English dropdown-ico

Manual Ford 2006 Five Hundred

272 pages 2.37 mb
Download

Go to site of 272

Summary
  • Ford 2006 Five Hundred - page 1

    Introduction 4 Instrument Cluster 10 W arning and control lights 10 Gauges 14 Entertainment Systems 17 AM/FM stereo with CD 17 AM/FM stereo with in-dash six CD 20 Family entertainment system 25 Climate Controls 40 Manual heating and air conditioning 40 Automatic temperature control 42 Rear window defroster 47 Lights 48 Headlamps 48 T urn signal con ...

  • Ford 2006 Five Hundred - page 2

    Seating and Safety Restraints 100 Seating 100 Safety restraints 107 Airbags 120 Child restraints 134 Tires, Wheels and Loading 146 T ire Information 146 T ire Inflation 148 V ehicle loading 160 T railer towing 166 Recreational towing 168 Driving 170 Starting 170 Brakes 173 T raction control 175 T ransmission operation 177 Roadside Emergencies 190 G ...

  • Ford 2006 Five Hundred - page 3

    Maintenance and Specifications 226 Engine compartment 228 Engine oil 230 Battery 233 Engine Coolant 235 Fuel information 241 Part numbers 255 Refill capacities 256 Lubricant specifications 258 Accessories 264 Index 267 All rights reserved. Reproduction by any means, electronic or mechanical including photocopying, recording or by any information st ...

  • Ford 2006 Five Hundred - page 4

    CALIFORNIA Proposition 65 W arning W ARNING: Engine exhaust, some of its constituents, and certain vehicle components contain or emit chemicals known to the State of California to cause cancer and birth defects or other reproductive harm. In addition, certain fluids contained in vehicles and certain products of component wear contain or emit chemic ...

  • Ford 2006 Five Hundred - page 5

    SAFETY AND ENVIRONMENT PROTECTION W arning symbols in this guide How can you reduce the risk of personal injury to yourself or others? In this guide, answers to such questions are contained in comments highlighted by the warning triangle symbol. These comments should be read and observed. W arning symbols on your vehicle When you see this symbol, i ...

  • Ford 2006 Five Hundred - page 6

    SPECIAL NOTICES New V ehicle Limited W arranty For a detailed description of what is covered and what is not covered by your vehicle’ s New V ehicle Limited W arranty , refer to the Warranty Guide that is provided to you along with your Owner’ s Guide. Service Data Recording Service data recorders in your vehicle are capable of collecting and s ...

  • Ford 2006 Five Hundred - page 7

    Please read the section Supplemental restraint system (SRS) in the Seating and Safety Restraints chapter . Failure to follow the specific warnings and instructions could result in personal injury . Front seat mounted rear -facing child or infant seats should NEVER be placed in front of an active passenger airbag. Cell phone use The use of Mobile Co ...

  • Ford 2006 Five Hundred - page 8

    These are some of the symbols you may see on your vehicle. V ehicle Symbol Glossary Safety Alert See Owner’ s Guide Fasten Safety Belt Airbag - Front Airbag - Side Child Seat Child Seat Installation W arning Child Seat Lower Anchor Child Seat T ether Anchor Brake System Anti-Lock Brake System Brake Fluid - Non-Petroleum Based Powertrain Malfuncti ...

  • Ford 2006 Five Hundred - page 9

    V ehicle Symbol Glossary Power W indows Front/Rear Power W indow Lockout Child Safety Door Lock/Unlock Interior Luggage Compartment Release Symbol Panic Alarm Engine Oil Engine Coolant Engine Coolant T emperature Do Not Open When Hot Battery A void Smoking, Flames, or Sparks Battery Acid Explosive Gas Fan W arning Power Steering Fluid Maintain Corr ...

  • Ford 2006 Five Hundred - page 10

    W ARNING LIGHTS AND CHIMES W arning lights and gauges can alert you to a vehicle condition that may become serious enough to cause extensive repairs. A warning light may illuminate when a problem exists with one of your vehicle’ s functions. Many lights will illuminate when you start your vehicle to make sure the bulbs work. If any light remains ...

  • Ford 2006 Five Hundred - page 11

    Check fuel cap (if equipped): Illuminates when the fuel cap may not be properly installed. Continued driving with this light on may cause the Check engine warning light to come on, refer to Fuel filler cap in the Maintenance and Specification chapter . Brake system warning light: To confirm the brake system warning light is functional, it will mome ...

  • Ford 2006 Five Hundred - page 12

    Safety belt: Reminds you to fasten your safety belt. A chime will also sound to remind you to fasten your safety belt. Charging system: Illuminates when the battery is not charging properly . Engine oil pressure: Illuminates when the oil pressure falls below the normal range, refer to Engine oil in the Maintenance and Specifications chapter . Engin ...

  • Ford 2006 Five Hundred - page 13

    Speed control: Illuminates when the speed control is engaged. T urns off when the speed control system is disengaged. Low washer fluid (if equipped): Illuminates when the windshield washer fluid is low . Door ajar (if equipped): Illuminates when the ignition is in the ON position and any door or decklid is open. Anti-theft system: Flashes when the ...

  • Ford 2006 Five Hundred - page 14

    GAUGES Speedometer: Indicates the current vehicle speed. Engine coolant temperature gauge: Indicates engine coolant temperature. At normal operating temperature, the needle will be in the normal range (between “H” and “C”). If it enters the red section, the engine is overheating. Stop the vehicle as soon as safely possible, switch off the e ...

