English dropdown-ico

Manual Cal Flame BBQ11955P

36 pages 2.93 mb
Download

Go to site of 36

Summary
  • Cal Flame BBQ11955P - page 1

    ...

  • Cal Flame BBQ11955P - page 2

    Copyright 2011 LMS, Inc. All rights re- served. Duplication without writ ten consent is strictly prohibited. Cal Flame ® is a registered trademark. Due to continuous improvement programs, all models, operation, and/or specications are subject to change without prior notice. L TR50001100, Rev . A 4/26/11 250-403 CONTACT INFORMATION For customer ...

  • Cal Flame BBQ11955P - page 3

    Safety Instructions 1 Power Burner L TR50001100, Rev . A w ww . c a l  a m e b b q . c o m Placement and Location The Cal Flame Power Burner is designed for outdoor use only. Never locate this appliance in an enclosed room, under a sealed • overhead structure, or in any type of enclosed area such as a ga- rage, shed, or breez eway . K eep clea ...

  • Cal Flame BBQ11955P - page 4

    2 Safety Instructions Power Burner L TR50001100, Rev . A w ww . c a l  a m e b b q . c o m Operation Do not use the Power Burner f or oth • er than its intended use. Never use the Power Burner if the drip pan is not in place. The drip • pan should be pushed all the w ay in under the P ower Burner . Fire or explosion can result from an improp ...

  • Cal Flame BBQ11955P - page 5

    Safety Instructions 3 Power Burner L TR50001100, Rev . A w ww . c a l  a m e b b q . c o m garments while using your Power Burner . F abric may ignite and result in personal injury . When using the P ower Burner , do not touch the grate or immediate • surroundings as these areas become extremely hot and can cause burns. Only use dry pot holder ...

  • Cal Flame BBQ11955P - page 6

    4 Installation / Assembl y Power Burner L TR50001100, Rev . A w ww . c a l  a m e b b q . c o m Most cities and counties require permits for exterior construction. In addition, some communities have codes requiring residential barriers such as fencing and/or self -closing gates on pr operty to prev ent unsu- pervised access to the pr operty by c ...

  • Cal Flame BBQ11955P - page 7

    Installation / Assembl y 5 Power Burner L TR50001100, Rev . A w ww . c a l  a m e b b q . c o m Cabinet Cut-out Dimensions Y our Cal Flame P ower Burner is designed for easy installation into a non-combustible enclosure. The supporting deck or counter must be at and level. Width Depth Height 18” 20” 9 ¼” WIDTH DEPTH HEIGHT ...

  • Cal Flame BBQ11955P - page 8

    6 Installation / Assembl y Power Burner L TR50001100, Rev . A w ww . c a l  a m e b b q . c o m LP Gas Tank Requirements For plumbed-in LP installation, use a convertible regulator and set it for LP gas. Maximum line pressure for plumbed-in propane is 14” WC (3.5 kP a). Minimum line pressure for pr opane is 11” WC. The Power B urner must be ...

  • Cal Flame BBQ11955P - page 9

    Installation / Assembl y 7 Power Burner L TR50001100, Rev . A w ww . c a l  a m e b b q . c o m The maximum fuel capacity is 20 lbs. of propane, or 5 gallons. Full cyl- inder weight should be approximately 38 lbs. (43.7 lbs. nominal water capacity . ) Never ll the cylinder beyond 80% full. Place the dust cap on the cylinder valve outlet whene ...

  • Cal Flame BBQ11955P - page 10

    8 Installation / Assembl y Power Burner L TR50001100, Rev . A w ww . c a l  a m e b b q . c o m Natural Gas Requirements Always check the rating plate to make sure the gas supply you are hooking up to is the gas type the P ower Burner is manufactured f or . IMPOR T ANT : Never connect the P ower Burner to an unregulated gas supply . The installa ...

  • Cal Flame BBQ11955P - page 11

    Installation / Assembl y 9 Power Burner L TR50001100, Rev . A w ww . c a l  a m e b b q . c o m Leak Testing Procedure Perf orm a leak test at least once a year whether the gas supply cylinder has been disconnected or not. In addition, whenever the gas cylinder is connected to the regulator or whenever any part of the gas system is disconnected ...

  • Cal Flame BBQ11955P - page 12

    10 Installation / Assembl y Power Burner L TR50001100, Rev . A w ww . c a l  a m e b b q . c o m Placing the Power Burner in a Built-in Enclosure You may need a second person to help you to avoid damag- ing the Power Burner or your enclosure. Before installing the P ower Burner in an enclosure, make sure that the opening is not bigger than the o ...

  • Cal Flame BBQ11955P - page 13

    Using Y our Grill 11 Power Burner L TR50001100, Rev . A w ww . c a l  a m e b b q . c o m Read all instructions before you operate your Power Burner. W e recommend you w ash the Power Burner thoroughly with soap and water prior to lighting it for the rst time. Oils are used during the manufacturing process and some residual oil may still be o ...

