English dropdown-ico

Manual Yamaha PW50Y

72 pages 1.72 mb
Download

Go to site of 72

Summary
  • Yamaha PW50Y - page 1

    5PG-28199-18 PW50Y OWNER’S MANUAL Read this manual carefully before operating this vehicle. LIT-11626-22-24 ...

  • Yamaha PW50Y - page 2

    EAU10042 Read this manual carefully bef ore operating this vehic le . This manual should sta y with this vehicle if it is sold. Q ...

  • Yamaha PW50Y - page 3

    INTRODUCTION EAU41062 Congratulations on your purchase of the Yamaha PW50(Y). This model is the result of Yamaha’s vast experience in the pro- duction of fine sporting, touring, and pacesetting racing machines. It represents the high degree of craftsmanship and reli- ability that have made Yamaha a leader in these fields. This manual will give yo ...

  • Yamaha PW50Y - page 4

    INTRODUCTION AN IMPORTANT SAFETY MESSAGE: ● Read this manual, the “PARENTS, YOUNGSTERS AND OFF-HIGHWAY MOTORCYCLES” booklet, and the “TIPS AND PRACTICE GUIDE FOR THE OFF HIGHWAY MOTORCYCLIST” booklet carefully and completely before oper- ating this motorcycle. Make sure you understand all instructions. ● Pay close attention to the warni ...

  • Yamaha PW50Y - page 5

    INTRODUCTION ● Obtain qualified training in safe and proper riding techniques. ● Obtain professional technical service as indicated in this Owner’s Manual and/or when made necessary by mechanical conditions. ...

  • Yamaha PW50Y - page 6

    IMPORTANT MANUAL INFORMATION EAU10132 Particularly important information is distinguished in this manual by the following notations: This is the safety alert symbol. It is used to alert you to potential personal injury hazards. Obey all safety messa ges that follo w this symbol to av oid possible injury or death. A W ARNING indicates a hazardous si ...

  • Yamaha PW50Y - page 7

    IMPORTANT MANUAL INFORMATION EAU10193 PW50(Y) O WNER ’ S MANU AL ©2008 by Y amaha Motor Corporation, U.S.A. 1st edition, March 2008 All rights reserved. Any reprinting or unauthorized use without the written permission of Y amaha Motor Corporation, U.S.A. is expressl y prohibited. Printed in Japan. P/N LIT -11626-22-24 ...

  • Yamaha PW50Y - page 8

    TABLE OF CONTENTS LOCATION OF IMPORTANT LABELS .............................................. 1-1 SAFETY INFORMATION ................... 2-1 DESCRIPTION ................................... 3-1 Left view ...........................................3-1 Right view ......................................... 3-2 Controls and instruments .................. ...

  • Yamaha PW50Y - page 9

    TABLE OF CONTENTS CONSUMER INFORMATION ............ 10-1 Identification numbers ................... 10-1 Motorcycle noise regulation ........... 10-2 YAMAHA MOTOR CORPORATION, U.S.A. OFF-ROAD MOTORCYCLE LIMITED WARRANTY ............... 10-3 YAMAHA EXTENDED SERVICE (Y.E.S.) ...................................... 10-5 ...

  • Yamaha PW50Y - page 10

    1-1 1 LOCATION OF IMPORTANT LABELS EAU41371 Read and understand all of the labels on your vehicle. They contain important information for safe and proper operation of your vehicle. Never remove any labels from your vehicle. If a label becomes difficult to read or comes off, a replacement label is available from your Yamaha dealer. 2 1 ...

  • Yamaha PW50Y - page 11

    LOCATION OF IMPORTANT LABELS 1-2 1 2 3 4 5 6 7 8 9 1 W ARNING BEFORE YOU OPERA TE THIS VEHICLE, READ THE OWNER’S MANUAL AND ALL LABELS. NEVER CARRY A P ASSENGER. Y ou increase your risk of losing control if you carry a passenger. NEVER OPERA TE THIS VEHICLE ON PUBLIC ROADS. Yo u can collide with another vehicle if you operate this vehicle on a pu ...