  • Ford 2006 Five Hundred - page 15

    Fuel gauge: Indicates approximately how much fuel is left in the fuel tank (when the ignition is in the ON position). The fuel gauge may vary slightly when the vehicle is in motion or on a grade. The FUEL icon and arrow indicates which side of the vehicle the fuel filler door is located. Refer to Filling the tank in the Maintenance and Specificatio ...

  • Ford 2006 Five Hundred - page 16

    • W ith Message Center T o reset with the ODO/TRIP button: • T ap on the button to toggle the display between the trip and the odometer . Holding the ODO/TRIP button for two seconds or more will reset the trip odometer to zero. T o reset with the message center buttons: • Select the TRIP function from the INFO menu. Depressing the RESET contr ...

  • Ford 2006 Five Hundred - page 17

    AUDIO SYSTEMS AM/FM stereo/ single CD sound system (if equipped) Accessory delay: Y our vehicle is equipped with accessory delay . W ith this feature, the window switches and radio may be used for up to ten minutes after the ignition is turned off or either front door is opened. 1. / T uner: Press to manually go up or down the radio frequency . Als ...

  • Ford 2006 Five Hundred - page 18

    Autoset: Allows you to set the strongest local radio stations without losing your original manually set preset stations for AM/FM1/FM2 . Press MENU to access. Use / / SEEK to set. When the six strongest stations are filled, the station stored in preset 1 will begin playing. If there are less than six strong stations, the system will store the last ...

  • Ford 2006 Five Hundred - page 19

    9. Repeat: Press to repeat the current CD track. 10. Fast forward: Press to manually advance in a CD track. 11. Rewind: Press to manually reverse in a CD track. 12. Memory presets: T o set a station: Select frequency band AM/FM; tune to a station, press and hold a preset button until sound returns. 13. Scan: Press for a brief sampling of radio stat ...

  • Ford 2006 Five Hundred - page 20

    19. CD slot: Insert a CD label side up. Premium/Audiophile In-Dash Six CD/MP3 Sound System (if equipped) Accessory delay: Y our vehicle is equipped with accessory delay . W ith this feature, the window switches and radio may be used for up to ten minutes after the ignition switch is turned off or until either front door is opened. 1. / T une/Disc s ...

  • Ford 2006 Five Hundred - page 21

    3. Menu: Press to toggle through the following modes: Autoset: Allows you to set the strongest local radio stations without losing your original manually set preset stations for AM/FM1/FM2 . Use / / SEEK to turn on/off. When the six strongest stations are filled, the station stored in preset 1 will begin playing. If there are less than six strong s ...

  • Ford 2006 Five Hundred - page 22

    Repeat: A vailable only in CD mode. Press to repeat the current CD track. RDS (A vailable on Audiophile radios only): Allows you to search RDS-equipped stations for a certain category of music format: Classic, Country , Info, Jazz/RB, Religious, Rock, Soft, T op 40. RDS (only available in FM mode) must be activated to access Find and Show functions ...

  • Ford 2006 Five Hundred - page 23

    10. Fast forward: Press to manually advance in a CD track. 11. Rewind: Press to manually reverse in a CD track. 12. Memory presets: T o set a station: Select frequency band AM/FM; tune to a station, press and hold a preset button until sound returns. 13. Scan: Press for a brief sampling of radio stations or CD tracks. Press again to stop. 14. Seek: ...

  • Ford 2006 Five Hundred - page 24

    20. CD slot: Insert a CD label side up. GENERAL AUDIO INFORMATION Radio frequencies: AM and FM frequencies are established by the Federal Communications Commission (FCC) and the Canadian Radio and T elecommunications Commission (CRTC). Those frequencies are: AM: 530, 540–1700, 1710 kHz FM: 87.7, 87.9–107.7, 107.9 MHz Radio reception factors: Th ...

  • Ford 2006 Five Hundred - page 25

    become jammed. It is recommended that homemade CDs be identified with permanent felt tip marker rather than adhesive labels. Ballpoint pens may damage CDs. Please contact your authorized dealer for further information. Audio system warranty and service Refer to the W arranty Guide for audio system warranty information. If service is necessary , see ...

  • Ford 2006 Five Hundred - page 26

    • FWD — Press to advance within the active CD track or DVD chapter in play mode. Also press to move the cursor right in the menu active mode. 2. PLA Y/P AUSE control Press to playback or pause the DVD. 3. DIM control Press (+) to increase or (-) to decrease the brightness on the screen. 4. ENTER control Press to select the function highlighted ...

  • Ford 2006 Five Hundred - page 27

    • Press the NEXT control to move the cursor one position upward • Press the PREV control to move the cursor one position downward • Press the REV control to move the cursor left one position • Press the FWD control to move the cursor right one position Next/Previous control The NEXT (up) and PREV (down) controls allows you to access the nex ...

  • Ford 2006 Five Hundred - page 28

    Enter control The ENTER control allows you to select highlighted items when in MENU mode. CD play mode Press NEXT during CD play to advance to the next track. If you press NEXT while the last track is playing, the system will wrap around to the first track and begin play . Slow play mode T o enter slow play mode, press the PLA Y/P AUSE control. Thi ...

  • Ford 2006 Five Hundred - page 29

    Remote control 1. REV (REVERSE) control Press to reverse the direction of the DVD movie. 2. FWD (FOR W ARD) control Press to advance the direction of the DVD movie. 3. PLA Y/STOP control When playing, press PLA Y/STOP to stop the disc. When stopped, press PLA Y/STOP to play the disc. 4. SEEK control Press to reverse ( ) or advance ( ) the chapter o ...

