English dropdown-ico

Manual York 291627-YTG-B-0807

32 pages 2.01 mb
Download

Go to site of 32

Summary
  • York 291627-YTG-B-0807 - page 1

    291627-YTG-B-0807 FOR DISTRIBUTION USE ONLY - NOT TO BE USED AT POINT OF RETAIL SALE TECHNICAL GUIDE AFFINITY™ SERIES SINGLE P ACKAGE GAS/ELEC TRIC AIR COOLED AIR CONDITIONERS 2-1/2 THROUGH 5 NOMINAL TON DNH030 THROUGH 060 UP TO 12.4 SEER ® FLEXIBLE LIGHT CO MMERCIAL UNIT GENERAL York ® Affinity™ Series packaged units are designed to han- dle ...

  • York 291627-YTG-B-0807 - page 2

    291627-YTG-B-0807 2 Unitary Products Group T ABLE OF CONTENTS DESCRIPTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 STANDARD FEATURES/BENEFITS . . . . . . . . . . . . 3 FIELD-INSTALLED ACCESSORIES . . . . . . . . . . . . . 4 TYPICAL WIRING DI AGRAM NOTES . . . . . . . . . . 28 MECHANICAL SPECIFICATIONS . . . . . . . . . . . . . ...

  • York 291627-YTG-B-0807 - page 3

    291627-YTG-B-0807 Unitary Products Group 3 DESCRIPTION These packaged cooling/heating ai r conditioners are designed for outdoor i nstallation. Only utility and duct con- nections are required at the point of installation . The gas-fired heaters have al umin ized steel tubu lar heat exchangers and spark to pilot ignition . They are available in nat ...

  • York 291627-YTG-B-0807 - page 4

    291627-YTG-B-0807 4 Unitary Products Group FAN SYSTEM - All models operate over a wide range of design conditions with a 3-spee d direct-drive fan motor. These units easily match all ty pes of applications and pro- vides greater o n site flexibili ty to match comfort requirement. SIMPLE CONTROL CIRCUIT - A low voltage p rinted circuit board contain ...

  • York 291627-YTG-B-0807 - page 5

    291627-YTG-B-0807 Unitary Products Group 5 ANTI SHORT CYCLE TIMER - Automatically prevents the compressor from restarting for 5 minutes after cycled off.Not required if Thermostat 2E T07700224 a nd 2ET0470022 4 are used. MOTORIZED FRESH AIR DAMPER - Designed for duct mounted side supply/return and unit mounted down supply/ return applications. Damp ...

  • York 291627-YTG-B-0807 - page 6

    291627-YTG-B-0807 6 Unitary Products Group T A BLE 1: PHYSICAL DA T A MODEL DN H 030 036 042 048 060 EV APORA TOR BLOWER CENTRIFUGAL BLOWER (Dia. x W . in.) 10 X 8 1 1 x 10 1 1 x 10 12 x 1 1 12 x 11 F AN MOTOR HP (3 S peed) 1/2 3/4 3/4 3/4 1 EV APORA TOR COIL ROWS DEEP 3 3 3 3 3 FINS PER INCH 13 13 13 16 16 F ACE AREA (Sq. Ft.) 3.5 3.5 4. 5 4.5 4. ...

  • York 291627-YTG-B-0807 - page 7

    291627-YTG-B-0807 Unitary Products Group 7 T A BLE 2: RA TINGS COOLI NG/GAS HEA TING MODEL DNH NET COOLING CAP ACITY 1 SOUND RA TING (dbels) 2 GAS HEA T CAP ACITY / EFFICIENCIES MBH SEER 3 INPUT (MBH) OUTPUT (MBH) AFUE 4 (%) NUMBER OF BURNERS TEMP . RISE (°F) RANGE 030N03625 28.0 12.0 80 45 36 80.2 2 25 - 55 030N03646 28.0 12.0 80 45 36 80.2 2 25 ...

  • York 291627-YTG-B-0807 - page 8

    291627-YTG-B-0807 8 Unitary Products Group T A BLE 3: DNH030 COOLING CAP ACITIES - 2-1/2 TON TEMPERA TURE OF AIR ON CONDENSER COIL AIR ON EV APORA TOR COIL 750 CFM 875 CFM 1,000 CFM 1,125 CFM 1,250 CFM WB °F WB °F WB °F WB °F WB °F 72 67 62 57 72 67 62 57 72 67 6 2 57 72 67 62 57 72 67 62 5 7 85 °F NET CAP . MBH 27.2 26.8 24.1 24.0 28.5 28.1 ...

