English dropdown-ico

Manual Baja Marine 202 Islander

83 pages 7.14 mb
Download

Go to site of 83

Summary
  • Baja Marine 202 Islander - page 1

    Baja Marine Owner ’ s Manual 202 I slander Owner ’ s Manual Part Number: MRP 1811974 © Baja Marine Corporation 2006 R Speed changes you. TM. ...

  • Baja Marine 202 Islander - page 2

    B aja M arIne C orpora tIon , 2600 s ea r a y B l vd ., K noxvIlle , tn 37914 F or InForMa tIon Call 1-865-971-6270 or F ax 1-865-971-6716 I nternet address : http :// www . BajaMarIne . CoM R Speed changes you. TM. ...

  • Baja Marine 202 Islander - page 3

    i 202 Islander ® w elCoMe Congratulations on becoming the new owner of the world’s #1 performance boat. Baja ® Marine Corporation welcomes you into our worldwide and ever-expanding family of boating enthusiasts. T h e O w n e r ’ s M a n u a l P a c k e t , t o b e k e p t o n board your Baja, gives you important information on the features o ...

  • Baja Marine 202 Islander - page 4

    ii 202 Islander ® THIS P AGE INTENTIONALL Y LEFT BLANK ...

  • Baja Marine 202 Islander - page 5

    iii 202 Islander ® I ntroduCtIon 1. T his M anual The material within this manual and your Owner ’s Manual Packet: • Gives you basic safety information • Describes the features of your boat • Describes the equipment on your boat • Describes the fundamentals of boat use • Contains service and maintenance information Y ou must learn to o ...

  • Baja Marine 202 Islander - page 6

    iv 202 Islander ® 6. h ull i DenTifica Tion n uMber (hin) The “Hull Identication Number” located on the starbo ard side of the trans om, is the most impo rtant identifying factor and must be included in all correspondence and orders. Failure to include it creates delays. Also of vital importance are the engine serial numbers and part number ...

  • Baja Marine 202 Islander - page 7

    v 202 Islander ® R Speed changes you. TM. a bouT Y our e xpress l iMiTeD W arranTY Baja Marine offers an Express Limited W arranty on each new Baja purchased through an authorized Baja dealer . A copy of the Limited W arranty was included in your owner ’s packet. If for any reason you did not receive a copy of the Limited W arranty , please cont ...

  • Baja Marine 202 Islander - page 8

    vi 202 Islander ® 202 I slander o wner ’ s M anual • t aBle oF C ontents i nTroDucTion 1. This Manual ............................................................iii 2. Y our Responsibilities .............................................. iii 3. Sources of Information ...........................................iii 4. Dealer Responsibilities .. ...

  • Baja Marine 202 Islander - page 9

    vii 202 Islander ® s ecTion 5 • f uel s YsTeM 1. Fuel System......................................................... 5.1 2. Fueling Precautions ............................................. 5.2 A. Static Electricity and the Fuel System .......... 5.2 B. General ......................................................... 5.2 C. Before and During F ...

  • Baja Marine 202 Islander - page 10

    viii 202 Islander ® Information in this publication is based upon the latest product specications available at printing. Baja ® Marine Corporation reserves the right to make changes at any time, without notice, in the colors, equipment, specications, materials and prices of all models, or to discontinue models. Should changes in production ...

  • Baja Marine 202 Islander - page 11

    202 Islander ® 1.1 s eCtIon 1 • s aFety SAFE boating means: • Knowing the limitations of your boat • Following the "Rules of the Road" • Keeping a sharp lookout for people and objects in the water • Not boating in water or weather conditions that are beyond the boat's and the operator's capability • Never boating wh ...

  • Baja Marine 202 Islander - page 12

    202 Islander ® 1.2 s eCtIon 1 • s aFety 2. l eGall Y M anDa TeD M iniMuM r equireD e quipMenT The following equipment is the minimum required by the U.S. Coast Guard for a boat less than 26' [7.9 meters] in length. Person al Flotatio n Devices (PFDs): One Coast Guard approved T ype I, II or III device is mandatory for each person aboard. On ...

  • Baja Marine 202 Islander - page 13

    202 Islander ® 1.3 s eCtIon 1 • s aFety Symptoms of carbon monoxide poisoning are dizziness, ears rin ging, headach es, naus ea, and unco nsci ousne ss. Get fresh air if anyone shows signs of carbon monoxide poisoning, and/or if carbon monoxide detector alarm sounds. A poisonin g victim 's skin often turns cherr y red. Because carbon monoxi ...