  • Ford 2006 Five Hundred - page 30

    In DVD playback mode, press to access the disc menu. In stop mode, press to change media types (e.g. AM, FM, C D...) 8. VOL (VOLUME) control Press (+) to increase or (-) to decrease the volume level. Dual play mode Press the radio preset controls 2 and 4 at the same time to enable or disable dual play . During dual play , the rear vehicle speakers ...

  • Ford 2006 Five Hundred - page 31

    Battery replacement Batteries are provided with the remote control unit. Since all batteries have a limited shelf life, replace them when the remote control fails to control the DVD player . There is a LED indicator light on the remote control that will illuminate when any control is pressed. Slide the battery cover off as shown on the remote contr ...

  • Ford 2006 Five Hundred - page 32

    Wireless headphones Y our system is equipped with 2 sets of wireless headphones. (T wo AAA batteries are needed to operate the headphones.) Batteries are included. T o install the batteries, remove the screw at the bottom of the cover . Then, lightly press down on top, and slide the cover off. When replacing the batteries, use two new batteries (al ...

  • Ford 2006 Five Hundred - page 33

    Note: The volume level of the wireless headphones can only be controlled by the thumbwheel. Neither the remote control nor the rear seat controls will affect the volume output of the wireless headphones. When not using the headphones, turn them off to preserve battery life. The headphones will automatically turn off after five minutes if they have ...

  • Ford 2006 Five Hundred - page 34

    3. Dimmer switch. Press +/- to increase/decrease the brightness of the display . Playback and format • The DVD player of your Family Entertainment DVD System can only be used in the “playback” mode. (The DVD player does not offer a record feature.) • The system plays standard CDs or DVDs, CDR/RW , DVDRs, VCDs and MP3 media. Family Entertain ...

  • Ford 2006 Five Hundred - page 35

    This unit is designed to play commercially pressed 4.75 (12 cm) audio compact discs and DVDs only . Due to technical incompatibility , certain recordable and re-recordable compact discs may not function correctly when used in Ford DVD/CD players. Irregular shaped discs, discs with a scratch protection film attached, and discs with homemade paper (a ...

  • Ford 2006 Five Hundred - page 36

    On-screen indicators Each time a control is pressed, the operational status of the DVD player is shown on the screen. The following are some possible indicators: 1. DVD/ CD ST A TUS (PLA Y/FWD/REV/P AUSE) 2. CD track number / DVD title 3. DVD chapter number 4. MEDIA COUNTER — displays current viewing time of desired media. (HOURS:MINUTES:SECONDS) ...

  • Ford 2006 Five Hundred - page 37

    The front glass on the flip-down liquid crystal display (LCD) may break when hit with a hard surface. If the glass breaks, do not touch the liquid crystalline material. In case of contact with skin, wash immediately with soap and water . Do not expose the flip-down liquid crystal display (LCD) to direct sunlight or intensive ultraviolet rays for ex ...

  • Ford 2006 Five Hundred - page 38

    However , there is no guarantee that interference will not occur in a particular installation. If this equipment does cause harmful interference to radio or television reception, (which can be determined by turning the equipment off and on), the user is encouraged to consult the dealer or an experienced radio/TV technician for help. Care and servic ...

  • Ford 2006 Five Hundred - page 39

    Cleaning compact discs Inspect all discs for contamination before playing. If necessary , clean discs only with an approved CD cleaner and wipe from the center out to the edge. Do not wipe in a circular motion. Cleaning the DVD player Clean the exterior of the DVD player with a damp cloth. Do not use CD cleaning kits or CDs intended to clean the in ...

  • Ford 2006 Five Hundred - page 40

    MANUAL HEATING AND AIR CONDITIONING SYSTEM (IF EQUIPPED) 1. T emperature selection: Controls the temperature of the airflow in the vehicle. 2. Air flow selections: Controls the direction of the airflow in the vehicle. See the following for a brief description on each control setting: MAX A/C: Distributes recirculated air through the instrument pane ...

  • Ford 2006 Five Hundred - page 41

    6. Fan speed adjustment: Controls the volume of air circulated in the vehicle. Operating tips • T o reduce fog build up on the windshield during humid weather , place the air flow selector in the position. • T o reduce humidity build up inside the vehicle: do not drive with the airflow selector in the O (OFF) or with recirculated air engaged. ? ...

  • Ford 2006 Five Hundred - page 42

    DUAL ZONE AUTOMATIC T EMPERATURE CONTROL (IF EQUIPPED) 1. Defrost: Distributes outside air through the windshield defroster and demister vents. Can be used to clear thin ice or fog from the windshield. T o exit select another mode. 2. Passenger temperature control: Press to increase/decrease the airflow temperature for the passenger in the front of ...

  • Ford 2006 Five Hundred - page 43

    8. : Distributes air through the instrument panel and floor vents. 9. : Distributes air through the instrument panel vents. 10. Manual override controls: Allows you to manually select where airflow is directed. T o return to full automatic control, press AUTO. 11. Front fan speed control: Press to manually increase or decrease the fan speed. T o re ...

  • Ford 2006 Five Hundred - page 44

    Dual Zone Automatic T emperature Control with heated seats (if equipped) 1. Defrost: Distributes outside air through the windshield defroster and demister vents. Can be used to clear thin ice or fog from the windshield. T o exit select another mode. 2. Passenger temperature control: Press to increase/decrease the airflow temperature for the passeng ...

  • Ford 2006 Five Hundred - page 45

    7. A/C: Press to activate/deactivate air conditioning. Use with recirculated air to improve cooling performance and efficiency . Engages automatically in AUTO, defrost and floor/defrost. 8. Airflow direction control: Press to toggle through the air distribution modes listed below . The selected mode will be shown in the display . : Distributes air ...

