English dropdown-ico

Manual Hunter Fan PH20-30A

26 pages 0.44 mb
Download

Go to site of 26

Summary
  • Hunter Fan PH20-30A - page 1

         Propane Heater 20,000 BTU/HR Model PH20-30A With Automatic Gas Ignition Control Installation  Operation  Service ...

  • Hunter Fan PH20-30A - page 2

      EXHAUST GASES Do not operate heater in an enclosed area unless the exhaust gases are piped outside. Exhaust gases may contain carbon monoxide, a colorless and poisonous gas.   FUEL USE This heater is designed for use w ith propane (LP gas) only . Do not attempt to use gasoline as fuel since fire or ...

  • Hunter Fan PH20-30A - page 3

          Section One ____________________________________________________________ 3 Introduction and Descr iption __________________________________________________ 3 Descri ption _______________________________________________________________________ 3 Section Two ____________________________________ ...

  • Hunter Fan PH20-30A - page 4

         This manual contains installation, operation, maintenance, and repair instruct ions for Model PH-20-30A Heaters manufactured by Hunter Manufacturing Company, Solon, Ohio.   The Falconaire PH20-30 ...

  • Hunter Fan PH20-30A - page 5

               1. Inspect the heater for damage that may hav e occurred during shipment. Check against the packing list or invoice for lost part s. 2. Inspect the contr ...

  • Hunter Fan PH20-30A - page 6

    LOCATION AND MOUNTING (cont .) 1. Mount the heater ho rizontally, as shown in figure 4. Choose a m ounting location that will enable mounting the heater on a level surface, with adequate room around the heater for removal and service. Check tha t the tilt switch is upright. Refer to figure 6 for mounting dimensions and clearances. 2. After selectin ...

  • Hunter Fan PH20-30A - page 7

    #    $ %   $%    ...

  • Hunter Fan PH20-30A - page 8

    &' %  $ %  #     ...

  • Hunter Fan PH20-30A - page 9

    (! " %  )*" )+    #  ...

  • Hunter Fan PH20-30A - page 10

       1. Locate and moun t the propane tank (gas bottle) aw ay f rom the engine and heater exhaust ports. The location should also p r otect the tank from accidental mechanical damage. 2. The propane tan k must be a gas bo ttle designed or modi fied for vapor takeoff only. Install POL (put on left) conne ...

  • Hunter Fan PH20-30A - page 11

       1. Refer to the wiring diagram in figure 7, locate the pow er and ground connections on your heater. The ground terminal is located one inch to the le f t of the f uel inlet. Connect this terminal to a good, clean chassis ground, using the wire size listed in Table 1. 2. Refer to ...

  • Hunter Fan PH20-30A - page 12

    (f igur e 7 ) Symbol Descript ion B1 Blower M otor ECM Electronic Co ntrol Module E1 Igniter L1 Solenoid Valve LED1 L.E.D. Assembly PS1 Pressure Sw itch S1 Tilt Switch S2 Over heat Thermos tat S3 Room Ther mostat (opti onal) S4 Comfort Control Thermo. SW1 Main Sw itch TB Termi nal Block LT1 External Diagnostic Lig ht (optional) ...

  • Hunter Fan PH20-30A - page 13

     '        Comfort Control Assembly Con trols an d In dic ato rs (figure 5) Table 2. Control and I ndicator Functions Name Function Main Switch Simple on/off sw itch. Move to ON for heater to run.  Note: Green l ...

  • Hunter Fan PH20-30A - page 14

    '+ The Falco naire PH 20-30A is a M icroprocessor Base d Direct S park Ignition, the rmostatically controlle d heater. The cont rol utilizes a microp rocessor to continu ally and safely monitor, anal yz e and control the pro per operation of the gas burner. Value added featur es such as c ombu ...

  • Hunter Fan PH20-30A - page 15

    " Cab or Cre w A rea 1. Flip Main switch to ON 2. Rota te Co mfort Control knob approximately 75% of full travel clock w ise. 3. W he n temperature in t he heated area is satisfactory rotate Comfo rt Control k n o b counter clock wise until a "click" is felt in t he knob. Now the cabin t emperature is set. The Co ...

  • Hunter Fan PH20-30A - page 16

        )( ##   The PH20-30A has built in diagnostic capabilities. W hen the microprocessor-based control detects a fault, it displays an error code by flashing t he red LED. To clear an error co de , tur ...

  • Hunter Fan PH20-30A - page 17

    '" The diagnostic features of the ECS w ill cover most problems that you may have with your heater. Table 5 Troubleshooting chart addresses some other problems that may arise TA BLE 5. T ROUBLE SH OOTIN G CHA RT Trouble Cause and/or Remedy Heater fails to start - motor does not run, green light is no ...

