English dropdown-ico

Manual Cal Flame LTR20091006

32 pages 5.94 mb
Download

Go to site of 32

Summary
  • Cal Flame LTR20091006 - page 1

    ...

  • Cal Flame LTR20091006 - page 2

    Copyright 2008-2009 LMS, Inc. All rights re- served. Duplication without writ ten consent is strictly prohibited. Cal Flame ® is a registered trademark. Due to continuous improvement programs, all models, operation, and/or specications are subject to change without prior notice. L TR20091006, R ev . B 3/30/09 Installation Location ............. ...

  • Cal Flame LTR20091006 - page 3

    Safety Instructions 1 2009 Fireplaces and Firepits L TR20091006, Rev . B w w w . c a l s p a s . c o m Most cities and counties require permits for exteri- or construction and electrical circuits. In addition, some communities have codes requiring residential barriers such as fencing and/or self -closing gates on property to prevent unsupervised ac ...

  • Cal Flame LTR20091006 - page 4

    2 Safety Instructions 2009 Fireplaces and Firepits L TR20091006, Rev . B w w w . c a l s p a s . c o m Do not block the vents located near the base of your repit or • replace as gas may build up in case of leak and cause serious damage. Do not install or operate your replace in such a manner that the • cross ventilation openings are bl ...

  • Cal Flame LTR20091006 - page 5

    Safety Instructions 3 2009 Fireplaces and Firepits L TR20091006, Rev . B w w w . c a l s p a s . c o m K eep all electrical supply cords away from the heated areas of the • replace or repit. Never use the replace or repit in windy conditions. If used in a • consistently windy area a windbreak will be required. Always ad- here to the ...

  • Cal Flame LTR20091006 - page 6

    4 Safety Instructions 2009 Fireplaces and Firepits L TR20091006, Rev . B w w w . c a l s p a s . c o m More frequent cleaning ma y be required as necessary . It is imper a- • tive the control compartment, burner and circulation air passage- ways of the appliance be k ept clean and free. Any guard or other protective device removed for servicing t ...

  • Cal Flame LTR20091006 - page 7

    Installation / Assembl y 5 2009 Fireplaces and Firepits L TR20091006, Rev . B w w w . c a l s p a s . c o m Installation must conform with local building and/or re codes, or in the absence of local codes: National Fuel Gas Code ANSI Z223.1 / INFPA 54 (for installation in • the United States) CSA B149.1 Natural Gas and CAN/CGA-BIL/9-2, Propane ...

  • Cal Flame LTR20091006 - page 8

    6 Installation / Assembl y 2009 Fireplaces and Firepits L TR20091006, Rev . B w w w . c a l s p a s . c o m Leak Testing Procedure Perf orm a leak test at least once a year whether the gas supply cylinder has been disconnected or not. In addition, whenever the gas cylinder is connected to the regulator or whenever any part of the gas system is disc ...

  • Cal Flame LTR20091006 - page 9

    Installation / Assembl y 7 2009 Fireplaces and Firepits L TR20091006, Rev . B w w w . c a l s p a s . c o m Liquid Propane (LP) Requirements The 20 lb LP gas supply cylinder used wi th LP models must be con- structed and marked in accordance with the specications for LP-gas cylinders as required by the U.S. Department of T ransportation (DOT) or ...

  • Cal Flame LTR20091006 - page 10

    8 Installation / Assembl y 2009 Fireplaces and Firepits L TR20091006, Rev . B w w w . c a l s p a s . c o m 2) Having at least two ventilation openings at cylinder valve level in the side wall, equally sized, spaced at 180 degrees (3.14 rad), and unobstructed. Make sure each opening has a total free area of not less then ½ square inch per pound (3 ...

  • Cal Flame LTR20091006 - page 11

    Installation / Assembl y 9 2009 Fireplaces and Firepits L TR20091006, Rev . B w w w . c a l s p a s . c o m Connection Inspect the hose shipped with the unit for damage. Never attempt to use damaged or plugged equipment. See your local LP gas dealer for repairs. After inspecting the LP hose shipped with the unit, connect the end with the female  ...

  • Cal Flame LTR20091006 - page 12

    10 Installation / Assembl y 2009 Fireplaces and Firepits L TR20091006, Rev . B w w w . c a l s p a s . c o m Natural Gas The appliance and its individual shut off v alve must be disconnected from the gas supply piping system during any pressure testing of the system at test pressures in excess of ½ psig (3.5kP a). This appliance must be isolated f ...