  • Ford 2006 Five Hundred - page 46

    Operating tips • T o reduce fog build up on the windshield during humid weather , place the air flow selector in the position. • T o reduce humidity build up inside the vehicle: do not drive with the airflow selector in the OFF or with recirculated air engaged. • Do not put objects under the front seats that will interfere with the airflow to ...

  • Ford 2006 Five Hundred - page 47

    REAR WINDOW DEFROSTER R The rear defroster control is located on the climate control panel and works to clear the rear window of fog and thin ice. The ignition must be in the 3 (RUN) position to operate the rear window defroster . The rear defroster turns off automatically after 10 minutes or when the ignition is turned to the 1 (LOCK) position. T ...

  • Ford 2006 Five Hundred - page 48

    HEADLAMP CONTROL T urns the lamps off. T urns on the parking lamps, instrument panel lamps, license plate lamps and tail lamps. T urns the headlamps on. Autolamp control (if equipped) The autolamp system provides light sensitive automatic on-off control of the exterior lights normally controlled by the headlamp control. • T o turn autolamps on, r ...

  • Ford 2006 Five Hundred - page 49

    5. W ait the desired amount of time for the exit delay you want (up to three minutes), then turn the headlamp switch to . The headlamps will turn off. High beams Pull the lever towards you, to the second detent, to activate. Pull the lever towards you again to deactivate. Flash to pass Pull toward you, to the first detent, to activate and release t ...

  • Ford 2006 Five Hundred - page 50

    Daytime running lamps (DRL) (if equipped) T urns the headlamps on with a reduced output. T o activate: • the ignition must be in the ON position, • the headlamp control is in the OFF , autolamps or parking lamp position and • the transmission must be out of the Park position. Always remember to turn on your headlamps at dusk or during incleme ...

  • Ford 2006 Five Hundred - page 51

    • (1) 8 feet (2.4 meters) • (2) Center height of lamp to ground • (3) 25 feet (7.6 meters) • (4) Horizontal reference line 2. Measure the height of the headlamp bulb center from the ground and mark an 8 foot (2.5 meter) horizontal reference line on the vertical wall or screen at this height (a piece of masking tape works well). 3. T urn on ...

  • Ford 2006 Five Hundred - page 52

    TURN SIGNAL CONTROL • Push down to activate the left turn signal. • Push up to activate the right turn signal. INTERIOR LAMPS Dome lamps and map lamps The map lamps are located on the overhead console. Press the controls on either side of each map lamp to turn on the lamps. Y our vehicle may also have reading lamps within the rear dome lamp(s). ...

  • Ford 2006 Five Hundred - page 53

    “E” for Europe to assure lamp performance, light brightness and pattern and safe visibility . The correct bulbs will not damage the lamp assembly or void the lamp assembly warranty and will provide quality bulb burn time. Function Number of bulbs T rade number Headlamp high beam 2 9005 Headlamp low beam 2 9006 Front park/turn lamp 2 3157AK or 3 ...

  • Ford 2006 Five Hundred - page 54

    3. Locate the outboardmost top electrical connector and remove it by releasing the locking tab and pulling it straight down. 4. Remove the bulb socket by turning it counterclockwise and pulling it straight out. Handle a halogen headlamp bulb carefully and keep out of children’ s reach. Grasp the bulb only by its plastic base and do not touch the ...

  • Ford 2006 Five Hundred - page 55

    Replacing front parking lamp/turn signal bulbs 1. Make sure headlamp switch is in the OFF position, then open the hood. 2. Reach up from the underside of the fascia to access the bulb sockets and connectors. 3. Locate the parking/turn signal lamp electrical connector and remove it by pulling it straight off. 4. Remove the bulb socket by turning it ...

  • Ford 2006 Five Hundred - page 56

    4. Remove the bulb socket by rotating it counterclockwise, then pulling it out of the lamp assembly . 5. Pull the bulb straight from the socket. Install new bulb(s) in reverse order . Replacing high-mount brake lamp bulbs 1. Make sure the ignition control is in the OFF position. 2. Open the trunk and reach under the decklid. 3. Remove the bulb sock ...

  • Ford 2006 Five Hundred - page 57

    Replacing foglamp bulbs 1. Make sure the foglamp switch is in the OFF position. 2. Remove the bulb socket from the foglamp by turning counterclockwise. 3. Disconnect the electrical connector . Install the new bulb in reverse order . 2006 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus) Lights 57 ...

  • Ford 2006 Five Hundred - page 58

    MUL TI-FUNCTION LEVER W indshield wiper: For intermittent operation, move control up one position. Adjust the rotary control to the desired speed setting. Mist function: T o activate mist, push control down from the OFF position and release to get one wipe. For normal or low speed wiper operation, move control up two positions from OFF . For high s ...

  • Ford 2006 Five Hundred - page 59

    TILT STEERING WHEEL T o adjust the steering wheel: 1. Pull down and hold the steering wheel release control. 2. Move the steering wheel up or down until you find the desired location. 3. Pull the steering wheel release control up. This will lock the steering wheel in position. Never adjust the steering wheel when the vehicle is moving. ILLUMINATED ...

  • Ford 2006 Five Hundred - page 60

    CLOCK (IF EQUIPPED) Press and release the button to adjust forward. Press and hold to fast forward. INSTRUMENT PANEL STORAGE COMPARTMENT The storage compartment may be used to secure sunglasses or similar sized objects. Press the control to open the storage compartment. CENTER CONSOLE Y our vehicle may be equipped with a variety of console features ...

