English dropdown-ico

Manual Chamberlain 3453135556

28 pages 1 mb
Download

Go to site of 28

Summary
  • Chamberlain 3453135556 - page 1

    3453135556 Included W all Control MUST be installed prior to operation of this Garage Door Operator Safe-T -Beam ® Safety Reverse System Must be installed to close door SA VE THIS MANUAL FOR FUTURE REFE RE NC E NOTE: Y our Operator comes with a Rail Assembly which is standard for up to a 7 foot 6 inch high door . An extension kit for an 8 foot hig ...

  • Chamberlain 3453135556 - page 2

    6 To avoid damage to your door and/or operator , make sure you disable any door locks prior to installing your operator . 1 Check your ceiling where the power head of your new unit will be mounted . Plan how you will be mounting the power head. It is possible that ceiling joists may not be in the exact position needed with respect to the garage doo ...

  • Chamberlain 3453135556 - page 3

    3 7 TYPICAL SECTIONAL DOOR INST ALLA TION FOR HELP-1.800.929.3667 OR OVERHEADDOOR.COM TYPICAL SUPPORT BRACKET EXTENSION SPRING OR T ORSION SPRING SAFE-T -BEAM ® BRACES ADDED HEADER BRACKET MOUNTING BOARD TYPICAL 1-PIECE DOOR INST ALLA TION 48" POWER CORD TO 120V GROUNDED OUTLET 4 1 3 6 2 3 5 SECTIONAL DOOR 1-PIECE DOOR ...

  • Chamberlain 3453135556 - page 4

    4 SECTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . PA G E PRE-INST ALLA TION CHECKS . . . . . . . . . . . . . . . . . . . . . . . . . . 2- 3 OPERA TOR FEA TURES . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 SAFETY FEA TURES . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ...

  • Chamberlain 3453135556 - page 5

    5 T OOLS RECOMMENDED FOR HELP-1.800.929.3667 OR OVERHEADDOOR.COM 5/32" Drill Bit 7/16" and 9/16" Sockets Step ladder Drill Ratchet Carpenter ’ s level Pencil T ape measure Wire strippers Phillips screwdriver Adjustable wrench PA R TS IDENTIFICA TION - Not Shown Full Size . 30 40 Single-button remote control Multi-button remote cont ...

  • Chamberlain 3453135556 - page 6

    6 Item Part Name Number Required 1P ower head assembly (box) 1 2B oom assembly (box) 1 3B oom (box) 1 91 /4"-20 x 5/8" hex head bolt (blue bag) 4 10 1/4"-20 hex flange nut (blue bag) 4 11 Carriage assembly (box) 1 12 Boom strap (blue bag) 1 13 Limit switch OPEN (white wire) (green bag) 1 14 Limit switch CLOSE (brown wire) (green bag) ...

  • Chamberlain 3453135556 - page 7

    Power Head Assembly 1J 1N 1X 1L 1N 1E 1K 1D 1A 1N 1H 1B 1Q 1G 1D 1F 49 1P 1M 1N 7 POWER HEAD EXPLODED VIEW Item Part Name 1P ower head assembly 1A Cover (by series/model) 1B Front panel assembly 1D Motor parts 1E Circuit board assembly 1F Capacitor (by series/model) 1G Opto wheel (not shown) 1H Carriage slide 1J Chain 1K Circuit board bracket 1L Dr ...

  • Chamberlain 3453135556 - page 8

    FIG. 1-2 Align arro w . FIG. 1-1 Attach boom strap . 8 OPERA T OR ASSEMBL Y FOR HELP-1.800.929.3667 OR OVERHEADDOOR.COM 1 NO TE: Boom assemblies are for 7 foot 6 inch high door . An extension kit for an 8 foot high door is available. OPEN BLUE P ARTS BAG 1. Attach boom strap (Fig. 1-1) . • Place boom strap against boom so that projection on strap ...

  • Chamberlain 3453135556 - page 9

    FIG. 1-5 Attach emergency release cor d & tag . 9 3. Attach boom to power head. • Place boom in front of power head with boom strap at opposite end. • Support door end of boom (boom strap) at about same height as power head. – Check if magnet is in place (Fig. 1-3 inset) . Insert carriage slide into boom (Fig. 1-3) . (Carriage slide is lo ...

