English dropdown-ico

Manual Tecumseh OH195SP

32 pages 2.04 mb
Download

Go to site of 32

Summary
  • Tecumseh OH195SP - page 1

    4-Cycle Snow King Engine Operator’s Manual Horizonta l Crankshaf t • Air-Cooled LH195SA/LH195SP LH318SA/LH358SA OH195SA/OH195SP OH318SA/OH358SA Register Y our T ecumseh Engine Maintenance T ips Parts Look-Up S ystem Great T ecumseh Apparel Nearest Authoriz ed T ecumseh S ervicing Dealer Location Visit our w eb site a t w w w .T ecumsehP ower .c ...

  • Tecumseh OH195SP - page 2

    Page ii 4-Cycle • Snow King Engine 181-1275- 14 IMPORT ANT NOTICE! Safety Definitions Statements in this manual preceded by the following wor ds and graphics are o f special significance: Or WARNING indicat es a potent ially hazardous situation which if NOT avoided, could result in death or ser ious injury. NOTE Refers to important in formation a ...

  • Tecumseh OH195SP - page 3

    181-1275-14 4-Cycle • Snow King Engine Page 1 I. General Safety Precautions ! W ARNING A. A void Carbon Monoxide Poisoning All engine exhaust contain s carbon monoxide, a dead ly gas. Breathing carbon monoxide can cause headaches, dizziness, drowsiness, nausea, co nfusion and eventually death. Carbon monoxide is a colorless, odor less, tasteless ...

  • Tecumseh OH195SP - page 4

    Page 2 4-Cycle • Snow King Engin e 181-1275-14 E. DO NOT Modify Engine To avoid serio us injury or death, DO NOT modify engine in any way. Tampering with the governor setting can lead to a runaway engine and cause it to operate at unsa fe speeds. NEVER tamper with factory se tting of engi ne governor. ! W ARNING F . A void Burns and Fi re from Ho ...

  • Tecumseh OH195SP - page 5

    181-1275-14 4-Cycle • Snow King Engine Page 3 II. How to Get Service For engine adjustm ents, repairs or warranty service NOT covered in this manual, co nsult your local Authoriz ed Tecumseh Servicing Deal er, call 1-800- 558-5402, or go to www.Tecumse hPower.co m for addit ional inform ation. A. Engine Identification Decal A sample engine identi ...

  • Tecumseh OH195SP - page 6

    Page 4 4-Cycle • Snow King Engin e 181-1275-14 III. Oil and Fuel S pecifications A. Oil To operate engine you ne ed to use a clean, high quality, detergent oil. Fo r recommended en gine oil, see Table 1. In addition, you need to be sure the oil sump contains the correct amount of oil to operate proper ly. For recommended oil sum p capacity, see T ...

  • Tecumseh OH195SP - page 7

    181-1275-14 4-Cycle • Snow King Engine Page 5 B. Filling Oil Sump I. Oil Fill Cap/Dip stick If your engine has an oil fill cap/ dipstic k go to step 1. If your engine does NOT have an oil f ill cap/dipstick, see "II. Oil Fill Cap/Plug" instru ctions below. 1. Be sure engine is upright and level. 2. Unscrew oil fill cap/ dipstick from oi ...

  • Tecumseh OH195SP - page 8

    Page 6 4-Cycle • Snow King Engin e 181-1275-14 C. Check the Following Items NOTE Be sure equipment is in neutral before attempting to st art (see equipment manufacturer’s instructions). 1. Be sure ig nition switch o n engine or equipment is in “ON”, “RUN” o r “ST ART” position. Se e Figures 10, 11 and 12. Or Ignition key, if present ...

  • Tecumseh OH195SP - page 9

    181-1275-14 4-Cycle • Snow King Engine Page 7 Figure 14. 4-Cycle Sn ow Engine Component s 2 3 7 12 8 6 13 9 10 4 5 2 4 3 7 12 8 6 13 10 1 5 1 3 4 7 12 8 6 13 9 10 2 5 1 9 11 11 OH318SA/OH358SA 1 3 4 8 12 7 6 13 9 10 2 5 OH195SA/OH195SP LH195SA/LH195SP LH318SA/LH358SA ...

  • Tecumseh OH195SP - page 10

    Page 8 4-Cycle • Snow King Engin e 181-1275-14 E. Filling Fuel T ank An adult should fuel this engin e. NEVER allow children to refuel this engine. Gasoline (fuel) vapors are hig hly flammable and can explode . Fuel vapo rs can spre ad and be ig nited by a spark or flame many feet away from engine. To preven t injury or death from fuel fires, fol ...

  • Tecumseh OH195SP - page 11

    181-1275-14 4-Cycle • Snow King Engine Page 9 V . S t arting Y our Engine An adult should start the engine. Only allow children to start engine if an adult has determined they are exp erienced an d capable of such operation. If you are unable to star t this engine after following instru ctions in this manual, contact your Authorized Te cumseh Ser ...