  • Ford 2006 Five Hundred - page 61

    The auxiliary power points are located on the instrument panel and in the center console utility compartment. Do not use the power point for operating the cigarette lighter element (if equipped). T o prevent the fuse from being blown, do not use the power point(s) over the vehicle capacity of 12 VDC/180W . T o prevent the battery from being dischar ...

  • Ford 2006 Five Hundred - page 62

    Press and pull the window switches to open and close windows. • Push down (to the first detent) and hold the switch to open. • Pull up (to the first detent) and hold the switch to close. One touch up or down This feature is present on the driver’ s window only . T o operate ONE TOUCH DOWN: • Press the switch completely down to the second de ...

  • Ford 2006 Five Hundred - page 63

    Window lock The window lock feature allows only the driver to operate the power windows. T o lock out all the window controls except for the driver’ s press the right side of the control. Press the left side to restore the window controls. Bounce-Back (Driver ’ s window only) When an obstacle has been detected in the window opening as the windo ...

  • Ford 2006 Five Hundred - page 64

    (darkened) state when bright lights (glare) reach the mirror . When the mirror detects bright light from behind the vehicle, it will automatically adjust (darken) to minimize glare. The mirror will automatically return to the normal state whenever the vehicle is placed in R (Reverse) to ensure a bright clear view when backing up. Do not block the s ...

  • Ford 2006 Five Hundred - page 65

    Heated outside mirrors (if equipped) Both mirrors are heated automatically to remove ice, mist and fog when the rear window defrost is activated. Do not remove ice from the mirrors with a scraper or attempt to readjust the mirror glass if it is frozen in place. These actions could cause damage to the glass and mirrors. POWER ADJUSTABLE FOOT PEDALS ...

  • Ford 2006 Five Hundred - page 66

    Do not use the speed control in heavy traffic or on roads that are winding, slippery or unpaved. Setting speed control The controls for using your speed control are located on the steering wheel for your convenience. 1. Press the ON control and release it. 2. Accelerate to the desired speed. 3. Press the SET + control and release it. 4. T ake your ...

  • Ford 2006 Five Hundred - page 67

    Resuming a set speed Press the RES control and release it. This will automatically return the vehicle to the previously set speed. The RES control will not work if the vehicle speed is not faster than 30 mph (48 km/h). Increasing speed while using speed control There are two ways to set a higher speed: • Press and hold the SET + control until you ...

  • Ford 2006 Five Hundred - page 68

    • Depress the brake pedal or press CNCL (Cancel) until the desired vehicle speed is reached, press the SET + control. Turning of f speed control There are two ways to turn off the speed control: • Depress the brake pedal or press CNCL (Cancel). This will not erase your vehicle’ s previously set speed. • Press the speed control OFF control. ...

  • Ford 2006 Five Hundred - page 69

    In Radio mode: • Press SEEK to access the next/previous strong station. In CD mode: • Press SEEK to listen to the next track on the disc. In any mode: • Press VOL up or down to adjust the volume. • Press MUTE to mute the volume. MOON ROOF (IF EQUIPPED) Y ou can move the glass panel of the moon roof back to open or tilt up to ventilate the v ...

  • Ford 2006 Five Hundred - page 70

    The moon roof has a sliding shade that can be opened or closed when the glass panel is shut. T o close the shade, pull it toward the front of the vehicle Do not let children play with the moon roof or leave children unattended in the vehicle. They may seriously hurt themselves. When closing the moon roof, you should verify that it is free of obstru ...

  • Ford 2006 Five Hundred - page 71

    transmitter of the device being programmed to HomeLink 威 for quicker training and accurate transmission of the radio-frequency signal. 1. Press and hold the two outside buttons releasing only when the indicator light begins to flash after 20 seconds. Do not repeat Step 1 to program additional hand-held transmitters to the remaining two HomeLink ? ...

  • Ford 2006 Five Hundred - page 72

    7. Press and release the “learn” or “smart” button. (The name and color of the button may vary by manufacturer .) Note: There are 30 seconds in which to initiate Step 8. 8. Return to the vehicle and firmly press, hold for two seconds and release the HomeLink 威 button. Repeat the press/hold/release sequence again, and, depending on the bra ...

  • Ford 2006 Five Hundred - page 73

    Operating the HomeLink 姞 Wireless Control System T o operate, simply press and release the appropriate HomeLink 威 button. Activation will now occur for the trained product (garage door , gate operator , security system, entry door lock, or home or office lighting etc.). For convenience, the hand-held transmitter of the device may also be used a ...

  • Ford 2006 Five Hundred - page 74

    MESSAGE CENTER (IF EQUIPPED) W ith the ignition in the ON position, the message center , located on your instrument cluster , displays important vehicle information through a constant monitor of vehicle systems. Y ou may select display features on the message center for a display of status. The system will also notify you of potential vehicle probl ...

  • Ford 2006 Five Hundred - page 75

    DTE is calculated using a running average fuel economy , which is based on your recent driving history of 500 miles (800 km). This value is not the same as the average fuel economy display . The running average fuel economy is reinitialized to a factory default value if the battery is disconnected. Average fuel economy (AFE) Select this function fr ...

  • Ford 2006 Five Hundred - page 76

    Trip elapsed drive time Select this function from the INFO menu to display a timer . T o operate the T rip Elapsed Drive T ime perform the following: 1. Press and release RESET in order to start the timer . 2. Press and release RESET to pause the timer . 3. Press and hold RESET for 2 seconds in order to reset the timer . Compass display Select this ...

