English dropdown-ico

Manual Brinkmann Series 2630

28 pages 2.25 mb
Download

Go to site of 28

Summary
  • Brinkmann Series 2630 - page 1

    OFF HIGH LOW OFF HIGH LOW OFF HIGH LOW OFF HIGH LOW MAXIMUM SIDE BURNER LOAD = 15 lbs. 1. Read and follow all warnings and instructions in owner’s manual before lighting. 2. Open lid before lighting burner. 3. Make sure all control knobs are in the OFF position. 4. Select the burner to be lit. Push and turn the control knob of that burner to HIGH ...

  • Brinkmann Series 2630 - page 2

    WE W ANT YOU T O ASSEMBLE AND USE YOUR GRILL AS SAFEL Y AS POSSIBLE. THE PURPOSE OF THIS SAFETY ALERT SYMBOL IS TO A TTRACT YOUR A TTENTION TO POSSIBLE HAZARDS AS YOU ASSEMBLE AND USE YOUR GRILL. WHEN YOU SEE THE SAFETY ALERT SYMBOL P A Y CLOSE A TTENTION T O THE INFORMA TION WHICH FOLLOWS! READ ALL SAFETY W ARNINGS AND INSTRUCTIONS CAREFULL Y BEFO ...

  • Brinkmann Series 2630 - page 3

    2 W ARNING • Never use liquid propane gas (LP) in a unit designed for natural gas. • Never use charcoal briquets or lighter fluid in a gas grill. • Leak test all connections before first use, even if grill was purchased fully assembled and after each time the hose is connected to the natural gas supply . • Never check for leaks using a matc ...

  • Brinkmann Series 2630 - page 4

    3 W ARNING W ARNING • DO NOT use hard metal piping of any kind to connect this type of grill to a natural gas source. Use only hose specified by manufacturer . Using hard metal piping or convoluted metal tubing is an unsafe practice. Movement of the grill can cause breakage of metal pipe. • The appliance and its individual shut off valve must b ...

  • Brinkmann Series 2630 - page 5

    4 • Never use your grill without leak testing all gas connections and hoses. See the section on “ Leak T esting ” in this manual for proper procedures. • Visually inspect the hose assembly prior to each use for evidence of damage, excess wear or deterioration. If found, replace the assembly before using your grill. Only the Brinkmann suppli ...

  • Brinkmann Series 2630 - page 6

    LEAK TESTING: T o prevent fire or explosion hazard: • DO NOT smoke or permit ignition sources in the area while conducting a leak test. • Perform test OUTDOORS only in a well ventilated area. • Never perform a leak test with a match or open flame. • Never perform a leak test while the grill is in use or while grill is still hot. WHEN TO PER ...

  • Brinkmann Series 2630 - page 7

    W ARNING 6 6. Check each place listed (A -G) for growing bubbles which indicates a leak. 7. T urn OFF gas supply at natural gas supply . 8. T urn on control knobs to release gas pressure in hose. 9. T urn control knobs to OFF position. 10. T ighten any leaking connections. 1 1. Repeat soapy water test until no leaks are detected. DO NOT use the gri ...

  • Brinkmann Series 2630 - page 8

    LIGHTING INSTRUCTIONS: Follow the instructions exactly . 1. OPEN THE GRILL LID before attempting to light a burner so that fumes do not accumulate inside the grill. An explosion could occur if grill lid is down. 2. Check that all burner control knobs and the natural gas supply are turned to the OFF position. 3. T urn on the natural gas supply . 4. ...

  • Brinkmann Series 2630 - page 9

    LIGHTING THE SIDE BURNER: 1. Open lid to the side burner before lighting. 2. T urn on the side burner by pressing in and rotating the control knob to the HIGH position. 3. Press and hold the igniter button on the main control panel for 3-5 seconds until the burner ignites. 4. If burner does not ignite immediately , turn the burner control knob to O ...

  • Brinkmann Series 2630 - page 10

    9 OPERA TING THE GRILL: Never use Charcoal or Lighter Fluid inside your Natural Gas Grill. Read and follow all warnings and instructions contained in the preceding sections of this manual. BREAKING IN YOUR GRILL: • In manufacturing and preserving the components of your grill, oil residue may be present on the burner and cooking surfaces of your g ...

