English dropdown-ico

Manual Char-Broil 463460708

28 pages 6.38 mb
Download

Go to site of 28

Summary
  • Char-Broil 463460708 - page 1

    THIS GRILL IS FOR OUTDOOR USE ONL Y . If you have questions or need assistance during assembly , please call . T o insure your satisfaction and for follow-up service, register your grill online at www.grillregistration.com 1-800-241-7548 463460708 • 80016598 • 01-03-08 CA UTION: Read and follow all safety statements, assembly instructions, and ...

  • Char-Broil 463460708 - page 2

    2 • 463460708 1. Do not store or use gasoline or other flammable liquids or vapors in the vicinity of this or any other appliance. 2. An LP cylinder not connected for use shall not be stored in the vicinity of this or any other appliance. WARNING CA UTION For residential use only. Do not use for commercial cooking. Call Grill Service Center for H ...

  • Char-Broil 463460708 - page 3

    T ABLE OF CONTENTS F o r Y o u r S a f e t y ......................................2 G r i l l S e r v i c e C e n t e r ...................................2 P r o d u c t R e c o r d I n f o r m a t i o n ............................2 Installation Safety Precautions . . . . . . . . . . . . . . . . . . . . . . . . . . 2 S a f e t y S y m b o l s .. ...

  • Char-Broil 463460708 - page 4

    • NEVER store a spare LP cylinder under or near the appliance or in an enclosed area. • Never fill a cylinder beyond 80% full. • An over filled or improperly stored cylinder is a hazard due to possible gas release from the safety relief valve. • If you see, smell or hear gas escaping, immediately get away from the LP cylinder/appliance and ...

  • Char-Broil 463460708 - page 5

    WARNING If “growing” bubbles appear do not use or move the LP cylinder . Contact an LP gas supplier or your fire department! Connecting Regulator to the LP Cylinder 1. LP cylinder must be properly secured onto grill. (Refer to assembly section.) 2. T urn all control knobs to the OFF position. 3. T urn LP cylinder OFF by turning hand-wheel clock ...

  • Char-Broil 463460708 - page 6

    6. T urn the coupling nut clockwise and tighten to a full stop. The regulator will seal on the back-check feature in the LP cylinder valve, resulting in some resistance. An additional one-half to three-quarters turn is required to complete the connection. Tighten by hand only – do not use tools. NOTE: If you cannot complete the connection, discon ...

  • Char-Broil 463460708 - page 7

    WARNING For Safe Use of Your Grill and to Avoid Serious Injury: • Do not let children operate or play near grill. • Keep grill area clear and free from materials that burn. • Do not block holes in sides or back of grill. • Check burner flames regularly . • Use grill only in well-ventilated space. NEVER use in enclosed space such as carpor ...

  • Char-Broil 463460708 - page 8

    Burner Flame Check • Remove cooking grates and flame tamers. Light burners, rotate knobs from HIGH to LOW . Y ou should see a smaller flame in LOW position than seen on HIGH. Perform burner flame check on sideburner , also. Always check flame prior to each use. If only low flame is seen refer to "Sudden drop or low flame" in the T roubl ...

  • Char-Broil 463460708 - page 9

    Cleaning the Burner Assembly Follow these instructions to clean and/or replace parts of burner assembly or if you have trouble igniting grill. 1. Turn gas off at control knobs and LP cylinder. 2. Remove cooking grates and flame tamers. 3. Remove screws and carryover tubes from rear of burners. 4. Remove screw and washers to disengage burner from br ...

  • Char-Broil 463460708 - page 10

    Indirect Cooking Poultry and large cuts of meat cook slowly to perfection on the grill by indirect heat. The heat from selected burners circulates gently throughout the grill, cooking meat or poultry without the touch of a direct flame. This method greatly reduces flare-ups when cooking extra fatty cuts because there is no direct flame to ignite th ...

