English dropdown-ico

Manual Norcold 452

23 pages 0.38 mb
Download

Go to site of 23

Summary
  • Norcold 452 - page 1

    INSTALLATION AN D OPERATING INSTRUCTIONS 442 443 452 4 53 482 483 462 4 63 Part No .: 61 8484B (9 5-09) These refri g erators are desi g ned to operate on the followin g ener gy sources: LP GAS OPERATION - 11.0 inch es Propane & 12 volt DC contro l volta g e ( 15.4 volts m ax., 10. 5 volts min. ) . AC OPERATION - 120 volts AC ( 132 volts max., ...

  • Norcold 452 - page 2

    Safety Precautions Read this manual and b ecome thoroughly acquain ted with it before installing or starting the refrigerator. The following safety precautio ns and recommendation s contained h erein are for your protection. Improper installation, adjustment, or operation can cause injury or property damage. The safety symbols used in this manual c ...

  • Norcold 452 - page 3

    Safety Precautions - continued Electrical Circuits - AC and DC • The 120 volt AC circuit must be properly grounded. Never cut or remove the round grou nding prong f rom the re friger ator’s AC co rd. Do not us e a two- prong adapter . Do not use an extension cord to connect to t he approved AC recept acle. • Protect all wir in g from physical ...

  • Norcold 452 - page 4

    General Instructions - All Model s The refri g erators described in thi s manual are de- si g ned for built-in ins tallations and re q uire cut out di- mensions as i ndicated on pa g e . The refri g erators must be plac ed on a solid and level floor awa y from heat g eneratin g sources. The floor must be stron g enou g h to support the combined wei ...

  • Norcold 452 - page 5

    VENTILATION REQUIREMENTS WARNING: Carbon Monoxide can cause nausea, fainting, or deat h. Inadequat e ven- tilation or partial blockage of the refrigera- tor’s flue can result in increased car bon monoxide emissions when operating in the gas mode. To prevent the emission o f lev- els of carbon monoxide, in stallation must assure complete isolation ...

  • Norcold 452 - page 6

    Optimum Installation - Fi gure 1 The optimum instal lation is illustrated in Fi g ure 1. 1. Area above refri g erator blocked ( baffled ) off to preven t trap pin g of hot a ir ab ove th e refri g erat o r . 2 . 0 -1/ 4 in ch cl ear ance at th e t op of the r e f r i g erator. 3. Exhaust vent centered di rectl y over refri g era- tor’s condenser. ...

  • Norcold 452 - page 7

    Side Wall Clearance - Figure 4 1. Fi g ure 4 il lustrates the re q uirement to minimize the clearance at the sides of the refri g erator. The clearance is not to exceed 1/2 inch. Side clearances in ex cess of 1/2 inch must be either filled wi th Fiber g las battin g or blocked with pan- elin g , etc. Upper Side Wall Exhaust Vent For Mod- els 45 2, ...

  • Norcold 452 - page 8

    INSTALLATION INSTRUCTIONS Certification and Code Requi rements The refri g erators described herein are certif ied un- der the lates t edition of ANS I Z21.19 Standards b y the American Gas A ssociation ( A.G.A. ) for installa- tion in mobi le home or recreational vehicle and ap- proval b y the Canadian Gas Association ( CGA ) . Installation must b ...

  • Norcold 452 - page 9

    Gas Connection The refri g erators are desi g ned to operate on pro- pane g as at a suppl y pressure of 11 inches water column. A pressure re g ulator is re q uired between the refri g erator and the main g as tank. Do not connect the refrigerator dir ectly to the main propane tank without a pressur e regulator. Use suppl y pipin g and fittin g s t ...

  • Norcold 452 - page 10

    suppl y connects to the terminal bloc k at the rear of the refri g erator ( See Fi g ure 9 on pa g e 8 ) . The 12 volt DC should enter the refri g erator’s encl osure near the refri g erator’s terminal block . The 12 volt DC connects at ( 2 ) one q uarter inch q uick connects. The positi ve DC input l ead connects to terminal marked ( + ) , and ...

  • Norcold 452 - page 11

    Check O ut - Flame Fail ure Safe ty Devi ce Before placin g the refri g erator into operation, the g as safet y device must be tested ( see Operatin g In- structions on pa g e 13 ) . The purpose of the g as safet y device is to prev ent the escape of unbur ned g as from the burner if the burner flame is extin- g uished. Onc e a flame is establi she ...

  • Norcold 452 - page 12

    4 Remove the lower door b y openin g it sli g htl y and pullin g the top of the door awa y from the refri g erator. Allow enou g h room so the door can be li fted up and off of the bottom hi n g e pin shoulder ( See Fi g ure 18 ) . Be sure to save the hin g e plates alon g with the spacer used in the middle hin g e bracket, for reassembl y late r. ...