  • Ford 2006 Five Hundred - page 77

    Note: If message center displays the message ⬙ SLOW CIRCLES TO CALIBRA TE ⬙ , then perform the CALIBRA TION PROCEDURE. 4. Determine your magnetic zone by referring to the zone map. 5. Press and hold the RESET until the message center display changes to show the current zone setting. 6. Release the RESET control, then slowly press RESET down aga ...

  • Ford 2006 Five Hundred - page 78

    Note: If message center displays the message ⬙ SLOW CIRCLES TO CALIBRA TE ⬙ , then continue with Step 4. Otherwise, if a heading is displayed, continue with Step 5. 4. Drive the vehicle in circles up to three times until the message ⬙ CALIBRA TION COMPLETED ⬙ appears and one of the 8 valid headings (N, NE, E, SE, S, SW , W , NW) is displaye ...

  • Ford 2006 Five Hundred - page 79

    3. Press and hold the RESET control to set the language choice. Units (English/Metric) 1. Select this function from the SETUP menu for the current units to be displayed. 2. Press the RESET control to change from English to Metric. System check Selecting this function from the SETUP menu causes the message center to cycle through each of the systems ...

  • Ford 2006 Five Hundred - page 80

    The message center will display the last selected feature if there are no more warning messages. This allows you to use the full functionality of the message center after you acknowledge the warning by pressing the RESET control and clearing the warning message. W arning messages that have been reset are divided into three categories: • They will ...

  • Ford 2006 Five Hundred - page 81

    P ARK BRAKE ENGAGED. Displayed when the park brake is engaged. If the warning stays on after the park brake is off, contact your authorized dealer as soon as possible. LOW FUEL LEVEL. Displayed as an early reminder of a low fuel condition. CHECK CHARGING SYSTEM. Displayed when the electrical system is not maintaining proper voltage. If you are oper ...

  • Ford 2006 Five Hundred - page 82

    T o reset the oil life to 100% with system warnings CHANGE OIL SOON/OIL CHANGE REQUIRED displayed: 1. Select this function from the SETUP control for current display mode. 2. Press and release the RESET control to display “IF NEW OIL HOLD RESET”. 3. Press and hold the RESET control to display OIL LIFE SET TO 100%. Y our oil life is now reset. T ...

  • Ford 2006 Five Hundred - page 83

    INTERIOR TRUNK CONTROL Press the remote trunk release control on the instrument panel to the left of the steering wheel. CARGO AREA FEATURES Cargo net (if equipped) The cargo net secures lightweight objects in the cargo area. Attach the net to the anchors provided. Do not put more than 50 lbs. (22 kg) in the net. This net is not designed to restrai ...

  • Ford 2006 Five Hundred - page 84

    KEYS One key operates all the locks and starts the vehicle. Always carry a spare key with you in case of an emergency . Y our keys are programmed to your vehicle; using a non-programmed key will not permit your vehicle to start. If you lose your authorized dealer supplied keys, replacement keys are available through your authorized dealer . Refer t ...

  • Ford 2006 Five Hundred - page 85

    1. Place the key in the ignition and turn the ignition to the 3 (RUN) position. 2. Press the power door unlock control on the door panel three times. 3. T urn the ignition from the 3 (RUN) position to the 1 (LOCK) position. 4. Press the power door unlock control on the door panel three times. 5. T urn the ignition back to the 3 (RUN) position. The ...

  • Ford 2006 Five Hundred - page 86

    Adults are advised to familiarize themselves with the operation and location of the release handle. T o open the luggage compartment door (lid) from within the luggage compartment, pull the illuminated “T” shaped handle and push up on the trunk lid. The handle is composed of a material that will glow for hours in darkness following brief exposu ...

  • Ford 2006 Five Hundred - page 87

    REMOTE ENTRY SYSTEM This device complies with part 15 of the FCC rules and with RS-210 of Industry Canada. Operation is subject to the following two conditions: (1) This device may not cause harmful interference, and (2) This device must accept any interference received, including interference that may cause undesired operation. Changes or modifica ...

  • Ford 2006 Five Hundred - page 88

    2. Press and release again within three seconds to unlock all the doors. The remote entry system activates the illuminated entry feature; this feature turns on the lamps for 25 seconds or until the ignition is turned to the 3 (RUN) position. The inside lights will not turn off if: • they have been turned on using the dimmer control or • any doo ...

  • Ford 2006 Five Hundred - page 89

    Press to automatically move the seat, mirrors and adjustable pedals to the desired memory position (the positions correspond to the transmitter being used). Note: Y ou can associate a specific remote entry transmitter to each memory position. For more information on programming the transmitters to Driver 1 and Driver 2 memory positions respectively ...

  • Ford 2006 Five Hundred - page 90

    2. Do not wipe off any grease on the battery terminals on the back surface of the circuit board. 3. Remove the old battery . Note: Please refer to local regulations when disposing of transmitter batteries. 4. Insert the new battery . Refer to the diagram inside the remote entry transmitter for the correct orientation of the battery . Press the batt ...

  • Ford 2006 Five Hundred - page 91

    T o reprogram the remote entry transmitters: 1. Ensure the vehicle is electronically unlocked. 2. Put the key in the ignition. 3. Cycle eight times rapidly (within 10 seconds) between the 1 (LOCK) position and 3 (RUN). Note: The eighth turn must end in the 3 (RUN) position. 4. The doors will lock, then unlock, to confirm that the programming mode h ...

  • Ford 2006 Five Hundred - page 92

    • If the dome lamps were turned on using the panel dimmer control, the battery saver will shut off them off 30 minutes after the ignition has been turned to the 1 (LOCK) position. • If the courtesy lamps were turned on because one of the vehicle doors was opened, the battery saver will shut them off 10 minutes after the ignition has been turned ...