  • Cal Flame BBQ11955P - page 14

    12 Using Y our Grill Power Burner L TR50001100, Rev . A w ww . c a l  a m e b b q . c o m Basic Operation Before lighting, make sure all burner controls are off . Do not at- tempt to light the burners if the smell of gas is present. Check the connection with a soap and w ater solution after attaching the hose. For LP units, make sure there is ga ...

  • Cal Flame BBQ11955P - page 15

    Using Y our Grill 13 Power Burner L TR50001100, Rev . A w ww . c a l  a m e b b q . c o m Lighting the Power Burner Electronic Ignition Lift the cover . 1. K eep your face as f ar awa y from the burners as possible. 2. T urn the burner knob counter clockwise past the light position 3. to HIGH. Y ou will hear a loud click as the electronic lighte ...

  • Cal Flame BBQ11955P - page 16

    14 Using Y our Grill Power Burner L TR50001100, Rev . A w ww . c a l  a m e b b q . c o m Power Burner Lid W e strongly recommend you remove the lid for your P ower Burner before each use. The P ower Burner lid is attached to the unit by two hinges on each side. Each hinge has a detachable spring-loaded hinge pin that re- moves easily when pulle ...

  • Cal Flame BBQ11955P - page 17

    Using Y our Grill 15 Power Burner L TR50001100, Rev . A w ww . c a l  a m e b b q . c o m Using the Wok Ring If you have a wok, you can use it wi th the P ower B urner . Remove the grate and set it aside. Inside the burner ar ea, surrounding the brass burners, is a stainless steel ring that will securely hold your wok in place while you cook wit ...

  • Cal Flame BBQ11955P - page 18

    16 Cleaning and Maintenance Power Burner L TR50001100, Rev . A w ww . c a l  a m e b b q . c o m Cleaning and Maintenance Removing and Replacing Burners The burner has three pieces plus a wok ring. If y ou remo ve the burner for cleaning, make sure to clean each piece and replace them in proper order . Removal Disconnect or shut of f the gas lin ...

  • Cal Flame BBQ11955P - page 19

    Cleaning and Maintenance 17 Power Burner L TR50001100, Rev . A w ww . c a l  a m e b b q . c o m Replacement Set the burner body in place, 1. making sure the stud in prop- erly seated and the burner body is at and level. Set the burner ring on the 2. burner body , making sure the pin on the burner ring is seat- ed in the notch on the burner b ...

  • Cal Flame BBQ11955P - page 20

    18 Cleaning and Maintenance Power Burner L TR50001100, Rev . A w ww . c a l  a m e b b q . c o m T o ensure safe and proper maintenance, we recommend you follow these directions caref ully . Clean internal parts of the Power Burner regularly as determined by the amount of use and foods cooked. The entire Power Burner should be cleaned at least o ...

  • Cal Flame BBQ11955P - page 21

    Cleaning and Maintenance 19 Power Burner L TR50001100, Rev . A w ww . c a l  a m e b b q . c o m Caution Do not use WD-40 or Sheila Shine near food or on food preparation surfaces as it is a health hazard. This includes the interior of the Power Burner and the gr ate. Cleaning Products and Materials Avoid using these common cleaning products and ...

  • Cal Flame BBQ11955P - page 22

    20 Cleaning and Maintenance Power Burner L TR50001100, Rev . A w ww . c a l  a m e b b q . c o m Clean 1. Thoroughly clean stains, food, and grime using a sponge or damp cloth with warm water and a mild dish soap. Use Fantastik or F or- mula 409 to remove hea vier soil. Rinse 2. Thoroughly rinse all surfaces and dry them completely with a clean ...

  • Cal Flame BBQ11955P - page 23

    Cleaning and Maintenance 21 Power Burner L TR50001100, Rev . A w ww . c a l  a m e b b q . c o m Rust Removal It is a common misconception that stainless steel does not rust. It does not stain, corrode, or rust as easily as ordinary steel (it stains less ), but it is not stain-proof . If not properly protected and maintained, it can corrode, pit ...

  • Cal Flame BBQ11955P - page 24

    22 Cleaning and Maintenance Power Burner L TR50001100, Rev . A w ww . c a l  a m e b b q . c o m from the P ower Burner by carefully lifting each burner up and away from the gas v alve orice. Use a wire brush to clean the outer surface of each burner to remove food residue and dirt. Clean any clogged ports with a stiff wire such as an opened ...

  • Cal Flame BBQ11955P - page 25

    Appendix 23 Power Burner L TR50001100, Rev . A w ww . c a l  a m e b b q . c o m Troubleshooting Problem: Smell of gas is present Solution: Check for loose connections in the gas line. Perform a leak test following the procedure on page 9. Problem: Burner does not ignite Solution: Use the following procedure with the gure below . Check the po ...

  • Cal Flame BBQ11955P - page 26

    24 Appendix Power Burner L TR50001100, Rev . A w ww . c a l  a m e b b q . c o m Problem: Plugged orice Solution: Unplug the orice as follows: Remov e grate and gr ease tray . • Remov e the burner ring and the outer burner . • Carefully lift the center burner up and away from • the gas orice. Remov e the orice from the control ...

