English dropdown-ico

Manual Desa BHDV34PA

38 pages 1.07 mb
Download

Go to site of 38

Summary
  • Desa BHDV34PA - page 1

    DIRECT -VENT FIREPLACE ® OWNER’S OPERA TION AND INST ALLA TION MANUAL NA TURAL GAS MODEL BHDV34NA PROP ANE/LP GAS MODEL BHDV34P A Save this manual for future reference. FOR YOUR SAFETY WHAT TO DO IF YOU SMELL GAS • Do not try to light any appliance. • Do not touch any electrical switch • Do not use any phone in your building. • Immediate ...

  • Desa BHDV34PA - page 2

    2 105981 DIRECT -VENT FIREPLACE (NA TURAL/PROP ANE/ L P ) ® BHDV34NA, P A SAFETY INFORMA TION 1. This appliance is only for use with the type of gas indicated on the rating plate. This appliance is not con vertible for use with other gases unless a certif ied kit is used. 2. For propane/LP fireplace, do not place propane/LP supply tank(s) inside a ...

  • Desa BHDV34PA - page 3

    3 105981 OWNER’S MANUAL PRODUCT IDENTIFICA TION Install and use fireplace with care. Follow all local codes. In the absence to local codes, use the current National Fuel Gas Code ANS Z223.1 , also known as NFPA 54* (USA) or the current CAN/CGA-B149[.1 or .2] Installation Codes (Canada) . *Available from: American National Standards Institute, Inc ...

  • Desa BHDV34PA - page 4

    4 105981 DIRECT -VENT FIREPLACE (NA TURAL/PROP ANE/ L P ) ® BHDV34NA, P A Fireplace size D x FW x RW 34" 18 1 / 2 " 34 3 / 8 " 14" PRE-INST ALLA TION PREP ARA TION LOCATION AND SPACE REQUIREMENTS Determine the safest and most efficient loca- tion for your Vanguard direct-vent fireplace. Make sure that rafters and wall studs are ...

  • Desa BHDV34PA - page 5

    5 105981 OWNER’S MANUAL 29" 13" 12 5 / 8 " 34 3 / 8 " 35 1 / 16 " 58" 9 1 / 4 " 41" Nailing T abs PRE-INST ALLA TION PREP ARA TION Continued Figure 6 - Framing Clearances for Corner Installation LOCATION OF VENT TERMINATION When locating vent termination, it is impor- tant to observe the minimum clearances ...

  • Desa BHDV34PA - page 6

    6 105981 DIRECT -VENT FIREPLACE (NA TURAL/PROP ANE/ L P ) ® BHDV34NA, P A Fixed Closed Openable Fixed Closed Openable V V V V V V V V X X V X G G J F B B K N H I A N E L D B M A C B V V A G G B TERMINA TION CAP AIR SUPPL Y INLET GAS METER RESTRICTED AREA (TERMINA TION PROHIBITED) A = clearance above grade, veranda, porch, deck, or balcony [*12 inc ...

  • Desa BHDV34PA - page 7

    7 105981 OWNER’S MANUAL WARNING: Read all instruc- tions completely and thoroughly before attempting installation. Failure to do so could result in serious injury, property damage or loss of life. Operation of im- properly installed and maintained venting system could result in serious injury, property damage or loss of life. WARNING: Seal all ve ...

  • Desa BHDV34PA - page 8

    8 105981 DIRECT -VENT FIREPLACE (NA TURAL/PROP ANE/ L P ) ® BHDV34NA, P A INSTALLATION FOR HORIZONTAL TERMINATION 1. Determine the route your horizontal venting will tak e. Note: The location of the horizontal vent termination on the exterior w all must meet all local and national building codes and must not be easily blocked or obstructed. Snorke ...

  • Desa BHDV34PA - page 9

    9 105981 OWNER’S MANUAL UP UP VENTING INST ALLA TION Continued (Framing Detail) 10" (254mm) 10" (254mm) 7 1 / 2 " (190mm) V ent Opening Combustible W all V ent Opening Noncombustible W all Figure 12 - Vent Opening Requirements Continued 3. Attach v ent pipe assembly to the fire- place. Set fireplace in front of it’ s per- manent ...

  • Desa BHDV34PA - page 10

    10 105981 DIRECT -VENT FIREPLACE (NA TURAL/PROP ANE/ L P ) ® BHDV34NA, P A VENTING INST ALLA TION Continued UP UP Horizontal V enting V ertical (V) Horizontal (H) 37" min. 10" max. Figure 16 - Horizontal Termination Con- figuration for Rigid Venting Figure 17 - Horizontal Termination Configuration for Rigid Venting Using One 90 ° Elbow ...