  • Tecumseh OH195SP - page 12

    Page 10 4-Cycle • Snow King Engine 181-1275- 14 A. Engines with El ectric St arters If you have a recoil starter see "B. E ngines with Recoil Starters" instructions on page 13. Some electric starters are equipped with a 120V A.C. Three-Wire Power Cord and Plug designed to opera te on a 120V A.C. household current. It must be properly gr ...

  • Tecumseh OH195SP - page 13

    181-1275-14 4-Cycle • Snow King Engine Page 11 5. Move engine speed control to “FAST” position. See Figures 21 and 22. 6. Set choke control to “FULL CHOKE” position (see equipment manu facturer’s inst ructions). See Figure 24 on page 12. Af terward, continue reading instructio ns below . 7. Hold the primer bulb in fo r one full second e ...

  • Tecumseh OH195SP - page 14

    Page 12 4-Cycle • Snow King Engine 181-1275- 14 Figure 24. Choke Contr ol Positions ST O P STOP ST O P STOP S T OP STOP STOP STOP STOP S T O P STOP S T O P STOP S T O P STOP LH195SA/LH195SP OH195SA/OH195SP OH318SA/OH358SA LH318SA/LH358SA 1. “NO CHOKE” Position 2. “1/2 CHOKE” Position 3. “FULL CHOKE” Position 1 2 3 3 1 2 3 1 2 1 2 3 ...

  • Tecumseh OH195SP - page 15

    181-1275-14 4-Cycle • Snow King Engine Page 13 B. Engines with Recoil St arters If you have an electric starter see "A. Engines with Electr ic Starters" instructions on page 10. DO NOT pull star ter rope with engine running. Doing so may VOID YOUR WARRANTY. 1. T o avoid carbon monoxide poisoning, be sure e ngine is outdoors in a well-ve ...

  • Tecumseh OH195SP - page 16

    Page 14 4-Cycle • Snow King Engine 181-1275- 14 When pulling starter ro pe, the rope can unexpe ctedly jerk bac k toward engine causin g serious injury. To avoid this ris k, carefully follow these instructions: 7. Grasp starter cord handle. See Figur e 29. a. Pull rop e out slowly u ntil you feel dr ag. b. Without allowing the rope to retract, co ...

  • Tecumseh OH195SP - page 17

    181-1275-14 4-Cycle • Snow King Engine Page 15 VI. S topping Y our Engine and Short-T erm St orage Stop engine according to equipment manufa cturer’s instructions. To avoid unsupervised op eration of an engine, especially by children, NEVER leave it unattended when it is running. Always turn off the engine after use an d remove ignition key, if ...

  • Tecumseh OH195SP - page 18

    Page 16 4-Cycle • Snow King Engine 181-1275- 14 B. Af ter Engine is S topped To prevent po ssible freeze-u p of engine controls, follow instructions with engine STOPPED , listed below. 1. Wipe all snow a nd moisture from engine control leve r and choke areas. 2. Move equipment control, if pr esent (see manufacturer’s instructions), engin e cont ...

  • Tecumseh OH195SP - page 19

    181-1275-14 4-Cycle • Snow King Engine Page 17 VII. Maintenance An adult should perform maintenance on this engine. Only allow children to perform maintenance if an adult has determin ed they are experienced and capable of su ch operation. To prevent acc idental start ing when working on equipment, always: • Carefully disconnect sp ark plug wir ...

  • Tecumseh OH195SP - page 20

    Page 18 4-Cycle • Snow King Engine 181-1275- 14 I. Oil Fill Cap/Dip stick If your engine has an oil fill cap/ dipstic k go to step 1. If your engine does NOT have an oil f ill cap/dipstick, see "II. Oil Fill Cap/Plug" inst ructions on page 20. 1. Carefully disconnect spark plug wir e and keep it away from spar k plug. See Figures 38 and ...

  • Tecumseh OH195SP - page 21

    181-1275-14 4-Cycle • Snow King Engine Page 19 5. Place approved recyclable oil container under oil drain plug, if present. See Figure 41 on page 18. Af terward, continue readin g in structions below . 6. Remove oil drain plug, if present. 7. T ip engine to position the oil flow , so it will drain from the lowest point on the engine (see equipme ...

  • Tecumseh OH195SP - page 22

    Page 20 4-Cycle • Snow King Engine 181-1275- 14 II. Oil Fill Cap/Plug If your engine does NOT have an oil fill c ap/dipstick, go to step 1. If your engine has an o il fill cap/dipstick, see "I. Oil Fill Cap/Dipstick" instructions on page 18. 1. Carefully disconnect spark plug wir e and keep it away from spar k plug. See Figures 44 and 4 ...

  • Tecumseh OH195SP - page 23

    181-1275-14 4-Cycle • Snow King Engine Page 21 5. Place approved recyclable oil container under oil drain plug. See Figures 47 and 48 starting on p age 20. After - ward, continue reading instructions below . 6. T ip engine to positio n the oil drain plug at the lowest point on the engine (see equipme nt manufacturer ’s instructions). 7. Remove ...