  • Yamaha PW50Y - page 12

    2-1 1 2 SAFETY INFORMATION EAU40933 Be a Responsible Owner As the vehicle ’ s owner, you are respon- sible for the safe and proper operation of your motorcycle. Motorcycles are single-track vehicles. Their safe use and operation are de- pendent upon the use of proper riding techniques as well as the expertise of the operator. Every operator shoul ...

  • Yamaha PW50Y - page 13

    SAFETY INFORMATION 2-2 1 2 cornering (insufficient lean angle for the speed). Never travel faster than warranted by conditions. ● Ride cautiously in unfamiliar ar- eas. You may encounter hidden obstacles that could cause an ac- cident. ● The posture of the operator is im- portant for proper control. The op- erator should keep both hands on the ...

  • Yamaha PW50Y - page 14

    SAFETY INFORMATION 2-3 1 2 your motorcycle. Use extra care when riding a motorcycle that has added ac- cessories. Here are some general guidelines to follow if adding accesso- ries to your motorcycle: Operation of an overloaded vehicle could cause an accident. ● The weight of the operator must not exceed 25 kg (55 lb). ● Accessory weight should ...

  • Yamaha PW50Y - page 15

    SAFETY INFORMATION 2-4 1 2 ries are added to the handlebar or front fork area, they must be as lightweight as possible and should be kept to a minimum. ● Bulky or large accessories may seriously affect the stability of the motorcycle. Wind may at- tempt to lift the motorcycle, or the motorcycle may become un- stable in cross winds. ● Certain ac ...

  • Yamaha PW50Y - page 16

    3-1 1 2 3 4 5 6 7 8 9 DESCRIPTION EAU10410 Left view 12 3 4 5 1. Fuel cock (page 4-5) 2. Throttle stop screw (page 7-11) 3. Air fi lter element (page 7-9) 4. Kickstarter (page 4-6) 5. Centerstand (page 7-18) ...

  • Yamaha PW50Y - page 17

    DESCRIPTION 3-2 2 3 4 5 6 7 8 9 EAU10420 Right view 3 1 2 4 1. Spark arrester (page 7-10) 2. Seat (page 4-7) 3. T ransmission oil fi ller cap (page 7-8) 4. 2-stroke engine oil tank (page 4-5) ...

  • Yamaha PW50Y - page 18

    DESCRIPTION 3-3 1 2 3 4 5 6 7 8 9 EAU10430 Controls and instruments 12 7 34 5 6 1. Rear brake le ver (page 4-3) 2. Star ter (choke) le ver (page 4-6) 3. 2-stroke engine oil tank cap (page 4-5) 4. Right handlebar switch (page 4-1) 5. F ront brake lev er (page 4-2) 6. Throttle grip (page 7-12) 7. Fuel tank cap (page 4-3) ...

  • Yamaha PW50Y - page 19

    4-1 2 3 4 5 6 7 8 9 INSTRUMENT AND CONTROL FUNCTIONS EAU40660 Handlebar switch EAU40674 Engine stop switch “ OFF/RUN/ START ” Set this switch to “ START ” before start- ing the engine. Set this switch to “ RUN ” after warming up the engine or before starting off. Set this switch to “ OFF ” to stop the engine. TIP ● The engine cann ...

  • Yamaha PW50Y - page 20

    INSTRUMENT AND CONTROL FUNCTIONS 4-2 1 2 3 4 5 6 7 8 9 3. Tighten the locknut. TIP The adjusting range of the speed limiter screw is from the fully turned-in position to 7 mm (0.28 in) turned out. When the screw is turned out to 7 mm (0.28 in), the throttle grip can only be opened ap- proximately halfway. If more power is required, please consult a ...