  • Cal Flame BBQ11955P - page 27

    Appendix 25 Power Burner L TR50001100, Rev . A w ww . c a l  a m e b b q . c o m Problem: Misalignment of Igniter on Burner Solution: Check for proper position of the electrode tip , which • should be pointing forward towar ds the front of the burner and free of grease to allow proper sparking. The ignition wire should be connected rmly to ...

  • Cal Flame BBQ11955P - page 28

    26 Appendix Power Burner L TR50001100, Rev . A w ww . c a l  a m e b b q . c o m All Cal Flame gas appliances are manufactur ed to operate with standard liquid propane (LP and can be converted to burn natural gas (NG). There are two steps required to con vert from LP to NG. You must perform both steps. Step 1: Switching the regulator behind the ...

  • Cal Flame BBQ11955P - page 29

    Appendix 27 Power Burner L TR50001100, Rev . A w ww . c a l  a m e b b q . c o m Step 1: Switching the regulator The regulator in the image below has been removed to illustrate this pro- cedure. Remov e the LP gas line. 1. Remov e the cap tting from the 2. end of the NG gas regulator . Place the cap tting over the LP 3. gas inlet. Insert a ...

  • Cal Flame BBQ11955P - page 30

    28 Appendix Power Burner L TR50001100, Rev . A w ww . c a l  a m e b b q . c o m Step 2: Changing the burner orices Remov e the grate, burner ring, 1. and burner from the Power Burn- er . Locate the gas orices. They will 2. be directly behind the gas v alves. Using a 6mm socket or nut driver , 3. remove the orice. Y ou will need: 6 mm s ...

  • Cal Flame BBQ11955P - page 31

    Appendix 29 Power Burner L TR50001100, Rev . A w ww . c a l  a m e b b q . c o m Apply a small amount of pipe compound to the orice threads. 4. Screw in the orice until it is nger tight. 5. Tighten the orice with the 6mm wrench. 6. Repeat the abo ve steps for the remaining burners. 7 . Replace the burners and the gr ate. 8. Mark the ...

  • Cal Flame BBQ11955P - page 32

    30 Appendix Power Burner L TR50001100, Rev . A w ww . c a l  a m e b b q . c o m Limited Warranty LMS w arrants the P ower Burner and associated hardwar e fr om defects in material and workmanship f or a period of one year from the original date of purchase. This includes deterior ation and corrosion of burners, mountings, and lid and body . Ext ...

  • Cal Flame BBQ11955P - page 33

    Appendix 31 Power Burner L TR50001100, Rev . A w ww . c a l  a m e b b q . c o m This warranty is void if the barbecue gril l has been subject to negligence, alteration, misuse, repairs, dings, dents, scratches, or incorrect and / or prohibited applications, as specied in the owner’s manual. Gas lines must be installed by a licensed plumber ...

  • Cal Flame BBQ11955P - page 34

    32 Appendix Power Burner L TR50001100, Rev . A w ww . c a l  a m e b b q . c o m Legal Remedies This limited warranty gives you specic legal rights. Y ou may have other rights, which may v ary from state to state. Customer Service For customer service, contact the authorized selling dealer immediately . If you need additional information or a ...

  • Cal Flame BBQ11955P - page 35

    Appendix 33 Power Burner L TR50001100, Rev . A w ww . c a l  a m e b b q . c o m ...

  • Cal Flame BBQ11955P - page 36

    L TR50001100, Rev . A 4/26/11 California Proposition 65 Warning: Chemicals known to the State of California to cause cancer , birth defects or other reproductive harm are found in and/or created by the combustion of natural gas, propane, butane and other fuels. Always operate this unit as described in the owner’s manual and in well ventilated are ...

Manufacturer Cal Flame Category Burner

Documents that we receive from a manufacturer of a Cal Flame BBQ11955P can be divided into several groups. They are, among others:
- Cal Flame technical drawings
- BBQ11955P manuals
- Cal Flame product data sheets
- information booklets
- or energy labels Cal Flame BBQ11955P
All of them are important, but the most important information from the point of view of use of the device are in the user manual Cal Flame BBQ11955P.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Cal Flame BBQ11955P, service manual, brief instructions and user manuals Cal Flame BBQ11955P. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Cal Flame BBQ11955P.

Similar manuals

A complete manual for the device Cal Flame BBQ11955P, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Cal Flame BBQ11955P by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Cal Flame BBQ11955P.

A complete Cal Flame manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Cal Flame BBQ11955P - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Cal Flame BBQ11955P, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Cal Flame BBQ11955P, that we can find in the current document
3. Tips how to use the basic functions of the device Cal Flame BBQ11955P - which should help us in our first steps of using Cal Flame BBQ11955P
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Cal Flame BBQ11955P
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Cal Flame BBQ11955P in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Cal Flame BBQ11955P?

Use the form below

If you did not solve your problem by using a manual Cal Flame BBQ11955P, ask a question using the form below. If a user had a similar problem with Cal Flame BBQ11955P it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)