English dropdown-ico

Manual Weber S-440

28 pages 4.26 mb
Download

Go to site of 28

Summary
  • Weber S-440 - page 1

    43165 US 01/30/07 LP G AS GRILL B uilt-In LP Gas Grill Installa tio n Guid e #43165 S-440 S-640 YOU MUST READ THIS O WNER’S GUIDE BEF ORE OPERA TING YOUR G A S GRILL  DANGER If you smell gas: 1. Shut off gas to the appliance. 2. Extinguish any open fl ames. 3. Open lid. 4. If odor continues, keep away from the appliance and immediately call y ...

  • Weber S-440 - page 2

    2 WWW . WEBER.COM ® LOC A TING YOUR GRILL When determining a suitable location for your Summit ® gas grill installation, give attention to concerns such as exposure to wind, proximity to traffi c paths, and keeping any gas supply lines as short as possible. Never locate the Summit ® gas grill in a garage, breezeway , shed, under an unprotected ...

  • Weber S-440 - page 3

    3 WWW . WEBER.COM ® 3 1 6 7 8 5 3 2 4 a c d b 1 1 1 3 2 b GENERAL CONSTRUCTION DET AILS Summit ® Built-In unit and all other accessory units should be on site before construction begins. All dimensions have a tolerance of plus or minus (+/-) 1 / 4 inch (6.35 mm). The grill frame rests directly on the Island Structure top fi nished surface. Make ...

  • Weber S-440 - page 4

    4 WWW . WEBER.COM ® OR S-440 S-640 Lid - 1 Cookbox - 1 Lid - 1 Cookbox - 1 Front Frame Rail - 1 Rear Frame Rail - 1 Rear Panel Assembly - 1 Bottom Shelf - 1 Left Door - 1 Right Door - 1 W arming Rack - 1 Right Enclosure Panel - 1 Left Enclosure Panel - 1 Front V ent Panel - 1 Rear V ent - 1 P ARTS LIST ...

  • Weber S-440 - page 5

    5 WWW . WEBER.COM ® 5 S-440 S-640 S-440 S-640 Flavorizer® Bars - 8 - 12 Stainless Steel Cooking Grates - 2 - 3 Collection T ray - 1 Catch-Pan Holder - 1 Catch-Pan - 1 Disposable Drip Pans - 2 Hinge Pin- 2 Hair Pin Cotter- 2 Corrugated gas line - 1 Right Front V ent Clip - 1 Left Front V ent Clip - 1 7/16 inch Wrench - 1 #10 Sheet Metal Screws - 5 ...

  • Weber S-440 - page 6

    6 WWW . WEBER.COM ® 1 1 2 2 3 1 2 Arrow stickers on Frame Rail (1) and Left Side Panel (2) should point toward each other (shown above). Door Stop Bracket (3) should be positioned as shown (left). ASSEMBL Y ...

  • Weber S-440 - page 7

    7 WWW . WEBER.COM ® 7 3  A TTENTION! Do not fully tighten screws. Clips should slide freely when installed. 4 ASSEMBL Y ...

  • Weber S-440 - page 8

    8 WWW . WEBER.COM ® 5 6 Back ASSEMBL Y ...

  • Weber S-440 - page 9

    9 WWW . WEBER.COM ® 9 7 ASSEMBL Y ...

  • Weber S-440 - page 10

    10 WWW . WEBER.COM ®  CAUTION: Use two people to lift and install the Summit ® Built-In frame assembly . A.) Lift the frame assembly into the “island” structure opening. Make sure the frame is resting level on the fi nished surface of the structure. B.) Adjust the Front V ent to rest squarely on ground. 8 B . A . 1 1 1 1 1 1 a a b CLEARAN ...

  • Weber S-440 - page 11

    11 WWW . WEBER.COM ® 11 9 10 C . (1) S440 S640 C.) Apply a bead of silicone sealant (1) around the perimeter and front edges of the grill that are in contact with the “island” structure. This will prevent moisture seepage. The sealant you use must have a temperature rating above 120°F (48.8° C). 1/4” (6.35 mm) Drill Bit ASSEMBL Y ...

  • Weber S-440 - page 12

    12 WWW . WEBER.COM ® F)'# S440 11 (1) (3) (2) 12 ASSEMBL Y ...

  • Weber S-440 - page 13

    13 WWW . WEBER.COM ® 13 S640 S440 13 14 (1) (2) S640 S440 ASSEMBL Y ...

  • Weber S-440 - page 14

    14 WWW . WEBER.COM ® S640 S440 a b c 15 Match Holder ASSEMBL Y ...

  • Weber S-440 - page 15

    15 WWW . WEBER.COM ® 15 S640 S440 16 17 1/4” (6.35 mm) Drill Bit ASSEMBL Y ...

  • Weber S-440 - page 16

    16 WWW . WEBER.COM ® S640 S440 18 19 20 S440 S640 S640 S440 ASSEMBL Y ...

  • Weber S-440 - page 17

    17 WWW . WEBER.COM ® 17 ASSEMBL Y 21 S640 S440  ...

  • Weber S-440 - page 18

    18 WWW . WEBER.COM ® (1) (2) (3) 22 S-440 S-640 ASSEMBL Y ...

  • Weber S-440 - page 19

    19 WWW . WEBER.COM ® 19 + AAA + AAA + AAA a 23 - 1 S-440 S-640 - 2 - 2 S-440 S-640 - 4 S-640 The Weber Grill Out ™ Handle Light has a “T ilt Sensor”: Lid up - ON / Lid Closed - OFF . The power button (a) activates or deactivates the “T ilt Sensor .” For daytime use, deactivate the sensor by pressing power button (a) . ASSEMBL Y ...