  • Yamaha PW50Y - page 21

    INSTRUMENT AND CONTROL FUNCTIONS 4-3 2 3 4 5 6 7 8 9 EAU12950 Rear brake lever The rear brake lever is located on the left handlebar grip. To apply the rear brake, pull this lever toward the handle- bar grip. EAU13182 Fuel tank cap To remove the fuel tank cap, turn it counterclockwise, and then pull it off. To install the fuel tank cap, insert it i ...

  • Yamaha PW50Y - page 22

    INSTRUMENT AND CONTROL FUNCTIONS 4-4 1 2 3 4 5 6 7 8 9 3. Wipe up any spilled fuel immedi- ately. NOTICE: Immediately wipe off spilled fuel with a clean, dry, soft cloth, since fuel may deteri- orate painted surfaces or plastic parts. [ECA10071] 4. Be sure to securely close the fuel tank cap. W ARNING EWA15151 Gasoline is poisonous and can cause in ...

  • Yamaha PW50Y - page 23

    INSTRUMENT AND CONTROL FUNCTIONS 4-5 2 3 4 5 6 7 8 9 EAU13412 Fuel tank breather hose Before operating the motorcycle: ● Check the fuel tank breather hose connection. ● Check the fuel tank breather hose for cracks or damage, and replace it if damaged. ● Make sure that the fuel tank breather hose is not blocked, and clean it if necessary. EAU1 ...

  • Yamaha PW50Y - page 24

    INSTRUMENT AND CONTROL FUNCTIONS 4-6 1 2 3 4 5 6 7 8 9 O (on) With the lever in this position, fuel flows to the carburetor. Normal riding is done with the lever in this position. EAU13590 Starter (choke) lever “” Starting a cold engine requires a richer air-fuel mixture, which is supplied by the starter (choke). Move the lever in direction (a) ...

  • Yamaha PW50Y - page 25

    INSTRUMENT AND CONTROL FUNCTIONS 4-7 2 3 4 5 6 7 8 9 EAU40920 Seat To remove the seat 1. Remove the mudguard by remov- ing the bolts and washers. 2. Pull the seat off. To install the seat 1. Insert the projection on the front of the seat into the seat holder as shown. 2. Place the seat in the original posi- tion. 3. Install the mudguard by installi ...

  • Yamaha PW50Y - page 26

    5-1 1 2 3 4 5 6 7 8 9 FOR YOUR SAFETY – PRE-OPERATION CHECKS EAU15595 Inspect your vehicle each time you use it to make sure the vehicle is in safe operating condition. Always follow the inspection and maintenance procedures and schedules described in the Owner ’ s Manual. W ARNING EWA11151 Failure to inspect or maintain the vehicle properly in ...

  • Yamaha PW50Y - page 27

    FOR YOUR SAFETY – PRE-OPERATION CHECKS 5-2 2 3 4 5 6 7 8 9 EAU15605 Pre-operation check list ITEM CHECKS P AGE Fuel ● Check fuel le vel in fuel tank. ● Refuel if necessary . ● Check fuel line f or leakage. 4-3 2-stroke engine oil ● Check oil le vel in oil tank. ● If necessary , add recommended oil to speci fi ed lev el. ● Check v ehi ...

  • Yamaha PW50Y - page 28

    FOR YOUR SAFETY – PRE-OPERATION CHECKS 5-3 1 2 3 4 5 6 7 8 9 Centerstand ● Make sure that operation is smooth. ● Lubricate pivot if necessary . 7-18 Chassis fasteners ● Make sure that all nuts , bolts and screws are properly tightened. ● Tighten if necessary . — Engine stop switch ● Check operation. 4-1 ITEM CHECKS P AGE ...

  • Yamaha PW50Y - page 29

    6-1 2 3 4 5 6 7 8 9 OPERATION AND IMPORTANT RIDING POINTS EAU40771 W ARNING EWA14531 ● This model is designed for off-road use only. Become thor- oughly familiar with all operat- ing controls and their functions before riding. Consult a Yamaha dealer regarding any control or function that you do not thor- oughly understand. ● Never start the en ...

