English dropdown-ico

Manual Char-Broil 10201595

16 pages 1.52 mb
Download

Go to site of 16

Summary
  • Char-Broil 10201595 - page 1

    Product Guide Model 10201595 T ools needed for assembly: Phillips Screwdriver Flat Head Screwdriver T wo adjustable wrenches Hammer FOR OUTDOOR USE ONL Y CA UTION: Read and follow all safety statements, assembly instructions, and use and care directions before attempting to assemble and cook. INST ALLER/ASSEMBLER: Leave this manual with consumer . ...

  • Char-Broil 10201595 - page 2

    D ANGER Safety Symbols The symbols and boxes shown below explain what each heading means. Read and follow all of the messages found throughout the manual. DANGER: Indicates an imminently hazardous situation which, if not avoided, will result in death or serious injury . WARNING W ARNING: Indicates an potentially hazardous situation which, if not av ...

  • Char-Broil 10201595 - page 3

    Page 3 1. Brush all interior surfaces including grills and grates with vegetable cooking oil. 2. Build a small fire on the fire grate, being sure not to lay coals against the walls. 3. Close door . (Position butterfly damper and smokestack damper approximately at one quarter open.) This burn should be sustained for at least two hours, the longer th ...

  • Char-Broil 10201595 - page 4

    Page 4 THE HEA T OF THE COALS seconds you can hold the palm of your hand 4 inches above the coals temperature range (Fº) visual cues HOT COALS 2 400 to 450 barely covered with gray ash; deep red glow MODERA TEL Y HOT 375 to 450 thin coating of gray ash; deep red glow MODERA TEL Y HOT COALS 4 325 to 375 significant coating of gray ash; red glow MOD ...

  • Char-Broil 10201595 - page 5

    Page 5 GRILL MAINTENANCE Frequency of cleanup is determined by how much your smoker is used. Make sure coals are completely extinguished before cleaning inside of smoker . Inside surfaces may be cleaned with a strong solution of detergent and water applied with a scrub brush. Thoroughly rinse with water and allow to air dry before using again. HELP ...

  • Char-Broil 10201595 - page 6

    This warranty only applies to units purchased from an authorized retailer . Manufacturer warrants to the original consumer -purchaser only that this product shall be free from defects in workmanship and materials after correct assembly and under normal and reasonable home use for the periods indicated below beginning on the date of purchase*. The m ...

  • Char-Broil 10201595 - page 7

    P ARTS LIST Page 7 Key Qty Description 17 1 Firebox Cook Grate 18 2 Wheel 19 1 Firebox Bottom 20 2 Leg Support T ube 21 2 Leg With End Caps 22 2 Leg For Wheels 23 2 Leg Brace 24 1 Firebox Door 25 2 Hinges for Firebox Door 26 1 Damper Door — 1 Hardware Pack --- 1 Assembly Instructions, English — 1 Assembly Instructions, Spanish Key Qty Descripti ...

  • Char-Broil 10201595 - page 8

    2 1 ASSEMBL Y Page 8 2 1 FIRST , GET A HELPER! This unit is heavy and requires a second person for lifting and moving. NEXT , pick a suitable location to work. Open the carton and slit the corners so that the carton lays flat. This will give you a protective surface during assembly . Smoker Chamber Leg Supports 1/4 - 20 Flange Nut 1/4-20 Flange Nut ...

  • Char-Broil 10201595 - page 9

    3 4 Axle Wheel Hitch Pin Firebox Lid Firebox Bottom Figure A Figure B Axle Hitch Pin Hitch Pin Wheel Legs with holes • Slide axle into holes at ends of legs (legs without end caps). • Attach wheels onto axle rod using hitch pins. Hitch pins insert through hole in axle as shown in box A. Check to be sure that all screws and nuts used so far are ...

  • Char-Broil 10201595 - page 10

    Page 10 5 • Place unit in upright position. • Attach small hinge half to smoker chamber using two #10-24 X 1/2” screws and two #10-24 flange nuts for each hinge half. Install screws from inside the smoker chamber . • Attach large hinge half to smoker chamber lid using two #10- 24 X 1/2” screws and two #10-24 flange nuts for each hinge hal ...

  • Char-Broil 10201595 - page 11

    Page 1 1 7 NOTE: The temperature gauge may be packed inside of the smokestack to prevent damage during shipping. If so, remove gauge before assembling smokestack to chamber . • Place fiber washers on handle rods. • Place the handle assembly into the holes on the front of the smoker chamber door and secure with two 1/4-20 flange nuts. • Repeat ...

  • Char-Broil 10201595 - page 12

    10 Page 12 9 • Attach shelf support to side of smoker chamber with one #10-24 X 1/2” machine screw where screw is going through inside of chamber through hole of support and secured with one #10-24 flange nut. • Lay side shelf on top of other end of shelf support so that it fits inside holding bracket. • Secure side shelf to smoker chamber ...

  • Char-Broil 10201595 - page 13

    12 11 Page 13 The assembly is completed. • Place two Smoker Chamber Cooking Grates into the smoker chamber . • Place the Firebox Cook Grate into the Firebox. Smoker Chamber Firebox Firebox Cook Grate Smoker Chamber Cook Grates • Hang the grease clip under the smoker chamber on right side. • An empty soup can is recommended to hang from grea ...

  • Char-Broil 10201595 - page 14

    HARD WARE LIST Y ou may have spare hardware after assembly is complete. Page 14 Hinge Pin Qty . 2 Qty . 4 Hair Pin Clip Logo Clip Qty . 2 #6-32 X 3/8” Machine Screw Qty . 8 #10-24 x 1/2” Machine Screw Qty . 21 1/4-20 X 1-3/4” Machine Screw Qty . 12 Fiber W asher Qty . 4 1/4-20 Flange Nut Qty . 18 #10-24 Flange Nut Qty . 21 Hardware not shown ...

  • Char-Broil 10201595 - page 15

    ...

  • Char-Broil 10201595 - page 16

    REGTEMP REV02 W arranty Registration Department P .O. Box 1240 Columbus, GA 31902-1240 ...

Manufacturer Char-Broil Category Charcoal Grill

Documents that we receive from a manufacturer of a Char-Broil 10201595 can be divided into several groups. They are, among others:
- Char-Broil technical drawings
- 10201595 manuals
- Char-Broil product data sheets
- information booklets
- or energy labels Char-Broil 10201595
All of them are important, but the most important information from the point of view of use of the device are in the user manual Char-Broil 10201595.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Char-Broil 10201595, service manual, brief instructions and user manuals Char-Broil 10201595. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Char-Broil 10201595.

Similar manuals

A complete manual for the device Char-Broil 10201595, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Char-Broil 10201595 by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Char-Broil 10201595.

A complete Char-Broil manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Char-Broil 10201595 - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Char-Broil 10201595, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Char-Broil 10201595, that we can find in the current document
3. Tips how to use the basic functions of the device Char-Broil 10201595 - which should help us in our first steps of using Char-Broil 10201595
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Char-Broil 10201595
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Char-Broil 10201595 in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Char-Broil 10201595?

Use the form below

If you did not solve your problem by using a manual Char-Broil 10201595, ask a question using the form below. If a user had a similar problem with Char-Broil 10201595 it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)