  • Baja Marine 202 Islander - page 14

    202 Islander ® 1.4 s eCtIon 1 • s aFety Even strong swimmers can tire quickly in the water and drow n due to exha usti on, hyp other mia, or both. The buoyancy provided by a personal otation device (PFD) will allow the person who has fallen overboard to remain aoat with far less effort and heat loss, extending survival time necessary to ? ...

  • Baja Marine 202 Islander - page 15

    202 Islander ® 1.5 s eCtIon 1 • s aFety Drugs and/or alcohol impair the operator's ability to control the boat safely . Death or serious injury can result from improper boat operation. ! W ARNING 6. a DDiTional r ecoMMenDeD e quipMenT for s afe o pera Tion In addition to legally mandated equipment, the following items are necessary for safe ...

  • Baja Marine 202 Islander - page 16

    202 Islander ® 1.6 s eCtIon 1 • s aFety Whe n eng ine is runn in g, kee p pas sen ger s awa y from areas not designed for riding, such as seat backs, bow, gunw ales, tr ansom pl atfor m, fro nt and re ar decks and on sun pads. Passen gers can fall overboard if not seated properly on the seats provided. ! W ARNING Never carry more weight or passe ...

  • Baja Marine 202 Islander - page 17

    202 Islander ® 1.7 s eCtIon 1 • s aFety Death or serious injury can result if you fail to observe these safety rules: • Anyone who controls the boat must have taken a boating safety course and have been trained in the proper operation of the boat. • Always operate the boat at speeds that will not put people or property in danger . • Be con ...

  • Baja Marine 202 Islander - page 18

    202 Islander ® 1.8 s eCtIon 1 • s aFety The wind speed and wave height specied as the upper limit for your category of boat does not mean that you or your passengers can survive if your boat is exposed to these conditions. It is only the most experienced operators and crew that may be able to operate a boat sa fe ly und er the se con di ti on ...

  • Baja Marine 202 Islander - page 19

    202 Islander ® 1.9 s eCtIon 1 • s aFety Shut engine off if an object is struck or if you run aground. Check for hull leaks and propulsion system damage, before restarting engine. Use hand pump if bilge pumps don't remove water . Boa t ve ry sl owl y , if you must proc ee d wit h a dama ge d propulsion system. ! W ARNING Y our boat's pr ...

  • Baja Marine 202 Islander - page 20

    202 Islander ® 1.10 s eCtIon 1 • s aFety SKIING SIGNALS (FIG. 1.10.1) DIVERS FLAGS (FIG. 1.10.2) CODE ALPHA FLAG SPORT DIVER'S FLAG RED WHITE BLUE WHITE T urn - Arm raised, circle with index nger extended. Skier in W ater - Extend one ski vertically out of water . Back to Dock - Pat top of head. Cut Motor - Draw nger across throat. Sl ...

  • Baja Marine 202 Islander - page 21

    202 Islander ® 1.1 1 s eCtIon 1 • s aFety a. M eDical e MerGencY Y ou may be far fr om pro fe ss ion al me di cal he lp whe n you are boating. At least two people on board your boat should be CPR certied, and should have taken a rst aid course. Equip your boat with a rst aid kit. b. W a Ter r escue A person who has fallen overboard will ...

  • Baja Marine 202 Islander - page 22

    202 Islander ® 1.12 s eCtIon 1 • s aFety e. c ollisions anD l eakinG In the event of collisions and leaking: • Slow down or stop to reduce water intake, unless maintaining speed will keep the hole above water . • Switch on bilge pump. • Operate manual bilge pump, if the powered bilge pump can't handle the water ow . • A c co u n ...

  • Baja Marine 202 Islander - page 23

    202 Islander ® 1.13 s eCtIon 1 • s aFety ! W ARNING A wide variety of components used on this vessel contain or emit chemicals known to the State of California to cause cancer and birth defects and other reproductive harm. EXAMPLES INCLUDE: • Engine and generator exhaust • Engine and generator fuel, and other liquids such as coolants and oil ...