  • Char-Broil 463460708 - page 11

    463460708 • 1 1 CARE AND CLEANING OF YOUR ST AINLESS STEEL GRILL Routine cleaning is necessary to preserve the appearance and corrosion resistance of Stainless Steel. The perception that many people have is that stainless steel will not rust. That is not the case in certain conditions. Rust marks are regular steel particles that have become attac ...

  • Char-Broil 463460708 - page 12

    P ARTS LIST – Model No. 463460708 12 • 463460708 Key Qty Description Part # A 1 F i r e b o x .........................8 0 0 0 9 9 4 6 B 4 T ube Burner . . . . . . . . . . . . . . . . . . . . . 80009947 C 1 Electrode, Main Burner. . . . . . . . . . . . . 80009948 D 3 Carryover T ubes . . . . . . . . . . . . . . . . . . 80009949 E 1 Lid Assembly ...

  • Char-Broil 463460708 - page 13

    463460708 • 13 P ARTS DIAGRAM – Model No. 463460708 P S G H E F R Q D B A I Y Z L C N K BB JJ GG HH AA DD II FF EE KK CC N O X J O M NN OO T LL U MM W V ...

  • Char-Broil 463460708 - page 14

    14 • 463460708 ASSEMBL Y – Model No. 463460708 1 Attach the two locking casters at the rear of the bottom shelf and the two non-locking casters at the front . Use the provided caster wrench to fully tighten casters. Locking caster Bottom shelf Non-locking caster R ear F ron t 2 1/4-20x1/2” screw Attach side panels to bottom shelf using three ...

  • Char-Broil 463460708 - page 15

    4 3 463460708 • 15 Insert wire ends on tank exclusion shelf into bottom shelf (A) . Attach with two #8-32x3/8" screws diagonally . T ighten two #8- 32x3/8" screws at the back of tank exclusion wire first (B) . Line up the front of tank exclusion wire to holes in top brace and secure with two #8-32x3/8" screws and #8-32 flange nuts. ...

  • Char-Broil 463460708 - page 16

    16 • 463460708 5 6 T wo #8-32x3/8" machine screws are installed partially in the cart side panel. Slide door hinges onto the screws as shown. Secure right door with four #8-32x3/8" machine screws . Repeat assembly for left door . #8-32x3/8" machine screw This step requires two people to lift and position grill head onto cart. Caref ...

  • Char-Broil 463460708 - page 17

    463460708 • 17 Mount fascia onto side shelf using three #10-24x1/2" screws , 5mm lock washers and 5mm flat washers (A) . Hang side shelf on tabs mounted on the firebox. Secure shelf brackets to cart side panel using two 1/4-20x1/2" screws , fiber washers and 1/4-20 flange nuts on each bracket (B) . Secure fascia to firebox using two 1/4 ...

  • Char-Broil 463460708 - page 18

    9 Place drip pan onto sideburner shelf. Secure with #10-24x 1/2" screws, insulation washers , 5mm flat washers, 5mm lock washers , #10-24 hex nuts, #10-24x 1/2” screws, 5mm lock washers, 5mm flat washers and side burner lid supports. 18 • 463460708 10 Remove two #8-32x3/8" screws from sideburner valve bracket. From behind the fascia, ...

  • Char-Broil 463460708 - page 19

    12 463460708 • 19 11 Insert sideburner into sideburner drip pan (A) , make sure burner tube engages with sideburner valve. Illustration (B) shows correct burner-to-valve engagement. Center stud on bottom of sideburner fits into center hole in sideburner drip pan. Secure with one wingnut (C) . Connect sideburner ignitor wire to sideburner electrod ...

  • Char-Broil 463460708 - page 20

    20 • 463460708 13 Place four flame tamers over burners by inserting tabs into slots in front of firebox. Opposite ends of flame tamers rest on pins in back of firebox. Flame tamer B ack of firebo x Flame t a mer Front of firebox 14 Place cooking grates into grill bottom. Cooking Grates ...

  • Char-Broil 463460708 - page 21

    463460708 • 21 T o assemble Swing A way , first insert pivot wire into holes in side of grill lid. Second, insert leg wires into holes in sides of grill bottom. 15 Pivot wire Swing Away Leg wire Hang grease cup wire from bottom of firebox and place grease cup into grease cup clip. Failure to install grease cup will cause hot grease to drip from b ...