  • Brinkmann Series 2630 - page 11

    ROTISSERIE COOKING: • Y our grill was pre-drilled from factory to include mounting holes for a Brinkmann rotisserie (sold separately). Do not use a rotisserie not specifically manufactured for this grill. • Read and follow all instructions provided with the rotisserie. Save instructions for future reference. • Do not use the side burner when ...

  • Brinkmann Series 2630 - page 12

    TRANSPORTING AND STORAGE: • Never move a grill when it is hot or when objects are on the cooking surfaces. • Make sure that natural gas supply is shut off. After moving the grill check that all gas connections are free of leaks. Refer to instructions for leak test on page 5 of this manual. • DO NOT store a spare LP gas cylinder (filled or emp ...

  • Brinkmann Series 2630 - page 13

    BURNER ASSEMBL Y/MAINTENANCE • Although your burners are constructed of cast iron, they may rust as a result of the extreme heat and acids from cooking foods. Regularly inspect the burners cracks, abnormal holes, and other signs of corrosion damage. If found, replace the burner . • DO NOT obstruct the flow of combustion and ventilation air . Bu ...

  • Brinkmann Series 2630 - page 14

    TROUBLE SHOOTING: Problem: Possible Causes: • Burner will not light 1. Check natural gas supply . 2. Bad electrode spark. Check to see if the grill will “ match light. ” (See Page 9) Electrode or collector may need adjustment. 3. Burner may not be properly seated. 4. Burner may be obstructed. • Fire at control knobs 1. Burner holes may be o ...

  • Brinkmann Series 2630 - page 15

    14 • T o protect your grill from excessive rust, the unit must be kept clean and covered at all times when not in use. A grill cover may be ordered directly from Brinkmann by calling 1-800-468-5252 or 1-800-527-0717. • W ash cooking grills and heat shields with hot, soapy water , rinse well and dry . Lightly coat cooking grill with vegetable oi ...

  • Brinkmann Series 2630 - page 16

    15 ASSEMBL Y INSTRUCTIONS READ ALL SAFETY W ARNINGS & ASSEMBL Y INSTRUCTIONS CAREFULL Y BEFORE ASSEMBLING OR OPERA TING YOUR GRILL. WE RECOMMEND TWO PEOPLE WORK TOGETHER WHEN ASSEMBLING THIS UNIT . The following provided tools are required to assemble this Brinkmann Pro Series 2630 Grill: • Flathead Screwdriver • Hex Nut Wrench 1 Electronic ...

  • Brinkmann Series 2630 - page 17

    16 (Proof of purchase will be required.) Inspect contents of the box to ensure all parts are included and undamaged. 1 FOR MISSING P ARTS, PLEASE CALL CUSTOMER SER VICE A T 1-800-527-0717. 2 3 4 5 6 7 8 9 10 24 11 13 12 14 15 16 17 18 19 20 21 22 23 27 25 26 28 15 29 30 31 32 33 34 35 36 37 ...

  • Brinkmann Series 2630 - page 18

    17 4 M6 X 12mm bolts 8 M6 X 20mm bolts 14 M6 X 60mm bolts 1 AA /1.5V Alkaline battery P AR TS CARD CONTENTS Make sure you have all items listed under P ARTS LIST and P ARTS BAG CONTENTS before you begin the installation process. Y our Parts Bag will include: M6 X 12mm bolts M6 X 20mm bolts M6 X 60mm bolts AA /1.5V Alkaline battery Screwdriver Hex n ...

  • Brinkmann Series 2630 - page 19

    Choose a good, cleared assembly area and get a friend to help you put your grill together . Lay cardboard down to protect grill finish and assembly area. Step 1 Assemble bottom cart panel and right side cart panel assembly by using four M6 X 60mm bolts (hand tighten only at this point). Step 2 Assemble bottom cart panel and left side cart panel ass ...

  • Brinkmann Series 2630 - page 20

    19 Step 4 Attach back cart panel by using six M6 X 60mm bolts. Note: Leave bolts hand tight until Step 1 1. Step 5 Install door bracket using the four #10 X 1/2 ” self taping screws. Make sure door stop is set toward back of cart. Step 6 Insert right side door , placing lower pivot into the pivot hole on bottom cart panel, then align door with ca ...

  • Brinkmann Series 2630 - page 21

    Step 7 Attach the grease tray bracket onto the back cart panel by inserting the three tabs into the slots on the back cart panel. Note: When performing Step 8, Lift grill body from front and rear panels to avoid injury to hands and fingers. Step 8 With the help of a friend, place grill body assembly on grill cart. Grill body will rest between upper ...

