-
Invacare HF2E540M9 - page 1
Dealer: This manual MUST be given to the end user. User: Before using this cylinder, read this manual and save for future reference. For more information regarding Invacare products, parts, and services, please visit www.invacare.com Operator’s Manual HomeFill ® Cylinder Oxygen 540 Valve HF2E540M9 “Caution: Federal law restricts ? ...
-
Invacare HF2E540M9 - page 2
HomeFill ® Cylinder 2 Part No 116315 6 WARNING DO NOT USE THIS PRODUCT OR ANY AVAILABLE OPTIONAL EQUIPMENT WITHOUT FIRST COMPLETELY READING AND UN DERSTANDING THESE INSTRUCTIONS AND ANY ADDITIONAL INSTRUCTIONAL MATERIAL SUCH AS OWNER’S MANUALS, SERVICE MANUALS OR INSTRUCTION SHEETS SUPPLIED WITH THIS PRODUCT OR OPTIONAL EQUIPMENT. IF YOU ARE ...
-
Invacare HF2E540M9 - page 3
TABLE OF CONTENTS Part No 1163156 3 HomeFill ® Cylinder TABLE OF CONTENTS SPECIAL NOTES ............................................... 4 RECEIVING INSPECTION .................................. 4 INTENDED USE ................................................ 4 SECTION 1—GENERAL GUIDELINES .................. 5 SECTION 2—FEATURES ................ ...
-
Invacare HF2E540M9 - page 4
SPECIAL NOTES HomeFill ® Cylinder 4 Part No 116315 6 SPECIAL NOTES Signal words are used in this manual and apply to hazards or unsafe practices which could result in personal injury or property damage. Refer to the following table for ? ...
-
Invacare HF2E540M9 - page 5
SECTION 1—GENERAL GUIDELINES Part No 1163156 5 HomeFill ® Cylinder SECTION 1—GENERAL GUIDELINES WARNING SECTION 1 - GENERAL GU IDELINES contains important information for the safe operation and use of this product. DANGER This product is not intended as a life-sustaining or life-supporting device. WARNING Only personnel ins ...
-
Invacare HF2E540M9 - page 6
SECTION 1—GENERAL GUIDELINES HomeFill ® Cylinder 6 Part No 116315 6 WARNING DO NOT attempt to repair product. DO NOT immerse product in any kind of liquid. Store product in a clean area when not in use. Only use an Invacare Cor ...
-
Invacare HF2E540M9 - page 7
SECTION 1—GENERAL GUIDELINES Part No 1163156 7 HomeFill ® Cylinder WARNING NEVER oil or lubricate the cylinder fittings. NEVER use any penetrating oil or lubricant such as WD ‐ 40 or 3 in One. If connection difficulty is experienced ve r ...
-
Invacare HF2E540M9 - page 8
SECTION 2—FEATURES HomeFill ® Cylinder 8 Part No 116315 6 SECTION 2—FEATURES FIGURE 2.1 Product Diagram Cylinder Fill Port Cylinder Valve 540 Connection Port (with Protective Cap) ...
-
Invacare HF2E540M9 - page 9
SECTION 3—TYPICAL PRODUCT PARAMETERS Part No 1163156 9 HomeFill ® Cylinder SECTION 3—TYPICAL PRODUCT PARAMETERS DIMENSIONS : Weight 5.1 lbs (2.31 kg ) Overall Length 13.25 in (33.6 cm) Diameter 4.4 in (11.1 cm) STORAGE CONDITIONS TEMPERATURE: -40°F (-40°C) to 140°F (60°C) MAXIMUM HUMIDIT Y: 95% ...
-
Invacare HF2E540M9 - page 10
SECTION 4—INSPECTION AND COMPRESSOR INTERFACE HomeFill ® Cylinder 10 Part No 1163156 SECTION 4—INSPECTION AND COMPRESSOR INTERFACE NOTE: Refer to the HomeFill ® Compr essor Owner’s Manual for compressor operating instructions. Cylinder Prefill Inspection WARNING All cylinders MUST be inspe ...
-
Invacare HF2E540M9 - page 11
SECTION 4—INSPECTION AN D COMPRESSOR INTERFACE Part No 1163156 11 HomeFil l ® Cylinder External Examination 1. Examine the outside of the cylinder for the following conditions and replace the cylinder if they exist: •D e n t s or dings •A r c burns •O i l or ? ...
-
Invacare HF2E540M9 - page 12
SECTION 4—INSPECTION AND COMPRESSOR INTERFACE HomeFill ® Cylinder 12 Part No 1163156 Checking Cylinder Pressure WARNING NEVER use tools of any kind to conn ect/disconnect the cylinder and the compressor. Otherwise, severe injury and/or damage may occur. DO NOT drop oxygen cylind ers. Use two hands when handling/transporting oxygen cylinders. ...