  • Baja Marine 202 Islander - page 24

    202 Islander ® 1.14 s eCtIon 1 • s aFety NOTICE It is ille gal for any vess el to dum p plas tic trash anywhe re in the ocean or navigable waters of the United States. ! W ARNING SPEED HAZARD- W atch your wake. It might capsize a small craft. Y ou are responsible for damage caused by your wake. ! CAUTION Reduce speed in congested waterway . Be a ...

  • Baja Marine 202 Islander - page 25

    202 Islander ® 1.15 s eCtIon 1 • s aFety 20. n auTical T erMs Abeam – object 90 degrees ( 90° ) to center line on either side of boat. Abaft – a point on a boat that is aft of another . Aft - toward the rear or stern of the boat. Beam - the maximum width of a boat. Bilge - the lowest part of the hull on the inside where uids collect. Bow ...

  • Baja Marine 202 Islander - page 26

    202 Islander ® 1.16 s eCtIon 1 • s aFety 21. k eY To s YMbols on c onTrols & p rinTs These symbols may be found on your controls and gauges and/or used in this owner's manual. This page is to help you understand what the symbols mean. PROPULSION SYSTEM TRIM PROPULSION SYSTEM TRIM BOW UP PROPULSION SYSTEM TRIM BOW DOWN TRIM T AB TRIMMING ...

  • Baja Marine 202 Islander - page 27

    202 Islander ® 1.17 R Speed changes you. TM. 22. W arninG l abel l oca Tions w arnIng l aBel l oCa tIons (F Ig 1.17.1) Located in Owner’s Packet California Residents Only The above warning is attached to the steering wheel prior to delivery of any boats sold in the state of California in accordance with California Health and Safety Code §§ 252 ...

  • Baja Marine 202 Islander - page 28

    202 Islander ® 1.18 R Speed changes you. TM. THIS P AGE INTENTIONALL Y LEFT BLANK ...

  • Baja Marine 202 Islander - page 29

    202 Islander ® 2.1 s eCtIon 2 • g eneral B oa t a rrangeMent ! CAUTION Do Not use cleats for lifting. 2. p assenGer l oca Tions 1. When the boat is moving, all passengers must be on the seating provided or , if standing, holding on rmly . While the person at the wheel must alert passengers before any sudden or erratic boat mov em en t, s uc h ...

  • Baja Marine 202 Islander - page 30

    202 Islander ® 2.2 s eCtIon 2 • g eneral B oa t a rrangeMent 3. b asic b oa T D iMensions anD c learances (u niTeD s T a Tes s T anDarD s.a.e.) 202 I slander s pecifica Tions Overall Length ................................................................. 20'4" Overall Length w/ Swim Platform .................................. 21' ...

  • Baja Marine 202 Islander - page 31

    202 Islander ® 2.3 s eCtIon 2 • g eneral B oa t a rrangeMent b asic b oa T D iMensions anD c learances (M eTric ) B oa t d IMensIons and C learanCes (F Ig . 2.3.1) 202 I slander s peCIFICa tIons Overall Length..............................................................6.20 m w/std. Swim Platform................................................. ...

  • Baja Marine 202 Islander - page 32

    202 Islander ® 2.4 s eCtIon 2 • g eneral B oa t a rrangeMent 6. G eneral D eck l a YouT GENERAL DECK LA YOUT (FIG. 2.4.1) FWD REAR (AFT) LEFT (PORT) RIGHT (STBD) Navigation Light (Bow) Horn Steering Wheel Helm Seat Passenger Seat Inspection Plates Aft Bench Seat Engine Hatch Cleat Cleat Navigation / Anchor Lt. (Stern) Fuel Fill Bow Seat Cushion ...

  • Baja Marine 202 Islander - page 33

    202 Islander ® 2.5 s eCtIon 2 • g eneral B oa t a rrangeMent 7. D escripTion of M ajor c onTrols a. G ear s hifT anD T hroTTle c onTrol The shift/throttle control unit for the engine is activated by individual handles. (See Figure 2.5.1) The shift handle must be in neutral position to start your engine. Moving the shift handle forward engages th ...

  • Baja Marine 202 Islander - page 34

    202 Islander ® 2.6 s eCtIon 2 • g eneral B oa t a rrangeMent c. T railer s WiTch The trailer switch (Power T ilt) is not to be confused with the Power T rim function. The trailer switch is to be used only when the engine is off. The trailer switch allows the drive unit to be raised for trailering, beaching and launching. T o operate, press and h ...