  • Brinkmann Series 2630 - page 22

    21 Step 9 Attach side burner assembly to grill body assembly by inserting four M6 X 20mm bolts through the holes in the side burner assembly and into holes of grill body assembly . T ighten all four bolts. Install side burner grate and control knob. Step 10 Remove the plastic cap on gas supply manifold and attach rubber gas hose to gas supply manif ...

  • Brinkmann Series 2630 - page 23

    Step 12 Attach side table/ice bucket assembly to grill body assembly by inserting four M6 X 20mm bolts through the holes in the side table/ice bucket assembly and into holes of grill body assembly . T ighten all four bolts. Step 13 Insert tool drawer into front opening under control panel by dropping roller wheels into side channels. W arning: DO N ...

  • Brinkmann Series 2630 - page 24

    Step 14 Insert grill bottom into opening on backside of grill. Make sure to slide tray onto tracks as illustrated. Step 15 Slide grease tray into grease tray bracket located under grill bottom on backside of grill. Step 16 Hang stainless steel bucket in cut- out of left side table/ice bucket assembly . Step 17 Place ice bucket insulation around sta ...

  • Brinkmann Series 2630 - page 25

    24 Step 18 Place the stainless steel heat shields on lower level of grill body assembly directly above burners. Step 19 Place stainless steel cooking grills on support ribs directly above stainless steel heat shields. Step 20 Place warming rack in slots above stainless steel cooking grills. OFF HIGH LOW OFF HIGH LOW OFF HIGH LOW OFF HIGH LOW MAXIMU ...

  • Brinkmann Series 2630 - page 26

    PROFESSIONAL SHISH-KABOB SKEWERS These heavy-duty , 18" shish-kabob skewers are extra-long for fabulous restaurant style kabobs. Made of rust resistant stainless steel to last for years. SET OF 12 812-2904-0 ACCESSORIES 25 RIB RACK Chrome-plated rack can greatly increase the cooking capacity of your grill. Holds ribs, chicken halves, potatoes ...

  • Brinkmann Series 2630 - page 27

    ACCESSORIES LOOK FOR THESE AND OTHER BRINKMANN ACCESSORIES A T YOUR LOCAL RET AILER WHERE SMOKERS ARE SOLD, OR ORDER DIRECT BY CALLING 1-800-468-5252. THE UL TIMA TE 5-PIECE BBQ TOOL SET Yo u ’ ll be the envy of your fellow outdoor chefs with this ultimate BBQ tool set. It ’ s sleek ergonomic design combined with durable, heavy- gauge stainless ...

  • Brinkmann Series 2630 - page 28

    10/03 140-2630-0 W ARRANTY ©2002 The Brinkmann Corporation Dallas, T exas 75244 U.S.A www .brinkmanncorp.com The Brinkmann Corporation warrants to the original purchaser that the Brinkmann Stainless Steel Pro Series 2630 TM is free from defects due to workmanship or materials for: Stainless steel and die cast parts - Lifetime Electronic ignition a ...

Manufacturer Brinkmann Category Gas Grill

Documents that we receive from a manufacturer of a Brinkmann Series 2630 can be divided into several groups. They are, among others:
- Brinkmann technical drawings
- Series 2630 manuals
- Brinkmann product data sheets
- information booklets
- or energy labels Brinkmann Series 2630
All of them are important, but the most important information from the point of view of use of the device are in the user manual Brinkmann Series 2630.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Brinkmann Series 2630, service manual, brief instructions and user manuals Brinkmann Series 2630. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Brinkmann Series 2630.

Similar manuals

A complete manual for the device Brinkmann Series 2630, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Brinkmann Series 2630 by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Brinkmann Series 2630.

A complete Brinkmann manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Brinkmann Series 2630 - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Brinkmann Series 2630, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Brinkmann Series 2630, that we can find in the current document
3. Tips how to use the basic functions of the device Brinkmann Series 2630 - which should help us in our first steps of using Brinkmann Series 2630
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Brinkmann Series 2630
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Brinkmann Series 2630 in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Brinkmann Series 2630?

Use the form below

If you did not solve your problem by using a manual Brinkmann Series 2630, ask a question using the form below. If a user had a similar problem with Brinkmann Series 2630 it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)