English dropdown-ico

Manual Char-Broil 4984619

20 pages 1.79 mb
Download

Go to site of 20

Summary
  • Char-Broil 4984619 - page 1

    Natural Gas Conversion Kit • • 09/29/07 3496258 N A TURAL GAS CONVERSION KIT FOR OUTDOOR USE ONL Y T his Na tur al Gas Con v er sion Kit can be used ONL Y with Dual Fuel™ g rills. Model # 4984619 For use with Commercial Series Dual Fuel™ Grills only . D ANGER If you smell gas: 1. Shut off gas to the appliance. 2. Extinguish any open flame. ...

  • Char-Broil 4984619 - page 2

    D ANGER Safety Symbols The symbols and boxes shown below explain what each heading means. Read and follow all of the messages found throughout the manual. DANGER: Indicates an imminently hazardous situation which, if not avoided, will result in death or serious injury . WARNING W ARNING: Indicates a potentially hazardous situation which, if not avo ...

  • Char-Broil 4984619 - page 3

    Connecting Y our Grill to the Natural Gas Source. 1. 2. Figure A A professionally-installed shut-off valve between the supply piping and the socket is recommended, but not required, by the National Fuel Gas Code. Socket connection must be made outdoors. Coat the gas supply pipe nipple with gas resistant pipe dope or approved teflon tape. Screw sock ...

  • Char-Broil 4984619 - page 4

    Safety Tips s When grill is not in use, turn off all control knobs and gas source. CA UTION CAUTION: Sideburner lid must be open when sideburner is in operation, if so equipped. Burner Flame Check • Remove cooking grates and flame tamers. Light burners, rotate knobs from to . Y ou should see a smaller flame in low position than seen on HIGH. Perf ...

  • Char-Broil 4984619 - page 5

    T ube Burner Conversion 2 - Remove Self-tap screws and remove Carryover tubes. - Remove screws and washers at back of burners to detach T ube Burners from Burner Brackets. Burner Brackets Lock W asher Burner Machine Screws 1 - - Next, open Lid and remove W arming Rack, Cooking Grates, and Flame T amers. First, make sure all control knobs are in the ...

  • Char-Broil 4984619 - page 6

    3 - Remove two screws that secure each Electrode to T ube Burner (Electrode remains in Firebox). - Lift back end of burner while sliding T ube Burner out of Firebox, disengaging burners from V alves. Electrode T ube Burner Front of Grill Firebox T ube Burner Screws V alve 4 - Insert Orifice Removal T ool provided with Kit into Firebox Burner openin ...

  • Char-Broil 4984619 - page 7

    - Pull the T ube Burner Control Knobs off of V alve Stems. - Remove screws and washers that secure each Bezel to the Control Panel. Save removed Bezels for converting back to LP T ank Gas. - Install new Natural Gas Bezels provided with Kit (see illustration below) in place of old Bezels onto Control Panel, and secure using previously removed screws ...

  • Char-Broil 4984619 - page 8

    7 8 Y our Grill may differ from illustration shown. Natural Gas Hose Conversion 6 - Using a wrench, not provided, remove LP Regulator Hose Assembly from Manifold Connection. Saved removed LP Manifold Connection for converting back to LP T ank Gas. Y our LP Regulator hose will be located either inside the cart or under the sideburner shelf depending ...

  • Char-Broil 4984619 - page 9

    Sideburner Sideburner cooking grate Burner cap Wind diverter Natural Gas Conversion Kit  9 9 Sideburner Conversion 6 - Open sideburner lid and remove the sideburner cooking grate, burner cap and wind diverter . - Beneath sideburner shelf, remove the two screws, lock washers and flat washers that secure sideburner to shelf. 10 6 - Remove sideburn ...

  • Char-Broil 4984619 - page 10

    Bezel V alve stem Natural gas bezel 80004350 Orifice Orifice removal tool 80004378 Sideburner valve Sideburner control knob 11 6 - Using the provided orifice removal tool, unscrew the orifice from the end of the sideburner valve. Save removed orifice for converting back to LP T ank Gas. No replacement orifice is required. 5 12 - Pull the sideburner ...

  • Char-Broil 4984619 - page 11

    Flat washer Lock washer Sideburner Sideburner cooking grate Burner cap Wind Diverter Natural Gas Conversion Kit  1 1 - Return sideburner to shelf. Make sure burner engages sideburner valve. See illustration below for correct burner-to-valve engagement. Secure burner to shelf bracket with two screws, lock washers and flat washers. 13 Correct burn ...