  • Baja Marine 202 Islander - page 35

    202 Islander ® 2.7 s eCtIon 2 • g eneral B oa t a rrangeMent The alarm indicates a problem with engine water temperature, oil pressure and/or stern drive oil level. 8. i Mpor T anT G auGes a. T achoMeTer anD h our M eTer The tachometer (see Figure 2.7.2) indicates the revolutions per minute (RPM) of the engine (it does not indicate the speed of ...

  • Baja Marine 202 Islander - page 36

    202 Islander ® 2.8 s eCtIon 2 • g eneral B oa t a rrangeMent I nser tIng the a Ft r eMov aBle n a vIga tIon / a nChor l Ight ( l oCa ted a t the s tern oF the B oa t ) (F Ig 2.8.1) ANCHOR LIGHT MAST SCREW IN TYPE CONNECTOR COMPRESSION TYPE CONNECTOR DECK ANCHOR LIGHT FITTING b. o il p ressure , W a Ter T eMpera Ture , v ol TMeTer anD f uel G auG ...

  • Baja Marine 202 Islander - page 37

    3.1 202 Islander ® s eCtIon 3 • u sIng y our B oa t 1. p re -l aunch , l aunch anD p osT - l aunch c hecklisT Listed below are the critical items you must check and do each time you use your boat. It does not list all of the necessary maintenance and service items required to keep your boat running properly . These other items are found in Secti ...

  • Baja Marine 202 Islander - page 38

    3.2 s eCtIon 3 • u sIng y our B oa t 202 Islander ® 3. f uelinG The b oa T The fuel ll cap is located on the port side of the boat (Figu re 3.2. 1). Do not mist ake th e wate r tank ll and waste pump out caps for the gasoline ll cap. Refer to your engine manual for the proper grade of gasoline. b efore f uelinG • Fuel during daylight ...

  • Baja Marine 202 Islander - page 39

    3.3 202 Islander ® s eCtIon 3 • u sIng y our B oa t • Shut of f gas burning appliances (gas stove, etc.). • Close all hatches, doors, and keep engine compartment closed to prevent gasoline fumes from entering the cabin or cockpit area. • All passengers must leave the boat until it is refueled and engine is safely started. • There must be ...

  • Baja Marine 202 Islander - page 40

    3.4 s eCtIon 3 • u sIng y our B oa t 202 Islander ® • If there are passengers not wearing PFDs, the PFDs must be readily accessible. “Readily accessible” means out of the storage bag and unbuckled. • All throwable otation devices (cushions, rings, etc.) must be right at hand. 6. p assenGer i nsTrucTion anD l oca Tion • Ev er yo ne o ...

  • Baja Marine 202 Islander - page 41

    3.5 202 Islander ® s eCtIon 3 • u sIng y our B oa t it is recommended that the bilge blower run all the time the engine is running. 6. Place drive unit in full DOWN/IN position. 7. Put shift control lever into neutral; then for a: COLD ENGINE - Move throttle lever forward to full open throttle, then return to about 1/4 throttle. In cold weather ...

  • Baja Marine 202 Islander - page 42

    3.6 s eCtIon 3 • u sIng y our B oa t 202 Islander ® 10. s TeerinG s YsTeMs Y our Baja ® may be will be equipped with one of two types of steering. Please refer to the Owner ’ s Packet for information on the steering system installed on your boat. a. h YDraulic s TeerinG Some Baja ® boats may use a hydraulic steering system (Fig. 3.6.1). Peri ...

  • Baja Marine 202 Islander - page 43

    3.7 202 Islander ® s eCtIon 3 • u sIng y our B oa t b. p oWer s TeerinG The pow er st ee rin g sy ste m is an en cl ose d pu sh- pul l cable that is hydraulically assisted (power steering) at the stern drive end (Fig. 3.7.1). The cable and its connections to the steering wheel and to the out drive MUST be inspected at least twice a year by your ...

  • Baja Marine 202 Islander - page 44

    4.1 202 Islander ® s eCtIon 4 • B Ilge & u nder w a ter g ear 1. b ilGe a. f uel & o il s pillaGe Regulations prohibit discharging fuel or oily waste in navigable waters. Discharge is dened as any ac ti on w hi ch ca u se s a l m , s he en o r d is co l or at i on on the water surface, or causes a sludge or emulsion beneath the wat ...