  • York 291627-YTG-B-0807 - page 9

    291627-YTG-B-0807 Unitary Products Group 9 T A BLE 4: DNH036 COOLING CAP ACITIES - 3 TON TEMPERA TURE OF AIR ON CONDENSER COIL AIR ON EV APORA TOR COIL 900 CFM 1,050 CFM 1,200 CFM 1,300 CFM 1,400 CFM WB °F WB °F WB °F WB °F WB °F 72 67 62 57 72 67 62 57 72 67 62 57 72 67 62 57 72 67 62 57 85 °F NET CAP . MBH 35.9 33.6 31 .7 31.6 38.4 35.9 33. ...

  • York 291627-YTG-B-0807 - page 10

    291627-YTG-B-0807 10 Unitary Products Group T A BLE 5: DNH042 COOLING CAP ACITIES - 3-1/2 TON TEMPERA TURE OF AIR ON CONDENSER COIL AIR ON EV APOR A TOR COIL 1,050 CFM 1,225 CFM 1,400 CFM 1,575 CFM 1,750 CFM WB °F WB °F WB °F WB °F WB °F 72 67 62 57 72 67 62 57 72 67 62 57 72 67 62 57 72 67 6 2 57 85 °F NET CAP . MBH 38.6 38.4 34.0 33.3 42.1 ...

  • York 291627-YTG-B-0807 - page 11

    291627-YTG-B-0807 Unitary Products Group 11 T A BLE 6: DNH048 COOLING CAP ACITIES - 4 TON TEMPERA TURE OF AIR ON CONDENSER COIL AIR ON EV APORA T OR COIL 1,200 CFM 1,400 CFM 1,600 CFM 1,800 CFM 2,000 CFM WB °F WB °F WB °F WB °F WB °F 72 67 62 57 72 67 62 57 72 67 62 57 72 67 62 57 72 67 62 57 85 °F NET CAP . MBH 50.8 47.4 43.1 42.8 52.8 49.3 ...

  • York 291627-YTG-B-0807 - page 12

    291627-YTG-B-0807 12 Unitary Products Group T A BLE 7: DNH060 COOLING CAP ACITIES - 5 TON TEMPERA TURE OF AIR ON CONDENSER COIL AIR ON EV APORA TOR COIL 1,700 CFM 1,800 CFM 1,900 CFM 2,000 CFM 2,100 CFM WB °F WB °F WB °F WB °F WB °F 72 67 62 57 72 67 62 57 72 67 62 57 72 67 62 57 72 67 62 57 85 °F NET CAP . MBH 66.8 63.1 58.2 57.0 68. 2 64.4 ...

  • York 291627-YTG-B-0807 - page 13

    291627-YTG-B-0807 Unitary Products Group 13 T A BLE 8: SIDE SUPPL Y AIR BL OWER PERFORMANCE - 208 VOL T 1 MODEL # DNH (Cooling/ Heating) MTR SPD EXTERNAL ST AIC PRESSURE - IWG .10 .20 .30 .40 .50 .6 0 .70 .80 .90 1.00 1.10 CFM WATT S CFM WATT S CFM WATT S CFM WATT S CFM WATT S CFM WATT S CFM WATT S CFM WATT S CFM WATT S CFM WATT S CFM WATT S 030 H ...

  • York 291627-YTG-B-0807 - page 14

    291627-YTG-B-0807 14 Unitary Products Group T A BLE 9: SIDE SUPPL Y AIR BLOWER PERFORMANCE - 230 & 460 VOL T 1 MODEL # DNH (Cooling/ Heating) MTR SPD EXTERNAL ST A TIC PRESSURE - IWG .10 .20 .30 .40 .50 .60 .7 0 .80 .90 1.00 1.10 CFM W A TTS CFM W A TTS CFM W A TTS CFM W A TTS CFM W A TTS CFM W A TTS CFM W A TTS CFM W A TTS CFM W A TTS CFM W A ...

  • York 291627-YTG-B-0807 - page 15

    291627-YTG-B-0807 Unitary Products Group 15 T AB LE 10: BOTTOM SUPPL Y AIR BLOWER PERFORMANCE - 208 VOL T 1 MODEL # DNH (Cooling/ Heating) MTR SPD EXTERNAL ST A TIC PRESSURE - IWG .10 .20 .30 .40 .50 .60 .70 .80 .90 1.00 1 .10 CFM W A TTS CFM W A TTS CFM W A TTS CFM W A TTS CFM W A TTS CFM W A TTS CFM W A TTS CFM W A TTS CFM W A TTS CFM W A TTS CFM ...

