English dropdown-ico

Manual Pentair PLDE36

24 pages 0.89 mb
Download

Go to site of 24

Summary
  • Pentair PLDE36 - page 1

    System 2 TM Modular DE F ilter O W N E R’ S M A N U A L INST ALLA TION, OPERA TION & P ARTS MODELS PLDE36 PLDE48 Sta-Rite P ool/Spa Gr oup 293 Wright Street, Delavan, WI 53115 International: 262-728-5551, FAX: 262-728-7550 www.starite.com Union City, TN • Delavan, WI • Mississauga, Ont. • Murrieta, CA © 2005, Sta-Rite Industries S749 ( ...

  • Pentair PLDE36 - page 2

    T able of Contents Safety Instructions .........................................................2 General Information ......................................................3 Specifications ...............................................................4 Installation ....................................................................5 Initial Start ...

  • Pentair PLDE36 - page 3

    3 GENERAL INFORMA TION • Clean a new pool as well as possible before filling pool and operating filter . Excess dirt and large particles of foreign matter in the system can cause serious damage to the filter and pump. • W ith a modular Diatomaceous Earth (DE) filter in place and operating correctly , clean water is returned to the pool faster t ...

  • Pentair PLDE36 - page 4

    4 Inlet Outlet 7-13/16 (198) 9-3/16 (233) 18.5 (470) 18.5 (470) 36 (914) 45.25 (1 150) 0 5 10 15 20 20 40 60 80 100 Pressure drop (PSI) Flow (GPM) PLDE36 PLDE48 SPECIFIC A TIONS FIGURE 1A – Dimensions in inches (mm) T able 1 - Recommended DE Manufacturers Johns Manville Celite 545™ GREFCO, Inc. Decalite 4200™ Eagle-Picher Minerals, Inc. Celat ...

  • Pentair PLDE36 - page 5

    5 INST ALLA TION Installation of filter should only be done b y qualified, li- censed personnel. Filter Assembl y Filter mount must: • Be solid, level, rigid, vibration free, and provide for ad- equate drainage. • Be as close to pool as possible to reduce pressure loss from pipe friction. • Provide weather and freezing protection. • Provide ...

  • Pentair PLDE36 - page 6

    6 valve, close the valve. NO TICE: Leaking around the Posi-Lok™ ring may indi- cate that the ring is not fully locked. In this case, pro- ceed as follows: a. Stop the pump, close the isolation valves, and open the air release valve to release any pressure within the filter . b. Remove the drain plug and drain all water from the filter . c. Push d ...

  • Pentair PLDE36 - page 7

    7 5. Remove Posi-Lok™ ring as follows: a. Press safety latch (below the ring) toward the tank to release it (see Figure 4). b. Hold latch in the release position and rotate ring COUNTERCLOCKWISE to remove. If ring is difficult to turn, tap gently with a rubber mallet to overcome initial resistance. NO TICE: DO NOT use screwdriver or bladed instru ...

  • Pentair PLDE36 - page 8

    MODULE CLEANING PRO- CEDURE Risk of chemical burns. Do not attempt to acid clean the filter or module. If the filter re- quires acid cleaning, have a trained pool professional do the job. Follow all steps in the “Disassembly” section of this manual. The filter module should be removed and cleaned when pressure rises more than 10 psi (69 kPa) ab ...

  • Pentair PLDE36 - page 9

    9 SYSTEM INSPECTION Gener al: W ash the outside of the filter with a mild detergent and water . Rinse off with a hose. NO TICE: DO NOT use solvents to clean the filter; sol- vents may damage plastic components in the system. NO TICE: Open the air bleed valve and bleed all air from the filter each time the pump is stopped and restarted. W eekly Insp ...

  • Pentair PLDE36 - page 10

    10 3 6 4 5 7 8 11 10 9 1 6 A 2 4 3 2 O P E N C L O S E PLDE 36 PLDE 48 12 Key Part No. Description Qty. PLDE36 PLDE48 1 Posi-Lok™ Ring 1 27001-0054S 27001-0054S 2 Air Release Valve with O-ring 1 25010-0200 24206-0103S 3 Presure Gauge 1 15060-000T 15060-000T 4 Tank Upper Half with Air Relief Valve 1 27001-0020S 27001-0030S 5 Tank O-Ring 1 27001-00 ...

  • Pentair PLDE36 - page 11

    11 1. Short Cycle T ime: NOTICE: Cycle Time will vary with each installation and be- tween different areas of the country. The following causes and remedies are for cycle times shorter than normal for your area. A. Chlorine residual too low; maintain proper residual (con- sult pool professional for recommendation). B. Flow rate too high; restrict f ...

  • Pentair PLDE36 - page 12

    CREATE A RECORD OF YOUR WARRANTY AT STA-RITE: • Complete a warranty registration at www.staritepool.com by clicking on “Register Products” and selecting Sta-Rite Pool OR • Complete bottom portion completely and mail within 10 days of installation to Sta-Rite, Attn.: Pool Warranty Dept., 293 Wright St., Delavan , WI 53115 W arranty Registrat ...

  • Pentair PLDE36 - page 13

    F iltr o modular de tierr a de diatomeas “System 2 TM” MANUAL DEL PROPIET ARIO INST ALACIÓN, OPERACIÓN Y REPUEST OS MODELOS PLDE36 PLDE48 Sta-Rite P ool/Spa Group 293 Wright Street, Delavan, WI 53115 Internacional: 262-728-5551, FAX: 262-728-7550 www.starite.com Union City, TN • Delavan, WI • Mississauga, Ont. • Murrieta, CA © 2005, St ...

  • Pentair PLDE36 - page 14

    Índice Instrucciones de seguridad ............................................2 Información general ......................................................3 Especificaciones ............................................................4 Instalación ....................................................................5 Arranque inicial ............. ...