  • Weber S-440 - page 20

    20 WWW . WEBER.COM ® T able 10-1 Maximum Capacity of Pipe in Cubic Feet of Gas per Hour for Gas Pressures of 0.5 psi or Less and a Pressure Drop of 0.3 Inch W ater Column. (Based on a 0.60 Specifi c Gravity Gas) Nominal Iron Pipe Size (Inches) Internal Diameter (Inches) Length of Pipe (Feet) 10 20 30 40 50 60 70 80 90 100 125 150 175 200 1/4 .364 ...

  • Weber S-440 - page 21

    21 WWW . WEBER.COM ® 21 GAS LINE PIPING • Refer to the piping chart at the bottom of previous page. • The corrugated gas line from the manifold is 58 inches (1,473.2 mm) long. Do not extend the gas line. • We have provided the means to make an SAE 45° fl are connection. Do not use pipe sealant on this connection. • If the length of line ...

  • Weber S-440 - page 22

    22 WWW . WEBER.COM ® OPERA TING  W ARNING: Only use the Weber ® T ank Enclosure Kit outdoors in a well-ventilated area. Do not use in a garage, building, breezeway or any other enclosed area.  W ARNING: Y our Weber ® T ank Enclosure Kit shall not be used under an unprotected combustible roof or overhang.  W ARNING: Y our Weber ® T ank ...

  • Weber S-440 - page 23

    23 WWW . WEBER.COM ® 23 LOC A TING YOUR LP T ANK ENCL OSURE KIT When determining a suitable location for your LP T ank Enclosure Kit installation, give attention to concerns such as proximity to traffi c paths, and keeping any gas supply lines as short as possible. Never locate the Summit ® LP T ank Enclosure Kit in a garage, breezeway , shed, u ...

  • Weber S-440 - page 24

    24 WWW . WEBER.COM ® 4 8 4 1 2 4 2 2 P ARTS LIST 2 Hose and regulator - 1 T ank stand - 1 T ank stand base - 1 T ank Scale - 1 1/4-20 nut - 6 Nylon washer - 12 1/4-20 x 1/2” bolt - 6 Cylinder glide - 2 1/2” Flare Gasket - 2 3/8” Flare Gasket - 2 P ARTS LIST / ASSEMBL Y ...

  • Weber S-440 - page 25

    25 WWW . WEBER.COM ® 25 MOUNTING THE LP T ANK BRACKET Mount the LP tank bracket to the right hand side of the enclosure opening using non corrosive hardware. Mounting holes are provided on the sides and bottom of your LP tank bracket. Be sure to mount the bracket securley to the enclosure before use. MOUNTING HARDW ARE NOT INCL UDED. MOUNTING THE ...

  • Weber S-440 - page 26

    26 WWW . WEBER.COM ® A B C D E i ii iii iv v CONNEC T GAS SUPPL Y A 58 inch (1,473.2 mm) corrugated gas line is supplied with the grill. This line needs to pass through the gas inlet opening to the main gas supply . 1) Connect the corrugated gas line to the manifold located on the right hand side of grill under the control panel. Use the 1/2” ? ...

  • Weber S-440 - page 27

    27 WWW . WEBER.COM ® 27 VENTILA TION  W ARNING: Air holes must be provided in the structure at the top and bottom to provide ventilation in the event of a gas leak. Air holes can be located in a low visibility area and should be protected by screening material to prevent rodents and insects from entering the structure. Air holes will also help ...

  • Weber S-440 - page 28

    ©2007 The following trademarks are registered in the name of W eber-Stephen Products Co., an Illinois corporation, located at 200 East Daniels Road, Palatine, Illinois 60067 U.S.A. Australia; Smokey Joe, Weber , Kettle Silhouette ® , Genesis, Austria; Kettle Silhouette ® , Smokey Joe, Weber , Benelux; Kettle Silhouette ® , Smokey Joe, Weber , C ...

Manufacturer Weber Category Gas Grill

Documents that we receive from a manufacturer of a Weber S-440 can be divided into several groups. They are, among others:
- Weber technical drawings
- S-440 manuals
- Weber product data sheets
- information booklets
- or energy labels Weber S-440
All of them are important, but the most important information from the point of view of use of the device are in the user manual Weber S-440.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Weber S-440, service manual, brief instructions and user manuals Weber S-440. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Weber S-440.

Similar manuals

A complete manual for the device Weber S-440, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Weber S-440 by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Weber S-440.

A complete Weber manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Weber S-440 - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Weber S-440, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Weber S-440, that we can find in the current document
3. Tips how to use the basic functions of the device Weber S-440 - which should help us in our first steps of using Weber S-440
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Weber S-440
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Weber S-440 in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Weber S-440?

Use the form below

If you did not solve your problem by using a manual Weber S-440, ask a question using the form below. If a user had a similar problem with Weber S-440 it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)