  • Ford 2006 Five Hundred - page 93

    2. W ithin five seconds press the 1 • 2 on the keypad. 3. Enter your personal 5-digit code. Each number must be entered within five seconds of each other . 4. T o associate the entry code with a memory setting, enter a sixth digit to indicate which driver should be set in a memory recalled by the personal entry code: • Pressing 1 • 2 recalls ...

  • Ford 2006 Five Hundred - page 94

    Unlocking and locking the doors using keyless entry T o unlock the driver’ s door , enter the factory set 5-digit code or your personal code. Each number must be pressed within five seconds of each other . The interior lamps will illuminate. T o unlock all doors, enter the factory set code or your personal code, then press the 3 • 4 control wit ...

  • Ford 2006 Five Hundred - page 95

    Power door unlock/lock procedure Y ou must complete steps 1-5 within 30 seconds or the procedure will have to be repeated. If the procedure needs to be repeated, you must wait 30 seconds. 1. T urn the ignition to the 3 (RUN) position. 2. Press the power door unlock control three times. 3. T urn the ignition from the 3 (RUN) to the 1 (LOCK) position ...

  • Ford 2006 Five Hundred - page 96

    Note: The SecuriLock 娂 passive anti-theft system is not compatible with non-Ford aftermarket remote start systems. Use of these systems may result in vehicle starting problems and a loss of security protection. Note: Large metallic objects, electronic devices that are used to purchase gasoline or similar items, or a second coded key on the same k ...

  • Ford 2006 Five Hundred - page 97

    Replacement keys If your keys are lost or stolen and you don’t have an extra coded key , you will need to have your vehicle towed to an authorized dealer . The key codes need to be erased from your vehicle and new coded keys will need to be programmed. Replacing coded keys can be very costly . Store an extra programmed key away from the vehicle i ...

  • Ford 2006 Five Hundred - page 98

    6. T urn the ignition to the 1 (LOCK) position and remove the second previously programmed coded key from the ignition. 7. W ithin twenty seconds of turning the ignition to the 1 (LOCK) position and removing the previously programmed coded key , insert the new unprogrammed key (new key/valet key) into the ignition. 8. T urn the ignition from the 1 ...

  • Ford 2006 Five Hundred - page 99

    • Press the driver or passenger interior door lock control while the door is open, then close the door . • Press the 7 • 8a n d9 • 0 controls on the keyless entry pad at the same time to lock the doors (driver’ s door must be closed). There is a 20 second countdown when any of the above actions occur before the vehicle becomes armed. Each ...

  • Ford 2006 Five Hundred - page 100

    SEATING Notes: Reclining the seatback can cause an occupant to slide under the seat’ s safety belt, resulting in severe personal injuries in the event of a collision. Do not pile cargo higher than the seatbacks to reduce the risk of injury in a collision or sudden stop. Adjustable head restraints Head restraints help to limit head motion in the e ...

  • Ford 2006 Five Hundred - page 101

    Using the manual lumbar support (if equipped) The lumbar support control is located on the outboard side of the seatback. Move the control up or down to adjust lumbar support. Folding down the front passenger seatback The front passenger seatback can be folded to a horizontal position to make room for a long load. T o fold the seatback: 1. Move the ...

  • Ford 2006 Five Hundred - page 102

    Adjusting the front manual seat (if equipped) Never adjust the driver’ s seat or seatback when the vehicle is moving. Always drive and ride with your seatback upright and the lap belt snug and low across the hips. Lift handle to move seat forward or backward. Pull lever up to adjust seatback. Before returning the seatback to its original position ...

  • Ford 2006 Five Hundred - page 103

    Do not pile cargo higher than the seatbacks to reduce the risk of injury in a collision or sudden stop. Always drive and ride with your seatback upright and the lap belt snug and low across the hips. Reclining the seatback can cause an occupant to slide under the seat’ s safety belt, resulting in severe personal injuries in the event of a collisi ...

  • Ford 2006 Five Hundred - page 104

    Press the control to move the seat forward, backward, up or down. • Driver Press the control to move the seat forward, or backward. • Passenger Press the control (if equipped) to recline the seatback forward or rearward. Heated seats (if equipped) T o operate the heated seats: • Push the control located on the climate control system panel onc ...

  • Ford 2006 Five Hundred - page 105

    Memory seats/power mirrors/adjustable pedals (if equipped) This system allows automatic positioning of the driver seat, power mirrors, and adjustable pedals to two programmable positions. The memory seat control is located on the driver door . • T o program position 1, move the driver seat, mirrors and pedals (if equipped) to the desired position ...

  • Ford 2006 Five Hundred - page 106

    The head restraints can be moved up by pulling up on the head restraint. Push release button to lower head restraint. Split-folding rear seat One or both rear seatbacks can be folded down to provide additional cargo space. T o lower the seatback(s) from inside the vehicle, pull the strap located on the outboard side of the seatback to release it, a ...

  • Ford 2006 Five Hundred - page 107

    Before returning the seatback to its original position, make sure that cargo or any objects are not trapped behind the seatback. After returning the seatback to its original position, pull on the seatback to ensure that it has fully latched. An unlatched seat may become dangerous in the event of a sudden stop or collision. Seat mounted cup holders ...

  • Ford 2006 Five Hundred - page 108

    • Driver’ s seat position sensor . • Passenger occupant classification sensor • Front crash severity sensor . • Restraints Control Module (RCM) with impact and safing sensors. • Restraint system warning light and back-up tone. • The electrical wiring for the airbags, crash sensor(s), safety belt pretensioners, front safety belt usage ...