  • Desa BHDV34PA - page 11

    11 105981 OWNER’S MANUAL VENTING INST ALLA TION Continued UP V enting with Tw o 90 ° Elbo ws V ertical (V) Horizontal (H 1 ) Horizontal (H 1 ) + Horizontal (H 2 ) 5' min. 2' max. 6' max. 6' min. 4' max. 12' max. 7' min. 6' max. 18' max. 8' min. 8' min. 20' max. 20' max. 8' max ...

  • Desa BHDV34PA - page 12

    12 105981 DIRECT -VENT FIREPLACE (NA TURAL/PROP ANE/ L P ) ® BHDV34NA, P A 4. Connect a section of pipe and extend up through the hole. Note: If an offset is needed to a v oid obstructions, you must support the vent pipe e very 3 feet. Use wall straps for this purpose (see Figure 21). Whenev er possible, use 45 ° elbows instead of 90 ° elbo ws. ...

  • Desa BHDV34PA - page 13

    13 105981 OWNER’S MANUAL VENTING INST ALLA TION Continued Continued Figure 23 - Cathedral Ceiling Support Box Installation Non-hardening Mastic under all edges of support box before nailing Figure 24 - Installed Cathedral Ceiling Support Box Vertical Termination Configurations Figures 25 through 28 show four different configurations for vertical ...

  • Desa BHDV34PA - page 14

    14 105981 DIRECT -VENT FIREPLACE (NA TURAL/PROP ANE/ L P ) ® BHDV34NA, P A V er tical V enting V = 40' max. Figure 28 - Vertical Rigid Venting Con- figuration With No Horizontal Run VENTING INST ALLA TION Continued V enting with Tw o 9 0 ° E lbows V ertical (V 1 ) Horizontal (H) 5' min. 6' max. 6' min. 12' max. 7' mi ...

  • Desa BHDV34PA - page 15

    15 105981 OWNER’S MANUAL VENTING INST ALLA TION Continued HIGH ALTITUDE INSTALLATION Your Vanguard direct-vent fireplace has been AGA tested and approved for eleva- tions from 0-2000 feet and CGA certified for elevations from 0-4500 feet. When installing this fireplace at an elevation above 2000 feet (in the USA), you may need to decrease the inp ...

  • Desa BHDV34PA - page 16

    16 105981 DIRECT -VENT FIREPLACE (NA TURAL/PROP ANE/ L P ) ® BHDV34NA, P A INSTALLING OPTIONAL BLOWER ACCESSORY IMPORTANT : For clarity, gas valve assem- bly and grate/burner assembly are not shown in Figures 30 through 33 , page 17. They will, however, be in your fireplace when you are installing the blower. Also for clarity the firebox is shown ...

  • Desa BHDV34PA - page 17

    17 105981 OWNER’S MANUAL FIREPLACE INST ALLA TION Continued WARNING: Never touch the blower wheel while in operation. 10 . Peel off the backing pa per and stick the supplied wiring diagram decal on the fir ebox bottom approximately 3" to the right of the blow er speed control bracket (see Figure 33). WARNING: Failure to position the parts in ...

  • Desa BHDV34PA - page 18

    18 105981 DIRECT -VENT FIREPLACE (NA TURAL/PROP ANE/ L P ) ® BHDV34NA, P A Figure 35 - Gas Connection * The A.G.A. design-certified manual shutoff valve may be supplied with the appliance or you can purchase it from your dealer. CAUTION: Use only new, black iron or steel pipe. Inter- nally-tinned copper tubing may be used in certain areas. Check y ...

  • Desa BHDV34PA - page 19

    19 105981 OWNER’S MANUAL Pressure Testing Gas Supply Piping System Test Pressures In Excess Of 1/2 PSIG (3.5 kPa) 1. Disconnect fireplace and its indi vidual manual shutoff v alve from g as supply piping system. Pressures in excess of 1/2 psig (3.5 kPa) will damage f ireplace gas regulator . 2. Cap of f open end of gas pipe where manual shutof f ...

  • Desa BHDV34PA - page 20

    20 105981 DIRECT -VENT FIREPLACE (NA TURAL/PROP ANE/ L P ) ® BHDV34NA, P A FIREPLACE INST ALLA TION Continued Test Pressures Equal To or Less Than 1/2 PSIG (3.5 kPa) 1. Close manual shutoff v alve (see Fig- ure 37). 2. Pressurize supply piping system by ei- ther opening propane/LP supply tank valv e for propane/LP gas fireplace or opening main gas ...