  • Char-Broil 4984619 - page 12

    Sideburner cooking grate Burner cap Griddle Wind diverter 12  Natural Gas Conversion Kit 15 Sideburner Conversion (Outdoor Stove & Griddle) 6 - Open sideburner lid and remove the sideburner cooking griddle, burner cap and wind diverter . - Beneath sideburner shelf, remove the two screws, lock washers and flat washers that secure sideburner t ...

  • Char-Broil 4984619 - page 13

    Natural Gas Conversion Kit  13 Bezel V alve stem Orifice Orifice removal tool 80004378 Sideburner valve Sideburner control knob 17 6 - Using the provided orifice removal tool, unscrew the orifice from the end of the sideburner valve. Save removed orifice for converting back to LP T ank Gas. No replacement orifice is required. 5 18 - Pull the sid ...

  • Char-Broil 4984619 - page 14

    Sideburner cooking grate Burner cap Wind diverter Griddle 14  Natural Gas Conversion Kit Flat washer Lock washer Sideburner - Return sideburner to shelf. Make sure burner engages sideburner valve. See illustration below for correct burner-to-valve engagement. Secure burner to shelf bracket with two screws, lock washers and flat washers. 19 Corre ...

  • Char-Broil 4984619 - page 15

    Natural Gas Conversion Kit  15 21 Lock W asher Nut Screw 22 - Remove screws, washers, and nuts that secures Rotisserie Cover to back of grill Firebox. - Remove Rotisserie Cover , if applicable. Y our Grill may differ from illustration shown, it may not have a Rotisserie Cover . Flat W asher Rotisserie Cover Rotisserie Burner Conversion 6 - Using ...

  • Char-Broil 4984619 - page 16

    Natural Gas Conversion Kit  16 23 24 - Using Orifice Removal T ool provided with Kit, unscrew Orifice from Rotisserie Connector. Save Orifice for converting back to LP T ank Gas. - Replace with Natural Gas Orifice provided with this supplement and secure tightly to Rotisserie Connector . * Light Blue dot - 1.15mm Orifice Orifice Removal T ool *O ...

  • Char-Broil 4984619 - page 17

    Natural Gas Conversion Kit •17 EMERGENCIES: If a gas leak cannot be stopped, or a fire occurs due to gas leakage, call the fire department. Emergencies Gas leaking from cracked/cut/burned hose. Possible Cause • Damaged hose. Prevention/Solution • T urn off gas at at source. If anything but burned, replace parts. If burned, discontinue use of ...

  • Char-Broil 4984619 - page 18

    Natural Gas Conversion Kit  18 THIS P AGE INTENTIONALL Y LEFT BLANK ...

  • Char-Broil 4984619 - page 19

    Natural Gas Conversion Kit •19 THIS P AGE INTENTIONALL Y LEFT BLANK ...

  • Char-Broil 4984619 - page 20

     Columbus, GA 31902  Assembly Instructions © 2007  Char-Broil, LLC ® ...

Manufacturer Char-Broil Category Gas Heater

Documents that we receive from a manufacturer of a Char-Broil 4984619 can be divided into several groups. They are, among others:
- Char-Broil technical drawings
- 4984619 manuals
- Char-Broil product data sheets
- information booklets
- or energy labels Char-Broil 4984619
All of them are important, but the most important information from the point of view of use of the device are in the user manual Char-Broil 4984619.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Char-Broil 4984619, service manual, brief instructions and user manuals Char-Broil 4984619. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Char-Broil 4984619.

Similar manuals

A complete manual for the device Char-Broil 4984619, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Char-Broil 4984619 by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Char-Broil 4984619.

A complete Char-Broil manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Char-Broil 4984619 - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Char-Broil 4984619, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Char-Broil 4984619, that we can find in the current document
3. Tips how to use the basic functions of the device Char-Broil 4984619 - which should help us in our first steps of using Char-Broil 4984619
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Char-Broil 4984619
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Char-Broil 4984619 in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Char-Broil 4984619?

Use the form below

If you did not solve your problem by using a manual Char-Broil 4984619, ask a question using the form below. If a user had a similar problem with Char-Broil 4984619 it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)