  • Pentair PLDE36 - page 15

    3 INFORMA CIÓN GENERAL • Limpie una piscina nueva a fondo antes de llenarla y hacer funcionar el filtro. El exceso de suciedad y de partículas de materias extrañas grandes en el sistema puede provocar daños graves en el filtro y en la bomba. • Con un filtro modular de diatomeas (DE) instalado y funcio- nando debidamente, el agua limpia vuel ...

  • Pentair PLDE36 - page 16

    4 Inlet Outlet 7-13/16 (198) 9-3/16 (233) 18.5 (470) 18.5 (470) 36 (914) 45.25 (1 150) 0 5 10 15 20 20 40 60 80 100 Pressure drop (PSI) Flow (GPM) PLDE36 PLDE48 ESPECIFIC ACIONES FIGURA 1A – Dimensiones en pulgadas (mm) Cuadro 1 - F abricantes de tierra de diatomeas recomendados Johns Manville Celite 545™ GREFCO, Inc. Decalite 4200™ Eagle-Pic ...

  • Pentair PLDE36 - page 17

    5 INST ALA CIÓN La instalación del filtro debe ser realizada sólo por personas calificadas y competentes. Ensamblaje del filtro La instalación del filtro debe: • Ser firme, nivelada, rígida, sin vibraciones y con un drenaje adecuado. • Estar lo más cerca posible de la piscina para reducir la pér- dida de presión debido a la fricción de ...

  • Pentair PLDE36 - page 18

    6 6. Cuando salga un chorro firme de agua de la válvula de desa- hogo de aire, cierre la válvula. AVISO: Fugas alrededor del aro Posi-Lok TM pueden indicar que el aro no está totalmente trabado. En este caso, proceda de la siguiente manera: a. Detenga la bomba, cierre las válvulas de aislamiento y abra la válvula de desahogo de aire para solta ...

  • Pentair PLDE36 - page 19

    7 5. Saque el aro Posi-Lok TM de la siguiente manera: a. Oprima el pasador de seguridad (debajo del aro) hacia el tanque para aflojarlo (consulte la Figura 4). b. Mantenga el pasador en la posición soltada y gire el aro HACIA LA IZQUIERDA para sacarlo. Si es difícil hacer girar el aro, se deberá golpetear suavemente con un mar- tillo de caucho p ...

  • Pentair PLDE36 - page 20

    PROCEDIMIENT O DE LIMPIEZA DEL MÓDULO Riesgo de quemaduras de índole química. NO trate de limpiar el filtro o el módulo con ácido. Si el filtro requiere limpieza con ácido, contrate a un profesional capacitado para piscinas para realizar ese trabajo. Siga todos los pasos indicados en la sección de “Desensamblaje” de este manual. Es neces ...

  • Pentair PLDE36 - page 21

    9 INSPECCIÓN DEL SIS- TEMA Gener al: Lave el exterior del filtro con un detergente suave y agua. Enjuague a manguera. AVISO: NO use solventes para limpiar el filtro, ya que estos pueden dañar los componentes de plástico en el sistema. AVISO: Abra la válvula de purga de aire y descargue todo el aire del filtro cada vez que detenga y vuelva a enc ...

  • Pentair PLDE36 - page 22

    10 3 6 4 5 7 8 11 10 9 1 6 A 2 4 3 2 O P E N C L O S E PLDE 36 PLDE 48 12 Clave No. Descripción Cant. PLDE36 PLDE48 1 Aro Posi-Lok TM 1 27001-0054S 27001-0054S 2 Válvula de desahogo de aire con aro tórico 1 25010-0200 24206-0103S 3 Manómetro 1 15060-000T 15060-000T 4 Mitad superior del tanque con válvula de desahogo de aire 1 27001-0020S 27001 ...

  • Pentair PLDE36 - page 23

    11 1. T iempo de ciclo corto: AVISO: El tiempo de ciclo varía con cada instalación y entre difer- entes áreas del país. Las siguientes causas y soluciones son para tiempos de ciclo inferiores a los normales para su área. A. Cloro residual demasiado bajo; mantenga el residuo adecuado (obtenga las recomendaciones de un profesional de piscinas). ...

  • Pentair PLDE36 - page 24

    PARA CREAR UN REGISTRO DE SU GARANTÍA CON STA-RITE: • Llene un registro de garantía en www.staritepool.com pulsando en “Registro de Productos” y seleccionando Albercas Sta-Rite O • Llene la porción inferior y envíela por correo dentro de los 10 días de la instalación, a Sta-Rite, a la atención del Departa mento de Garantías de Pisci ...

Manufacturer Pentair Category Water Dispenser

Documents that we receive from a manufacturer of a Pentair PLDE36 can be divided into several groups. They are, among others:
- Pentair technical drawings
- PLDE36 manuals
- Pentair product data sheets
- information booklets
- or energy labels Pentair PLDE36
All of them are important, but the most important information from the point of view of use of the device are in the user manual Pentair PLDE36.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Pentair PLDE36, service manual, brief instructions and user manuals Pentair PLDE36. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Pentair PLDE36.

Similar manuals

A complete manual for the device Pentair PLDE36, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Pentair PLDE36 by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Pentair PLDE36.

A complete Pentair manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Pentair PLDE36 - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Pentair PLDE36, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Pentair PLDE36, that we can find in the current document
3. Tips how to use the basic functions of the device Pentair PLDE36 - which should help us in our first steps of using Pentair PLDE36
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Pentair PLDE36
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Pentair PLDE36 in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Pentair PLDE36?

Use the form below

If you did not solve your problem by using a manual Pentair PLDE36, ask a question using the form below. If a user had a similar problem with Pentair PLDE36 it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)