  • Cal Flame LTR20091006 - page 13

    Installation / Assembl y 11 2009 Fireplaces and Firepits L TR20091006, Rev . B w w w . c a l s p a s . c o m Fireplace Burner Installation This procedure describes how to access the gas lines for installation. Gas ins talla tion sho uld b e pe rfor med by a qual ied cont ract or. Slide the hearth base out of 1. the replace. Pull the gas ex ...

  • Cal Flame LTR20091006 - page 14

    12 Installation / Assembl y 2009 Fireplaces and Firepits L TR20091006, Rev . B w w w . c a l s p a s . c o m While holding the burner in 4. place, extend the wire from the burner to the sparker switch located on the right side of the replace. Con - nect the wire to the electric sparker . Slide the hearth base back 5. into the replace. ...

  • Cal Flame LTR20091006 - page 15

    Installation / Assembl y 13 2009 Fireplaces and Firepits L TR20091006, Rev . B w w w . c a l s p a s . c o m Fire Pit Burner Installation The log set and crushed lava rock are shipped together on applicable models. R emove the log set and un-pack all components. The logs are fragile -- use car e when handling. T urn the re pit on its side. Conne ...

  • Cal Flame LTR20091006 - page 16

    14 Installation / Assembl y 2009 Fireplaces and Firepits L TR20091006, Rev . B w w w . c a l s p a s . c o m Set the burner in the center of the pit. Place the rocks on top of and around the burner . Arrange the log set on top . ...

  • Cal Flame LTR20091006 - page 17

    Installation / Assembl y 15 2009 Fireplaces and Firepits L TR20091006, Rev . B w w w . c a l s p a s . c o m Fireplace Log Set Placement The log set, log grate and crushed lav a rock are shipped together on applicable models. Remove the log set and un-pack al l components. The logs are fr agile -- use care when handling. Once the replace is in p ...

  • Cal Flame LTR20091006 - page 18

    16 Installation / Assembl y 2009 Fireplaces and Firepits L TR20091006, Rev . B w w w . c a l s p a s . c o m “Fire on Ice” Glass Placement Some re pit owners have the “Fire on Ice” option which uses decora - tive glass chips instead of lava rocks and a log set. (This option is avail- able to all re pit owners and may be ordered direct ...

  • Cal Flame LTR20091006 - page 19

    Installation / Assembl y 17 2009 Fireplaces and Firepits L TR20091006, Rev . B w w w . c a l s p a s . c o m High Elevation Installation Y our replace or re pit is approved for elevations up to 4500 feet in the US and Canada. When installing this appliance at an elevation above 4500 feet in the US, i t may be necessary to decrease the input r ...

  • Cal Flame LTR20091006 - page 20

    18 Installation / Assembl y 2009 Fireplaces and Firepits L TR20091006, Rev . B w w w . c a l s p a s . c o m low a controlled amount of air ow through the screen and into the fuel supply tube. Flame should have good retention. For a proper burn and as a general rule, the air shutter for propane installation should be completely open, and the air ...

  • Cal Flame LTR20091006 - page 21

    Using Y our Grill 19 2009 Fireplaces and Firepits L TR20091006, Rev . B w w w . c a l s p a s . c o m WARNING: DO NOT use solid fuel, such as wood or charcoal, in gas fueled replaces or re pits. Upon completing the gas line connection, a small amount of air will be in the lines. When the rst lighting the burner , it wi ll take a few second ...

  • Cal Flame LTR20091006 - page 22

    20 Using Y our Grill 2009 Fireplaces and Firepits L TR20091006, Rev . B w w w . c a l s p a s . c o m Do not use this appliance if any part has been under water . Imme- • diately call a qualied service technician to inspect the appliance and replace any part of the control system and any gas control which has been under water . Make sure the i ...

  • Cal Flame LTR20091006 - page 23

    Using Y our Grill 21 2009 Fireplaces and Firepits L TR20091006, Rev . B w w w . c a l s p a s . c o m To Turn Off Gas T urn the ON/OFF valv e to the off position at the unit for natural gas unit. F or LP unit, turn the ON/OFF v alve to the OFF position at the unit and then turn the valv e on the LP tank to the OFF position clockwise. NOTE The propa ...

  • Cal Flame LTR20091006 - page 24

    22 Using Y our Grill 2009 Fireplaces and Firepits L TR20091006, Rev . B w w w . c a l s p a s . c o m Lighting Your Wood Burning Fireplace Y our wood burning replace is designed to use a grate to hold the wood to be burned approximately 2”-3” off the base. This allows air to get to the bottom of the wood and gives room for ash to accumulate. ...

