English dropdown-ico

Manual Desa (V)T32EN SERIES

40 pages 2.03 mb
Download

Go to site of 40

Summary
  • Desa (V)T32EN SERIES - page 1

    For more information, visit www .desatech.com DIRECT -VENT FIREPLACE OWNER’S OPERA TION AND INST ALLA TION MANU AL NA TURAL GAS “TUDOR” MODEL (V)T32EN SERIES PROP ANE/LP GAS “TUDOR” MODEL (V)T32EP SERIES W ARNING: If the information in this manual is not fol-       ? ...

  • Desa (V)T32EN SERIES - page 2

    www .desatech.com 1 1 1987-01D 2 SAFETY INFORMA TION T ABLE OF CONTENTS Safety Information ............................................... 2 Local Codes......................................................... 4 Product Identication ........................................... 4 Product Features ................................................. 4 ...

  • Desa (V)T32EN SERIES - page 3

    www .desatech.com 1 1 1987-01D 3 SAFETY INFORMA TION Continued This replace must be installed by a qualied (cer - tied or licensed) service person. It has a sealed gas combustion chamber that uses a coaxial pipe (pipe within a pipe and having the same center) venting system. It brings in fresh air for combus - tion through the outer pipe a ...

  • Desa (V)T32EN SERIES - page 4

    www .desatech.com 1 1 1987-01D 4 SAFETY INFORMA TION Continued 2. If you smell gas • shut off gas supply • do not try to light any appliance • do not touch any electrica l switch; do not use any phone in your building • immediately call your gas supplier from a neighbor ’ s phone. Follow the gas supplier's instructions • if you can ...

  • Desa (V)T32EN SERIES - page 5

    www .desatech.com 1 1 1987-01D 5 Figure 2 - Common Fireplace Locations Flush with a wall Through exterior wall enclosed in a chase Corner installation • The blower requires electricity if installed and if you plan to install the blower at a later date, do not forget to wire the outlet at the bottom of the replace when framing. • The electron ...

  • Desa (V)T32EN SERIES - page 6

    www .desatech.com 1 1 1987-01D 6 PRE-INST ALLA TION PREP ARA TION Continued Figure 4 - Framing Clearances for Installation Against an Exterior Wall Figure 5 - Framing Clearances for Corner Installation C B A D E F G T op of Louver Opening 3 2 1 4 5 6 7 Wall Ref. Mantel Depth Ref. Mantel from T op of Louver Opening 1 14" A 16" 2 12" B ...

  • Desa (V)T32EN SERIES - page 7

    www .desatech.com 1 1 1987-01D 7 Figure 7 - Minimum Clearances for T ermination Cap LOCA TION OF TERMINA TION CAP Fixed Closed Op en ab le Fixed Closed V V V V V V V V X X V X G G J F B B K N H I A N E L D B M A C B V V A G G B TERMINA TION CAP AIR SUPPL Y INLET GAS METER RESTRICTED AREA (TERMINA TION PROHIBITED) A = clearance above grade, veranda, ...

  • Desa (V)T32EN SERIES - page 8

    www .desatech.com 1 1 1987-01D 8 VENT ING INST ALLA TION INSTRUCTIONS NOTICE: Read these instruc-                           -  Thes e mod els ar e t est ed and a ppr ove d f or us e with DESA (direct-vent) ...

  • Desa (V)T32EN SERIES - page 9

    www .desatech.com 1 1 1987-01D 9 INST ALLA TION PLANNING There are two basic types of direct-vent in - stallation: • Horizontal T ermination • V ertical T ermination Horizontal T ermination Installation IMPORTANT : Horizontal square terminations require only inner portion of wall restop. Hori - zon tal inst all atio ns using rou nd termi nat ...

  • Desa (V)T32EN SERIES - page 10

    www .desatech.com 1 1 1987-01D 10 VENTING INST ALLA TION INSTRUCTIONS Continued W ARNING: Do not recess       6.  ? ...

