English dropdown-ico

Manual Weil-McLain 80

40 pages 2.93 mb
Download

Go to site of 40

Summary
  • Weil-McLain 80 - page 1

    P art N o. 550-141-935/0602 Boiler Manual 80 W ater & steam boilers for use with Gas, Light Oil, & Gas/Light Oil – Fired Burners This manual must only be used by a qualified heat ing installer/serv ice technician. R ead all inst ructions before installing. Follo w al l instructions in pro per orde r . Failu re to co mply could r esult in ...

  • Weil-McLain 80 - page 2

    W eil-McLain 80 Boiler For Gas, Light Oil, Gas/Light Oil Fir ed Burners 2 P art No . 550-141-935/0602 Hazar d Definitions The following defined terms are used thr oughout this manual to bring attention t o the presenc e of hazards of various risk levels, or to important information conc erning the life of the product. Indicates p resenc e of hazard ...

  • Weil-McLain 80 - page 3

    • Installation • Start-Up • Maintenance • Parts 3 P art No . 550-141-935/0602 Installation must compl y with — • State, pr ov incial and local plumbing, heating and electr ical codes. • R egulations of serv icing utilities. • N ational codes where applicable. Before selecting boiler location 1. Check fo r nearby co nnections to: a. ...

  • Weil-McLain 80 - page 4

    W eil-McLain 80 Boiler For Gas, Light Oil, Gas/Light Oil Fir ed Burners 4 P art No . 550-141-935/0602 Befor e installing boiler (continued) 1 Figure 2 Combustion and v entilation air openings — Boiler room below grade Figure 3 Combustion and v entilation air openings — Boiler room par tially or completely abov e grade Pro vide combustion and ve ...

  • Weil-McLain 80 - page 5

    • Installation • Start-Up • Maintenance • Parts 5 P art No . 550-141-935/0602 Set boiler in place 2 For packa ged boiler: 1. Remo ve top jack et panels. Set aside until after boiler is piped. The boiler contains ceramic fiber and fiberglass materials. U se care when handling these materials per instruc tions on page 38 o f this manual. Fail ...

  • Weil-McLain 80 - page 6

    W eil-McLain 80 Boiler For Gas, Light Oil, Gas/Light Oil Fir ed Burners 6 P art No . 550-141-935/0602 Assemble block 3 Sections are top heavy . U nbolted sections ma y fall if not supported, r esulting in seve re personal inj ury or death. Install bac k refractory blanket 1. Lay back section o n floor with ports face up. 2. Appl y adhesiv e to blan ...

  • Weil-McLain 80 - page 7

    • Installation • Start-Up • Maintenance • Parts 7 P art No . 550-141-935/0602 Install intermediate sections Sections are top hea vy . U nbolted sections may fall if not supported, resulting in se ve re personal injury or death. 1. R emove and discar d 3 / 8 " diameter shipping tie r ods. 2. R emove grit from port machined surfaces with ...

  • Weil-McLain 80 - page 8

    W eil-McLain 80 Boiler For Gas, Light Oil, Gas/Light Oil Fir ed Burners 8 P art No . 550-141-935/0602 Perform hydr ostatic pr essur e test Prepare boiler and test: 1. See pages 28 and 29 for tapping locations. I nstall: a. Boiler drain (not furnished). b . W ater press ure gauge — for test only . Be sur e gauge can handle test pressure — see st ...

  • Weil-McLain 80 - page 9

    • Installation • Start-Up • Maintenance • Parts 9 P art No . 550-141-935/0602 Install burner mounting plate on fr ont section 1. Install four ½" x 4¾" studs to secure burner mounting plate to section: a. Thread and lock together two nuts on r ounded end of stud. Thr ead flat end of stud into one of four holes lo cated around ope ...

  • Weil-McLain 80 - page 10

    W eil-McLain 80 Boiler For Gas, Light Oil, Gas/Light Oil Fir ed Burners 10 P art No . 550-141-935/0602 Install flue collector 6 Figure 8 Collector hood preparation Figure 9 Flue collector sealing rope installation Flue collector assembl y 1. Figure 10, pag e 11, shows fl ue collector compo nents and locations. Figure 11, page 13, shows collector ho ...

