English dropdown-ico

Manual Cornelius CCM CCU

25 pages 1.19 mb
Download

Go to site of 25

Summary
  • Cornelius CCM CCU - page 1

    Nordic Ice Maker Model CCM and CCU Series Installation, Start-up and Maintenance Manual IMI CORNELIUS I NC. www.corne lius.com Publication Number: 631806051 Revision Date: September 1, 2007 Revision: A Visit the IMI Cornelius web site at www.cornelius.com for all your Literature needs. CCM and CCU Series Installation, Start-u p and Maintenance Manu ...

  • Cornelius CCM CCU - page 2

    * ...

  • Cornelius CCM CCU - page 3

    Forward Page i How To Use This Manual Cornelius provides this manual a s an ai d to the serv ice technician in installation and maintena nce of the CCM and CCU Series cube ice machines. Do not attempt to perform installation, start-up or maintenance unle ss you have read and fully understand this manual. If at any time you encounter conditions that ...

  • Cornelius CCM CCU - page 4

    Table of Contents Page ii F o r e w a r d Page i T a b l e o f C o n t e n t s Page ii Freight Claim Procedure Page iii Model Number and Serial Number Format Page 1 Installation Guidelines Page 2 Remote Condenser Guidelines Page 4 Electrical and Plumbing Requirements Page 6 H o w t h e M a c h i n e W o r k s Page 13 Start-Up Procedure Page 14 G e ...

  • Cornelius CCM CCU - page 5

    Freight Claim Procedure Page iii Freight Claims Important! Inspect Promptly This merchandise has been carefully inspecte d and packed in accordance with the carri er’s packing spe cifi cations. Responsibility for safe delivery has been assumed by the carrier. If loss or damage occurs, you as the consignee must file a claim with the carrier and ho ...

  • Cornelius CCM CCU - page 6

    Model and Serial Number Format Page 1 Model and Serial Number Format The serial number format and ma chin e spe cifics are detailed o n the data plate. Model Number CCM 06 30 A H 1 2 Engineering Rev Level Voltage:1=115V, 2=230V, 3=230V 3ph 5=50Hz. Cube Size: H=Half Cube, F=Full Cube Condenser Type: A=Air, W=Water, R=Remote Cabinet Width (in inches) ...

  • Cornelius CCM CCU - page 7

    Installation Guidelines Page 2 Installation Guidelines For proper operation of the Corneliu s ice machine, the following installation guid elines must be followed. Failure to do so may result in loss of productio n capacity, pr emature part failures, and ma y void all warranties. Reference the installation parameters prior to installi ng the machin ...

  • Cornelius CCM CCU - page 8

    Installation Guidelines Page 3 Secure the machine on top of the bin or disp enser. Attach the ice machine to the bin with the mounting strap s pr ovided with the bin or dispenser. Insure that the back of the ice machine is flush with the back of the bin. Prop er functioning of the bin door requires the bin door, when it is opened, to be in a stable ...

  • Cornelius CCM CCU - page 9

    Remote Condenser Guidelines Page 4 Remote Condenser Installation For proper operation of the Corneliu s ice machine, the following installation guid el ines must be followed. Failure to do so may result in loss of productio n ca pacity, premature part failure, and may void all warranties. Remote condensers must be inst alled per local buildi ng cod ...

  • Cornelius CCM CCU - page 10

    Remote Condenser Guidelines Page 5 The CCM0530R, CCM0630R, CCM08 3 0R, CCM1030R and CC M1530R remot e ice makers inco rporate the mixing valve in the condenser. This configuration allows up to a 100 foot calculated remote line set run. Reference the diagram below to calculate the maximum 100 foot line set run. ICE Machine Model Number Remote Conden ...

  • Cornelius CCM CCU - page 11

    Electrical and Plumbing Requirements Page 6 Electrical and Plumbing Requirements: CCU0150, and CCU0220 (Inclu des 50Hz. and 230 Volt Units) Note: The CCU Underco unter series do not have a splash curtain. These models utilize a thermostatic bin control in place of a mechanical bin sw it c h. ON-OFF-WASH S witch is located in the control box. Remove ...

  • Cornelius CCM CCU - page 12

    Electrical and Plumbing Requirements Page 7 Electrical and Plumbing Requirements: CCU0300 (Includes 50Hz. Units) Note: The CCU Underco unter Series do not have a splash curtain. These models utilize a thermostatic bin control in place of a mechanical bin sw it c h. ON-OFF-WASH S witch is located in the control box. Remove the grill screws to access ...

  • Cornelius CCM CCU - page 13

    Electrical and Plumbing Requirements Page 8 Electrical and Plum bing Requirements: CCM0330, CCM0430, CCM0530, CCM0630 (Includes 50Hz. Units) ...