  • Yamaha PW50Y - page 30

    OPERATION AND IMPORTANT RIDING POINTS 6-2 1 2 3 4 5 6 7 8 9 EAU41001 Starting off TIP Before starting off, allow the engine to warm up. 1. While applying the rear brake le- ver, push the motorcycle off the centerstand. 2. Completely close the throttle. 3. Set the engine stop switch to “ RUN ” . 4. Check for oncoming off-road vehi- cles, and the ...

  • Yamaha PW50Y - page 31

    OPERATION AND IMPORTANT RIDING POINTS 6-3 2 3 4 5 6 7 8 9 Front Rear EAU42030 Engine break-in There is never a more important period in the life of your engine than the first 5 hours of riding. It is also important to ac- custom the rider to the motorcycle dur- ing this time. Please read the following information carefully. Since the engine is bran ...

  • Yamaha PW50Y - page 32

    OPERATION AND IMPORTANT RIDING POINTS 6-4 1 2 3 4 5 6 7 8 9 EAU40722 Parking When parking, stop the engine, and then turn the fuel cock lever to “ S ” (stop). W ARNING EWA10311 ● Since the engine and exhaust system can become very hot, park in a place where pedestri- ans or children are not likely to touch them and be burned. ● Do not park ...

  • Yamaha PW50Y - page 33

    7-1 2 3 4 5 6 7 8 9 PERIODIC MAINTENANCE AND ADJUSTMENT EAU41951 Periodic inspection, adjustment, and lu- brication will keep your vehicle in the safest and most efficient condition pos- sible. Safety is an obligation of the vehi- cle owner/operator. The most important points of vehicle inspection, adjust- ment, and lubrication are explained on the ...

  • Yamaha PW50Y - page 34

    PERIODIC MAINTENANCE AND ADJUSTMENT 7-2 1 2 3 4 5 6 7 8 9 EAU17311 Owner ’ s tool kit The service information included in this manual and the tools provided in the owner ’ s tool kit are intended to assist you in the performance of preventive maintenance and minor repairs. How- ever, additional tools such as a torque wrench may be necessary to ...

  • Yamaha PW50Y - page 35

    PERIODIC MAINTENANCE AND ADJUSTMENT 7-3 2 3 4 5 6 7 8 9 EAU41741 Periodic maintenance chart for the emission control system TIP ● From 18 months, repeat the maintenance intervals starting from 6 months. ● Items marked with an asterisk should be performed by a Yamaha dealer as they require special tools, data and technical skills. NO . ITEM CHEC ...

  • Yamaha PW50Y - page 36

    PERIODIC MAINTENANCE AND ADJUSTMENT 7-4 1 2 3 4 5 6 7 8 9 EAU41753 General maintenance and lubrication chart NO . ITEM CHECK OR MAINTENANCE JOB INITIAL THEREAFTER EVER Y 1 month 3 months 6 months 6 months 12 months 1* Front brake Check operation. Adjust brake le ver free pla y . Replace brake shoes . Whenev er wor n to the limit 2* Rear brake Check ...

  • Yamaha PW50Y - page 37

    PERIODIC MAINTENANCE AND ADJUSTMENT 7-5 2 3 4 5 6 7 8 9 TIP The air filter needs more frequent service if you are riding in unusually wet or dusty areas. 10 * T ransmission oil Check for oil leakage . Correct if necessary . Change. 11 * Front and rear brake lever piv ot Apply lithium-soap-based grease lightly. 12 * Centerstand piv ot Check operatio ...

