English dropdown-ico

Manual Desa Tech CDVBNC

40 pages 4.47 mb
Download

Go to site of 40

Summary
  • Desa Tech CDVBNC - page 1

    For more information, visit www.desatech.com For more information, visit www.desatech.com CAST IRON STOVE AND DIRECT -VENT (FREEST ANDING FIREPLACE HEA TER) BURNER SYSTEM OWNER’S OPERATION AND INSTALLATION MANUAL WARNING: Improper instal- lation, adjustment, alteration, service, or maintenance can cause injury or property dam- age. Refer to this ...

  • Desa Tech CDVBNC - page 2

    105501-01G For more information, visit www.desatech.com For more information, visit www.desatech.com 2 SAFETY INFORMA TION WARNINGS TABLE OF CONTENTS SAFETY INFORMATION IMPORTANT: Read this owner’s manual carefully and completely before trying to assemble, operate, or service this stove and burner system. Improper use of this stove and burner sys ...

  • Desa Tech CDVBNC - page 3

    105501-01G For more information, visit www.desatech.com For more information, visit www.desatech.com 3 3 SAFETY INFORMA TION Continued 5. This stove reaches high temperatures. Keep children and adults away from hot surfaces to avoid burns or clothing ignition. Stove will remain hot for a time after shutdown. Allow sur- faces to cool before touching ...

  • Desa Tech CDVBNC - page 4

    105501-01G For more information, visit www.desatech.com For more information, visit www.desatech.com 4 PRODUCT FEA TURES OPERATION This cast iron stove with burner system is clean burning and vents easily through outside walls or vertically using outside air for combustion. Heat is generated by both realistic flames and glowing embers. When used wi ...

  • Desa Tech CDVBNC - page 5

    105501-01G For more information, visit www.desatech.com For more information, visit www.desatech.com 5 5 PRE-INSTALLATION PREPARATION Location and Space Requirements (Cont.) 6 " 4 " Front 4" 36" from Front 42" Ceiling Floor Back Wall Figure 3 - Clearances for Standard Installation 29" Must contain a minimum of 1" ...

  • Desa Tech CDVBNC - page 6

    105501-01G For more information, visit www.desatech.com For more information, visit www.desatech.com 6 STOVE BODY ASSEMBLY 1. Lift off corrugated box enclosing stove body crating. 2. Remove all screws fastening the wood frame enclosure. Spread wood frame open and lift away from plastic-bagged stove body . The bottom pieces of pallet wood will remai ...

  • Desa Tech CDVBNC - page 7

    105501-01G For more information, visit www.desatech.com For more information, visit www.desatech.com 7 7 10. Install door catch bolt (M8 x 1.25-55mm with two M8 hex nuts) into threaded hole on stove body (see Figure 9, page 6). Use an adjustable wrench or a 12mm socket. The catch bolt has two hex nuts attached to it (see Figure 12). The top nut is ...

  • Desa Tech CDVBNC - page 8

    105501-01G For more information, visit www.desatech.com For more information, visit www.desatech.com 8 INSTALLING OPTIONAL BLOWER ACCESSORY NOTICE: If installing blower in an existing stove with burner system with gas connections, shut off gas supply and disconnect burner system from gas sup- ply. Contact a qualified service person to do this. Atta ...

  • Desa Tech CDVBNC - page 9

    105501-01G For more information, visit www.desatech.com For more information, visit www.desatech.com 9 9 WARNING: Failure to position the parts in accor- dance with supplied diagrams or failure to use only parts specifically approved with this stove and burner system may result in damage or personal injury. WARNING: A qualified service person must ...

  • Desa Tech CDVBNC - page 10

    105501-01G For more information, visit www.desatech.com For more information, visit www.desatech.com 10 Fixed Closed Openable Fixed Closed Openable V V V V V V V V X X V X G G J F B B K N H I A N E L D B M A C B V V A G G B TERMINA TION CAP AIR SUPPL Y INLET GAS METER RESTRICTED AREA (TERMINA TION PROHIBITED) A = clearance above grade, veranda, por ...

  • Desa Tech CDVBNC - page 11

    105501-01G For more information, visit www.desatech.com For more information, visit www.desatech.com 11 11 WARNING: Read all instructions completely and thoroughly before attempting installation. Failure to do so could result in serious injury, property damage or loss of life. Operation of improperly installed and maintained venting system could re ...