  • Cornelius CCM CCU - page 14

    Electrical and Plumbing Requirements Page 9 Electrical and Plumbing Requirements: CCM0830 and CCM1030 (Includ es 50Hz. And 3 Phase Units) ...

  • Cornelius CCM CCU - page 15

    Electrical and Plumbing Requirements Page 10 Electrical and Plumbing Requirements: CCM1448, CCM1848 AND CCM2148 (Includes 50Hz. and 3 Phase Units) ...

  • Cornelius CCM CCU - page 16

    Electrical and Plumbing Requirements Page 11 Electrical and Plumbing Requirements: CCM0322 AND CCM0522 (Includes 50Hz.Units) ...

  • Cornelius CCM CCU - page 17

    Electrical and Plumbing Requirements Page 12 Electrical and Plumbing Requirements : CCM1530 Remote ...

  • Cornelius CCM CCU - page 18

    How the CCM Ice Machine Works Page 13 How the Ice Machine Works A general description of how the CCM Series cubers works is given below. With the ICE/OFF/WASH switch in the ICE position, the compressor, water pump and condense r fan motor (when appli cable) w ill energize starting the freeze cycle. During the freeze cycle, wa ter is ci rc ulated ov ...

  • Cornelius CCM CCU - page 19

    Start-Up Procedure Page 14 Start-Up Procedure Before starting the machine, make sure the machi ne is level within 1/8 inch in all directions, the bin or dispe nser leg height can be adjusted by rotating the leg foot. Check the water level in the water trough. It should be appr oximat ely ½ inch above the top of the water pump impeller housing. The ...

  • Cornelius CCM CCU - page 20

    Start-Up Procedure Page 15 Bin Control Operation The bin control is used to shut the machine off when the bin fills with ice. The bin control must be checked upon installation or initial start- up and when performing maintenance. There is one bin switch for each evaporator. The actu ator arm of the bin switch comes in contact with the splash curtai ...

  • Cornelius CCM CCU - page 21

    General Maintenance Page 16 Electrical shock and/or inju ry from mo ving parts inside this machine ca n cause serious injury. Disconnect electrical supply to machine prior to performing any adjustme nts or repairs. Failure to perform the required maintena nce at the frequency specified will void warranty coverage in the event of a related failure. ...

  • Cornelius CCM CCU - page 22

    Cleaning Procedure Page 17 Ice Machine Cleaning and Sanitizing Instructions 1. Remove the ice machine front panel. 2. Make sure that all the ice is o ff of the evaporator. If ice is being made, wait for cycle completion then turn the machine “OFF” at the ICE/OFF/WASH selector switch . 3. Remove or melt all ice in the storage bin. 4. Add recomme ...

  • Cornelius CCM CCU - page 23

    Cabinet Care Page 18 Cleaning stainless steel Commercial grades of stainles s ste el are susceptible to rusting if not pr operly maintained. It is important that you properly care for the st ainless steel surfaces of your ic e machine and bin to avoid the pos sibilit y of rust or corrosion. Use the following recommended guidelines for keep ing your ...

  • Cornelius CCM CCU - page 24

    Winterizing Procedure Page 19 Winterizing Procedures Important! Whenever the ice machine is take n out of operation dur ing the winter months, the procedu re below must be performed. Failure to do so may cause se rious damage and will void all warranties. 1. Turn off water to machine. 2. Make sure all ice is off of the ev aporator(s). If ice is bei ...

  • Cornelius CCM CCU - page 25

    Service History Page 20 9081365-01 Service History Model Number__________________Serial Number__________________Date Installed__________ ___________________ ______________ ___________________ ______________ ___________________ _____ ___________________ ______________ ___________________ ______________ ___________________ _____ ___________________ _ ...

Manufacturer Cornelius Category Ice Maker

Documents that we receive from a manufacturer of a Cornelius CCM CCU can be divided into several groups. They are, among others:
- Cornelius technical drawings
- CCM CCU manuals
- Cornelius product data sheets
- information booklets
- or energy labels Cornelius CCM CCU
All of them are important, but the most important information from the point of view of use of the device are in the user manual Cornelius CCM CCU.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Cornelius CCM CCU, service manual, brief instructions and user manuals Cornelius CCM CCU. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Cornelius CCM CCU.

Similar manuals

A complete manual for the device Cornelius CCM CCU, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Cornelius CCM CCU by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Cornelius CCM CCU.

A complete Cornelius manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Cornelius CCM CCU - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Cornelius CCM CCU, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Cornelius CCM CCU, that we can find in the current document
3. Tips how to use the basic functions of the device Cornelius CCM CCU - which should help us in our first steps of using Cornelius CCM CCU
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Cornelius CCM CCU
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Cornelius CCM CCU in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Cornelius CCM CCU?

Use the form below

If you did not solve your problem by using a manual Cornelius CCM CCU, ask a question using the form below. If a user had a similar problem with Cornelius CCM CCU it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)