  • York 291627-YTG-B-0807 - page 16

    291627-YTG-B-0807 16 Unitary Products Group T ABLE 1 1: BOTTOM SUPPL Y AIR BLOW ER PERFORMANCE - 230 & 460 VOL TS 1 MODEL # DNH (Cooling/ Heating) MTR SPD EXTERNAL ST A TIC PRESSURE - IWG .10 .20 .30 .40 .50 .60 .70 .80 .90 1.00 1.10 CFM W A TTS CFM W A TTS CFM W A TTS CFM W A TTS CFM W A TTS CFM W A TTS CFM W A TTS CFM W A TTS CFM W A TTS CFM ...

  • York 291627-YTG-B-0807 - page 17

    291627-YTG-B-0807 Unitary Products Group 17 FIGURE 3 - TYPICAL FIEL D CONTROL WIRING DIAGRAM FIGURE 4 - TYPICAL FIEL D POWER WIRING DIAGRAM T A BLE 13: ADDITIONAL ST A TIC PRESSURE RESIST ANCE 3-1/2 - 5 TON (DNH042 - 060) 1 DESCRIPTION RESIST ANCE, IWG CFM 1,100 1,200 1,300 1, 400 1,500 1,600 1,700 1,80 0 1,900 2,000 WET EV APORA TOR COI L .02 .03 ...

  • York 291627-YTG-B-0807 - page 18

    291627-YTG-B-0807 18 Unitary Products Group T A BLE 14: ELECTRICAL DA T A MODEL DNH POWER SUPPL Y VOL T AGE LIMIT A TIONS 1 COMPR ESSOR COND. FA N MOTOR, FLA SUPPL Y AIR BLOWER MOT OR FLA MINIMUM CIRCUIT AMP A CITY MAX. FUSE SIZE, AMPS 2 MAX. HACR BREAKE R SIZE, AMPS UNIT POWER FA C T O R TRANSFORMER SIZE (V A) MIN. MAX. RLA LRA 030 208/230-3-60 18 ...

  • York 291627-YTG-B-0807 - page 19

    291627-YTG-B-0807 Unitary Products Group 19 FIGURE 5 - UNIT DIMENSI ONS - FRONT All dimensions are in inches. They are subject to change with- out notice. Certified dimensions will be provided upon request. T A BLE 15: UNIT DIMENSIONS FRONT UNIT SIZE DIMENSION “A” “B” 030 - 036 33-1/2 18-1/4 042 - 060 41-1/2 23-1/8 T A BLE 16: UNIT MINIMUM ...

  • York 291627-YTG-B-0807 - page 20

    291627-YTG-B-0807 20 Unitary Products Group FIGURE 6 - UNIT DIMENSIONS - FRONT & BO TTOM FIGURE 7 - UNIT DIMENSIONS - BACK & BOTTOM 2 6 - 3 / 4 6 4 - 5 / 8 8 - 7 / 8 1 1 - 7 / 8 1 9 - 1 / 4 H I G H V O L T A G E C O N N . 1 - 3 / 3 2 " D I A . K N O C K O U T F R O N T C O N D E N S A T E D R A I N 3 / 4 " ' N P T I G A S S U ...

  • York 291627-YTG-B-0807 - page 21

    291627-YTG-B-0807 Unitary Products Group 21 FIGURE 8 - TYPICAL SLAB O N GROUND INST ALLA TION FIGURE 9 - TYPICAL ROOF CURB INST ALLA TION F I E L D S U P P L I E D D I S C O N N E C T S W I T C H L O C A T E D T O R E A R O F U N I T T O G A S S U P P L Y L I N E M A N U A L G A S S H U T - O F F V A L V E R E T U R N A I R D U C T SU PPL Y AI R D ...

  • York 291627-YTG-B-0807 - page 22

    291627-YTG-B-0807 22 Unitary Products Group FIGURE 10 - TYPICAL DUCT APPLI CA T IONS FIGURE 1 1 - UNIT CENTER OF GRA VITY R O O F C U R B I N S T A L L A T I O N R E A R D U C T R O O F C U R B I N S T A L L A T I O N B O T T O M D U C T S L A B O N G R O U N D I N S T A L L A T I O N T A BLE 17: UNIT WEIGHTS AND CENTER OF GRA V ITY UNIT SIZE SHIPP ...