  • Desa Tech CDVBNC - page 12

    105501-01G For more information, visit www.desatech.com For more information, visit www.desatech.com 12 VENTING INST ALLA TION Continued NOTICE: Treatment of firestops and construction of the chase may vary from building type to building type. These instructions are not substitutes for the requirements of local building codes. You must fol- low all ...

  • Desa Tech CDVBNC - page 13

    105501-01G For more information, visit www.desatech.com For more information, visit www.desatech.com 13 13 VENTING INST ALLA TION Continued WARNING: Do not recess vent termination in to any wall. This will cause a fire hazard. 3. Attach vent pipe assembly to the fireplace. Set fireplace in front of it’ s permanent location to insure minimum clear ...

  • Desa Tech CDVBNC - page 14

    105501-01G For more information, visit www.desatech.com For more information, visit www.desatech.com 14 Horizontal Termination Configurations Figures 25 through 28 show different configurations for venting with horizontal termination. Each figure includes a chart with vertical minimum/maximum and horizontal maximum dimensions which must be met. Sea ...

  • Desa Tech CDVBNC - page 15

    105501-01G For more information, visit www.desatech.com For more information, visit www.desatech.com 15 15 VENTING INST ALLA TION Continued INSTALLATION FOR VERTICAL TERMINATION NOTICE: Use rigid pipe only. Flex venting is not to be used with a vertical termination. Figure 29 - Offset with Wall Strap and 45 ° Elbows 45 ° Elbow Wall Strap Roof Fla ...

  • Desa Tech CDVBNC - page 16

    105501-01G For more information, visit www.desatech.com For more information, visit www.desatech.com 16 Cathedral Ceiling Installation 1. Remove shingles or other roof covering as necessary to cut the rectangular hole for the support box. Mark the outline of the cathedral ceiling support box on the roof sheathing using the locating hole as a center ...

  • Desa Tech CDVBNC - page 17

    105501-01G For more information, visit www.desatech.com For more information, visit www.desatech.com 17 17 V enting with T wo 9 0 ° E lbows V ertical (V 1 ) Horizontal (H) 5' min. 6' max. 6' min. 12' max. 7' min. 18' max. 8' min. 20' max. Note: V ertical (V 1 ) + V ertical (V 2 ) = 20' max. Figure 35 - ...

  • Desa Tech CDVBNC - page 18

    105501-01G For more information, visit www.desatech.com For more information, visit www.desatech.com 18 STOVE AND DIRECT-VENT BURNER SYSTEM INSTALLATION Check Gas Type Installing Gas Piping To Stove/Burner System Location STOVE AND DIRECT -VENT BURNER SYSTEM INST ALLA TION INSTALLING GAS PIPING TO STOVE/ BURNER SYSTEM LOCATION Installation Items Ne ...

  • Desa Tech CDVBNC - page 19

    105501-01G For more information, visit www.desatech.com For more information, visit www.desatech.com 19 19 We recommend that you install a sediment trap in supply line as shown in Figure 38. Locate sediment trap where it is within reach for cleaning. Install in piping system between fuel supply and burner system. Locate sediment trap where trapped ...

  • Desa Tech CDVBNC - page 20

    105501-01G For more information, visit www.desatech.com For more information, visit www.desatech.com 20 STOVE AND DIRECT-VENT BURNER SYSTEM INSTALLATION Checking Gas Connections (Cont.) STOVE AND DIRECT -VENT BURNER SYSTEM INST ALLA TION Continued Test Pressures Equal To or Less Than 1/2 PSIG (3.5 kPa) 1. Close equipment shutoff valve (see Figure 4 ...

  • Desa Tech CDVBNC - page 21

    105501-01G For more information, visit www.desatech.com For more information, visit www.desatech.com 21 21 INSTALLING OPTIONAL WIRELESS HAND- HELD REMOTE CONTROL ACCESSORIES - CGHRC AND CGHRCTA SERIES Installing Remote Receiver 1. Open bottom door on stove body and locate the switch plate on the left of the valve bracket. 2. Unscrew switch plate (s ...

  • Desa Tech CDVBNC - page 22

    105501-01G For more information, visit www.desatech.com For more information, visit www.desatech.com 22 Figure 48 - Removing Front Panel from Stove Bolt Bolt Stove Front Panel Figure 49 - Removing Glass Door from Burner System Insert Screw Glass Door STOVE AND DIRECT -VENT BURNER SYSTEM INST ALLA TION Continued Each log is marked with a number. The ...

