English dropdown-ico

Manual Char-Broil 10101550

24 pages 4.62 mb
Download

Go to site of 24

Summary
  • Char-Broil 10101550 - page 1

    FOR OUTDOOR USE ONL Y If you have questions or need assistance during assembly , please call . T o insure your satisfaction and for follow-up service, register your appliance online at www .charbroil.com/register 1-800-241-7548 CA UTION: Read and follow all warnings and instructions before assembling and using the appliance. INST ALLER/ASSEMBLER: L ...

  • Char-Broil 10101550 - page 2

    D ANGER Safety Symbols The symbols and boxes shown below explain what each heading means. Read and follow all of the messages found throughout the manual. DANGER: Indicates an imminently hazardous situation which, if not avoided, will result in death or serious injury . WARNING W ARNING: Indicates an potentially hazardous situation which, if not av ...

  • Char-Broil 10101550 - page 3

    WARNING CALIFORNIA PROPOSITION 65 1. Combustible by-products produced when using this product contains chemicals known to the State of California to cause cancer , birth defects, or other reproductive harm. 2. This product contains chemicals, including lead and lead compounds, known to the State of California to cause cancer , birth defects or othe ...

  • Char-Broil 10101550 - page 4

    Food Safety Food safety is a very important part of enjoying the outdoor cooking experience. T o keep food safe from harmful bacteria, follow these four basic steps: Clean: W ash hands, utensils, and surfaces with hot soapy water before and after handling raw meat and poultry . Separate: Separate raw meats and poultry from ready-to-eat foods to avo ...

  • Char-Broil 10101550 - page 5

    • NEVER store a spare LP cylinder under or near the appliance or in an enclosed area. • Never fill a cylinder beyond 80% full. • An over filled or improperly stored cylinder is a hazard due to possible gas release from the safety relief valve. This could cause an intense fire with risk of property damage, serious injury or death. • If you s ...

  • Char-Broil 10101550 - page 6

    WARNING If “growing” bubbles appear do not use or move the LP cylinder . Contact an LP gas supplier or your fire department! Connecting Regulator to the LP Cylinder 1. LP cylinder must be properly secured onto . (Refer to assembly section.) 2. T urn all control knobs to the OFF position. 3. T urn LP cylinder OFF by turning hand-wheel clockwise ...

  • Char-Broil 10101550 - page 7

    6. T urn the coupling nut clockwise and tighten to a full stop. The regulator will seal on the back-check feature in the LP cylinder valve, resulting in some resistance. An additional one-half to three-quarters turn is required to complete the connection. Tighten by hand only – do not use tools. NOTE: If you cannot complete the connection, discon ...

  • Char-Broil 10101550 - page 8

    24” 3 ft. 3 ft. WARNING CA UTION • Putting out grease fires by closing the lid is not possible. This a ppliance is well ventilated for safety reasons. • Do not use water on a grease fire. Personal injury may result. If a grease fire develops, turn knobs and LP cylinder off. • Do not leave appliance unattended while burning off food residue. ...

  • Char-Broil 10101550 - page 9

    CA UTION If ignition does NOT occur in 5 seconds, turn the control knob OFF , wait 5 minutes and repeat the lighting procedure. If the burner does not ignite with the valve open, gas will continue to flow out of the burner and could accidently ignite with risk of injury . T urn control knob and LP cylinder OFF when not in use. WARNING Ignitor Light ...

  • Char-Broil 10101550 - page 10

    Cleaning the Burner Assembly (Continued) 9. Clean inner burner as recommended below , shown E . We suggest three ways to clean the burner tube. Use the one easiest for you. (A) Bend a stiff wire (a light weight coat hanger works well) into a small hook. Run hook through burner tube several times. (B) Use a narrow bottle brush with a flexible handle ...

  • Char-Broil 10101550 - page 11

    This warranty only applies to units purchased from an authorized retailer . Manufacturer warrants to the original consumer-pur chaser only that this product shall be free from defects in workmanship and materials after correct assembly and under normal and reasonable home use for the periods indicated below beginning on the date of purchase*. The m ...

  • Char-Broil 10101550 - page 12

    P ARTS DIAGRAM Key Qty Description A 1 Outer Body B 1 Inner Body C 1 Body T op Ring D 1 Burner E 1 Heat Shield F 1 Ignition Kit G 1 Logo Plate H 1 Cooking Chamber I 1 Roaster Basket J 2 Side Handles K 3 Handle Springs L 1 Control Panel Key Qty Description M 1 Ignitor Knob N 1 Control Knob O 1 T op Lid P 4 Leg Assembly Q 1 Grease T ray R 2 Grease T ...

