-
Lopi 1080 - page 1
1080 C F F ir ep lace • Operation • Maintenance Tested and Listed by OMNI-Test Laboratories, Inc. Beaverton, Oregon Report # 028-F-81-5 ANSI Z21.88a-2007 WARNING: I f the information in these instructions is not followed exactly, a fire or explosion may result causing property damage, personal injury or loss of life. - Do not store or use gasol ...
-
Lopi 1080 - page 2
2 Introduction © Travis Industries 4070710 100-01194_000 Introduction We welcome you as a new owner of a 1080 CF gas fireplace. This manual details operation and maintenance of this fireplace. Please familiarize yourself with the Owner's Manual before operating your heater and save the manual for future reference. Important Information No oth ...
-
Lopi 1080 - page 3
Introduction 3 © Travis Industries 4070710 100-01194_000 Table of Contents Introduction and Important Information Introduction ............................................................. 2 Important Information ............................................... 2 Installation Warnings ................................................ 2 Features .... ...
-
Lopi 1080 - page 4
4 Safety Precautions © Travis Industries 4070710 100-01194_000 IF YOU SMELL GAS: * Do not light any appliance * Extinguish any open flame * Do not touch any electrical switch or plug or unplug anything * Open windows and vacate building * Call gas supplier from neighbor's house, if not reached, call fire department This unit must be installed ...
-
Lopi 1080 - page 5
Safety Precautions 5 © Travis Industries 4070710 100-01194_000 Do not place clothin g or other flammable items on or near the heater. Because this heater can be controlled by a thermostat there is a possibility of the heater turning on and igniting any items placed on or near it. Li g ht the heater usin g the built- in electronic igniter. Do not u ...
-
Lopi 1080 - page 6
6 Operation © Travis Industries 4070710 100-01194_000 Before You Begin Read this entire manual before you use your new fireplace (especially the section "Safety Precautions" on pages 4 & 5). Failure to follow the instructions may result in property damage, bodily injury, or even death. Controls Remote Control The remote control can t ...
-
Lopi 1080 - page 7
Operation 7 © Travis Industries 4070710 100-01194_000 The Two Modes of Operation This fireplace uses both a wall switch and thermostat to control the fireplace. NOTE: W hichever component is operated last controls the fireplace. If you are using the remote and you press any button on the wall switch, the remote is no longer in control of the firep ...
-
Lopi 1080 - page 8
8 Operation © Travis Industries 4070710 100-01194_000 Starting the Fireplace for the First Time • Burn the heater at a high setting for an extended period (up to 48 hours). This will cure the painted surfaces. Fumes from the paint curing and oil burning off the steel will occur. This is normal. We recommend opening a window to vent the room. • ...
-
Lopi 1080 - page 9
Maintenance 9 © Travis Industries 4070710 100-01194_000 Yearly Service Procedure WARNING: Prior to removing the glass, shut off gas to the appliance (or remove the batteries from the battery box and shut off electricity to the fireplace). This prevents any chance of accidental burner ignition when accessing the firebox. • Failure to inspect and ...
-
Lopi 1080 - page 10
10 Maintenance © Travis Industries 4070710 100-01194_000 Glass Frame Removal and Installation WARNING: Prior to removing the glass, shut off gas to the appliance (or remove the batteries from the battery box and shut off electricity to the fireplace). This prevents any chance of accidental burner ignition when accessing the firebox. Warning: The a ...
-
Lopi 1080 - page 11
Maintenance 11 © Travis Industries 4070710 100-01194_000 Log Set Installation Overview Below is a picture detailing log placement for this fireplace. Follow the directions on the following pages to place the logs correctly. NOTE: The log set includes a package of four (4) pins used for log installation. Lower Rear Lo g Ri g ht Twi g Upper Rear Lo ...
-
Lopi 1080 - page 12
12 Maintenance © Travis Industries 4070710 100-01194_000 Lower Rear Log The lower rear log has two holes that insert over pins on the grate and log bracket. ...