  • Yamaha PW50Y - page 38

    PERIODIC MAINTENANCE AND ADJUSTMENT 7-6 1 2 3 4 5 6 7 8 9 EAU19603 Checking the spark plug The spark plug is an important engine component, which is easy to check. Since heat and deposits will cause any spark plug to slowly erode, the spark plug should be removed and checked in accordance with the periodic mainte- nance and lubrication chart. In ad ...

  • Yamaha PW50Y - page 39

    PERIODIC MAINTENANCE AND ADJUSTMENT 7-7 2 3 4 5 6 7 8 9 then wipe off any grime from the spark plug threads. 3. Install the spark plug with the spark plug wrench, and then tight- en it to the specified torque. TIP If a torque wrench is not available when installing a spark plug, a good estimate of the correct torque is 1/4 – 1/2 turn past finger ...

  • Yamaha PW50Y - page 40

    PERIODIC MAINTENANCE AND ADJUSTMENT 7-8 1 2 3 4 5 6 7 8 9 EAU40892 Transmission oil The transmission oil must be checked for oil leakage before each ride. If any leakage is found, have a Yamaha deal- er check and repair the motorcycle. In addition, the transmission oil must be changed at the intervals specified in the periodic maintenance and lubri ...

  • Yamaha PW50Y - page 41

    PERIODIC MAINTENANCE AND ADJUSTMENT 7-9 2 3 4 5 6 7 8 9 EAU41711 Middle and final gear cases The middle and final gear cases must be checked for grease leakage before each ride. If any leakage is found, have a Yamaha dealer check and repair the motorcycle. In addition, have a Yamaha dealer check and lubricate the middle and final gears at the inter ...

  • Yamaha PW50Y - page 42

    PERIODIC MAINTENANCE AND ADJUSTMENT 7-10 1 2 3 4 5 6 7 8 9 not dripping. 5. Insert the sponge material into the air filter case. NOTICE: Make sure that the sponge material is prop- erly seated in the air filter case. The engine should never be op- erated without the sponge mate- rial installed, otherwise the piston(s) and/or cylinder(s) may become ...

  • Yamaha PW50Y - page 43

    PERIODIC MAINTENANCE AND ADJUSTMENT 7-11 2 3 4 5 6 7 8 9 3. Insert the tailpipe into the muffler, and then install and tighten the screw. TIP Make sure to align the screw hole when inserting the tailpipe. EAU39930 Adjusting the carburetor The carburetor is an important part of the engine and requires very sophisti- cated adjustment. Therefore, most ...

  • Yamaha PW50Y - page 44

    PERIODIC MAINTENANCE AND ADJUSTMENT 7-12 1 2 3 4 5 6 7 8 9 direction (b). TIP If the specified idling speed cannot be obtained as described above, have a Yamaha dealer make the adjustment. EAU21382 Checking the throttle cable free play The throttle cable free play should mea- sure 1.5 – 3.5 mm (0.06 – 0.14 in) at the throttle grip. Periodically ...

  • Yamaha PW50Y - page 45

    PERIODIC MAINTENANCE AND ADJUSTMENT 7-13 2 3 4 5 6 7 8 9 Tire inspection The tires must be checked before each ride. If the center tread depth reaches the specified limit, if the tire has a nail or glass fragments in it, or if the sidewall is cracked, have a Yamaha dealer re- place the tire immediately. Tire information This motorcycle is equipped ...

  • Yamaha PW50Y - page 46

    PERIODIC MAINTENANCE AND ADJUSTMENT 7-14 1 2 3 4 5 6 7 8 9 very carefully and replace it as soon as possible with a high-quality product. EAU40780 Panel wheels W ARNING EWA10610 The wheels on this model are not de- signed for use with tubeless tires. Do not attempt to use tubeless tires on this model. To maximize the performance, durabil- ity, and ...

  • Yamaha PW50Y - page 47

    PERIODIC MAINTENANCE AND ADJUSTMENT 7-15 2 3 4 5 6 7 8 9 EAU22151 Adjusting the front and rear brake lever free play Front Rear The front and rear brake lever free play should be measured at the positions as shown. Periodically check the front and rear brake lever free play and, if necessary, adjust them as follows. To increase the brake lever free ...