  • Chamberlain 3453135556 - page 10

    10 7. Attach limit switch wires . • Uncoil limit switch wires. – Place into channels located along top of boom. – Run wires back to power head through hole in top of power head (Fig. 1-8) . – Use wire clips to hold wires in place (Fig. 1-9) . • Attach limit switch wires to terminals on power head (Fig. 1-10) . – White wire (“OPEN”) ...

  • Chamberlain 3453135556 - page 11

    FIG. 2-1 Finding highest point of travel (sectional). 11 INST ALLA TION FOR HELP-1.800.929.3667 OR OVERHEADDOOR.COM 2 IMPORT ANT 1. READ AND FOLLOW ALL SAFETY , INST ALLA TION AND OPERA TION INSTRUCTIONS. If you have questions or do not understand an instruction, call Overhead Door Corp. or an authorized Overhead Door Dealer . 2. Do Not install ope ...

  • Chamberlain 3453135556 - page 12

    12 FIG. 2-4 Adding mounting surface . [ 22 ] Doors made of masonite, lightweight wood, fiberglass, and sheet metal must be properly braced before mounting door operator . Contact door manufacturer or distributor for a bracing kit. The Overhead Door Corporation is not responsible for damage caused due to improperly braced door . (Fig. 2-6) CAUTION F ...

  • Chamberlain 3453135556 - page 13

    Mounting Straps [22] 13 MOUNTING THE OPERA T OR: 1. Getting Started . • Position boom/power head assembly (Fig. 2-7) . – Boom strap leaning on wall next to header bracket. – Place material on floor under power head to protect from scratching. (A box, stool, or similar device may be needed to clear a torsion spring, as shown.) 2. Mounting the ...

  • Chamberlain 3453135556 - page 14

    INST ALL DOOR ARMS: Sectional doors OPEN YELLOW P ARTS BAG 1. Attach the arms . • Fasten curved door arm to door bracket using clevis pin (24) and cotter pin (25) (Fig. 2-10) . • Straight arm to carriage using clevis pin (24) and cotter pin (25) (Fig. 2-10) . 2. Connecting the arms . • Slide carriage back and forth to adjust arm length. – O ...

  • Chamberlain 3453135556 - page 15

    3. Wiring . • Route wires (29) using either method shown ( Fig. 3-5) . • Wires along boom are held in place with wire clips. – Wires can be slipped under the wire clips already in place. 15 SAFE-T -BEAM ® SYSTEM INST ALLA TION FOR HELP-1.800.929.3667 OR OVERHEADDOOR.COM 3 NOTE: The operator will not close the door automatically unless the Sa ...

  • Chamberlain 3453135556 - page 16

    FIG. 3-8 T erminal attachments at power head . OPEN RED P ARTS BAG 3. Wiring (cont’) . • Securely fasten wires to wall as you go. – Use insulated staples (included). – Staples should be snug only . 16 • Make wire attachments at “STB’s.” – Splitting and stripping wire ends to be connected as shown (Fig. 3-6) . – Loosen terminal s ...

  • Chamberlain 3453135556 - page 17

    FIG. 5-1 T erminal attac hments at power head . W ALL CONTROL INST ALLA TION FOR HELP-1.800.929.3667 OR OVERHEADDOOR.COM 4 1. Finding the mounting location . • Pick a convenient location for mounting wall control. – Location you choose should be in direct sight of door . – It should be at least 5' above floor to prevent small children fr ...

  • Chamberlain 3453135556 - page 18

    18 CONNECTING TO POWER FOR HELP-1.800.929.3667 OR OVERHEADDOOR.COM 5 1. Plug the operator into a properly grounded electrical outlet . 2. Check Safe-T -Beam ® alignment (Fig. 6-3) . To reduce the risk of electrical shock, this equipment has a grounded type plug that includes a third ( grounding ) pin. This plug will only fit a grounded type outlet ...

  • Chamberlain 3453135556 - page 19

    19 LIMIT SWITCH / FORCE ADJUSTMENT FOR HELP-1.800.929.3667 OR OVERHEADDOOR.COM 6 NOTE: During operator cycling for force adjustment, the motor protector may shut off power to the operator . If this occurs, wait about 20 minutes to allow the motor protector to reset. 1. Adjusting limit switches . • Locate force control knobs on power head (Fig. 7- ...

  • Chamberlain 3453135556 - page 20

    FCC and IC CER TIFIED 20 PROGRAMMING REMOTE CONTROLS 7 FIG. 8-1 Learn code button and LED . 1. Programming . • Locate learn code button and indicator LED on front of power head (under force adjustment screws) (Fig. 8-1) . • Press and release learn code button. – Indicator LED will blink at a rate of twice per second. • Wi thin 30 seconds , ...