  • Weil-McLain 80 - page 11

    • Installation • Start-Up • Maintenance • Parts 11 P art No . 550-141-935/0602 Install flue collector (continued) 6 Figure 10 Flue collector components, typical (Model 880 collector configurations sho wn) ...

  • Weil-McLain 80 - page 12

    W eil-McLain 80 Boiler For Gas, Light Oil, Gas/Light Oil Fir ed Burners 12 P art No . 550-141-935/0602 Install flue collector (continued) 6 Before installing flue collector 1. See Figure 10, page 11, for general assembly of flue collector c omponents. 2. See Figure 11, page 13 fo r the placement o f flue collec tor hoods on each model. 3. Pr epare ...

  • Weil-McLain 80 - page 13

    • Installation • Start-Up • Maintenance • Parts 13 P art No . 550-141-935/0602 Figure 11 Flue collector components by model (see Figure 10, page 11 f or flue collector components not shown below) 6 Install flue collector (continued) ...

  • Weil-McLain 80 - page 14

    W eil-McLain 80 Boiler For Gas, Light Oil, Gas/Light Oil Fir ed Burners 14 P art No . 550-141-935/0602 Connect water boiler piping 7 General water piping information: • Syst em wat er supply and r eturn piping should b e installed and piping connections attach ed to boiler befor e erecting jacket or installing co ntrols. • Do not pipe in throug ...

  • Weil-McLain 80 - page 15

    • Installation • Start-Up • Maintenance • Parts 15 P art No . 550-141-935/0602 Connect water boiler piping (continued) 7 3. Piping for multiple boilers (see Figure 13): A Size seco ndar y boiler pump GPM based on following form ulas: Calculat e only secondary piping circuit resistanc e. Boiler resistance will be about equal to three 90 degr ...

  • Weil-McLain 80 - page 16

    W eil-McLain 80 Boiler For Gas, Light Oil, Gas/Light Oil Fir ed Burners 16 P art No . 550-141-935/0602 Connect steam boiler piping 8 General steam piping information: • Hartfor d loop piping arrangement and wet return are required fo r steam boile rs. U se the Hartford loo p for both pumped-return and gr avity-ret urn systems. • Maintain 24-inc ...

  • Weil-McLain 80 - page 17

    • Installation • Start-Up • Maintenance • Parts 17 P art No . 550-141-935/0602 Connect steam boiler piping (continued) 8 Figure 15 Model 380 through 580 steam boiler piping — NO TE minimum 24 inches betw een boiler water line and bottom of header . Figure 16 Model 680 through 980 steam boiler piping — NO TE minimum 24 inches between boi ...

  • Weil-McLain 80 - page 18

    W eil-McLain 80 Boiler For Gas, Light Oil, Gas/Light Oil Fir ed Burners 18 P art No . 550-141-935/0602 T able 9 Condensate receiv er capacity Figure 18 Condensate piping to boiler Connect steam boiler piping (continued) 8 Figure 17 Model 1080 through 1280 steam boiler piping — NO TE minimum 24 inches between boiler w ater line and bottom of heade ...

  • Weil-McLain 80 - page 19

    • Installation • Start-Up • Maintenance • Parts 19 P art No . 550-141-935/0602 Figure 19 Multiple Steam Boiler Piping Gravity Condensate Return Connect steam boiler piping (continued) 8 A Pipe as shown for gr avity return systems, c onnecting point A t o the wet gravity return. For pumped-return syst ems, install boiler water lev el control ...

  • Weil-McLain 80 - page 20

    W eil-McLain 80 Boiler For Gas, Light Oil, Gas/Light Oil Fir ed Burners 20 P art No . 550-141-935/0602 Install jacket 9 Before installing jac ket 1. P ackaged boile rs • Install top jack et panels per instruc tions in this manual. 2. N on-packaged boilers • Follow the instructions in this section to install all jacket panels. • Make sure the ...