  • Yamaha PW50Y - page 48

    PERIODIC MAINTENANCE AND ADJUSTMENT 7-16 1 2 3 4 5 6 7 8 9 EAU41052 Checking the front and rear brake shoes The front and rear brake shoes must be checked for wear at the intervals spec- ified in the periodic maintenance and lubrication chart. TIP The wheels must be removed to check brake shoe lining thickness. ● To remove the front wheel: See pa ...

  • Yamaha PW50Y - page 49

    PERIODIC MAINTENANCE AND ADJUSTMENT 7-17 2 3 4 5 6 7 8 9 EAU23111 Checking and lubricating the throttle grip and cable The operation of the throttle grip should be checked before each ride. In addi- tion, the cable should be lubricated at the intervals specified in the periodic maintenance chart. EAU23120 Adjusting the Autolube pump The Autolube pu ...

  • Yamaha PW50Y - page 50

    PERIODIC MAINTENANCE AND ADJUSTMENT 7-18 1 2 3 4 5 6 7 8 9 EAU23192 Checking and lubricating the centerstand The operation of the centerstand should be checked before each ride, and the pivots and metal-to-metal con- tact surfaces should be lubricated if necessary. W ARNING EWA11301 If the centerstand does not move up and down smoothly, have a Yama ...

  • Yamaha PW50Y - page 51

    PERIODIC MAINTENANCE AND ADJUSTMENT 7-19 2 3 4 5 6 7 8 9 EAU45511 Checking the steering Worn or loose steering bearings may cause danger. Therefore, the operation of the steering must be checked as fol- lows at the intervals specified in the pe- riodic maintenance and lubrication chart. 1. Place the vehicle on the center- stand. WARNING! To avoid i ...

  • Yamaha PW50Y - page 52

    PERIODIC MAINTENANCE AND ADJUSTMENT 7-20 1 2 3 4 5 6 7 8 9 3. Remove the axle nut and washer. 4. Pull the wheel axle out, and then remove the wheel. EAU41031 To install the front wheel 1. Install the brake shoe plate into the wheel hub as shown. 2. Lift the wheel up between the fork legs. TIP Make sure that the slot in the brake shoe plate fits ove ...

  • Yamaha PW50Y - page 53

    PERIODIC MAINTENANCE AND ADJUSTMENT 7-21 2 3 4 5 6 7 8 9 8. Push down hard on the handlebar several times to check for proper fork operation. EAU25080 Rear wheel EAU41082 To remove the rear wheel W ARNING EWA10821 To avoid injury, securely support the vehicle so there is no danger of it falling over. 1. Place the motorcycle on the cen- terstand. 2. ...

  • Yamaha PW50Y - page 54

    PERIODIC MAINTENANCE AND ADJUSTMENT 7-22 1 2 3 4 5 6 7 8 9 5. Remove the exhaust chamber bolt and washers. 6. Remove the exhaust manifold bolts, and then remove the ex- haust chamber. 7. Remove the right-side rear shock absorber mounting bolt and then tilt the rear shock absorber upward as shown. 8. Remove the axle nut while apply- ing the rear bra ...

  • Yamaha PW50Y - page 55

    PERIODIC MAINTENANCE AND ADJUSTMENT 7-23 2 3 4 5 6 7 8 9 sorber by installing the mounting bolt. 6. While applying the rear brake, tighten the axle nut to the specified torque. 7. Tighten the rear arm nuts and rear shock absorber mounting bolt to the specified torques. 8. Install the exhaust chamber and then install the exhaust manifold bolts. 9. I ...