  • Desa (V)T32EN SERIES - page 11

    www .desatech.com 1 1 1987-01D 1 1 VENTING INST ALLA TION INSTRUCTIONS Continued Figure 13 - T ypical Horizontal T ermination Cap Mounting with Additional Siding Standoff Installed Siding Standoff Screws High Wind T ermination Apply Mastic to Outside Edge of Standoff Exterior W all with Vinyl Siding 10" x 10" Framed Opening Maintain 1&quo ...

  • Desa (V)T32EN SERIES - page 12

    www .desatech.com 1 1 1987-01D 12 CORN ER AND AL TERNA TE INST ALL A TIO N Recommended Applications: • Corner ground oor installation • G ro un d  o or in st a l la ti on w he re pi p e v en ts ho ri zo n - ta lly th rou gh wal l ( ove r 12" horizontal pipe) • Basement installation where one foot clearance from ground to terminatio ...

  • Desa (V)T32EN SERIES - page 13

    www .desatech.com 1 1 1987-01D 13 VENTING INST ALLA TION INSTRUCTIONS Continued      Horizontal (H 1  Horizontal (H 1  Horizontal (H 2  5' min. 2' max. 6' max. 6' min. 4' max. 12' max. ...

  • Desa (V)T32EN SERIES - page 14

    www .desatech.com 1 1 1987-01D 14 INST ALLA TION FOR VERTICAL TERMINA TION Note: V ertical restrictor must be installed in all vertical installations. 1. Determine the route your vertical venting will take. If ceiling joists, roof rafters or other framing will obstruct the venting system, consi der an offse t (see Figure 19) to avoid cut - ting loa ...

  • Desa (V)T32EN SERIES - page 15

    www .desatech.com 1 1 1987-01D 15 Figure 20 - Installing Firestop If area above is a living space, install restop below framed hole. If area above is an attic or insulated area, install restop above framed hole. 7. T wist-lock the vent cap onto the last section of vent pipe. Note : If the vent pipe passe s throu gh any occupie d areas above t ...

  • Desa (V)T32EN SERIES - page 16

    www .desatech.com 1 1 1987-01D 16 VENTING INST ALLA TION INSTRUCTIONS Continued Note : Install restrictor into inner collar of replace as shown.    V ertical (V 1   5' min. 6' max. 6' min. 12' max. 7&a ...

  • Desa (V)T32EN SERIES - page 17

    www .desatech.com 1 1 1987-01D 17   AND COMPONENTS   P47-6 6" Section Coaxial Pipe, Galvanized P47-12 12" Section Coaxial Pipe, Galvanized P47-24 24" Section Coaxial Pipe, Galvanized P47-36 36" S ...

  • Desa (V)T32EN SERIES - page 18

    www .desatech.com 1 1 1987-01D 18 FIREPLACE INST ALLA TION  Use proper gas type for replace unit you are installing. If your gas supply is not correct, do not install replace. See retailer where you purchased the replace for proper replace according to your gas type or to purchase gas conversion ...

  • Desa (V)T32EN SERIES - page 19

    www .desatech.com 1 1 1987-01D 19 FIREPLACE INST ALLA TION Continued Figure 28 - Location of Wiring Diagram Decal (Model May V ary from Illustration) Wiring Diagram Decal 12" in Front of Burner 9. Check to make sure power cord is completely clear of blower wheel and there are no other foreign objects in blower wheel. Turn blower on and check f ...

  • Desa (V)T32EN SERIES - page 20

    www .desatech.com 1 1 1987-01D 20 1 1. Peel off backing paper and stick supplied wiring diagram decal on rebox bottom ap - proxima tely 12" in front of blower (see Figure 28, page 19).       ? ...

  • Desa (V)T32EN SERIES - page 21

    www .desatech.com 1 1 1987-01D 21 FIREPLACE INST ALLA TION Continued Figure 32 - Gas Connection CSA Design-Certied Equipment Shutoff V alve with 1/8" NPT T ap* 3" Minimum Approved Flexible Gas Line Cap Pipe Nipple T ee Joint Sediment T rap/Drip Leg Natural - From Gas Meter (5.5" W .C. to 10.5" W .C. Pressure) * The CSA design ...