  • Desa Tech CDVBNC - page 23

    105501-01G For more information, visit www.desatech.com For more information, visit www.desatech.com 23 23 WARNING: The glass door must be securely in place before running this burner system. Do not run this burner system if glass is missing or broken. STOVE AND DIRECT -VENT BURNER SYSTEM INST ALLA TION Continued STOVE AND DIRECT-VENT BURNER SYSTEM ...

  • Desa Tech CDVBNC - page 24

    105501-01G For more information, visit www.desatech.com For more information, visit www.desatech.com 24 9. Push in gas control knob all the way and hold. Immedi- ately light the pilot by repeatedly depr essing the piezo spar k ignitor until a flame appears. Continue to hold for about one (1) minute after the pilot is lit. Release gas contr ol knob ...

  • Desa Tech CDVBNC - page 25

    105501-01G For more information, visit www.desatech.com For more information, visit www.desatech.com 25 25 CGHRC Series Operation: 2a. Press the ON/OFF b utton to turn the b urners on and off. When turning b urners off , the pilot will remain lit. CGHRCTA Series Operation: 2b . Press the A UTO/ON/OFF b utton on the hand-held r emote control (see Fi ...

  • Desa Tech CDVBNC - page 26

    105501-01G For more information, visit www.desatech.com For more information, visit www.desatech.com 26 OPERATING STOVE WITH BURNER SYSTEM Operating Optional GWMT1 Wall Mounted Thermostat INSPECTING BURNERS Pilot Assembly Burner Flame Pattern OPERA TING STOVE WITH BURNER SYSTEM Continued OPERATING OPTIONAL GWMT1 WALL MOUNTED THERMOSTAT Light the bu ...

  • Desa Tech CDVBNC - page 27

    105501-01G For more information, visit www.desatech.com For more information, visit www.desatech.com 27 27 CLEANING AND MAINTENANCE WARNING: Turn off burner system and let cool before cleaning. CAUTION: You must keep control areas, burners, and circulating air passageways of burner system and stove clean. Inspect these areas of burner sys- tem and ...

  • Desa Tech CDVBNC - page 28

    105501-01G For more information, visit www.desatech.com For more information, visit www.desatech.com 28 TROUBLESHOOTING Note: All troubleshooting items are listed in order of operation. WARNING: Turn off burner sys- tem and let cool before servicing. Only a qualified service person should ser- vice and repair burner system or stove. CAUTION: Never ...

  • Desa Tech CDVBNC - page 29

    105501-01G For more information, visit www.desatech.com For more information, visit www.desatech.com 29 29 TROUBLESHOOTING OBSERVED PROBLEM Burner does not light after pilot is lit Delayed ignition burner Burner backfiring during combustion Slight smoke or odor during initial operation Burner system produces a whistling noise when burner is lit Gla ...

  • Desa Tech CDVBNC - page 30

    105501-01G For more information, visit www.desatech.com For more information, visit www.desatech.com 30 TROUBLESHOOTING TROUBLESHOOTING Continued WARNING: If you smell gas • Shut off gas supply. • Do not try to light any appliance. • Do not touch any electrical switch; do not use any phone in your building. • Immediately call your gas suppl ...

  • Desa Tech CDVBNC - page 31

    105501-01G For more information, visit www.desatech.com For more information, visit www.desatech.com 31 31 WIRING DIAGRAM CAUTION: Label all wires prior to disconnection when servicing controls. Wiring errors can cause improper and dangerous operation. Verify proper operation after servicing. Figure 60 - Blower Wiring Diagram for Thermostat-Control ...

  • Desa Tech CDVBNC - page 32

    105501-01G For more information, visit www.desatech.com For more information, visit www.desatech.com 32 ILLUSTRA TED P AR TS BREAKDOWN MODELS CDVBNC AND CDVBPC TPTH TPTH TP TP TH TH 27 19 20 21 23 29 30 4 25 1 2 4 7 8 9 10 11 13 12 31 16 17 18 22 4 5 32 3 24 26-1 26-4 26-2 26-3 28 28 15 22 14 6 ILLUSTRATED PARTS BREAKDOWN Models CDVBNC and CDVBPC ...