  • Yamaha PW50Y - page 56

    PERIODIC MAINTENANCE AND ADJUSTMENT 7-24 1 2 3 4 5 6 7 8 9 EAU25851 Troubleshooting Although Yamaha motorcycles receive a thorough inspection before shipment from the factory, trouble may occur dur- ing operation. Any problem in the fuel, compression, or ignition systems, for example, can cause poor starting and loss of power. The following trouble ...

  • Yamaha PW50Y - page 57

    PERIODIC MAINTENANCE AND ADJUSTMENT 7-25 2 3 4 5 6 7 8 9 EAU25972 Troubleshooting chart Check the fuel level in the fuel tank. 1. Fuel There is enough fuel. There is no fuel. Supply fuel. Operate the kickstarter. 2. Compression There is compression. There is no compression. Check the ignition. Have a Yamaha dealer check the vehicle. Remove the spar ...

  • Yamaha PW50Y - page 58

    8-1 1 2 3 4 5 6 7 8 9 MOTORCYCLE CARE AND STORAGE EAU37833 Matte color caution NO TICE ECA15192 Some models are equipped with matte colored finished parts. Be sure to consult a Yamaha dealer for advice on what products to use be- fore cleaning the vehicle. Using a brush, harsh chemical products or cleaning compounds when cleaning these parts will s ...

  • Yamaha PW50Y - page 59

    MOTORCYCLE CARE AND STORAGE 8-2 2 3 4 5 6 7 8 9 cleaning products, solvent or thinner, fuel (gasoline), rust re- movers or inhibitors, brake flu- id, antifreeze or electrolyte. ● Do not use high-pressure wash- ers or steam-jet cleaners since they cause water seepage and deterioration in the following ar- eas: seals (of wheel and swing- arm bearin ...

  • Yamaha PW50Y - page 60

    MOTORCYCLE CARE AND STORAGE 8-3 1 2 3 4 5 6 7 8 9 braking performance and cor- nering behavior. NO TICE ECA10800 ● Apply spray oil and wax spar- ingly and make sure to wipe off any excess. ● Never apply oil or wax to any rubber and plastic parts, but treat them with a suitable care product. ● Avoid using abrasive polishing compounds as they w ...

  • Yamaha PW50Y - page 61

    MOTORCYCLE CARE AND STORAGE 8-4 2 3 4 5 6 7 8 9 install the spark plug and the spark plug cap. WARNING! To prevent damage or injury from sparking, make sure to ground the spark plug elec- trodes while turning the en- gine over. [EWA10951] 6. Lubricate all control cables and the pivoting points of all levers and pedals as well as of the center- stan ...

  • Yamaha PW50Y - page 62

    9-1 1 2 3 4 5 6 7 8 9 SPECIFICATIONS EAU2633N Dimensions: Overall length: 1245 mm (49.0 in) Overall width: 575 mm (22.6 in) Overall height: 715 mm (28.1 in) Seat height: 485 mm (19.1 in) Wheelbase: 855 mm (33.7 in) Ground clearance: 105 mm (4.13 in) Minimum turning radius: 1300 mm (51.2 in) Weight: With oil and fuel: 39.0 kg (86 lb) Engine: Engine ...

  • Yamaha PW50Y - page 63

    SPECIFICATIONS 9-2 2 3 4 5 6 7 8 9 Size: 2.50-10 4PR Manufacturer/model: BRIDGESTONE/KNOBBY Manufacturer/model: IRC/KNOBBY Loading: Maximum rider weight: 25.0 kg (55 lb) * (T otal weight of r ider , cargo and accessories) Tire air pressure (measured on cold tires): Front: 100 kPa (1.00 kgf/cm 2 , 15 psi) Rear: 100 kPa (1.00 kgf/cm 2 , 15 psi) Front ...

  • Yamaha PW50Y - page 64

    10-1 1 2 3 4 5 6 7 8 9 10 CONSUMER INFORMATION EAU40790 Identification numbers Record the vehicle identification num- ber and model label information in the spaces provided below for assistance when ordering spare parts from a Yamaha dealer or for reference in case the vehicle is stolen. VEHICLE IDENTIFICATION NUMBER: MODEL LABEL INFORMATION: EAU26 ...