  • Char-Broil 10101550 - page 13

    ASSEMBL Y 2 1 T ools required for assembly: Phillips Screwdriver (Not Supplied); Small Adjustable W rench (Not Supplied) • Carefully turn the unit upside down. Slide Heatshield into place over the exposed burner tube. • Align hole in Heat Shield with end of Burner T ube Heat Shield in Position • While holding the Heat Shield in place, slide t ...

  • Char-Broil 10101550 - page 14

    Ignitor Wire The windshield is held in place once the legs are attached. 3 • The ignitor wire is factory installed to the ignitor . Pass the loose end of the wire through the hole in the body , shown Figure A • Place Windshield inside the bottom of the body . NOTE: Fasteners are not required for the windshield. . Figure B Grease T ray Rail Wind ...

  • Char-Broil 10101550 - page 15

    4 • Install legs by engaging leg tabs over bottom edge of the appliance body . • • Slide the grease tray into the rear of the unit. • Once the leg is in place, attach two #10-24x1" screws through the leg and into the appliance body . • Repeat for the remaining legs. When all four legs are securely installed, carefully turn the unit u ...

  • Char-Broil 10101550 - page 16

    Page 16 Qty: 8 #10-24x3/8" Screw Qty: 4 #10-24 Keps Nut Qty: 8 Fiber W asher 7 • Attach the hinges to the lid inserting a #10-24x3/8" screw into hinge, install a fiber washer onto screw , align lid onto screw , install fiber washer from inside the lid, and finally secure with a #10-24 Keps nut. Repeat for opposite hinge. Shown A . #10-2 ...

  • Char-Broil 10101550 - page 17

    Accessory Use and Storage Cooking Basket NOTE: Before cooking on your appliance for the first time, refer to the separate Cooking Guide on how to prepare the appliance for cooking. It is recommended that you season your appliance prior to cooking . • Once seasoning is complete, the appliance is now ready for use. The cooking chamber will continue ...

  • Char-Broil 10101550 - page 18

    Half Rack Storage Accessory Use and Storage Accessory storage Accessory items such as the cooking grate, smoker box and half racks can be stored on board the Smoker , Roaster, & Grill as shown. Hanging hooks Hole Cooking Grate Storage Smoker Box Storage Slot Smoker Box The Smoker Box has a clip that secures it into one of the four vent holes on ...

  • Char-Broil 10101550 - page 19

    EMERGENCIES: If a gas leak cannot be stopped, or a fire occurs due to gas leakage, call the fire department. Emergencies Problem Gas leaking from cracked/cut/burned hose. Gas leaking from LP cylinder . Gas leaking from LP cylinder valve. Gas leaking between LP cylinder and regulator connection. Fire coming through control panel. Grease fire or cont ...

  • Char-Broil 10101550 - page 20

    T roubleshooting ( continued ) Possible Cause • Rotary knob rotates without clicking. • Sparking between ignitor and electrode. • See “GAS ISSUES:” on previous page. • Match will not reach. • Improper method of match-lighting. • Out of gas. • Excess flow valve on regulator tripped. • V apor lock at coupling nut/LP cylinder conne ...

  • Char-Broil 10101550 - page 21

    Notes Page 21 ...

  • Char-Broil 10101550 - page 22

    Notes Page 22 ...

  • Char-Broil 10101550 - page 23

    ...

  • Char-Broil 10101550 - page 24

    REGTEMP REV00 Page 24 ...

Manufacturer Char-Broil Category Smoker

Documents that we receive from a manufacturer of a Char-Broil 10101550 can be divided into several groups. They are, among others:
- Char-Broil technical drawings
- 10101550 manuals
- Char-Broil product data sheets
- information booklets
- or energy labels Char-Broil 10101550
All of them are important, but the most important information from the point of view of use of the device are in the user manual Char-Broil 10101550.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Char-Broil 10101550, service manual, brief instructions and user manuals Char-Broil 10101550. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Char-Broil 10101550.

Similar manuals

A complete manual for the device Char-Broil 10101550, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Char-Broil 10101550 by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Char-Broil 10101550.

A complete Char-Broil manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Char-Broil 10101550 - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Char-Broil 10101550, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Char-Broil 10101550, that we can find in the current document
3. Tips how to use the basic functions of the device Char-Broil 10101550 - which should help us in our first steps of using Char-Broil 10101550
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Char-Broil 10101550
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Char-Broil 10101550 in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Char-Broil 10101550?

Use the form below

If you did not solve your problem by using a manual Char-Broil 10101550, ask a question using the form below. If a user had a similar problem with Char-Broil 10101550 it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)