English dropdown-ico

Manual GSW JW317

20 pages 0.46 mb
Download

Go to site of 20

Summary
  • GSW JW317 - page 1

    T ABLE OF CONTENTS I) Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2 II) Safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3 III) Inst allation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3 Location . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3 Air Requirements . . . ...

  • GSW JW317 - page 2

    – 2 – Thank you for purchasing this water heater . Properly inst alled and maint ained, it will provide years of trouble free service. This manual gives instructions for the proper inst al- lation, safe operation and maintenance of this water heater . It is your responsibility to ensure that your water heater is properly inst alled and cared fo ...

  • GSW JW317 - page 3

    – 3 – R elief V alv e R equir ements For protection against excessive pressure and/or tempera- tures, an ASME approved T emperature and Pressure (T&P) Relief V alve must be inst alled in the opening provided and labeled near the hot water outlet. Pressure rating of the valve must not exceed the working pressure shown on the rating plate of ...

  • GSW JW317 - page 4

    – 4 – 610mm (24 in.) MIN. FOR SER VICING 457mm (18 in.) MIN. FLUE SEE T ABLE T OP SEE T ABLE FLUE SIZES SEE T ABLE NON-COMBUSTIBLE FLOOR COMBUSTIBLE CEILING DRAFT REGULA T OR FLUE SEE T ABLE Figure 1 ROUGH-IN DIMENSIONS NOTE: JWF307V requires additional “Through-the-wall V ent Kit” available in 3 lengths: 5’ (63320), 10’ (63321) or 20? ...

  • GSW JW317 - page 5

    – 5 – Figure 2 INST ALLA TION DIMENSIONS (CENTER FLUE MODELS) J W F3 07 J W F5 07 J W F6 57 J W F307 V mm 50 8 559 6 60 50 8 in. 20 2 2 26 20 mm 22 9 229 2 54 22 9 in. 9 9 10 9 mm 45 7 457 5 24 45 7 in. 18 18 20 5/8 18 mm 69 9 660 7 75 69 9 in. 27 1/2 26 30 1/2 27 1/2 mm 128 6 14 86 16 61 12 86 in. 50 5/8 58 1/2 65 3/8 50 5/8 mm 132 6 15 34 16 ...

  • GSW JW317 - page 6

    – 6 – Air R equir ements An adequate supply of combustion and ventilation air is required to: • Ensure proper combustion. • Reduce risk of property damage, severe bodily injury or death from possible flue gas leakage and carbon monoxide emissions. Do not inst all an exhaust fan in the same room as the water heater . Satisfactory combustion ...

  • GSW JW317 - page 7

    – 7 – appliances in the enclosure, freely communicating with inte- rior areas that have in turn adequate infiltration from the out- side. It shall also have a combustion air supply opening so that the tot al air received through the opening will be at least as much as would be admitted by openings having a tot al free area of 4.5 cm 2 /kWh (1 i ...

  • GSW JW317 - page 8

    – 8 – Chimney Be sure that the chimney is suf ficiently high and large enough to meet the specifications of the burner unit inst alled. Check that there is suf ficient draf t for the proper burning of oil. At least -0.015 in. (-0.381mm) water column of over-fire draf t is recommended. Block ed V ent Saf ety Switc h Oil-fired water heaters inst ...

  • GSW JW317 - page 9

    – 9 – Burning Equipment (NFP A 31)” (as applicable), local codes and the manufacturer ’ s instructions. The burner should be inst alled only by a qualified Oil-Burner T echnician. Oil Suppl y Connections All aspect s of oil t ank location and inst allation, t ank size, oil piping supply and burners, including any fittings, valves, fil- ters ...

  • GSW JW317 - page 10

    – 10 – up of lime in the T&P valve, there are two recommendations: 1. Inst all a pressure relief (only) valve in the cold water supply line. Make sure that the discharge of this valve is directed to a drain and it is protected from freezing. or: 2. Inst all an exp ansion t ank on the cold water supply line. For every 50 gallons of stored wa ...

  • GSW JW317 - page 11

    – 11 – LINE VOL T AGE THERMOST A T OR AQUAST A T® CONTROL OIL V AL VE BURNER MOT OR IGNIT OR CAD CELL LIMIT TO REMOTE ALARM CIRCUIT JUMPER ENVIRACOM™ TERMINAL L1 LIMIT L2 V AL VE CAD CELL ALARM T T3 2 1 VIOLET WHITE BLUE ORANGE RED BLACK YELLOW YELLOW BURNER MOT OR IGNIT OR R7184 BURNER JUNCTION BOX Figure 9 TYPICAL PRIMAR Y CONTROL WIRING ( ...

  • GSW JW317 - page 12

    – 12 – St artup MAKE SURE THA T THE HEA TER IS FULL OF W A TER. See “Filling the W ater Heater” section. DO NOT A TTEMPT T O ST ART BURNER IF ANY OF THE FOLLOWING CONDITIONS EXIST : 1. Excess oil has accumulated. 2. The unit is full of vapours. Af ter the inst allation is finished and the inst allation checklist completed, proceed as follow ...