  • Baja Marine 202 Islander - page 45

    4.2 202 Islander ® s eCtIon 4 • B Ilge & u nder w a ter g ear Except for checkin g the operation of the bilge pump using the ON position, leave the switch in the OFF (AUT O) positio n. In th e OFF (AUT O) positi on, whe n the bilge liquid is deep enough to activate the oat switch, the bilge pump turns on and pumps out the bilge liquid unt ...

  • Baja Marine 202 Islander - page 46

    4.3 202 Islander ® s eCtIon 4 • B Ilge & u nder w a ter g ear c. i Mp acT To s Tern D rive The stern drive can be damaged by impact, either whi le tr ai le ri ng or b oa ti ng . T o min im iz e th e p os si bi li ty of impact damage while trailering, keep the stern drive raised to the trailering position. The hydraulic system used to raise a ...

  • Baja Marine 202 Islander - page 47

    4.4 202 Islander ® s eCtIon 4 • B Ilge & u nder w a ter g ear f. Install the thrust washer , propeller , continuity washer , thrust hub, propeller nut retainer and the propeller nut onto the shaft (Figure 4.3.3). g. Place a block of wood between the gear case and the propeller (Figure 4.4.1) and torque the propeller nut to recommended manufa ...

  • Baja Marine 202 Islander - page 48

    202 Islander ® 5.1 s eCtIon 5 • F uel s ysteM 1. f uel s YsTeM Section 3 • Using Y our Boat contain s important fueling information. T ake time to read all the fuel related information in the owner ’s manual. The 202 Islander standard gasoline fuel system consists of a 50 gallon fuel tank, fuel tank vent, an anti-siphon valve, engine fuel su ...

  • Baja Marine 202 Islander - page 49

    202 Islander ® 5.2 s eCtIon 5 • F uel s ysteM 2. f uelinG p recauTions Ce r ta in pr ec aut i on s mus t be ca r ef ull y and com ple t el y observed every time a boat is fueled, even with diesel fuel. Diesel fuel is nonexplosive but it will burn. a. s T a Tic e lecTriciTY anD The f uel s YsTeM There is a danger that static electricity can ignit ...

  • Baja Marine 202 Islander - page 50

    202 Islander ® 5.3 s eCtIon 5 • F uel s ysteM • Elec tric al equi pmen t, inc ludi ng blow ers – pow er off. • Doors, hatches – closed. • Smoking material – extinguished. • Inboard tanks – grounded. • Filler pipe – marked GAS or DIESEL. • Fue l no zz le – in c ont ac t wi th  ll er p ipe to p rev en t static sparks. ? ...

  • Baja Marine 202 Islander - page 51

    202 Islander ® 5.4 s eCtIon 5 • F uel s ysteM THIS P AGE INTENTIONALL Y LEFT BLANK ...

  • Baja Marine 202 Islander - page 52

    202 Islander ® 6.1 R Speed changes you. TM. s eCtIon 6 • e leCtrICal s ysteMs 1. e lecTrical s YsTeMs D irecT c urrenT (Dc) The 12 volt direct current (DC) electrical system (similar to that in your car or truck) derives its power from the battery . An engine-driv en alternator keeps the battery in a charged condition. The battery voltage is ind ...

  • Baja Marine 202 Islander - page 53

    202 Islander ® 6.2 s eCtIon 6 • e leCtrICal s ysteMs R Speed changes you. TM. Protective terminal covers, such as rubber boots on electrical connections, must be in place when engine is operating or when working in the engine compartment. Jumper cables are not ignition-protected. DO NOT US E ju mp er ca bl es in th e e ng in e c om pa rt me nt . ...

  • Baja Marine 202 Islander - page 54

    202 Islander ® 6.3 s eCtIon 6 • e leCtrICal s ysteMs R Speed changes you. TM. Zinc anodes require replacement about every six months, if the boat is operated in salt wate r . In fresh water , the zinc anodes can be replaced about once a year . If the anodes deteriorate more rapidly than this, there is probably a stray current problem within the ...

  • Baja Marine 202 Islander - page 55

    202 Islander ® 6.4 s eCtIon 6 • e leCtrICal s ysteMs R Speed changes you. TM. I gnItIon s wItCh (FIg. 6.4.1) TO ENGINE RUN CIRCUIT 16 A WG PURPLE/BLACK 16 A WG PURPLE/BLACK LANY ARD STOP SWITCH B EXHAUST 12 A WG RED TO EXHAUST BREAKER FROM IGNITION SWITCH ( I ) 16 A WG PURPLE/BLACK TO ENGINE B RUN OFF I B S ST ART 16 A WG YEL/RED TO ST AR TER SO ...

