English dropdown-ico

Manual Empire Comfort Systems CHBR-16-3

20 pages 0.86 mb
Download

Go to site of 20

Summary
  • Empire Comfort Systems CHBR-16-3 - page 1

    Page 1 16934-3-0806 INST ALLA TION INSTRUCTIONS AND OWNER'S MANUAL INDOOR UNVENTED GAS FIREPLACE MODEL CHBR-16-3 EFFECTIVE DA TE AUGUST 2006 W A TER V APOR: A BY -PRODUCT OF UNVENTED ROOM HEA TERS W ater vapor is a by-pr od uct of ga s combustion. An un ve nt ed ro om hea te r pr o du ce s ap pr o xi ma te ly one (1) ounce (30ml) of water for ...

  • Empire Comfort Systems CHBR-16-3 - page 2

    Page 2 16934-3-0806 Section Page Important Safety Information .........................................................................................................................3 Safety Information for Users of LP Gas ..........................................................................................................4 Introduction ..... ...

  • Empire Comfort Systems CHBR-16-3 - page 3

    Page 3 16934-3-0806 When used without adequate combustion and ventilation air , heater may give off CARBON MONOXIDE, an odorless, poisonous gas. Do not install heater until all necessary provisions are made fo r c o mb us t io n a nd v e nt i la t io n a ir. Co n su l t t he w r it t en instructions provided with the heater for information concerni ...

  • Empire Comfort Systems CHBR-16-3 - page 4

    Page 4 16934-3-0806 Some people cannot smell well. Some people cannot smell the odor of the chemical put into the gas. Y ou must find out if you can smell the odorant in propane. Smoking can decrease your ability to smell. Being around an odor for a time can affect your sensitivity or ability to detect that odor . Sometimes other odors in the area ...

  • Empire Comfort Systems CHBR-16-3 - page 5

    Page 5 16934-3-0806 Qualified Installing Agency Instal lation and repla cement of gas pipi ng, gas ut ilizat ion equip ment or accessories and repair and servicing of equipment shall be performed only by a qualified agency . The term "qualified agency" means any individual, firm, corporation, or company that either in person or throug ...

  • Empire Comfort Systems CHBR-16-3 - page 6

    Page 6 16934-3-0806 GENERAL INFORMA TION W A TER V APOR: A BY -PRODUCT OF UNVENTED ROOM HEA TERS W ater vapor is a by-product of gas combustion. An unvented room heater produces approximately one (1) ounce (30ml) of water for every 1,000 BTU’ s (.3KW’ s) of gas input per hour . Unvented room heaters must be used as supplemental heat (a room) ra ...

  • Empire Comfort Systems CHBR-16-3 - page 7

    Page 7 16934-3-0806 PROVISIONS FOR ADEQUA TE COMBUSTION & VENTILA TION AIR Provisions for Adequate Combustion and V entilation Air This heater shall not be installed in a confined space or unusually tight construction unless provisions are provided for adequate combustion and ventilation air . The National Fuel Gas Code, ANSI Z223.1 defines a ...

  • Empire Comfort Systems CHBR-16-3 - page 8

    Page 8 16934-3-0806 CLEARANCES CLEARANCES Minimum Clearances From Combustible Construction (Figures 2 and 3) Side 2" Rear 2" T op 24" Floor Combustible Figure 1 Figure 2 ...

  • Empire Comfort Systems CHBR-16-3 - page 9

    Page 9 16934-3-0806 GAS SUPPL Y Check all local codes for requirements, especially for the size and type of gas supply line required. Note: Never use plastic pipe. Check to confirm whether your local codes allow copper tubing or galvanized. Note: Since some municipalities have additional local codes, it is always best to consult your local authori ...

  • Empire Comfort Systems CHBR-16-3 - page 10

    Page 10 16934-3-0806 SET -UP INSTRUCTIONS Attention: T wo people are required to assemble indoor chimenea. 1. Remove packing material from top of box. 2. Lift stack casting section out and set aside. 3. Remove remaining items and packing from inside body casting. 4. Lift body casting out of box and sit on flat surface near desired final location. ...

  • Empire Comfort Systems CHBR-16-3 - page 11

    Page 1 1 16934-3-0806 PLACEMENT OF GLOWING EMBERS AND LA V A ROCK Placement of the glowing embers (rock wool) is very individual and light coverage of the areas indicated will provide your best effects. W e recommend separation of the rock wool by hand and make your coverage as light and fluffy as possible. Place just enough embers on the burner t ...

  • Empire Comfort Systems CHBR-16-3 - page 12

    Page 12 16934-3-0806 Flames from the pilot (rear right back side of the pan burner) as well as the main flame should be visually checked as the log set is installed. In normal operation at full rate after 10 to 15 minutes, the flame appearance should be sets of yellow flames. NOTE: All flames will be random by design, flame height will go up a ...