  • Tecumseh OH195SP - page 24

    Page 22 4-Cycle • Snow King Engine 181-1275- 14 D. Adjustment s DO NOT make any engine adju stments. Factory sett ings are satisfactory for most co nditions. If adjustments are needed, contact your Authorize d Tecumseh Servicing Dealer. E. Carburetor If you think your carburetor needs adjusting, see your nearest Authorized Tecumseh Ser vicing Dea ...

  • Tecumseh OH195SP - page 25

    181-1275-14 4-Cycle • Snow King Engine Page 23 Figure 52. Snow and Debris Removal Locations 4 1 5 4 1 5 3 2 LH195SA/LH195SP 4 1 2 OH195SA/OH195SP OH318SA/OH358SA LH318SA/LH358SA 1. Oil Fill Cap/D ip stick 2. Fuel Fill Ca p Areas 3. Recoil Starter/Flywheel Gu ard Areas 4. Linkag e Areas 5. Sp ark Plug Connection 4 3 2 3 2 3 1 5 5 ...

  • Tecumseh OH195SP - page 26

    Page 24 4-Cycle • Snow King Engine 181-1275- 14 IX. S toring Y o ur Engine A. Short-T erm/Seasonal Storage I. Clean Engine Before servicing the en gine remove the carburetor cover and/or blower housing. Discard dirt and debris from the following areas: • Cooling Fins • Air Int ake Screen or Reco il S t arter/Flywhee l Guard Areas • Oil Fill ...

  • Tecumseh OH195SP - page 27

    181-1275-14 4-Cycle • Snow King Engine Page 25 II. Oil Cylinder Bore When lubricatin g cylinder bo re, fuel may spray from spar k plug hole. To prevent se rious injury fr om fuel fires, follow these instructions: 1. Carefully disconnect spark plug wir e and keep it away from spa rk plug. See Figures 53 and 54 . • Keep the disconnected sp ark pl ...

  • Tecumseh OH195SP - page 28

    Page 26 4-Cycle • Snow King Engine 181-1275- 14 X. Preventing Forest, Brush and Grass Fires Local, state and federal laws may require use of a spark arrester to prevent fires. For examp le, it is a violation of California Public Resource s Code (section 4442) to use or operate engine on any forest-cover ed, brush-covered or unimproved grass-cove ...

  • Tecumseh OH195SP - page 29

    181-1275-14 4-Cycle • Snow King Engine Page 27 Before Each Use Scheduled Maintenan ce Every 5 Hours or Before Each Use 1. Check Oil Level 2. Clean Cooling Fins Date____________ ___Owner/Dealer Date________ _______Owner/Dealer Date________ _______Owner/Dealer Date________ _______Owner/Dealer Date________ _______Owner/Dealer Date________ _______Own ...

  • Tecumseh OH195SP - page 30

    Page 28 4-Cycle • Snow King Engine 181-1275- 14 IMPORT ANT! The emission Regulations may be different for you r country. The emissions Control Warran ty Sta tement is only applicable to engines with an emissi ons compliance statement and decal that referenc es “Emissio ns Regulation s”. CALIFORNIA & US EP A EMISSION CONTROL W ARRANTY S T ...

  • Tecumseh OH195SP - page 31

    181-1275-14 4-Cycle • Snow King Engine Page 29 IMPORT ANT! The emission Regulations may be different for you r country. The emissions Control Warran ty Sta tement is only applicable to engines with an emissi ons compliance statement and decal that referenc es “Emissio ns Regulation s”. EMISSION CONTROL SYSTEM W ARRANTY Emission Control System ...

  • Tecumseh OH195SP - page 32

    XII. W arranty Information T ecumseh Power Company • Grafton, Wisconsin 53024-1499 • USA Telephone: 1-800-558-5402 Visit us at: www. TecumsehPower.com 181-1275-14 (English) 08/01/05 LIMITED WARRANTY FOR NE W TECUMSEH ENGINES AND ELECTRONIC IGNITION MODULES For the time period shown below from the date of purchase an d su bject to the exceptions ...

Manufacturer Tecumseh Category Snow Blower

Documents that we receive from a manufacturer of a Tecumseh OH195SP can be divided into several groups. They are, among others:
- Tecumseh technical drawings
- OH195SP manuals
- Tecumseh product data sheets
- information booklets
- or energy labels Tecumseh OH195SP
All of them are important, but the most important information from the point of view of use of the device are in the user manual Tecumseh OH195SP.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Tecumseh OH195SP, service manual, brief instructions and user manuals Tecumseh OH195SP. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Tecumseh OH195SP.

Similar manuals

A complete manual for the device Tecumseh OH195SP, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Tecumseh OH195SP by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Tecumseh OH195SP.

A complete Tecumseh manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Tecumseh OH195SP - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Tecumseh OH195SP, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Tecumseh OH195SP, that we can find in the current document
3. Tips how to use the basic functions of the device Tecumseh OH195SP - which should help us in our first steps of using Tecumseh OH195SP
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Tecumseh OH195SP
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Tecumseh OH195SP in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Tecumseh OH195SP?

Use the form below

If you did not solve your problem by using a manual Tecumseh OH195SP, ask a question using the form below. If a user had a similar problem with Tecumseh OH195SP it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)