  • Baja Marine 202 Islander - page 56

    202 Islander ® 6.5 s eCtIon 6 • e leCtrICal s ysteMs R Speed changes you. TM. TRAILER TRIM BLUE/WHITE RED GREEN/WHITE 14 A WG RED 14 A WG GREEN 14 A WG BLUE 14 A WG PURPLE TRAILER LIMIT SWITCH TO GROUND BLOCK TO ENGINE ST ARTER 8 AW G BLACK 8 AW G RED 100 AMP d rIve p uMp (FIg. 6.5.1) ...

  • Baja Marine 202 Islander - page 57

    202 Islander ® 6.6 s eCtIon 6 • e leCtrICal s ysteMs R Speed changes you. TM. THIS P AGE INTENTIONALL Y LEFT BLANK ...

  • Baja Marine 202 Islander - page 58

    6.7 202 Islander ® R Speed changes you. TM. s wItCh p anel w Ire I nForMa tIon (FIg 6.7.1) #1 #2 #3 #4 PLUG 1 8 - Way Deutsch DT Series Receptacle Receptacle DT04 - 08 P A Secondary Lock W6-P BLOWER HORN FIRE EXTINGUISHER BOW LIGHT #8 #7 #6 #5 16 AWG DARK BL UE 16 AWG DARK BL UE WITH A WHITE STRIPE 14 AWG BROWN 14 AWG GRA Y WITH A WHITE STRIPE 14 ...

  • Baja Marine 202 Islander - page 59

    6.8 202 Islander ® R Speed changes you. TM. dC w Ire I nForMa tIon (FIg 6.8.1) ...

  • Baja Marine 202 Islander - page 60

    202 Islander ® 7.1 s eCtIon 7 • o ptIons & a CCessorIes 1. o pTions & a ccessories l oca Tions Figure 7.1.1 shows the location of some of the components. T ake time to walk through your boat, locate the features, and become familiar with their operation and maintenance. ST ANDARD & OPTIONAL EQUIPMENT LOCA TIONS (FIG. 7.1.1) Item Loca ...

  • Baja Marine 202 Islander - page 61

    202 Islander ® 7.2 s eCtIon 7 • o ptIons & a CCessorIes 2. a uToMa Tic f ire e xTinGuisher s YsTeM (o pTion ) The 202 Islander may be equipped with an automatic fire extinguisher system located aft of the engine on th e tr an so m. I n t he ev en t of a re , th e h eat sen sitive automatic head will release the extinguishant as a vapor , ...

  • Baja Marine 202 Islander - page 62

    202 Islander ® 7.3 s eCtIon 7 • o ptIons & a CCessorIes For safety and ease of installation and removal of canvas, use at least two people. The following canvas options are available for the 202 Islander: • Cockpit Cover • Mooring Cover • T railering Cover a. c anv as c are anD M ainTenance See Sec tion 9, page 9. 2, for in stru ctio n ...

  • Baja Marine 202 Islander - page 63

    202 Islander ® 7.4 s eCtIon 7 • o ptIons & a CCessorIes REFER TO OWNER'S MANUAL P ACKET FOR IN S T RU C TI ONS AND W AR R AN T Y IN F O RM A T I O N ON DEPTH FINDER. 8. s Tereo s YsTeM Y our 202 Islander comes with a JBL MR4 AM/ FM stereo package from Marine Audio. JBL's MR design eliminates the need for after-market housing kits o ...

  • Baja Marine 202 Islander - page 64

    8.1 202 Islander ® s eCtIon 8 • r equIred I nspeCtIon , s er vICe , & M aIntenanCe ITEM REQUIRED MAINTENANCE/SERVICE REFERENCE SOURCE BEFORE EVERY USE AFTER FIRST 20 HOURS EVERY 25* OR 50 HOURS EVERY 50* OR 100 HOURS EVERY 6 MOS. OR ANNUALL Y Battery Check water level Owner ’ s Manual p. 6.1 • • • Bilge Area Clean and check Owner ’ ...

