English dropdown-ico

Manual Henny Penny DCW-2

18 pages 1.31 mb
Download

Go to site of 18

Summary
  • Henny Penny DCW-2 - page 1

    Henny Penny Display Counter Warmer Model DCW-2 OPERATOR’S MANUAL ...

  • Henny Penny DCW-2 - page 2

    ...

  • Henny Penny DCW-2 - page 3

    LIMITED WARRANTY FOR HENNY PENNY EQUIPMENT Subject to t he follo wing condi tions, He nny Penny Corporat ion makes the following limited warranties to the original purchaser only for Henny Penny appliances and replacement parts: NEW EQUIPMENT: Any pa rt of a new appliance, exc ept baskets, lamps, and fuses , which proves to be defecti ve in materia ...

  • Henny Penny DCW-2 - page 4

    TABLE OF CONTENTS Section Page Section 1. INTRODUCTION ........................................................................................................ 1 1-1. Heated Display Cabinet ...................................................................................... 1 1-2. Features.......................................................... ...

  • Henny Penny DCW-2 - page 5

    SECTION 1. INTRODUCTION 1-1. HEATED DISPLAY The Henny Penny Heated Display Cabinet is a basic unit of food CABINET processing equipment used to display the food product and maintain the temperature of hot foods in the comm ercial food service operation. This highly effi cient, quality-built cabinet will keep hot foods at pr oper holding temperature ...

  • Henny Penny DCW-2 - page 6

    CAUTION used without the safe ty alert symbol indicates a potentially hazardous situation which, if not avoided, may result in property damage. CAUTION indicates a potentially hazardous situation which, if not avoided, may result in minor or moderate injury. The word WARNING is used to alert you to a procedure, that if not performed properly, might ...

  • Henny Penny DCW-2 - page 7

    SECTION 2. INSTALLATION 2-1. INTRODUCTION This section provides the installa tion instructions for the Henny Penny Heated Display Cabinet. Installation of this unit should be performed only by a qualified service technician. Do not puncture the skin of the unit with drills or screw s as component damage or electrical shock could result. 2-2. UNPACK ...

  • Henny Penny DCW-2 - page 8

    2-2. UNPACKING (Continued) Step 2 2. Open top flaps and remove packing. Step 3 3. Lift carton off skid. Step 4 4. Remove four bolts from under skid. The unit is now ready for location and set-up. 4 ...

  • Henny Penny DCW-2 - page 9

    2-3. LOCATION Place the unit on a table, preferably with a cut-o ut opening below the cabinet to allow easy servic e connection s and serviceability. When setting up the Henny Penny Heated Display Cabinet, be sure to level the table. 2-4. ELECTRIC DATA TABLE Model Volts Phase Watts Amps DCW-2 120/230 1 760 4.7 2-5. LIGHT BULBS AND GLASS PANELS 1. C ...

  • Henny Penny DCW-2 - page 10

    2-6. CABINET DIMENSIONS 6 ...

  • Henny Penny DCW-2 - page 11

    SECTION 3. OPERAT ING INSTRUCTIONS 3-1. INTRODUCTION This section provides operating proc edures for the heated display cabinets. The Introduction, Inst allation and Operation sections should be read, and all instruc tions should be followed before operating the cabinet. 3-2. OPERATING CONTROLS Figures 3-1 through 3- ７ identify and describe the f ...

  • Henny Penny DCW-2 - page 12

    3-2. OPERATING CONTROLS (Continued) Figure 3-5 Figure 3-6 Figure 3-7 8 ...

  • Henny Penny DCW-2 - page 13

    3-2. OPERATING CONTROLS (Continued) Fig . No. Item No. Description Function 3-1 1 Radiant Heat A time proportioning controller, which means the higher Infinite Regulator the number setti ng, the greater percenta ge of time the Radiant heat will be on 3-1 2 Tubular Heat A time proportioning controller, which means the higher Infinite Regulator the n ...

  • Henny Penny DCW-2 - page 14

    3-3. START-UP Before using, the Henny Penny Heated Display Cabinet should be thoroughly cleaned as indicated in the Shut-Down and Cleanup section of this manual. 1. Move all switches and cont rols on th e cabinet to the OFF position. 2. Turn on power supply for the cabinet at the main circuit breaker. Step 2 3. Place the grids in the lower level. 4 ...

  • Henny Penny DCW-2 - page 15

    3-5. SHUT-DOWN AND CLEANUP 1. Turn the radiant heat to OFF 2. Open the doors. 3. Remove all the pans. 4. Remove the grids from the lower level and clean with soap and water at sink. Do not use steel wool, ot her abrasive cleaners or cleaners/sanitizers con taining chlorine, bromine, iodine or ammonia chemicals, as these will deteriorate the stainle ...

  • Henny Penny DCW-2 - page 16

    SECTION 4. TROUBLESHOOTING 4-1. TROUBLESHOOTING GUIDE PROBLEM CAUSE CORRECTION Product not hold ing z Doors are not kept closed z Product held too long z Temperature too low z Radiant heat too low z Light bulbs out z Keep doors closed when holding possible z Only hold product for recommended times z Turn to higher setting z Turn to higher setting z ...

  • Henny Penny DCW-2 - page 17

    G L O S S A R Y HENNY PENNY HO LDING CABI NETS air temperature probe a round devi ce located inside t he cabinet that measures the i nside air temperature an d sends that inf ormation to t he control panel concentration ring assembly a metal assembly located in the water pan in the bottom of the unit that helps keep an even humidity lev el inside t ...

  • Henny Penny DCW-2 - page 18

    parameters a preset group of setpoint s designed for h olding specific food products at certain temperature and humidity levels power switch the ON/OFF switch that sends electri city to the unit’s operating systems; this switch does not disconnect the electrical power from the wall to the unit pressure sprayer a device that shoots a stream of wat ...

Manufacturer Henny Penny Category Food Warmer

Documents that we receive from a manufacturer of a Henny Penny DCW-2 can be divided into several groups. They are, among others:
- Henny Penny technical drawings
- DCW-2 manuals
- Henny Penny product data sheets
- information booklets
- or energy labels Henny Penny DCW-2
All of them are important, but the most important information from the point of view of use of the device are in the user manual Henny Penny DCW-2.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Henny Penny DCW-2, service manual, brief instructions and user manuals Henny Penny DCW-2. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Henny Penny DCW-2.

Similar manuals

A complete manual for the device Henny Penny DCW-2, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Henny Penny DCW-2 by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Henny Penny DCW-2.

A complete Henny Penny manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Henny Penny DCW-2 - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Henny Penny DCW-2, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Henny Penny DCW-2, that we can find in the current document
3. Tips how to use the basic functions of the device Henny Penny DCW-2 - which should help us in our first steps of using Henny Penny DCW-2
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Henny Penny DCW-2
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Henny Penny DCW-2 in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Henny Penny DCW-2?

Use the form below

If you did not solve your problem by using a manual Henny Penny DCW-2, ask a question using the form below. If a user had a similar problem with Henny Penny DCW-2 it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)