flame not touching ther - mocouple, which allows ther - mocouple to cool, causing pilot flame to go out. This problem could be caused ...

  • Desa VSGF36PTA - page 29

    www .desatech.com 1 16746-01A 29 POSSIBLE CAUSE 1. Not enough air 2. Gas regulator defective 3. Residues from manufacturing processes and logs curing 1. Not enough combustion/ven - tilation air 1. Turning control knob to HI position when burners are cold 2. Air in gas line 3. Air passageways on heater blocked 4 . Dirty or partially clogged burner o ...

  • Desa VSGF36PTA - page 30

    www .desatech.com 1 16746-01A 30 POSSIBLE CAUSE 1. Heater burning vapors from pa in t, ha ir sp ra y , g lues , cl ea ne rs , ch em ic al s, ne w car pe t, et c. (S ee IM PO R T ANT s ta te men t a bo ve ) 2. Low fuel supply (propane/LP only) 3. G a s l e a k . S e e W a r n i n g statement at top of page 1. Not enough fresh air is avail - able 2. ...

  • Desa VSGF36PTA - page 31

    www .desatech.com 1 16746-01A 31 ACCESSORIES NOTICE: All accessories may not be available for all fireplace models. Purcha se these firebox accessorie s from your local dealer . If they can not supply these accessories, call DESA ʼ s Sales Department at 1-866-672-6040 for information. Y ou can also write to the address listed on the back page of ...

  • Desa VSGF36PTA - page 32

    www .desatech.com 1 16746-01A 32 ILL USTRA TED P ARTS BREAKDOWN MODELS VSGF36PT A, VSGF36NT A L PG 19 21 22 23 24 17 14 14 16 13 12 27 28 29 2 1 1 5 4 3 7 9 10 10 8 6 1 18 20 26 16 15 25 ...

  • Desa VSGF36PTA - page 33

    www .desatech.com 1 16746-01A 33 P ARTS LIST This list contains replaceable parts used in your firebox. When ordering parts, follow the instructions listed under Replacement Parts on page 26 of this manual. KEY P ART NUMBER NO. VSGF36PT A VSGF36NT A DESCRIPTION QTY . 1 109824-02 109824-02 Rear Burner Assembly 1 2 102239-02 102239-02 Front Burner A ...

  • Desa VSGF36PTA - page 34

    www .desatech.com 1 16746-01A 34 ILL USTRA TED P ARTS BREAKDOWN MODELS VSGF36PRA, VSGF36NRA L PG 25 19 21 17 14 14 16 13 12 30 31 32 2 1 1 5 4 3 7 9 10 10 8 6 1 18 24 26 27 20 22 23 29 16 15 28 ...

  • Desa VSGF36PTA - page 35

    www .desatech.com 1 16746-01A 35 P ARTS LIST This list contains replaceable parts used in your firebox. When ordering parts, follow the instructions listed under Replacement Parts on page 26 of this manual. KEY P ART NUMBER NO. VSGF36PRA VSGF36NRA DESCRIPTION QTY . 1 109824-02 109824-02 Rear Burner Assembly 1 2 102239-02 102239-02 Front Burner Ass ...

  • Desa VSGF36PTA - page 36

    www .desatech.com 1 16746-01A 36 ILL USTRA TED P ARTS BREAKDOWN MODELS VSGF36PT A, VSGF36NT A, VSGF36PRA AND VSGF36NRA 1 4 8 7 6 27 9 10 28 29 30 1 1 12 22 18 25 26 20 17 21 19 16 15 13 5 2 3 14 23 24 ...

  • Desa VSGF36PTA - page 37

    www .desatech.com 1 16746-01A 37 KEY P ART NO. NUMBER DESCRIPTION QTY . 1 1 13190-01CK Screen 2 2 1 16865-01CK Bottom Louver Assembly 1 3 ** Face W eldment 1 4 101355-03CK Hood 1 5 1 16864-01CK Louver Assembly 1 6 1 12862-02CK Firebox Bottom Bracket 1 7 21 195 Right Firebox Support Leg 1 8 21 194 Left Firebox Support Leg 2 9 ** Firebox Surround 1 1 ...

  • Desa VSGF36PTA - page 38

    www .desatech.com 1 16746-01A 38 _____________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ___________________________________________ ...

  • Desa VSGF36PTA - page 39

    www .desatech.com 1 16746-01A 39 _____________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ___________________________________________ ...

  • Desa VSGF36PTA - page 40

    LIMITED WARRANTY VENT -FREE GAS FIREPLACE SY STEM DESA Heating Products warrants this product to be free from defects in materials and components for four (4) years from the date of first purchase, provided that the product has been properly installed, operated and maintained in accordance with all applicable instructions. T o make a claim under t ...

Manufacturer Desa Category Outdoor Fireplace

Documents that we receive from a manufacturer of a Desa VSGF36PTA can be divided into several groups. They are, among others:
- Desa technical drawings
- VSGF36PTA manuals
- Desa product data sheets
- information booklets
- or energy labels Desa VSGF36PTA
All of them are important, but the most important information from the point of view of use of the device are in the user manual Desa VSGF36PTA.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Desa VSGF36PTA, service manual, brief instructions and user manuals Desa VSGF36PTA. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Desa VSGF36PTA.

Similar manuals

A complete manual for the device Desa VSGF36PTA, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Desa VSGF36PTA by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Desa VSGF36PTA.

A complete Desa manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Desa VSGF36PTA - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Desa VSGF36PTA, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Desa VSGF36PTA, that we can find in the current document
3. Tips how to use the basic functions of the device Desa VSGF36PTA - which should help us in our first steps of using Desa VSGF36PTA
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Desa VSGF36PTA
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Desa VSGF36PTA in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Desa VSGF36PTA?

Use the form below

If you did not solve your problem by using a manual Desa VSGF36PTA, ask a question using the form below. If a user had a similar problem with Desa VSGF36PTA it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)