  • Weil-McLain 80 - page 21

    • Installation • Start-Up • Maintenance • Parts 21 P art No . 550-141-935/0602 Figure 20 Installing jack et suppor t brack ets and rails and jac ket front and rear panels Install jacket (continued) 9 ...

  • Weil-McLain 80 - page 22

    W eil-McLain 80 Boiler For Gas, Light Oil, Gas/Light Oil Fir ed Burners 22 P art No . 550-141-935/0602 Figure 21 Installing (removing) jack et side panels and top panels Install jacket (continued) 9 Install jacket side panels 1. Re move jack et side panels from cartons. 2. Insert a plastic plug (pr ovided in jacket cartons) in the 1-inch hole in th ...

  • Weil-McLain 80 - page 23

    • Installation • Start-Up • Maintenance • Parts 23 P art No . 550-141-935/0602 Figure 22 Jac ket side panel placement — Models 380, 480, 580 and 680 Install jacket (continued) 9 ...

  • Weil-McLain 80 - page 24

    W eil-McLain 80 Boiler For Gas, Light Oil, Gas/Light Oil Fir ed Burners 24 P art No . 550-141-935/0602 Figure 23 Jac ket side panel placement — Models 780, 880 and 980 Install jacket (continued) 9 ...

  • Weil-McLain 80 - page 25

    • Installation • Start-Up • Maintenance • Parts 25 P art No . 550-141-935/0602 Figure 24 Jac k et side panel placement — Models 1080, 1180, and 1280 Install jacket (continued) 9 ...

  • Weil-McLain 80 - page 26

    W eil-McLain 80 Boiler For Gas, Light Oil, Gas/Light Oil Fir ed Burners 26 P art No . 550-141-935/0602 Figure 25 J ack et top panel placement Install jacket (continued) 9 ...

  • Weil-McLain 80 - page 27

    • Installation • Start-Up • Maintenance • Parts 27 P art No . 550-141-935/0602 T o pipe tankless heaters: 1. Size piping no smaller than heater inlet and outlet. 2. A uto matic mixing valve must be installed. See Figure 26. Follow manufact urer’ s instr uctions to install. 3. Flow r egulating valve must be installed. Size ac cor ding to c ...

  • Weil-McLain 80 - page 28

    W eil-McLain 80 Boiler For Gas, Light Oil, Gas/Light Oil Fir ed Burners 28 P art No . 550-141-935/0602 Install water boiler controls Install controls: 1. Install furnished co ntrols wher e shown in T able 11 and Figure 27. Failure t o pro perly install, pipe and wire boiler controls can r esult in severe damage to boiler , building and perso nnel; ...

  • Weil-McLain 80 - page 29

    • Installation • Start-Up • Maintenance • Parts 29 P art No . 550-141-935/0602 Install steam boiler controls 12 Install controls: 1. Install controls whe re shown in T able 12 and Figure 28. Failure t o pr operly install, pipe and wire boiler c ontrols can r esult in severe damage to boiler , building and personnel; and is not cov ered by b ...

  • Weil-McLain 80 - page 30

    W eil-McLain 80 Boiler For Gas, Light Oil, Gas/Light Oil Fir ed Burners 30 P art No . 550-141-935/0602 Install steam boiler contr ols (continued) 12 Figure 29 Steam control siphon and fittings T able 13 W ater le vel control locations Figure 30 W ater lev el control locations (see T able 13) ...

  • Weil-McLain 80 - page 31

    • Installation • Start-Up • Maintenance • Parts 31 P art No . 550-141-935/0602 13 Connect br eeching and venting systems Figure 31 Stub vent – f orced draft — single boiler Figure 33 Conv entional chimney – balanced draft with barometric draft control when required — single boiler Figure 32 Stub vent – f orced draft — multiple b ...

  • Weil-McLain 80 - page 32

    W eil-McLain 80 Boiler For Gas, Light Oil, Gas/Light Oil Fir ed Burners 32 P art No . 550-141-935/0602 Install bur ner 14 Wiring and fuel piping Make final adjustments 16 15 T o install burner: 1. U npack b urner . 2. Place gasket around air tube and against burner mounting flange. If sealing rope is used, apply 1 / 8 " continuous bead of rope ...