  • Desa BHDV34PA - page 21

    21 105981 OWNER’S MANUAL t W R FIREPLACE INST ALLA TION Continued Continued INSTALLING OPTIONAL WALL MOUNTED THERMOSTAT - GWMT1 WARNING: Installation must be done by a qualified installer familiar with low voltage wiring procedures. WARNING: Do not connect this thermostat to any electrical source! Electrical shock and/or fire hazard will occur. 1 ...

  • Desa BHDV34PA - page 22

    22 105981 DIRECT -VENT FIREPLACE (NA TURAL/PROP ANE/ L P ) ® BHDV34NA, P A REMOVING/REPLACING GLASS DOOR CAUTION: Do not operate this fireplace with a broken glass door panel or without the glass door panel securely in place. For re- placement part information see Replacement Parts , page 32. 1. Remov e the upper louver panel by lift- ing upward a ...

  • Desa BHDV34PA - page 23

    23 105981 OWNER’S MANUAL INSTALLING OPTIONAL BRICK LINER D8037A WARNING: If fireplace has been running, turn off and un- plug fireplace. Let cool before installing brick liner. This brick liner kit is optional. You may purchase brick liner from your local dealer or see Accessories , pages 34 and 35. CAUTION: Always handle brick panels with two ha ...

  • Desa BHDV34PA - page 24

    24 105981 DIRECT -VENT FIREPLACE (NA TURAL/PROP ANE/ L P ) ® BHDV34NA, P A 1 2 3 4 6. Pull ember material apart into pieces no larger than a dime. Place these pieces loosely and sparingly directly onto the exposed section of the front bur ner and along the space betw een the burner and gra te prongs (see Figure 54). This will create the glo wing e ...

  • Desa BHDV34PA - page 25

    25 105981 OWNER’S MANUAL O F F P I L O T O N L O I H OPERA TING FIREPLACE WARNING: If you do not fol- low these instructions exactly, a fire or explosion may result caus- ing property damage, personal injury or loss of life. A. This appliance has a pilot which must be lighted by hand. When lighting the pilot, follo w these instructions exactl y . ...

  • Desa BHDV34PA - page 26

    26 105981 DIRECT -VENT FIREPLACE (NA TURAL/PROP ANE/ L P ) ® BHDV34NA, P A 1. After lighting, let pilot flame burn f or about one minute. T urn gas contr ol knob on the control v alve to ON posi- tion. T urn va r ia b l e control knob any- where between HI and LO. Slide the selector switch to the REMO TE posi- tion. Note: The burners may light if ...

  • Desa BHDV34PA - page 27

    27 105981 OWNER’S MANUAL INSPECTING BURNERS Check pilot flame pattern and burner flame patterns often. PILOT ASSEMBLY The pilot assembly is factory preset for the proper flame height. Alterations may have occurred during shipping and handling. Call a qualified service person to readjust the pilot if necessary. The height of the thermopile must be ...

  • Desa BHDV34PA - page 28

    28 105981 DIRECT -VENT FIREPLACE (NA TURAL/PROP ANE/ L P ) ® BHDV34NA, P A PILOT AND BURNERS • Remo ve ember material before cleaning burners and r eplace when cleaning is complete. • Burner and controls should be cleaned with compressed air to remov e dust, dirt, or lint. • Use a vacuum cleaner or small, soft bristled brush to remov e exces ...

  • Desa BHDV34PA - page 29

    29 105981 OWNER’S MANUAL TROUBLESHOOTING Note: All troubleshooting items are listed in order of operation. WARNING: Turn off heater and let cool before servicing. Only a qualified service person should service and repair heater. CAUTION: Never use a wire, needle, or similar object to clean pilot. This can damage pilot unit. POSSIBLE CAUSE 1. Igni ...

  • Desa BHDV34PA - page 30

    30 105981 DIRECT -VENT FIREPLACE (NA TURAL/PROP ANE/ L P ) ® BHDV34NA, P A OBSERVED PROBLEM Burner does not light after pilot is lit Delayed ignition burner Burner backfiring during combustion Slight smoke or odor during initial operation Heater produces a whistling noise when burner is lit Glass soots Fireplace produces a clicking/ticking noise j ...

  • Desa BHDV34PA - page 31

    31 105981 OWNER’S MANUAL WARNING: If you smell gas • Shut off gas supply. • Do not try to light any appliance. • Do not touch any electrical switch; do not use any phone in your building. • Immediately call your gas supplier from a neighbor’s phone. Follow the gas supplier’s instructions. • If you cannot reach your gas supplier, cal ...