  • Desa (V)T32EN SERIES - page 22

    www .desatech.com 1 1 1987-01D 22 PRESSURE TESTING GAS SUPPL Y PIPING SYSTEM T est Pressures In Excess Of 1/2 PSIG  1. Dis conne ct rep lac e and i ts indiv idual equ ip - ment shutoff valve from gas supply piping sy st em . Pr es su res in exc es s of 1/ 2 ps ig (3. 5 kPa ) wil l dam age  repla ce ga s reg ul ato r ...

  • Desa (V)T32EN SERIES - page 23

    www .desatech.com 1 1 1987-01D 23 REMOVING/REPLACING GLASS DOOR                   ? ...

  • Desa (V)T32EN SERIES - page 24

    www .desatech.com 1 1 1987-01D 24         -  ...

  • Desa (V)T32EN SERIES - page 25

    www .desatech.com 1 1 1987-01D 25 4. Place log #4 (right log) onto pin on right side of front log as shown in Figure 44. 5. Pl ace lo g #5 (base log) onto front left part of grate making sure notches t over prongs of grate. See Figure 45. 6. Place log #6 (left log) onto two pins on left side of back and front log. See Figure 45. 7. Pla ce lava r ...

  • Desa (V)T32EN SERIES - page 26

    www .desatech.com 1 1 1987-01D 26 FIREPLACE INST ALLA TION Continued Ember Material Figure 46 - Placing Ember Material on Burner 8. Pull ember material apart into pieces no larg er than a dime. Place these pieces loosely and spa rin gl y dir ec tly o nto e xp ose d sec ti on of front burner and along space between burner and grate prongs (see Figur ...

  • Desa (V)T32EN SERIES - page 27

    www .desatech.com 1 1 1987-01D 27 STEP DOWN TRANSFORMER PV GND PV/MV TR MV TH IGN EV2 INCOMING MAIN GAS SUPPL Y EV1 GAS LINE TO BURNER 24V AC 120V AC INCOMING 120V AC (FUSE BOX OR BREAKER) OFF ON WALL SWITCH (NOT SUPPLIED) GREEN BLACK WHITE 120v , 60Hz, 0.7A ELECTRICAL RA TING: BLACK WHITE GREEN OPTIONAL REMOTE CONTROL Pilot Burner Pilot Gas Line W ...

  • Desa (V)T32EN SERIES - page 28

    www .desatech.com 1 1 1987-01D 28 5. T u rn eq ui pme nt shu to ff val ve clo ck wis e to the OFF position (see Figure 49). Do not force. 6. W ait ve (5) minutes to clear out any gas. Then smell for gas, including near the oor . Ifyousmell gas,STOP!Follow“B” int ...

  • Desa (V)T32EN SERIES - page 29

    www .desatech.com 1 1 1987-01D 29 OPERA TING FIREPLACE Continued TO TURN OFF GAS TO APPLIANCE 1. T urn off the wall switch. 2. T urn off all electric power to the appliance if service is to be performed. 3. Open lower louver panel. 4. T u rn eq ui pme nt shu to ff val ve clo ck wis e to OFF . Do not force. 5. Close lower louver panel. OPTIONAL REMO ...

  • Desa (V)T32EN SERIES - page 30

    www .desatech.com 1 1 1987-01D 30 CLEANING AND MAINTENANCE                 ...

  • Desa (V)T32EN SERIES - page 31

    www .desatech.com 1 1 1987-01D 31 TROUBLESHOO TING       ...

  • Desa (V)T32EN SERIES - page 32

    www .desatech.com 1 1 1987-01D 32  Pilot will not stay lit No gas to burner, although wall switch and valve are set to the ON position Frequent pilot outage Fire plac e produc es a cl icki ng/t ick - ing noise just after burner is lit or shut off Slight smoke or odor during initi al operation Gas odor ...