  • GSW JW317 - page 13

    – 13 – Wa ter T emper a tur e Re gula tion Once inst alled, the operation will be completely automatic. The thermost at (aquast at) on the water heater is adjust able and will maint ain water at the desired temperature. W ARNING: HOT W A TER CAN PRODUCE 3RD DEGREE BURNS IN 6 SECONDS A T 140 o F (60 O C) IN 30 SECONDS A T 130 O F (54 O C) Thermo ...

  • GSW JW317 - page 14

    W ARNING! The temperature and pressure relief valve must be manually operated at least once a year . Caution should be t aken to ensure that: 1. No one is in front of or around the outlet of the temper- ature and pressure relief valve discharge line. 2. The water manually discharged will not cause any bod- ily injury or property damage. The water m ...

  • GSW JW317 - page 15

    – 15 – • Black water can be an indication of organic cont ami- nates in the water supply . This can be problematic in areas where the water is obt ained from surface or cont- aminated sources. Organic p articles can develop bacte- rial growth, causing potential health hazards. • Cont act your water supplier for proper filtration or water co ...

  • GSW JW317 - page 16

    – 16 – 1. Shut of f the oil supply at the t ank. 2. Shut of f the cold water supply to the heater . 3. T urn "OFF" the electrical supply to the water heater . 4. Open an up st airs hot water faucet (to relieve any pres- sure). When freezing temperatures are expected: 1. Shut of f the oil supply at the t ank. 2. Shut of f the cold wate ...

  • GSW JW317 - page 17

    – 17 – W A TER HEA TER 8in T O 12in MAX. HOT OUTLET EXP ANSION T ANK (OPTIONAL) MIXING V AL VE COLD INLET CHECK V AL VE (IF USED REQUIRES EXP ANSION T ANK) COLD SUPPL Y HOSE BIB (OPTIONAL) FLOW CONTROL SUPPL Y RETURN CHECK V AL VE EXTERNAL CIRCULA T OR AIR HANDLER HOT W A TER T O HOUSE FIXTURE Figure 14 COMBO HEA TING - AIR HANDLER C H M INTERN ...

  • GSW JW317 - page 18

    – 18 – T able 1 LISTING OF OIL BURNERS. Mode l MFGR Burn er N ozz le & P u mp P re s s . Bl ast tube No t e s BE CKE T T AFG GSW - J3 037 0.75 GPH U . S. ON LY BE CKE T T AFG GSW - J3 036 0.75 GPH MA SS . ONL Y C ARLI N E Z 19 729 7AJW 31 7 0.75 GPH C ARLI N 972 97 A J W 3 17 0.75 x 6 0A D E L 854 72, 10 0 psi 9" BE CKE T T AFG GSW - J ...

  • GSW JW317 - page 19

    – 19 – Mode l MFGR Burn er N ozz le & P u mp P re s s . Bl ast tube No t e s AE RO FA FC- 2X 0.75 GPH AE RO S V - 2X 0.75 GPH AE RO FA FC- 2X 0.75 x 8 0A 5 15/16 " AE RO S V - 2X 0.75 x 8 0A 5 15/16 " BE CKE T T AFG GSW - J5 006 0.75 GPH C ANADA BE CKE T T AFG GSW - J5 032 0.75 GPH U . S. BE CKE T T AFG GSW - J5 031 0.75 GPH MA SS ...

  • GSW JW317 - page 20

    See Rating Label Serial Number prefix for W arranty Code. Reduced warranty period applies to Newfoundland. W arranty Code: P R S T U V W Y S tandard W arranty Y ears: 3 5 6 7 8 9 10 12 Reduced W arranty Y ears: 2 3 3 5 5 5 5 7 ~ Certificate of W arranty ~ For its GSW and John W ood water heaters and storage boosters ("Unit"), GSW W ater H ...

Manufacturer GSW Category Water Heater

Documents that we receive from a manufacturer of a GSW JW317 can be divided into several groups. They are, among others:
- GSW technical drawings
- JW317 manuals
- GSW product data sheets
- information booklets
- or energy labels GSW JW317
All of them are important, but the most important information from the point of view of use of the device are in the user manual GSW JW317.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals GSW JW317, service manual, brief instructions and user manuals GSW JW317. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product GSW JW317.

Similar manuals

A complete manual for the device GSW JW317, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use GSW JW317 by users. Manuals are usually written by a technical writer, but in a language understandable to all users of GSW JW317.

A complete GSW manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual GSW JW317 - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the GSW JW317, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the GSW JW317, that we can find in the current document
3. Tips how to use the basic functions of the device GSW JW317 - which should help us in our first steps of using GSW JW317
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with GSW JW317
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of GSW JW317 in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning GSW JW317?

Use the form below

If you did not solve your problem by using a manual GSW JW317, ask a question using the form below. If a user had a similar problem with GSW JW317 it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)