  • Norcold 452 - page 13

    ALIG NMENT OF THE DOORS 12. Ali g n the upper door with the lower so that there is a parallel g ap between the doors and around the frame. Ad j ust the doors to the cabi- net so the g askets seal but do not bind. Ti g hten the screws holdin g the hin g e brackets in place. 13. Door Seal: The door seal can be checked b y closi n g the door on a 1&qu ...

  • Norcold 452 - page 14

    Lighting and Start Up Procedures WARNING: DO NOT HOLD GAS VALVE (D) IN MORE THAN 30 SE CONDS. IF FLAME IS NOT INDICATED WITHIN THIS TIME, TURN GAS TO OFF, WAIT 2 MINUTES AND RETRY. CONTINUING T O HOLD GAS VALVE IN WILL CAUSE GAS BUILD-UP IN THE BURNE R AREA AND CAN RESULT IN AN EXPLOSION WHICH CAN CAUSE P E RSONAL INJURY OR DEATH. 2-Way and 3-Wa y ...

  • Norcold 452 - page 15

    OPERATING AND USER INSTRUCTIONS THIS APPLIANCE HAS BEEN DE SIGNED FOR STORAG E OF F OODS, S TORAGE O F FROZEN FOODS , AND M AKING ICE WH EN INS TALL ED AS DIRECTED BY THIS MANUAL. Location of Controls Figure 18 illustrates the location of the 400 Series refrigerator’s operating controls. All operating controls are conveniently located below the d ...

  • Norcold 452 - page 16

    tem not only s upplies power to the refrigerator, but to other DC components in the vehicle. DC electric operation is not as efficient as LP Gas or AC el ectric operation, and should therefore be used only when the other modes are unavail able (for example; while in transit - 4 to 6 hours). Reminder, before using the DC electric mode, the refrigera ...

  • Norcold 452 - page 17

    Leveling Comfortab le vehicle leveling is well within the re- frigera tor’s oper ating re quiremen ts of 3 de grees off lev el sid e-t o-sid e and 6 degr ees of f leve l fron t-to- back (loo king at t he fr ont of the re frigerator ). Co n- tinu ed op erati on out side of the se limi ts ca n resu lt in irreparab le damage t o the cooling system. ...

  • Norcold 452 - page 18

    is not bei ng used for storage. Keep the r efrig- erator area clear and free from combustible materials, gasol ine, and other fl ammable va- pors and liquids. 9. P eriodicall y inspect the ventil ation system. The air passage from the bottom intake vent to the refrigerator coil s and from the refrigerator coils through the upper exhaus t vent must ...

  • Norcold 452 - page 19

    Trouble Shooting SYMPT OM Refrigerator does not operate in AC Mode Possible Causes * Mode Selection swi tch may be set to "OFF" or "G AS". * Temperature Selector set too low. * Refrigerator’s power cord may not be se- curely p lugged in . * Circuit breaker or fuse may be tripped or blown (AC power source to r efrigera- tor). * ...

  • Norcold 452 - page 20

    FAILURE OF REFRIGERATION Failure of refrigeration does not necessarily indicate that the cooli ng system is defectiv e. Other factors governing its operation must be checked. If the refrigerator is operating on gas and a loss of cooling i s noticed, switc h the refrigerator to AC elec- tric operation. (See "O perating Instructions on page 13). ...

  • Norcold 452 - page 21

    2 1 ...

  • Norcold 452 - page 22

    2 2 ...

  • Norcold 452 - page 23

    LIMITED WARRANTY NORCOLD SERVICE CENTER P O BOX 42 48 SIDN EY OH 45365- 4248 This Limited Warranty is giv en by NORCOLD ("Company") to the original consumer-purchaser of any new refrigerating equipment ( "Equipment") suppl ied by the Company , excluding glasswar e and electric light bulbs, and will be effec tive for a period of ...

Manufacturer Norcold Category Refrigerator

Documents that we receive from a manufacturer of a Norcold 452 can be divided into several groups. They are, among others:
- Norcold technical drawings
- 452 manuals
- Norcold product data sheets
- information booklets
- or energy labels Norcold 452
All of them are important, but the most important information from the point of view of use of the device are in the user manual Norcold 452.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Norcold 452, service manual, brief instructions and user manuals Norcold 452. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Norcold 452.

Similar manuals

A complete manual for the device Norcold 452, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Norcold 452 by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Norcold 452.

A complete Norcold manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Norcold 452 - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Norcold 452, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Norcold 452, that we can find in the current document
3. Tips how to use the basic functions of the device Norcold 452 - which should help us in our first steps of using Norcold 452
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Norcold 452
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Norcold 452 in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Norcold 452?

Use the form below

If you did not solve your problem by using a manual Norcold 452, ask a question using the form below. If a user had a similar problem with Norcold 452 it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)