  • Yamaha PW50Y - page 65

    CONSUMER INFORMATION 10-2 2 3 4 5 6 7 8 9 10 EAU26560 Motorcycle noise regulation TAMPERING WITH NOISE CONTROL SYSTEM PROHIBITED: Federal law prohibits the following acts or the causing thereof: (1) The removal or rendering inoperative by any person other than for purposes of maintenance, repair, or replacement of any device or element of design in ...

  • Yamaha PW50Y - page 66

    CONSUMER INFORMATION 10-3 1 2 3 4 5 6 7 8 9 10 EAU38051 YAMAHA MOTOR CORPORATION, U.S.A. OFF-ROAD MOTORCYCLE LIMITED WARRANTY Y amaha Motor Cor poration, USA hereby w arrants that new Y amaha off-road motorcycles purchased from an authorized Y amaha motorcycle dealer in the continental United States will be free from defects in material and workman ...

  • Yamaha PW50Y - page 67

    CONSUMER INFORMATION 10-4 2 3 4 5 6 7 8 9 10 ...

  • Yamaha PW50Y - page 68

    CONSUMER INFORMATION 10-5 1 2 3 4 5 6 7 8 9 10 EAU26750 YAMAHA EXTENDED SERVICE (Y.E.S.) K eep your Y amaha protected ev en after your w arranty expires with gen uine Y amaha Extended Ser vice (Y .E.S.). Y .E.S. is designed and administered b y Y amaha Motor Corporation to provide maximum owner satisf action. Y ou get uninterrupted factory-backed c ...

  • Yamaha PW50Y - page 69

    CONSUMER INFORMATION 10-6 2 3 4 5 6 7 8 9 10 We urge y ou to act now . Y ou ’ ll get the excellent benefits of TRIP cov erage right awa y , and you ’ ll rest easy kno wing you ’ ll hav e strong factory-back ed protection ev en after your Y amaha Limited Warranty e xpires. A special note: If visiting your dealer isn ’ t con venient, contact ...

  • Yamaha PW50Y - page 70

    INDEX A Acceleration and deceleration................... 6-2 Air filter element, cleaning......................... 7-9 Autolube pump, adjusting ....................... 7-17 B Brake lever, front....................................... 4-2 Brake lever, rear ....................................... 4-3 Brake levers, lubricating.......................... ...

  • Yamaha PW50Y - page 71

    ...

  • Yamaha PW50Y - page 72

    PRINTED ON RECYCLED PAPER Y AMAHA MOT OR CO. , L TD . PRINTED IN JAPAN 2008.4–0.7 × 1 ! (E) ...

Manufacturer Yamaha Category Motorcycle

Documents that we receive from a manufacturer of a Yamaha PW50Y can be divided into several groups. They are, among others:
- Yamaha technical drawings
- PW50Y manuals
- Yamaha product data sheets
- information booklets
- or energy labels Yamaha PW50Y
All of them are important, but the most important information from the point of view of use of the device are in the user manual Yamaha PW50Y.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Yamaha PW50Y, service manual, brief instructions and user manuals Yamaha PW50Y. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Yamaha PW50Y.

Similar manuals

A complete manual for the device Yamaha PW50Y, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Yamaha PW50Y by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Yamaha PW50Y.

A complete Yamaha manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Yamaha PW50Y - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Yamaha PW50Y, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Yamaha PW50Y, that we can find in the current document
3. Tips how to use the basic functions of the device Yamaha PW50Y - which should help us in our first steps of using Yamaha PW50Y
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Yamaha PW50Y
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Yamaha PW50Y in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Yamaha PW50Y?

Use the form below

If you did not solve your problem by using a manual Yamaha PW50Y, ask a question using the form below. If a user had a similar problem with Yamaha PW50Y it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)