  • Desa Tech CDVBNC - page 33

    105501-01G For more information, visit www.desatech.com For more information, visit www.desatech.com 33 33 P AR TS LIST MODELS CDVBNC AND CDVBPC This list contains replaceable parts used in your burner system. When ordering parts, follow the instructions listed under Replace- ment Parts on page 31 of this manual. KEY NO. PART NUMBER DESCRIPTION QTY ...

  • Desa Tech CDVBNC - page 34

    105501-01G For more information, visit www.desatech.com For more information, visit www.desatech.com 34 ILLUSTRA TED P AR TS BREAKDOWN STOVE CHASSIS MODELS CISC AND CISG 1 4 6 4 5-4 5-1 5-2 3 5-3 5-4 2 ILLUSTRATED PARTS BREAKDOWN Models CISC and CISG ...

  • Desa Tech CDVBNC - page 35

    105501-01G For more information, visit www.desatech.com For more information, visit www.desatech.com 35 35 P AR TS LIST MODELS CISC AND CISG This list contains replaceable parts used in your stove. When ordering parts, follow the instructions listed under Replacement Parts on page 31 of this manual. * Included In Hardware Kit KEY PART NO. NO. DESCR ...

  • Desa Tech CDVBNC - page 36

    105501-01G For more information, visit www.desatech.com For more information, visit www.desatech.com 36 SER VICE HINTS When Gas Pressure Is Too Low • pilot will not stay lit • burners will have delayed ignition • burner system will not produce specified heat • propane/LP gas supply might be low (propane/LP units only) If you feel your gas p ...

  • Desa Tech CDVBNC - page 37

    105501-01G For more information, visit www.desatech.com For more information, visit www.desatech.com 37 37 1. Where will the product be used? ❍ Living/Family Room ❍ Office/W arehouse ❍ Utility Shed/Outbuilding ❍ Garage ❍ Bedroom ❍ Bathroom ❍ Other 2. If you bought this product yourself, did you plan to purchase this type of product be ...

  • Desa Tech CDVBNC - page 38

    105501-01G For more information, visit www.desatech.com For more information, visit www.desatech.com 38 2701 Industrial Drive P.O. Box 90004 Bowling Green, KY 42102-9004 TM Postage Required T APE T APE ...

  • Desa Tech CDVBNC - page 39

    105501-01G For more information, visit www.desatech.com For more information, visit www.desatech.com 39 39 NOTES _______________________________________________________________________________________________ _______________________________________________________________________________________________ _____________________________________________ ...

  • Desa Tech CDVBNC - page 40

    105501-01G For more information, visit www.desatech.com For more information, visit www.desatech.com 40 2701 Industrial Drive P.O. Box 90004 Bowling Green, KY 42102-9004 www.desatech.com KEEP THIS WARRANTY W ARRANTY INFORMA TION Model Serial No. Date Purchased NOT A UPC TM COMFORT GLOW LIMITED WARRANTY DIRECT-VENT BURNER SYSTEM AND STOVE CHASSIS DE ...

Manufacturer Desa Tech Category Oven

Documents that we receive from a manufacturer of a Desa Tech CDVBNC can be divided into several groups. They are, among others:
- Desa Tech technical drawings
- CDVBNC manuals
- Desa Tech product data sheets
- information booklets
- or energy labels Desa Tech CDVBNC
All of them are important, but the most important information from the point of view of use of the device are in the user manual Desa Tech CDVBNC.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Desa Tech CDVBNC, service manual, brief instructions and user manuals Desa Tech CDVBNC. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Desa Tech CDVBNC.

Similar manuals

A complete manual for the device Desa Tech CDVBNC, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Desa Tech CDVBNC by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Desa Tech CDVBNC.

A complete Desa Tech manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Desa Tech CDVBNC - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Desa Tech CDVBNC, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Desa Tech CDVBNC, that we can find in the current document
3. Tips how to use the basic functions of the device Desa Tech CDVBNC - which should help us in our first steps of using Desa Tech CDVBNC
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Desa Tech CDVBNC
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Desa Tech CDVBNC in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Desa Tech CDVBNC?

Use the form below

If you did not solve your problem by using a manual Desa Tech CDVBNC, ask a question using the form below. If a user had a similar problem with Desa Tech CDVBNC it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)