  • Char-Broil 463460708 - page 22

    17 Unscrew ignitor cap and place AA battery into ignitor slot with positive end (+) facing outward. Screw ignitor cap onto ignitor . + – AA Battery Tank screw LP tank is sold separately. Fill and leak check the tank (see Use & Care section) before attaching to grill and regulator . Once tank has been filled and leak checked, place tank into t ...

  • Char-Broil 463460708 - page 23

    EMERGENCIES: If a gas leak cannot be stopped, or a fire occurs due to gas leakage, call the fire department. Emergencies Problem Gas leaking from cracked/cut/burned hose. Gas leaking from LP cylinder . Gas leaking from LP cylinder valve. Gas leaking between LP cylinder and regulator connection. Fire coming through control panel. Grease fire or cont ...

  • Char-Broil 463460708 - page 24

    Troubleshooting ( continued ) Problem Burner(s) will not light using ignitor . (See Electronic Ignition T roubleshooting also) Burner(s) will not match light. Sudden drop in gas flow or low flame. Flames blow out. Flare-up. Persistent grease fire. Flashback... (fire in burner tube(s)). Unable to fill LP cylinder . One burner does not light from oth ...

  • Char-Broil 463460708 - page 25

    Troubleshooting - Electronic Ignition Problem (Ignition) SECTION I No sparks appear at any electrodes when ignition button is pushed; no noise can be heard from spark module. SECTION II No sparks appear at any electrodes when ignition switch is pushed; noise can be heard from spark module. SECTION III Sparks are present but not at all electrodes an ...

  • Char-Broil 463460708 - page 26

    26 • 463460708 Manufacturer warrants to the original consumer-purchaser only that this product shall be free from defects in workmanship and materials after correct assembly and under normal and reasonable home use for the periods indicated below beginning on the date of purchase. The manufacturer reserves the right to require that defective part ...

  • Char-Broil 463460708 - page 27

    Mail to: / Envíelo a: Consumer W arranty Service P . O. Box 1240 Columbus, GA 31902-1240 Thank you for completing this questionnaire. Y our answers will help us and other companies reach you with of fers that may interest you. If you prefer not to receive these offers, please check here . Gracias por completar este cuestionario. Sus respuestas nos ...

  • Char-Broil 463460708 - page 28

    ST OP Should you encounter a problem with our product CALL US FIRST Do not return this product to the store. WE CAN HELP GRILL SERVICE CENTER 1-800-241-7548 HOURS 8AM-6PM EST Mon-Fri Please ensure your warranty registration is complete. Grilling Safety Checklist Read and understand owners manual. Never overfill LP cylinder . Overfilled cylinders ma ...

Manufacturer Char-Broil Category Gas Grill

Documents that we receive from a manufacturer of a Char-Broil 463460708 can be divided into several groups. They are, among others:
- Char-Broil technical drawings
- 463460708 manuals
- Char-Broil product data sheets
- information booklets
- or energy labels Char-Broil 463460708
All of them are important, but the most important information from the point of view of use of the device are in the user manual Char-Broil 463460708.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Char-Broil 463460708, service manual, brief instructions and user manuals Char-Broil 463460708. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Char-Broil 463460708.

Similar manuals

A complete manual for the device Char-Broil 463460708, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Char-Broil 463460708 by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Char-Broil 463460708.

A complete Char-Broil manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Char-Broil 463460708 - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Char-Broil 463460708, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Char-Broil 463460708, that we can find in the current document
3. Tips how to use the basic functions of the device Char-Broil 463460708 - which should help us in our first steps of using Char-Broil 463460708
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Char-Broil 463460708
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Char-Broil 463460708 in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Char-Broil 463460708?

Use the form below

If you did not solve your problem by using a manual Char-Broil 463460708, ask a question using the form below. If a user had a similar problem with Char-Broil 463460708 it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)