  • Cal Flame LTR20091006 - page 25

    Cleaning and Maintenance 23 2009 Fireplaces and Firepits L TR20091006, Rev . B w w w . c a l s p a s . c o m Inspect the appliance before initial use. Clean the appliance at least annually and have it inspected by a qualied eld service person. Periodically remov e the logs and examine the burner . If the burner is dirty , clean it with a soft ...

  • Cal Flame LTR20091006 - page 26

    24 Appendix 2009 Fireplaces and Firepits L TR20091006, Rev . B w w w . c a l s p a s . c o m Replacement Parts Call 1-800-CAL-SPAS for any replacement parts not listed below. Be sure to have model name and number a vailable. Fireplace Parts 18” Log Set BBQ08000610 24” Log Set BBQ08000620 18” Grate BBQ08210650 Square Burner BBQ07210005 Rectang ...

  • Cal Flame LTR20091006 - page 27

    Appendix 25 2009 Fireplaces and Firepits L TR20091006, Rev . B w w w . c a l s p a s . c o m Firepit Parts NG Orice .125 BBQ04100077 Propane Orice #43 BBQ04100078 Replacement Crushed La va Rock Kit FP0100 Replacement Fire Pit Electronic I gniter FP0102 Replacement Fire Pit Gas Contr ol Knob FP0103 Replacement Fire Pit Propane Fuel Hose With R ...

  • Cal Flame LTR20091006 - page 28

    26 Appendix 2009 Fireplaces and Firepits L TR20091006, Rev . B w w w . c a l s p a s . c o m Specications Fireplace Specications LP Gas Natural Gas Max. Input BTU/ Hr 51,037 55,000 Orice Size #42 (0.0860) #26 (0.147) Manifold Pressure 10” W ater Column 7” W ater Column Maximum Gas Supply Pressure 11” W ater Column 7” W ater Column ...

  • Cal Flame LTR20091006 - page 29

    Appendix 27 2009 Fireplaces and Firepits L TR20091006, Rev . B w w w . c a l s p a s . c o m See your Cal Flame dealer f or a copy of the applicable w arranty , details and any questions you may hav e regarding the warr anty cover age on your re pit or replace. L.M.S. warr ants the re pits and replaces from defects in material and workm ...

  • Cal Flame LTR20091006 - page 30

    28 Appendix 2009 Fireplaces and Firepits L TR20091006, Rev . B w w w . c a l s p a s . c o m Neglect • The use of components not supplied with the appliance • The use of fuel other than those specied • W eather , including freezing damage, long periods of dampness, or • condensation Damaging chemical or cleaners • Parts installed f rom ...

  • Cal Flame LTR20091006 - page 31

    Appendix 29 2009 Fireplaces and Firepits L TR20091006, Rev . B w w w . c a l s p a s . c o m ...

  • Cal Flame LTR20091006 - page 32

    L TR20091006, Rev . B 3/30/09 CONTACT INFORMATION For customer service, please contact your authorized dealer immediately . If you need additional information and/or assistance, please contact: Customer Service Department 1462 East Ninth Street Pomona, CA 91766 T oll Free: 1-800-CAL -SPAS F ax: 1-909-629-3890 www.calspas.com ...

Manufacturer Cal Flame Category Outdoor Fireplace

Documents that we receive from a manufacturer of a Cal Flame LTR20091006 can be divided into several groups. They are, among others:
- Cal Flame technical drawings
- LTR20091006 manuals
- Cal Flame product data sheets
- information booklets
- or energy labels Cal Flame LTR20091006
All of them are important, but the most important information from the point of view of use of the device are in the user manual Cal Flame LTR20091006.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Cal Flame LTR20091006, service manual, brief instructions and user manuals Cal Flame LTR20091006. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Cal Flame LTR20091006.

Similar manuals

A complete manual for the device Cal Flame LTR20091006, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Cal Flame LTR20091006 by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Cal Flame LTR20091006.

A complete Cal Flame manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Cal Flame LTR20091006 - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Cal Flame LTR20091006, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Cal Flame LTR20091006, that we can find in the current document
3. Tips how to use the basic functions of the device Cal Flame LTR20091006 - which should help us in our first steps of using Cal Flame LTR20091006
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Cal Flame LTR20091006
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Cal Flame LTR20091006 in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Cal Flame LTR20091006?

Use the form below

If you did not solve your problem by using a manual Cal Flame LTR20091006, ask a question using the form below. If a user had a similar problem with Cal Flame LTR20091006 it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)