English dropdown-ico

Manual Bock Water heaters 20PP

12 pages 0.19 mb
Download

Go to site of 12

Summary
  • Bock Water heaters 20PP - page 1

    TO THE CONSUMER: Read these and all com- ponent instructions. Please keep for future reference. Please re- member to return the registration card. W aranty , registration card & parts list included. TO THE INST ALLER: Please attach these in- structions next to the w ater heater . BOCK RESIDENTIAL OIL-FIRED W A TER HEA TERS Model numbers: 20e, 2 ...

  • Bock Water heaters 20PP - page 2

    –2– THIS MANUAL HAS BEEN PREP ARED T O ACQUAINT YOU WITH THE INST AL- LA TION, OPERA TION, AND MAINTENANCE OF YOUR W A TER HEA TER AND T O PROVIDE IMPOR T ANT SAFETY INFORMA TION. Read all instructions thoroughly before attempting installation or operation of the water heater . Keep these and all component instructions for future reference. The ...

  • Bock Water heaters 20PP - page 3

    The drain valve fitting may be used as an alternate cold water inlet on heaters equipped with a dip tube, as shown in Figure 3. By plumbing a “T” into the drain fitting, the cold water inlet can be re lo cated to this point. The dip tube must be removed and its fitting plugged. Figure 3 also shows a copper loop heat trap installed on the hot wa ...

  • Bock Water heaters 20PP - page 4

    –4– Inspect the incoming water line for check valves or water pressure reducing v alves. Any type of check valve may cause pressure to build up in the heater and cause tank failure. If the heater is installed in a closed system or if backflow pre- v enters and pressure regulators are installed, add an expansion tank. Do not try to heat hard wat ...

  • Bock Water heaters 20PP - page 5

    –5– PLACE THE W A TER SYSTEM IN OPERA TION Warning: Handhole cover may loosen during shipping – check for tightness before putting heater in operation. For any horizontal run exceeding the maximum length specified in Figure 4, or any lift of more than 10 feet, a booster pump must be used. Booster pumps may b e obtained from Sun T ec Hydraulic ...

  • Bock Water heaters 20PP - page 6

    –6– 5 . While the burner is operating, disconnect one of the yellow cad cell wires. Check to see that the burner control locks out in the time specified on the control. R eattach the wire and reset the control. The burner should restart. Note: Y ou may have to wait a minute before resetting the control. 6. The thermostat is factory set at 120° ...

  • Bock Water heaters 20PP - page 7

    –7– SERVICE 1. Check the fuel supply , electrical wiring and fuses, and make sure temperature c ontrol is calling for heat. 2. If the motor runs but there is no flame, remove the electrode assembly , clean, readjust to the burner manufacturer ’s specifications, check the electrode porce- lain for cracks and replace if necessary . Check the tr ...

  • Bock Water heaters 20PP - page 8

    L4080B L4006A FIGURE 8 : Honeywell L4006A w/ L8080B For Models: 50, 120E FIGURE 6 : Beckett or Wayne burner w/ Carlin EZ-T emp F or Models: 32, 33, 40, 50, 51, 71, 120E FIGURE 7 : Honeywell L4103A-1 142 For Models: 32, 33, 40, 51, 71E FIGURE 7 NOTES: Set point 120 ° FIGURE 4 NOTES: High limit: 190 ° Aquastat: 120° set point 15 ° dif ferential ? ...

  • Bock Water heaters 20PP - page 9

    –9– ITEM DESCRIPTION 1. Cold W ater Inlet Dip T ube (N/A 33E & 40E) 2. Plastic Cap 3. Magnesium Anode Rod (aluminum avaliable) 4. Name Plate/Rating Label 6. Immersion W ell & Aquastat 8. Drain V alve 9. Mounting Bracket Gasket 10. Burner Mounting Bracket (part of jacket assembly on Models 20e, 32E through 51 Series; sold separately on 7 ...

  • Bock Water heaters 20PP - page 10

    – 10 – LIMITED W ARRANTY This warranty covers “Bock” W ater Heater models 20e, 20pp, 32E, 32EC, 32PP , 32PPC, 33E, 33PP , 40E, 40PP , 50ES, 50ESC, 51E, 51EC, 51PP , 51PPC, 71E and 120E. Bock W ater Heaters, Inc., a division of Bock Corporation–a Wisconsin corporation–at 1 10 South Dickinson Street, Madison, WI 53703 (“Company”), war ...

  • Bock Water heaters 20PP - page 11

    – 11 – BOCK BURNER MODEL/ MAX MODEL MAX MODEL (OIL) MFR. OEM # INPUT OEM # INPUT 32E, 32EC, 33E W A YNE MSR/371-001B 0.75 X 80A 32PP , 32PPC W A YNE HS/371-009HS 0.75 X 80A 40E W A YNE MSR/371-030B 0.90 X 70A 5IE, 51EC W A YNE MSR/371-003B 1.10 X 80A 50ES, 120E W A YNE MSR/371-029B 1.10 X 80A 51PP , 51PPC W A YNE HS/371-01 1HS 1.10 X 80A 71E W ...

  • Bock Water heaters 20PP - page 12

    – 12 – Bock W ater Heaters, Inc. 1 10 South Dickinson Street • P .O. Box 8632 • Madison, WI 53708-8632 Phone: 608/257-2225 • Fax: 608/257-5304 • www .bockwaterheaters.com Form 23420 Rev 4 3/2007 ...

Manufacturer Bock Water heaters Category Water Heater

Documents that we receive from a manufacturer of a Bock Water heaters 20PP can be divided into several groups. They are, among others:
- Bock Water heaters technical drawings
- 20PP manuals
- Bock Water heaters product data sheets
- information booklets
- or energy labels Bock Water heaters 20PP
All of them are important, but the most important information from the point of view of use of the device are in the user manual Bock Water heaters 20PP.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Bock Water heaters 20PP, service manual, brief instructions and user manuals Bock Water heaters 20PP. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Bock Water heaters 20PP.

Similar manuals

A complete manual for the device Bock Water heaters 20PP, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Bock Water heaters 20PP by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Bock Water heaters 20PP.

A complete Bock Water heaters manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Bock Water heaters 20PP - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Bock Water heaters 20PP, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Bock Water heaters 20PP, that we can find in the current document
3. Tips how to use the basic functions of the device Bock Water heaters 20PP - which should help us in our first steps of using Bock Water heaters 20PP
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Bock Water heaters 20PP
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Bock Water heaters 20PP in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Bock Water heaters 20PP?

Use the form below

If you did not solve your problem by using a manual Bock Water heaters 20PP, ask a question using the form below. If a user had a similar problem with Bock Water heaters 20PP it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)