  • Empire Comfort Systems CHBR-16-3 - page 13

    Page 13 16934-3-0806 HI/L O REGUL A TOR CONTROL K NOB PIEZO IGNITOR FOR YOUR SAFETY READ BEFORE LIGHTING W ARNING: If you do not follow these instructions exactly , a fire or explosion may result caus- ing property damage, personal injury or loss of life. A. This appliance has a pilot which must be lighted by hand. When lighting the pilot, follow ...

  • Empire Comfort Systems CHBR-16-3 - page 14

    Page 14 16934-3-0806 Figure 7 shows a correct pilot flame pattern. The correct flame will be blue and will extend beyond the thermocouple. The flame will surround the thermocouple just below the tip. A slight yellow flame may occur where the pilot flame and main burner flame meet. Figure 8 shows an incorrect pilot flame pattern. The incorrec ...

  • Empire Comfort Systems CHBR-16-3 - page 15

    Page 15 16934-3-0806 Annual inspection and cleaning by your dealer or qualified service technician is recommended to prevent malfunction and/or sooting. TURN OFF HEA TER AND ALLOW TO COOL BEFORE CLEANING. Remove logs, handling carefully by holding gently at each end. Gloves are recommended to prevent skin irritation from ceramic fibers. If skin be ...

  • Empire Comfort Systems CHBR-16-3 - page 16

    Page 16 16934-3-0806 WIRING Label all wires prior to disconnec tion when servicing controls . W iring errors can cause improper and dangerous operation. V erify proper operation after servicing. Control Panel Installation 1. Disco nnect black and green wire from TH/ TP and TH terminal on valve. 2. Insert REMOTE/OFF/ON switch with attached wires thr ...

  • Empire Comfort Systems CHBR-16-3 - page 17

    Page 17 16934-3-0806 If the gas quality is bad, your pilot may not stay lit, the burners may produce soot and the heater may backfire when lit. If the gas quality or pressure is low , contact your local gas supplier immediately . 1. When ignitor button is pressed, there is no spark at ODS/ pilot. a. Ignitor electrode positioned wrong - Replace pil ...

  • Empire Comfort Systems CHBR-16-3 - page 18

    Page 18 16934-3-0806 Parts can be ordered only through your service person or dealer . For best results, the service person or dealer should order parts through the distributor . Parts can be shipped directly to the service person/dealer . All parts listed in the Parts List have a Part Number . When ordering parts, first obtain the Model Number fr ...

  • Empire Comfort Systems CHBR-16-3 - page 19

    Page 19 16934-3-0806 P AR TS VIEW ...

  • Empire Comfort Systems CHBR-16-3 - page 20

    Page 20 16934-3-0806 SER VICE NOTES Empire Comfort Systems, Inc. 918 Freeburg A ve. Belleville, IL 62220 PH: 618-233-7420 or 800-851-3153 F AX: 618-233-7097 or 800-443-8648 info@empirecomfort.com www .empirecomfort.com ...

Manufacturer Empire Comfort Systems Category Indoor Fireplace

Documents that we receive from a manufacturer of a Empire Comfort Systems CHBR-16-3 can be divided into several groups. They are, among others:
- Empire Comfort Systems technical drawings
- CHBR-16-3 manuals
- Empire Comfort Systems product data sheets
- information booklets
- or energy labels Empire Comfort Systems CHBR-16-3
All of them are important, but the most important information from the point of view of use of the device are in the user manual Empire Comfort Systems CHBR-16-3.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Empire Comfort Systems CHBR-16-3, service manual, brief instructions and user manuals Empire Comfort Systems CHBR-16-3. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Empire Comfort Systems CHBR-16-3.

Similar manuals

A complete manual for the device Empire Comfort Systems CHBR-16-3, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Empire Comfort Systems CHBR-16-3 by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Empire Comfort Systems CHBR-16-3.

A complete Empire Comfort Systems manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Empire Comfort Systems CHBR-16-3 - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Empire Comfort Systems CHBR-16-3, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Empire Comfort Systems CHBR-16-3, that we can find in the current document
3. Tips how to use the basic functions of the device Empire Comfort Systems CHBR-16-3 - which should help us in our first steps of using Empire Comfort Systems CHBR-16-3
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Empire Comfort Systems CHBR-16-3
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Empire Comfort Systems CHBR-16-3 in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Empire Comfort Systems CHBR-16-3?

Use the form below

If you did not solve your problem by using a manual Empire Comfort Systems CHBR-16-3, ask a question using the form below. If a user had a similar problem with Empire Comfort Systems CHBR-16-3 it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)