  • Hunter Fan PH20-30A - page 18

    !  ,  * The follow ing service p rocedures, if performed as indicated, w ill help ensure prope r operation and extend the li f e of your hea ter. Description Daily Weekly Monthly Pre- season Inspect propane tank, regulator, and excess f low val ve ...

  • Hunter Fan PH20-30A - page 19

      *     Genera l This section lists and illustrates the major parts o f your model PH20-30A Hunter heater. In g eneral, attaching parts such as s crews, nuts and loc k washers have not been listed or illustrated since their application is obvious. If a part has not been assigned a part ...

  • Hunter Fan PH20-30A - page 20

     (&' " 1 2 3 4 5 6 7 8 9 10 11 12 1 3 Index # Part # Description 1 49131 Crossbar 2 49196 Covers 3 493151 Top Cover 4 49828 Terminal 5 52712 Panel 6 4347 Over Heat The rmo sta t 7 52618 Case Asse mbly 8 49420 Heat Exchan ger Index # Part # Description 9 50734 Deflector 10 495220 ...

  • Hunter Fan PH20-30A - page 21

    ," ,     +% 1 2 3 4 5 6 7 8 9 10 11 12 13 14 Index # Part # Description 1 52610 Electronic Control Module 2 52610-4 Ignition Cable 3 51964 Terminal Bloc k 4 52611 Pressure Sw itch (not Show n) 5 3629 45 o Flare Fitting 6 5260 ...

  • Hunter Fan PH20-30A - page 22

    ) ! % + 1 2 3 4 5 6 7 8 9 Index # Part # Description 1 10599-07 Inlet Air Duct 2 50875 Cover 3 51567 Combustion Blow er W heel 4 50576 Combustion Blow er Housing 5 49152 Combustion Air Hose 6 50783 Motor Mount 7 49226 M otor (12VDC) 8 49976 Prop Fan 9 49399 M ounting Plate * 5158212 Com ...

  • Hunter Fan PH20-30A - page 23

    %   % (  1 2 Index # Part # Description 1 52944-6 Remote Cable 6ft 2 52621 Comfort Control Asse mbly complete * L.E.D. Circuit * 52623 Thermostat * 52624 Knob * Main Switch * Con trol Harne ss * Part o f 52621 Co mf ort Control ...

  • Hunter Fan PH20-30A - page 24

    &   1 2 2- 1 / 2 " Duct Opening 3 Index # Part # Description 1 52944-10 10 Foot Lon g Remote Cable 52944-20 20 Foot Lon g Remote Cable 2 51643 Thermostat, Calibrated 3 47060 Defroster Kit ( "y" n ot included) ...

  • Hunter Fan PH20-30A - page 25

    %  ' %   Plug Thermostat In Here PH20-30A Heater (rear view ) Calibrated Thermos tat P/N51643 Plug the remote thermostat into the rear of the heater using the spade connectors supplied. Use 20ga w ir e. ...

  • Hunter Fan PH20-30A - page 26

    & "  "'   The Ph20-30A comes w it h a addi tional power lead on the bac k of the Comfort Control to attach a remo te or external dia gnostic light. On some applications, it is necessary to monitor the heater operation from ou t s ...

Manufacturer Hunter Fan Category Thermostat

Documents that we receive from a manufacturer of a Hunter Fan PH20-30A can be divided into several groups. They are, among others:
- Hunter Fan technical drawings
- PH20-30A manuals
- Hunter Fan product data sheets
- information booklets
- or energy labels Hunter Fan PH20-30A
All of them are important, but the most important information from the point of view of use of the device are in the user manual Hunter Fan PH20-30A.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Hunter Fan PH20-30A, service manual, brief instructions and user manuals Hunter Fan PH20-30A. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Hunter Fan PH20-30A.

Similar manuals

A complete manual for the device Hunter Fan PH20-30A, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Hunter Fan PH20-30A by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Hunter Fan PH20-30A.

A complete Hunter Fan manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Hunter Fan PH20-30A - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Hunter Fan PH20-30A, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Hunter Fan PH20-30A, that we can find in the current document
3. Tips how to use the basic functions of the device Hunter Fan PH20-30A - which should help us in our first steps of using Hunter Fan PH20-30A
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Hunter Fan PH20-30A
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Hunter Fan PH20-30A in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Hunter Fan PH20-30A?

Use the form below

If you did not solve your problem by using a manual Hunter Fan PH20-30A, ask a question using the form below. If a user had a similar problem with Hunter Fan PH20-30A it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)