  • York 291627-YTG-B-0807 - page 23

    291627-YTG-B-0807 Unitary Products Group 23 FIGURE 12 - ROOF CURB DIME NSIONS 1 FIGURE 13 - ROOF CURB CR OSS SECTION O P E N I N G F O R R E T U R N A I R D U C T O P E N I N G F O R S U P P L Y A I R D U C T 1 4 3 - 1 / 2 1 7 - 5 / 8 4 0 - 3 / 4 4 2 - 2 / 3 4 5 - 1 / 8 4 3 - 1 / 4 1 7 - 1 / 4 2 2 1 R E C O M M E N D E D D U C T S I Z E 1 7 - 1 / 8 ...

  • York 291627-YTG-B-0807 - page 24

    291627-YTG-B-0807 24 Unitary Products Group FIGURE 14 - TYPICAL WIRING DIAGRAM DNH 03 0, 036, 042, 048 (208/230- 3-60 POWER SUPPL Y) ...

  • York 291627-YTG-B-0807 - page 25

    291627-YTG-B-0807 Unitary Products Group 25 FIGURE 15 - TYPICAL WIRING DIAGRAM DNH 03 0, 036, 042, 048 (460-3-60 POWER SUPPL Y) ...

  • York 291627-YTG-B-0807 - page 26

    291627-YTG-B-0807 26 Unitary Products Group FIGURE 16 - TYPICAL WIRING DIAGRAM DNH 060 (2 08-230-3-60 P OWER SUPPL Y) ...

  • York 291627-YTG-B-0807 - page 27

    291627-YTG-B-0807 Unitary Products Group 27 FIGURE 17 - TYPICAL WIRING DIAG RAM DNH 060 (460-3-60 POWER SUPPL Y) ...

  • York 291627-YTG-B-0807 - page 28

    291627-YTG-B-0807 28 Unitary Products Group TYPICAL WIRING DIAGRAM NOTES (SEE FIGURES 14 THRU 17) 1. All field wiring to be accomplished followin g city , local and/or national codes in effect at time of installation of this unit. 2. Caution: Label all wires prior to disconnection when ser- vicing controls. Wiring errors can cause improper and dang ...

  • York 291627-YTG-B-0807 - page 29

    291627-YTG-B-0807 Unitary Products Group 29 MECHANICAL SPECIFICA TIONS GENERAL Units shall be manufactured by York International Unitary Products Group in an ISO 9001 certified facility. YORK’s Affinity™ package units are designed to handle appli cati ons ranging from residential to light commercial and any in between. The Affinity™ is a unit ...

  • York 291627-YTG-B-0807 - page 30

    291627-YTG-B-0807 30 Unitary Products Group be totally enclosed with perman ently lubricated bearings an d internally protected again st overload conditions. REFRIGERANT COMPONENTS Compressors: a. Shall be fully hermetic type, direct drive, interna lly protected with internal hi gh-pre ssure relief and over temperature protection. The hermetic moto ...

  • York 291627-YTG-B-0807 - page 31

    291627-YTG-B-0807 Unitary Products Group 31 ...

  • York 291627-YTG-B-0807 - page 32

    Subject to change without notic e. Printed in U.S.A. 291627-YTG-B-0807 Copyright © 2007 by Unitary Products Group. All ri ghts reserved. Supersedes: 291627-YTG-A-0207 Unitary 5005 Norman Product s Y ork OK Group Drive 73069 ...

Manufacturer York Category Air Conditioner

Documents that we receive from a manufacturer of a York 291627-YTG-B-0807 can be divided into several groups. They are, among others:
- York technical drawings
- 291627-YTG-B-0807 manuals
- York product data sheets
- information booklets
- or energy labels York 291627-YTG-B-0807
All of them are important, but the most important information from the point of view of use of the device are in the user manual York 291627-YTG-B-0807.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals York 291627-YTG-B-0807, service manual, brief instructions and user manuals York 291627-YTG-B-0807. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product York 291627-YTG-B-0807.

Similar manuals

A complete manual for the device York 291627-YTG-B-0807, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use York 291627-YTG-B-0807 by users. Manuals are usually written by a technical writer, but in a language understandable to all users of York 291627-YTG-B-0807.

A complete York manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual York 291627-YTG-B-0807 - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the York 291627-YTG-B-0807, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the York 291627-YTG-B-0807, that we can find in the current document
3. Tips how to use the basic functions of the device York 291627-YTG-B-0807 - which should help us in our first steps of using York 291627-YTG-B-0807
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with York 291627-YTG-B-0807
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of York 291627-YTG-B-0807 in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning York 291627-YTG-B-0807?

Use the form below

If you did not solve your problem by using a manual York 291627-YTG-B-0807, ask a question using the form below. If a user had a similar problem with York 291627-YTG-B-0807 it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)