  • Chamberlain 3453135556 - page 21

    21 MUL TI-BUTT ON REMOTE 1. Programming . NOTE: Each button on a multi-button remote is designed for use with 1 door . Y ou cannot program 2 buttons to operate the same door , nor can you program 1 button to operate 2 doors. • For each button. – Program each button separately . – Follow single button remote procedure (previous page) for each ...

  • Chamberlain 3453135556 - page 22

    22 IMPORT ANT SAFETY INSTRUCTIONS W ARNING : To reduce the risk of severe injury or death: MAINTENANCE 1. Door springs and hardware . • Do not operate garage door automatically or manually if springs are broken. – CONT ACT A PROFESSIONAL FOR SERVICE . 2. Door balance . • Close the door . • Pull emergency release knob down to release door fr ...

  • Chamberlain 3453135556 - page 23

    23 TROUBLESHOOTING GUIDE (CONTINUED) FOR HELP-1.800.929.3667 OR OVERHEADDOOR.COM • Check lock switch on wall console. • Check power source. – Plug a lamp into outlet used for power head. If lamp works, power source is OK. – If not, check fuse or circuit breaker . • Power is OK. – Check connections at power head terminals. – Check conn ...

  • Chamberlain 3453135556 - page 24

    24 WIRING DIAGRAM FOR HELP-1.800.929.3667 OR OVERHEADDOOR.COM STB Bracket Extensions - Provides additional bracket length where it may be needed for clearance. ...

  • Chamberlain 3453135556 - page 25

    25 INST ALLA TION NOTES FOR HELP-1.800.929.3667 OR OVERHEADDOOR.COM Tr ansmitters comply with all United States and Canadian legal requirements as of the date of manuf acture. No warranty is made that they comply with all legal requirements of an y other jurisdiction. If transmitters are to be used in another countr y , the i mpor ter m ust determi ...

  • Chamberlain 3453135556 - page 26

    26 SA VE THESE INSTRUCTIONS V isit Our W ebsite a t: www.overheaddoor.com Manufactured under one or more of the following U.S. patents: 3,898,582 4,041,259 4,048,630 4,064,487 4,103,238 5,222,403 Other Patents applied for . CORRESPONDENCE WITH F ACT ORY MUST INCLUDE DA TE / MFG. NO. ( LOCA TED UNDER LENS OF POWER HEAD ) FILL THIS IN A T TIME OF INS ...

  • Chamberlain 3453135556 - page 27

    A Universal W all Button Botón de pared universal Bouton mural universel Wireless Keypad Entry System Sistema de entrada por teclado numérico inalámbrico Système d’ouvre-porte de garage à clavier sans fil Universal Conversion Kit Juego de conversión universal Nécessaire de conversion universel 60 W A TT Light Bulb Bombilla de 60 V atios É ...

  • Chamberlain 3453135556 - page 28

    OverHead Door Corporation Access Systems Division 22790 Lake Park Blvd. Alliance, Ohio 44601 Call: 1.800.929.3667 W eb: www .overheaddoor .com ...

Manufacturer Chamberlain Category Garage Door Opener

Documents that we receive from a manufacturer of a Chamberlain 3453135556 can be divided into several groups. They are, among others:
- Chamberlain technical drawings
- 3453135556 manuals
- Chamberlain product data sheets
- information booklets
- or energy labels Chamberlain 3453135556
All of them are important, but the most important information from the point of view of use of the device are in the user manual Chamberlain 3453135556.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Chamberlain 3453135556, service manual, brief instructions and user manuals Chamberlain 3453135556. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Chamberlain 3453135556.

Similar manuals

A complete manual for the device Chamberlain 3453135556, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Chamberlain 3453135556 by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Chamberlain 3453135556.

A complete Chamberlain manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Chamberlain 3453135556 - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Chamberlain 3453135556, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Chamberlain 3453135556, that we can find in the current document
3. Tips how to use the basic functions of the device Chamberlain 3453135556 - which should help us in our first steps of using Chamberlain 3453135556
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Chamberlain 3453135556
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Chamberlain 3453135556 in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Chamberlain 3453135556?

Use the form below

If you did not solve your problem by using a manual Chamberlain 3453135556, ask a question using the form below. If a user had a similar problem with Chamberlain 3453135556 it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)