  • Weil-McLain 80 - page 33

    • Installation • Start-Up • Maintenance • Parts 33 P art No . 550-141-935/0602 Make final adjustments (continued) 16 Figure 35 Flue damper assembly , typical Skim steam boilers: Clean all newly installed steam boilers to remov e oil. F ailure t o pro perly clean can result in violent water level fluctuations, water passing into steam mains, ...

  • Weil-McLain 80 - page 34

    W eil-McLain 80 Boiler For Gas, Light Oil, Gas/Light Oil Fir ed Burners 34 P art No . 550-141-935/0602 Dimensions and ratings 17 Notes 1. Burner input based on maximum of 2,000 feet altitude. For higher altitudes consult local Weil-McLain representative. 2. No. 2 fuel oil Commercial Standard Spec. CS75-56. Heat value of oil — 140,000 Btu/Gal. 3. ...

  • Weil-McLain 80 - page 35

    • Installation • Start-Up • Maintenance • Parts 35 P art No . 550-141-935/0602 17 Dimensions and ratings (continued) ...

  • Weil-McLain 80 - page 36

    W eil-McLain 80 Boiler For Gas, Light Oil, Gas/Light Oil Fir ed Burners 36 P art No . 550-141-935/0602 18 Parts ...

  • Weil-McLain 80 - page 37

    • Installation • Start-Up • Maintenance • Parts 37 P art No . 550-141-935/0602 18 Parts (continued) ...

  • Weil-McLain 80 - page 38

    W eil-McLain 80 Boiler For Gas, Light Oil, Gas/Light Oil Fir ed Burners 38 P art No . 550-141-935/0602 Handling ceramic fiber and fiberglass materials REMO V AL OF COMBUSTION CHAMBER LINING OR BASE P ANELS The combustion chambe r lining or base insulation panels in this product contain c eramic fiber materials. C eramic fibers can be co nv e rted t ...

  • Weil-McLain 80 - page 39

    • Installation • Start-Up • Maintenance • Parts 39 P art No . 550-141-935/0602 P ropane boilers — propane gas odorant Pr opane boilers o nly — Y our pr opane supplier mix es an odorant w ith the pro pane to make its prese nce detectable. In some instances, the odor ant can fade and the gas may no longer ha ve an odor . ■ Propane gas c ...

  • Weil-McLain 80 - page 40

    W eil-McLain Limited W arranty f or Residential & Commercial Cast Iron Boilers ◆ ◆ ◆ ◆ ◆ RESIDENTIAL W A TER W ARRANTY—Limited Lifetime ◆ ◆ ◆ ◆ ◆ RESIDENTIAL STEAM W ARRANTY—Limited 10 Y ear ◆ ◆ ◆ ◆ ◆ COMMERCIAL W ARRANTY—Limited 10-Y ear N OT E : The residential steam and water warr anties do not cov er resi ...

Manufacturer Weil-McLain Category Boiler

Documents that we receive from a manufacturer of a Weil-McLain 80 can be divided into several groups. They are, among others:
- Weil-McLain technical drawings
- 80 manuals
- Weil-McLain product data sheets
- information booklets
- or energy labels Weil-McLain 80
All of them are important, but the most important information from the point of view of use of the device are in the user manual Weil-McLain 80.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Weil-McLain 80, service manual, brief instructions and user manuals Weil-McLain 80. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Weil-McLain 80.

Similar manuals

A complete manual for the device Weil-McLain 80, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Weil-McLain 80 by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Weil-McLain 80.

A complete Weil-McLain manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Weil-McLain 80 - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Weil-McLain 80, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Weil-McLain 80, that we can find in the current document
3. Tips how to use the basic functions of the device Weil-McLain 80 - which should help us in our first steps of using Weil-McLain 80
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Weil-McLain 80
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Weil-McLain 80 in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Weil-McLain 80?

Use the form below

If you did not solve your problem by using a manual Weil-McLain 80, ask a question using the form below. If a user had a similar problem with Weil-McLain 80 it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)