-
RedMax HEZ2450S - page 1
US-1 HEZ2450S/HEZ3050S U S OWNER 'S/ OPERA T OR'S MANUAL STICK EDGERS 115256926 (909) HEZ2450S HEZ3050S APPLICABLE SERIAL NUMBERS : DRIVE UNIT 90800101 and up ENGINE UNIT 90800101 and up W ARNING The engine exhaust from this product contains chemicals known to the State of California to cause cancer, birth defects or other reproductive ha ...
-
RedMax HEZ2450S - page 2
US-2 HEZ2450S/HEZ3050S SAFETY FIRST Instructions contained in warnings within this manual marked with a symbol concern critical points which must be taken into consideration to prevent possible serious bodily injury, and for this reason you are requested to read all such instructions carefully and follow them without fail. ■ WARNINGS IN THE MANUA ...
-
RedMax HEZ2450S - page 3
US-3 HEZ2450S/HEZ3050S U S 1. Parts location 1 2 3 4 5 6 7 8 9 10 11 12 13 1. Loop handle 2. Stop switch 3. Throttle cable 4. Throttle trigger 5. Blade guard 6. Blade 7. Wheel 8. Spark arrester 9. Starter knob 10. Fuel tank 11. Primer 12. Choke lever 13. Air cleaner cover 2. Specifications ■ HEZ2450S Overall size(LxWxH) ············· ...
-
RedMax HEZ2450S - page 4
US-4 HEZ2450S/HEZ3050S 3. W arning labels on the machine For safe operation and maintenance, symbols are carved in relief on the machine. According to these indications, please be careful not to take a mistake. (a) The port to refuel the "MIX GASOLINE" Position: FUEL TANK CAP (b) The direction to close the choke Position: AIR CLEANER COVE ...
-
RedMax HEZ2450S - page 5
US-5 HEZ2450S/HEZ3050S U S •A brushcutter or trimmer can be dangerous if used incorrectly or carelessly, and can cause serious or fatal injury to the operater or others. It is extremely important that you read and understand the contents of this Owner's manual. • Under no circumstances may the design of the machine be modified without the ...
-
RedMax HEZ2450S - page 6
US-6 HEZ2450S/HEZ3050S contain dangerous carbon monoxide. 10. Never to touch the spark plug or plug cord while the engine is in operation Doing so may result in being subjected to an electrical shock. 11.Never to touch the muffler, spark plug, other metallic parts of the engine or engine cover while the engine is in operation or immediately after s ...
-
RedMax HEZ2450S - page 7
US-7 HEZ2450S/HEZ3050S U S 5. For safe operation ■ Transport 1. Drain the fuel from the fuel tank before transporting or storing the product. 2. When hand-carrying the product, cover over the cutting part, lift up the product and carry it paying attention to the blade. 3. Secure the unit carefully to prevent movement when it is transported. 4. A ...
-
RedMax HEZ2450S - page 8
US-8 HEZ2450S/HEZ3050S 5. For safe operation lubricant, always be sure to use only RedMax products or products which have been certified by RedMax for use with the RedMax product. 5. In the event that any part must be replaced or any maintenance or repair work not described in this manual must be performed, please contact a representative from the ...
-
RedMax HEZ2450S - page 9
(B) (A) US-9 HEZ2450S/HEZ3050S U S 6. Set up ■ MOUNTING OTHER PARTS 1. Insert the driveshaft into the clutch drum, then attach the gearbox to the shaft tube as aligning the positioning holes and fasten the screw (A). Fasten the clamp bolt (B) firmly. (SE1) (A) Screw (B) Clamp bolt (B) Tightning Torque: 70~130 in-lb (8~15 N.m) 2. Install the handl ...
-
RedMax HEZ2450S - page 10
US-10 HEZ2450S/HEZ3050S 7. Fuel ■ FUEL • Gasoline is very flammable. Avoid smoking or bringing any flame or sparks near fuel. Make sure to stop the engine and allow it cool before refueling the unit. Select outdoor bare ground for fueling and move at least 10 ft (3 m) away from the fueling point before starting the engine. ■ GASOLINE REQUIREM ...