-
Invacare HF2E540M9 - page 13
SECTION 4—INSPECTION AN D COMPRESSOR INTERFACE Part No 1163156 13 HomeFil l ® Cylinder Filling the Cylinder NOTE: For this procedure, ref e r to FIGURE 4.1 thru FIGURE 4.6. 1. Check the cylinder pressure before attempting to fill cylinder . Refer to Checking ...
-
Invacare HF2E540M9 - page 14
SECTION 4—INSPECTION AND COMPRESSOR INTERFACE HomeFill ® Cylinder 14 Part No 1163156 FIGURE 4.2 Fillport Covers 5. On the compressor unit, momentarily push DOWN on the outer ring (sleev e) of the connector fillport to reset the connector (FIGURE 4.3). Connector F ...
-
Invacare HF2E540M9 - page 15
SECTION 4—INSPECTION AN D COMPRESSOR INTERFACE Part No 1163156 15 HomeFil l ® Cylinder NOTE: If the outer ring (sleeve) is in the UP position (GREEN dots not visible), the connector fillport will not be able to accept the cylinder fillport. ? ...
-
Invacare HF2E540M9 - page 16
SECTION 4—INSPECTION AND COMPRESSOR INTERFACE HomeFill ® Cylinder 16 Part No 1163156 NOTE: Refer to Cylinder Fill Ti m e s on page 20 for the length of time it will take to fill the cylinder . FIGURE 4.4 Connecting the Cylinde r to the Compressor Cylinder Compressor Crad ...
-
Invacare HF2E540M9 - page 17
SECTION 4—INSPECTION AN D COMPRESSOR INTERFACE Part No 1163156 17 HomeFil l ® Cylinder 11. After the cylinder is full, press the compressor pow er switch to the Off (O) position (FIGURE 4.5). 12. Grasp the cylinder assembly (FIGURE 4.5). 13. W ith the oth ...
-
Invacare HF2E540M9 - page 18
SECTION 4—INSPECTION AND COMPRESSOR INTERFACE HomeFill ® Cylinder 18 Part No 1163156 WARNING The fillport cover on the co nnector fillport and the post valve fillport MUST be replaced after filling and whenever not in use. If either of th e fillport covers are missing contact your healthcare provider before using. 17. Place the fillp ...
-
Invacare HF2E540M9 - page 19
SECTION 5—MAINTENANCE Part No 1163156 19 HomeFil l ® Cylinder SECTION 5—MAINTENANCE 1. After each use, cl ean exterior of the product with a dry , lint free cloth only . 2. Store product in a clean area free from grease, oil, and other sourc ...
-
Invacare HF2E540M9 - page 20
SECTION 6—CYLINDER FILL TIMES HomeFill ® Cylinder 20 Part No 1163156 SECTION 6—CYLINDER FILL TIMES NOTE: All filling times are appr oximate and may vary on environmental conditions. * Troubleshooting If post va l ve cylind er fails to function, try the following ? ...
-
Invacare HF2E540M9 - page 21
NOTES Part No 1163156 21 HomeFil l ® Cylinder NOTES ...
-
Invacare HF2E540M9 - page 22
LIMITED WARRANTY HomeFill ® Cylinder 22 Part No 1163156 LIMITED WARRANTY PLEASE NOTE: THE WARRANTY BELOW HAS BEEN DRAFTED TO COMPLY WITH FEDERAL LAW APPLICABLE TO PRODUCTS MANUFACTURED AFTER JULY 4, 1975. This warranty is extended only to the origina l purchaser/user of our products. This warranty gives you specific legal rights and you may al so ...
-
Invacare HF2E540M9 - page 23
LIMITED WARRANTY Part No 1163156 23 HomeFil l ® Cylinder LIMITATIONS AND EXCLUSIONS : THE FOREGOING WARRANTY SHALL NOT APPLY TO SERIAL NUMBERED PRODUCTS IF THE SERIAL NUMBER HAS BE EN REMOVED OR DEFACED; PRODUC TS SUBJECTED TO NEGL IGENCE, ACCIDENT, IMPROPER OPERATION, MAINTENA NCE, OR STORAGE; PRODUCTS MODIFIED WITHOUT INVACARE’S EXPRESS WRITTE ...
-
Invacare HF2E540M9 - page 24
Invacare Corporation www.invacare.co m USA One Invacare Way Elyria, Ohio USA 44036-2125 800-333-6900 Technical Services 800-832-4707 All rights reserved . Trademarks are identified by the symbols ™ and ®. All trademarks are owned by or licensed to Invacare Corporati on or its subsidiaries unless otherwise noted. © 2009 Invacare Corporation Part ...
Do you have a question concerning Invacare HF2E540M9?
Use the form below
If you did not solve your problem by using a manual Invacare HF2E540M9, ask a question using the form below. If a user had a similar problem with Invacare HF2E540M9 it is likely that he will want to share the way to solve it.