  • Baja Marine 202 Islander - page 65

    8.2 202 Islander ® s eCtIon 8 • r equIred I nspeCtIon , s er vICe , & M aIntenanCe s uMMar Y G uiDe f or i nspecTion , s er vice anD M ainTenance *Use in salt water or other severe operating conditions requires shorter maintenance/service intervals **May not be on your boat ITEM REQUIRED MAINTENANCE/SERVICE REFERENCE SOURCE BEFORE EVERY USE ...

  • Baja Marine 202 Islander - page 66

    8.3 202 Islander ® s eCtIon 8 • r equIred I nspeCtIon , s er vICe , & M aIntenanCe 2. u seful s er vice i nforMa Tion OWNER HOME PORT BOA T NAME REGISTRA TION NUMBER ST A TE HULL SERIAL NUMBER W ARRANTY REGISTRA TION DA TE ENGINE MAKE & MODEL SERIAL NUMBER GEAR MAKE & REDUCTION RA TIO SERIAL NUMBER PROPELLER SIZE P ART NUMBER SHAFT S ...

  • Baja Marine 202 Islander - page 67

    8.4 202 Islander ® s eCtIon 8 • r equIred I nspeCtIon , s er vICe , & M aIntenanCe 3. i nspecTion , s er vice anD M ainTenance p roTocol a. b ilGe a rea Many of your boat’ s systems have critical features located in the bilge area. A thorough and organized inspection of the bilge area will address many of these critical features. For examp ...

  • Baja Marine 202 Islander - page 68

    8.5 202 Islander ® s eCtIon 8 • r equIred I nspeCtIon , s er vICe , & M aIntenanCe • Check your rst aid kit, making certain it is complete and that the items in it have not passed an expiration date. • Check the signaling equipment and emergency flares. Make sure all items are within their expiration dates. • Inspect the anchor , mo ...

  • Baja Marine 202 Islander - page 69

    8.6 202 Islander ® s eCtIon 8 • r equIred I nspeCtIon , s er vICe , & M aIntenanCe 5. f iTTinG o uT a fTer s ToraGe a. f uel s YsTeM Check the entire fuel system for loose connections, worn hoses, leaks, etc. and repair . This is a primary safety precaution. Ch ec k fuel l in es fo r da ma ge a nd ma ke s ur e t ha t th ey do not come in con ...

  • Baja Marine 202 Islander - page 70

    8.7 202 Islander ® s eCtIon 8 • r equIred I nspeCtIon , s er vICe , & M aIntenanCe • Check fuel lines for damag e and/or leak s. Make sure that they do not come into contact with moving parts. • Check Carbon Monoxide detector to see if operational 6. s ecuriTY c onsiDera Tions Be conscious of the security of your boat. Always rem ov e th ...

  • Baja Marine 202 Islander - page 71

    8.8 202 Islander ® s eCtIon 8 • r equIred I nspeCtIon , s er vICe , & M aIntenanCe 8. q uick r eference c hecklisT As the owner/operator of a Baja ® Boat, you are responsible for the safe operation of your boat and the safety of your passengers. Always be sure that required documents, navigational equipment and Coast Guard required safety e ...

  • Baja Marine 202 Islander - page 72

    8.9 202 Islander ® s eCtIon 8 • r equIred I nspeCtIon , s er vICe , & M aIntenanCe q uick r eference c hecklisT ( conT ’ D ) *I f en g in e fa i ls t o st a rt , re f er t o t he E ng i ne O wn e r’ s Ma n ua l fo r f ur th er tr ou bl e sh oo ti n g pr oc e du re s b. p rep arinG To D ep arT anD a fTer l aunchinG G eneral 1. Bilge/Engin ...

  • Baja Marine 202 Islander - page 73

    8.10 202 Islander ® s eCtIon 8 • r equIred I nspeCtIon , s er vICe , & M aIntenanCe c. D ep arTinG G eneral 1. Passengers/Crew ................................................... Safely seated with PFDs on or immediately accessible 2. Lines, Fenders and Anchor ..................................... Stowed b oa T s YsTeMs 1. T rim T abs ...... ...

  • Baja Marine 202 Islander - page 74

    8.1 1 202 Islander ® s eCtIon 8 • r equIred I nspeCtIon , s er vICe , & M aIntenanCe q uick r eference c hecklisT ( conT ’ D ) 3. Ignition .................................................................... Once the motor is cooled down, turn the ignition keys counter clockwise to stop the engine. 4. Engine Operation ..................... ...