-
RedMax HEZ2450S - page 11
US-11 HEZ2450S/HEZ3050S U S 7. Fuel test standard has been discontinued by API in 1995 and it no longer exists. • Gasoline/Oil mixture Storage Recommendations Store your gasoline or gasoline/oil mixture in a cool dry area in a tightly sealed approved container to limit the entry of moisture and additional air (oxygen). Moisture and air cause the ...
-
RedMax HEZ2450S - page 12
US-12 HEZ2450S/HEZ3050S 8. Operation The RedMax stick edgers are designed for edging lawn in gardens, parks, roadsides and so on. Before starting the engine, take the operating position and adjust the handle position and the wheel height as necessary. ■ ADJUSTING WHEEL HEIGHT 1. Loosen the wing nut and change the wheel height to obtain desired cu ...
-
RedMax HEZ2450S - page 13
US-13 HEZ2450S/HEZ3050S U S 1. When restarting the engine immediately after stopping it, leave the choke open. 2. Overchoking can make the engine hard to start due to excess fuel. When the engine failed to start after several attempts, open the choke and repeat pulling the rope, or remove the spark plug and dry it. ■ STOPPING ENGINE (OP4) 1. Rele ...
-
RedMax HEZ2450S - page 14
Maintenance, replacement, or repair of the emission control device and systems may be performed by any non-road engine repair establishment or individual. • Always be sure to stop the engine before inspecting the stick edger for problems or performing maintenance. •N ever alter the stick edger or take the engine apart. •W hen replacing parts, ...
-
RedMax HEZ2450S - page 15
US-15 HEZ2450S/HEZ3050S U S • Make sure that the engine has stopped and is cool before performing any service to the machine. Contact with moving cutting head or hot muffler may result in a personal injury. ■ AIR FILTER • The air filter, if clogged, will reduce the engine performance. Check and clean the filter element. If the element is brok ...
-
RedMax HEZ2450S - page 16
US-16 HEZ2450S/HEZ3050S 9. Maintenance MA9 (1) (2) MA8 (1) (2) MA7 ■ BLADE (MA6) • Place the blade between holders (A) and (B) while locking the gear shaft by putting the bar, through the key holes on the holder (A) and the gearcase. Use the socket to tighten the blade mounting bolt. (1) Blade mounting bolt (Left-handed) Tightning Torque: 130~1 ...
-
RedMax HEZ2450S - page 17
US-17 HEZ2450S/HEZ3050S U S Case 1. Starting failure CHECK PROBABLE CAUSES ACTION fuel tank ➞ incorrect fuel ➞ drain it and with correct fuel fuel filter ➞ fuel filter is clogged ➞ clean carburetor adjustment screw ➞ out of normal range ➞ adjust to normal range sparking (no spark) ➞ spark plug is fouled/wet ➞ clean/dry ➞ plug gap ...
-
RedMax HEZ2450S - page 18
US-18 HEZ2450S/HEZ3050S The EPA (U.S. Environmental Protection Agency), CARB (California Air Resources Board), Environment Canada and RedMax are pleased to explain the emissions control system's warranty on your 2009 and later small off-road engine. In U.S. and Canada, new equipment that use small off-road engines must be designed, built, and ...
-
RedMax HEZ2450S - page 19
US-19 HEZ2450S/HEZ3050S U S warranty is warranted for the remaining warranty period. Any warranted part that is scheduled only for regular inspection in the maintenance schedule will be warranted for a period of two years. A statement in such written instructions to the effect of "repair or replace as necessary" will not reduce the period ...
Do you have a question concerning RedMax HEZ2450S?
Use the form below
If you did not solve your problem by using a manual RedMax HEZ2450S, ask a question using the form below. If a user had a similar problem with RedMax HEZ2450S it is likely that he will want to share the way to solve it.