English dropdown-ico

Manual Pentair MiniMax NT Heater

12 pages 0.47 mb
Download

Go to site of 12

Summary
  • Pentair MiniMax NT Heater - page 1

    Rev. B 1-20-04 1 P/N 472299 MiniMax ® NT Heater Digital Display T emperature Controller (DDTC) Installation Instructions Important Notice Attention Installer. This manual contains important information about the installation, operation and safe use of this product. This information should be given to the owner/operator of this equipment. Before in ...

  • Pentair MiniMax NT Heater - page 2

    P/N 472299 2 Rev. B 1-20-04 SECTION I. INST ALLA TION 1. Turn off the electrical power to the heater. 2. Open the heater’s right door. 3. Disconnect all wires from the 6800 Temperature Controller. 4. Remove the left and right doors from the heater if necessary. 5. Remove four screws on the cover of the 6800 Temperature Controller. 6. Remove the e ...

  • Pentair MiniMax NT Heater - page 3

    Rev. B 1-20-04 3 P/N 472299 Apply silicone between the gask et and front-mounting frame. Apply silicone between the gask et and rear-mounting frame. Secure DDTC cov er and rain shield by using six scre ws. Figure 2. Figure 3. ...

  • Pentair MiniMax NT Heater - page 4

    P/N 472299 4 Rev. B 1-20-04 GRN IGN MODULE IGNITOR HOT SURFACE BURNER GND VAL TH IGN L2 L1 IGN/240 MiniMax NT LN Dual Voltage W/DDTC Wiring Diagram ORG WHT GRN ORG RED THERMAL FUSE WHT BLU RED SWITCH WATER PRESSURE GAS VALVE RED WHT BLU RED HIGH LIMIT 115˚F 1 2 3 4 5 3 2 1 GRN AIR PRESS. SW. BLU RED WHT BLOCK TERM BLOCK TERM WHT WHT BLK WHT BLK WH ...

  • Pentair MiniMax NT Heater - page 5

    Rev. B 1-20-04 5 P/N 472299 GRN IGN MODULE IGNITOR HOT SURFACE BURNER GND VAL TH IGN L2 L1 IGN/240 MiniMax NT STD Dual Voltage W/DDTC Wiring Diagram ORG WHT GRN ORG RED THERMAL FUSE WHT BLU RED SWITCH WATER PRESSURE GAS VALVE RED WHT BLU RED HIGH LIMIT 115˚F 1 2 3 4 5 3 2 1 GRN AIR PRESS. SW. BLU RED WHT BLOCK TERM BLOCK TERM WHT WHT BLK WHT BLK O ...

  • Pentair MiniMax NT Heater - page 6

    P/N 472299 6 Rev. B 1-20-04 Figure 6. J1 DDTC WATER PRESSURE SWITCH MiniMax NT TSI w/DDTC WIRING DIAGRAM GY AIR PRESSURE SW. O BLOWER O J5 J6 J8 G COM NO R/W R BK/W BK O REMOTE CONTROL MANUAL FOR & INSTALLATION SEE OPERATION 150˚F W HIGH LIMITS O 115˚F R R BL JI0 TFUSE/HLMT/PRESS J4 24V J2 J7 J9 P9 J11 BK W BL GY O R BL Y O W W W IF ORIGINAL ...

  • Pentair MiniMax NT Heater - page 7

    Rev. B 1-20-04 7 P/N 472299 SECTION III. INTRODUCTION OF DDTC The DDTC board, shown in Figure 7, is a digital temperature controller capable of controlling the pool, spa or both to a minimum temperature of 65° F. (below 65° F. display reads "Off") and a maximum of 104° F. The DDTC board also functions as a system status indicator, usin ...

  • Pentair MiniMax NT Heater - page 8

    P/N 472299 8 Rev. B 1-20-04 SECTION IV . SET UP The MiniMax NT Heater comes from the factory preset with a pool temperature setting of 78° F. and a preset spa temperature of 100° F., and in the off mode setting. Once the power is turned on, the DDTC board will do a self diagnostic internal check, during this time the display will first read “ 8 ...

  • Pentair MiniMax NT Heater - page 9

    Rev. B 1-20-04 9 P/N 472299 • THERMOST A T This light is on when the thermostat contacts close, signaled by the water temperature falling below the set-point, calling for the heater to fire to maintain the desired water temperature. • HEA TING The heating light is on any time the thermostat has signaled a call for heat which initializes the ign ...

  • Pentair MiniMax NT Heater - page 10

    P/N 472299 10 Rev. B 1-20-04 NOTE: With this type of two-wire remote, with its own temperature sensors and system control, using the up arrows on the front of the DDTC, hold down the up arrow until you reach the maximum setting of 104° F., this allows the remote system thermostat to operate the heater at any set-point below 104° F., the heater th ...

  • Pentair MiniMax NT Heater - page 11

    Rev. B 1-20-04 11 P/N 472299 Figure 8. ...

  • Pentair MiniMax NT Heater - page 12

    P/N 472299 12 Rev. B 1-20-04 Pentair Pool Products 1620 Hawkins Ave., Sanford, NC 27330 • (919) 774-4151 10951 West Los Angeles Ave., Moorpark, CA 93021 • (805) 523-2400 SECTION X. MINIMAX NT HEA TER DDTC RETROFIT KIT PAR TS SAVE THESE INSTRUCTIONS. P/N Description Qt y . 072204 Wir e Ti e 2 471870 Wir e As sem bly , O r ange 2 472060 S ilicone ...

Manufacturer Pentair Category Water Heater

Documents that we receive from a manufacturer of a Pentair MiniMax NT Heater can be divided into several groups. They are, among others:
- Pentair technical drawings
- MiniMax NT Heater manuals
- Pentair product data sheets
- information booklets
- or energy labels Pentair MiniMax NT Heater
All of them are important, but the most important information from the point of view of use of the device are in the user manual Pentair MiniMax NT Heater.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Pentair MiniMax NT Heater, service manual, brief instructions and user manuals Pentair MiniMax NT Heater. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Pentair MiniMax NT Heater.

Similar manuals

A complete manual for the device Pentair MiniMax NT Heater, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Pentair MiniMax NT Heater by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Pentair MiniMax NT Heater.

A complete Pentair manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Pentair MiniMax NT Heater - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Pentair MiniMax NT Heater, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Pentair MiniMax NT Heater, that we can find in the current document
3. Tips how to use the basic functions of the device Pentair MiniMax NT Heater - which should help us in our first steps of using Pentair MiniMax NT Heater
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Pentair MiniMax NT Heater
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Pentair MiniMax NT Heater in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Pentair MiniMax NT Heater?

Use the form below

If you did not solve your problem by using a manual Pentair MiniMax NT Heater, ask a question using the form below. If a user had a similar problem with Pentair MiniMax NT Heater it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)