-
Lopi 1080 - page 13
Maintenance 13 © Travis Industries 4070710 100-01194_000 Upper Rear Log The upper rear log has two holes that insert over pins on the lower rear log. NOTE: With the upper rear log in place, the logs may tend to tilt backward slightly. Once the twigs are installed, the logs will remain in place. ...
-
Lopi 1080 - page 14
14 Maintenance © Travis Industries 4070710 100-01194_000 Center Ember Note how the pointed end faces inwards. Push the ember back so it rests against the air channel (and not over any burner holes). ...
-
Lopi 1080 - page 15
Maintenance 15 © Travis Industries 4070710 100-01194_000 Upper Left Log Place the upper left log as shown below. This flat portion rests on the left side of the grate. The front log has a hole that fits over the pin on the grate. This bracket is for the front log. Slide the log back until the back edge of the log rests against the bracket. When in ...
-
Lopi 1080 - page 16
16 Maintenance © Travis Industries 4070710 100-01194_000 Left Twig Note how the left twig fits directly over the g rate. This notch fits over the grate. The left twig has a hole for the pin on the front log. ...
-
Lopi 1080 - page 17
Maintenance 17 © Travis Industries 4070710 100-01194_000 Right Twig Note how the notch in the right twig fits over the g rate. This notch fits over the g rate The right twig has a hole for the pin on the rear log. ...
-
Lopi 1080 - page 18
18 Maintenance © Travis Industries 4070710 100-01194_000 Ember Placement Place the embers along the firebox floor and burner to help conceal the burner. Make sure none of the embers are directly over the burner holes. See the photo below. Rock Wool Placement This fireplace is shipped with a larger amount of rock wool to provide the proper coverage ...
-
Lopi 1080 - page 19
Maintenance 19 © Travis Industries 4070710 100-01194_000 Glass Cleaning The glass may be cleaned with a non-abrasive cleaner. To clean the inside of the glass, simply remove the glass frame, place it on a non-scratching surface, and clean the inside surface. WARNING : do not operate the fireplace without the glass assembly in place. Battery Instal ...
-
Lopi 1080 - page 20
20 Maintenance © Travis Industries 4070710 100-01194_000 Wiring Diagram PRESS TO OPEN POWER AUX Learn Continuous Pilot Off/On Remote/Off ADJ S I Battery Box Wires (DC Motor Drive) - 12' Length Black, Brown, Red, and Orange wires DCMD Wires (DC Motor Drive) - 12' Length Red and Black/Red wires (w quick connects) White Green Orange White M ...
-
Lopi 1080 - page 21
Warranty 21 © Travis Industries 4070710 100-01194_000 To register your TRAVIS INDUSTRIES, INC. 7 Year Warranty, complete the enclosed Warranty card and mail it within ten (10) days of the appliance purchase date to: TRAVIS INDUSTRIES, INC., 4800 Harbour Pointe Blvd. SW, Mukilteo, WA 98275. TRAVIS INDUSTRIES, INC. warrants this gas appliance (appli ...
-
Lopi 1080 - page 22
22 Optional Equipment © Travis Industries 4070710 100-01194_000 Accessories The accessories listed below are available at your Travis dealer. To locate a dealer, visit: www.travisproducts.com Andirons These decorative additions attach to the grate inside the firebox and enhance the wood-fire look of your fireplace. Trim Kit This decorative upgrade ...
-
Lopi 1080 - page 23
Optional Equipment 23 © Travis Industries 4070710 100-01194_000 ...
-
Lopi 1080 - page 24
24 Index © Travis Industries 4070710 100-01194_000 Index Accessories .......................................................2 2 Adjusting the Flame Height ..................................8 Before You Begin ...............................................6 Cleaning ............................................................ Continuous Pilot – F ...
Do you have a question concerning Lopi 1080?
Use the form below
If you did not solve your problem by using a manual Lopi 1080, ask a question using the form below. If a user had a similar problem with Lopi 1080 it is likely that he will want to share the way to solve it.