  • Desa (V)T32EN SERIES - page 33

    www .desatech.com 1 1 1987-01D 33  Glass soots Remote does not function Dark residue on logs or inside of replace  1. Flame impingement on logs 2 . Debris around burner air mixer 1. Battery is not installed. Bat - tery power is low 1. Improper log placement ...

  • Desa (V)T32EN SERIES - page 34

    www .desatech.com 1 1 1987-01D 34 ILL USTRA TED P ARTS BREAKDOWN    6 7 ...

  • Desa (V)T32EN SERIES - page 35

    www .desatech.com 1 1 1987-01D 35 P ARTS LIST This list contains replaceable parts used in your replace. When ordering parts, follow the instructions listed under Replacement Parts on page 38 of this manual.     DESCRIPTION     ? ...

  • Desa (V)T32EN SERIES - page 36

    www .desatech.com 1 1 1987-01D 36 ILL USTRA TED P ARTS BREAKDOWN     ? ...

  • Desa (V)T32EN SERIES - page 37

    www .desatech.com 1 1 1987-01D 37 P ARTS LIST This list contains replaceable parts used in your replace. When ordering parts, follow the instructions listed under Replacement Parts on page 38 of this manual.     DESCRIPTION   1 1 1 102 Screw #8-32 x 3/8 PPH Zinc 2 2 1 1 105 Screw #10 x 1/2 ...

  • Desa (V)T32EN SERIES - page 38

    www .desatech.com 1 1 1987-01D 38 REPLACEMENT P ARTS Note: Use only original replacement parts. This will protect your warranty coverage for parts replaced under warranty . P ARTS UNDER W ARRANTY Contact authorized retailers of this product. If they can not supply original replacement part(s), call DESA ’ s Customer Service Department at 1-866-67 ...

  • Desa (V)T32EN SERIES - page 39

    www .desatech.com 1 1 1987-01D 39 ACCESSORIES NOTICE: All accessories may     Pu rch ase th ese rep lace acce ss or ies from your loca l reta iler . If they ca n not sup ply the se acc esso ries , call DESA ’ s Sale s Depa ...

  • Desa (V)T32EN SERIES - page 40

    2701 Industrial Drive P .O. Box 90004 Bowling Green, KY 42102-9004 www .desatech.com NOT A UPC 1 1 1987-01 Rev . D 03/06 WARRANTY INFORMA TION KEEP THIS WARRANTY Model Serial No. Date Purchased Always specify model and serial numbers when communicating with the factory . W e reserve the right to amend these specications at any time without notic ...

Manufacturer Desa Category Indoor Fireplace

Documents that we receive from a manufacturer of a Desa (V)T32EN SERIES can be divided into several groups. They are, among others:
- Desa technical drawings
- (V)T32EN SERIES manuals
- Desa product data sheets
- information booklets
- or energy labels Desa (V)T32EN SERIES
All of them are important, but the most important information from the point of view of use of the device are in the user manual Desa (V)T32EN SERIES.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Desa (V)T32EN SERIES, service manual, brief instructions and user manuals Desa (V)T32EN SERIES. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Desa (V)T32EN SERIES.

Similar manuals

A complete manual for the device Desa (V)T32EN SERIES, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Desa (V)T32EN SERIES by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Desa (V)T32EN SERIES.

A complete Desa manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Desa (V)T32EN SERIES - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Desa (V)T32EN SERIES, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Desa (V)T32EN SERIES, that we can find in the current document
3. Tips how to use the basic functions of the device Desa (V)T32EN SERIES - which should help us in our first steps of using Desa (V)T32EN SERIES
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Desa (V)T32EN SERIES
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Desa (V)T32EN SERIES in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Desa (V)T32EN SERIES?

Use the form below

If you did not solve your problem by using a manual Desa (V)T32EN SERIES, ask a question using the form below. If a user had a similar problem with Desa (V)T32EN SERIES it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)