  • Desa BHDV34PA - page 32

    32 105981 DIRECT -VENT FIREPLACE (NA TURAL/PROP ANE/ L P ) ® BHDV34NA, P A SER VICE HINTS When Gas Pressure Is Too Low • pilot will not stay lit • b urners will have delay ed ignition • f ireplace will not produce specif ied heat • propane/LP gas supply might be lo w (propane/LP units only) When Gas Quality Is Bad • pilot will not stay l ...

  • Desa BHDV34PA - page 33

    33 105981 OWNER’S MANUAL SPECIFICA TIONS BHDV34NA BHDV34PA 17,000/24,000 Btu/hr 17,000/22,000 Btu/hr Gas Type Natural Propane/LP Ignition Piezo Piezo Manifold Pressure 3.5" w.c. 10.0" w.c. Minimum Inlet Supply Pressure 4.5" w.c. 11.0" w.c. Thermal Efficiency 70% 70% Dimension, Inches/mm (HxWxD) Fireplace (Actual size of firebo ...

  • Desa BHDV34PA - page 34

    34 105981 DIRECT -VENT FIREPLACE (NA TURAL/PROP ANE/ L P ) ® BHDV34NA, P A ACCESSORIES Purchase these fireplace accessories from your local dealer. If they can not supply these accessories, call DESA International’s Sales Department at 1-800-432-2382 for information. You can also write to the ad- dress listed on the back page of this manual. CAB ...

  • Desa BHDV34PA - page 35

    35 105981 OWNER’S MANUAL MANUAL BLOWER KIT GA3700 Manual-variable control blower accessory for both the HDV and BHDV Series fireplaces. THERMOSTATICALLY- CONTROLLED BLOWER KIT DA3610T Provides better heat distribution. Blower turns off and on automatically, as needed. Complete installation and operation instruc- tions included in this manual. ACC ...

  • Desa BHDV34PA - page 36

    36 105981 DIRECT -VENT FIREPLACE (NA TURAL/PROP ANE/ L P ) ® BHDV34NA, P A ILLUSTRA TED PA R T S BREAKDOWN BHDV34NA BHDV34PA 48 1 2 3 4 6 6 36 5 5 6 5 1 1 (Included in Hardware Pack) 7 7 8 10 9 12 13 14 15 16 17 18 19 20 32 21 22 23 24 25 26 27 28 28 29 30 31-1 31-4 31-2 31-3 33 32 32 34 35 40 37 38 41 39 44 42 43 6 46 45 47 ...

  • Desa BHDV34PA - page 37

    37 105981 OWNER’S MANUAL P ARTS LIST DIRECT-VENT FIREPLACE BHDV34NA BHDV34PA This list contains replaceable parts used in your fireplace. When ordering parts, follow the instructions listed under Replacement Parts on page 32 of this manual. KEY NO. PART NUMBER DESCRIPTION QTY. 1 104445-01 Top Outer Casing 1 2 105278-01 Outer Casing 1 3 105297-01 ...

  • Desa BHDV34PA - page 38

    LIMITED WARRANTY DIRECT-VENT FIREPLACE DESA International warrants this product to be free from defects in materials and components for four (4) years from the date of first purchase, provided that the product has been properly installed, operated and maintained in accordance with all applicable instructions. To make a claim under this warranty the ...

Manufacturer Desa Category Indoor Fireplace

Documents that we receive from a manufacturer of a Desa BHDV34PA can be divided into several groups. They are, among others:
- Desa technical drawings
- BHDV34PA manuals
- Desa product data sheets
- information booklets
- or energy labels Desa BHDV34PA
All of them are important, but the most important information from the point of view of use of the device are in the user manual Desa BHDV34PA.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Desa BHDV34PA, service manual, brief instructions and user manuals Desa BHDV34PA. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Desa BHDV34PA.

Similar manuals

A complete manual for the device Desa BHDV34PA, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Desa BHDV34PA by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Desa BHDV34PA.

A complete Desa manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Desa BHDV34PA - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Desa BHDV34PA, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Desa BHDV34PA, that we can find in the current document
3. Tips how to use the basic functions of the device Desa BHDV34PA - which should help us in our first steps of using Desa BHDV34PA
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Desa BHDV34PA
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Desa BHDV34PA in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Desa BHDV34PA?

Use the form below

If you did not solve your problem by using a manual Desa BHDV34PA, ask a question using the form below. If a user had a similar problem with Desa BHDV34PA it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)