  • Baja Marine 202 Islander - page 75

    8.12 202 Islander ® s eCtIon 8 • r equIred I nspeCtIon , s er vICe , & M aIntenanCe 9. a fTer M arkeT e quipMenT c hecklisT Any safe ty or opera tiona l equip ment add ed to your boat after deliver y shoul d be checke d for seawo rthin ess and proper working condition. Use the area below to list any equipment and the proper operating conditi ...

  • Baja Marine 202 Islander - page 76

    8.13 202 Islander ® s eCtIon 8 • r equIred I nspeCtIon , s er vICe , & M aIntenanCe 10. M ainTenance l oG Follow the recommended maintenance listed on pages 1 & 2 of this section and keep a record of this and ALL maintenance performed on your boat. Date Maintenance Description Engine Hours ...

  • Baja Marine 202 Islander - page 77

    8.14 202 Islander ® s eCtIon 8 • r equIred I nspeCtIon , s er vICe , & M aIntenanCe M ainTenance l oG (c onT ’ D ) Date Maintenance Description Engine Hours ...

  • Baja Marine 202 Islander - page 78

    9.1 202 Islander ® s eCtIon 9 • C are & r eFInIshIng Y our new boat has been designed to provide you with years of enjoyment and satisfaction. In order to maintain the factory new appearance of your boat, we recommend the use of Y acht Bright ™ products designed specically for pleasure boats. Fol low ing p rop er b erg lass mai nten ...

  • Baja Marine 202 Islander - page 79

    9.2 s eCtIon 9 • C are & r eFInIshIng 202 Islander ® • Minor scratches and deeper stains that do not penetrate the gelcoat may be removed by light sanding and bufng. 4. p erManenTl Y M ooreD or D ockeD b oa Ts If permanently moored in salt water or fresh water , your boat will collect marine growth on its bottom. This will detract from ...

  • Baja Marine 202 Islander - page 80

    9.3 202 Islander ® s eCtIon 9 • C are & r eFInIshIng The fabric should be cleaned regularly before substances such as dirt, pollen, etc. are allowed to accumulate on and become embedded in the fabric. The fabric can be cleaned without being removed from the installation. Simply brush of f any loose dirt, particles, etc.; hose down and clean ...

  • Baja Marine 202 Islander - page 81

    9.4 s eCtIon 9 • C are & r eFInIshIng 202 Islander ® T his P age i nTenTionall y l efT B lank ...

  • Baja Marine 202 Islander - page 82

    i ndex 202 i slander ® I ndex A Accessories. See Options & Accessories Locations B Bilge 4.1 Blower 4.2 Maintenance 4.2, 8.4 Pump 4.1 Boarding 3.3 Breakers. See Electrical Systems Builder ’ s Plate 1.6 C Canvas 7.2, 9.2 Carbon Monoxide 1.2 Certications CE (Common European) Mark iv Clearances 2.2 D Diving 1.10 Docking 2.1 E Electrical Syst ...

  • Baja Marine 202 Islander - page 83

    i ndex 202 i slander ® T his P age i nTenTionall y l efT B lank ...

Manufacturer Baja Marine Category Boat

Documents that we receive from a manufacturer of a Baja Marine 202 Islander can be divided into several groups. They are, among others:
- Baja Marine technical drawings
- 202 Islander manuals
- Baja Marine product data sheets
- information booklets
- or energy labels Baja Marine 202 Islander
All of them are important, but the most important information from the point of view of use of the device are in the user manual Baja Marine 202 Islander.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Baja Marine 202 Islander, service manual, brief instructions and user manuals Baja Marine 202 Islander. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Baja Marine 202 Islander.

Similar manuals

A complete manual for the device Baja Marine 202 Islander, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Baja Marine 202 Islander by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Baja Marine 202 Islander.

A complete Baja Marine manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Baja Marine 202 Islander - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Baja Marine 202 Islander, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Baja Marine 202 Islander, that we can find in the current document
3. Tips how to use the basic functions of the device Baja Marine 202 Islander - which should help us in our first steps of using Baja Marine 202 Islander
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Baja Marine 202 Islander
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Baja Marine 202 Islander in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Baja Marine 202 Islander?

Use the form below

If you did not solve your problem by using a manual Baja Marine 202 Islander, ask a question using the form below. If a user had a similar problem with Baja Marine 202 Islander it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)