  • Ford 2006 Five Hundred - page 109

    levels of crash severity and modify the deployment strategy of the dual-stage airbags and safety belt pretensioners. Driver ’s seat position sensor The driver’ s seat position sensor allows your Personal Safety System 娂 to tailor the deployment level of the driver dual-stage airbag based on seat position. The system is designed to help protec ...

  • Ford 2006 Five Hundred - page 110

    allows your Personal Safety System 娂 to tailor the airbag deployment and safety belt pretensioner activation depending upon safety belt usage. Refer to Safety belt section in this chapter . Front safety belt pretensioners The safety belt pretensioners at the front outboard seating positions are designed to tighten the safety belts firmly against ...

  • Ford 2006 Five Hundred - page 111

    Safety belt precautions Always drive and ride with your seatback upright and the lap belt snug and low across the hips. T o reduce the risk of injury , make sure children sit where they can be properly restrained. Never let a passenger hold a child on his or her lap while the vehicle is moving. The passenger cannot protect the child from injury in ...

  • Ford 2006 Five Hundred - page 112

    Combination lap and shoulder belts 1. Insert the belt tongue into the proper buckle (the buckle closest to the direction the tongue is coming from) until you hear a snap and feel it latch. Make sure the tongue is securely fastened in the buckle. 2. T o unfasten, push the release button and remove the tongue from the buckle. All restraints in the ve ...

  • Ford 2006 Five Hundred - page 113

    All safety restraints in the vehicle are combination lap and shoulder belts. All of the passenger combination lap and shoulder belts have two types of locking modes described below: V ehicle sensitive mode This is the normal retractor mode, which allows free shoulder belt length adjustment to your movements and locking in response to vehicle moveme ...

  • Ford 2006 Five Hundred - page 114

    • Grasp the shoulder portion and pull downward until the entire belt is pulled out. • Allow the belt to retract. As the belt retracts, you will hear a clicking sound. This indicates the safety belt is now in the automatic locking mode. How to disengage the automatic locking mode Ford Motor Company recommends that all passenger safety belt assem ...

  • Ford 2006 Five Hundred - page 115

    Position the safety belt height adjusters so that the belt rests across the middle of your shoulder . Failure to adjust the safety belt properly could reduce the effectiveness of the seat belt and increase the risk of injury in a collision. Safety belt warning light and indicator chime The safety belt warning light illuminates in the instrument clu ...

  • Ford 2006 Five Hundred - page 116

    Both the driver’ s and passenger’ s safety belt usages are monitored and either may activate the BeltMinder 娂 feature. The warnings are the same for the driver and the front passenger . If the BeltMinder 娂 warnings have expired (warnings for approximately 5 minutes) for one occupant (driver or front passenger), the other occupant can still ...

  • Ford 2006 Five Hundred - page 117

    The following are reasons most often given for not wearing safety belts (All statistics based on U.S. data): Reasons given... Consider ... “Crashes are rare events” 36700 crashes occur every day . The more we drive, the more we are exposed to “rare” events, even for good drivers. 1i n4o fu sw i l lb e seriously injured in a crash during our ...

  • Ford 2006 Five Hundred - page 118

    Do not sit on top of a buckled safety belt to avoid the BeltMinder 娂 chime. Sitting on the safety belt will increase the risk of injury in an accident. T o disable (one-time) or deactivate the BeltMinder 娂 feature please follow the directions stated below . One time disable If at any time the driver/front passenger quickly buckles then unbuckle ...

  • Ford 2006 Five Hundred - page 119

    • Step 3 must be completed within 50 seconds after the safety belt warning light turns off. 3. For the seating position being disabled, at a moderate speed, buckle then unbuckle the safety belt 9 times, ending in the unbuckled state. (Step 3 must be completed within 50 seconds after the safety belt warning light turns off.) • After Step 3, the ...

  • Ford 2006 Five Hundred - page 120

    hardware, should be inspected after a collision. Ford Motor Company recommends that all safety belt assemblies in use in vehicles involved in a collision be replaced. However , if the collision was minor and an authorized dealer finds that the belts do not show damage and continue to operate properly , they do not need to be replaced. Safety belt a ...

  • Ford 2006 Five Hundred - page 121

    Important supplemental restraint system precautions Airbags DO NOT inflate slowly or gently and the risk of injury from a deploying airbag is greatest close to the trim covering the airbag module. All occupants of the vehicle, including the driver , should always properly wear their safety belts, even when an air bag supplemental restraint system ( ...

  • Ford 2006 Five Hundred - page 122

    Do not attempt to service, repair , or modify the airbag supplemental restraint system (SRS) or its fuses. See your authorized dealer . Modifying or adding equipment to the front end of the vehicle (including frame, bumper , front end body structure and tow hooks) may affect the performance of the airbag system, increasing the risk of injury . Do n ...

  • Ford 2006 Five Hundred - page 123

    How does the airbag supplemental restraint system work? The airbag SRS is designed to activate when the vehicle sustains longitudinal deceleration sufficient to cause the sensors to close an electrical circuit that initiates airbag inflation. The fact that the airbags did not inflate in a collision does not mean that something is wrong with the sys ...

  • Ford 2006 Five Hundred - page 124

    Several air bag system components get hot after inflation. Do not touch them after inflation. If the air bag has deployed, the air bag will not function again and must be replaced immediately . If the air bag is not replaced, the unrepaired area will increase the risk of injury in a collision. The SRS consists of: • driver and passenger airbag mo ...

  • Ford 2006 Five Hundred - page 125

    • the system determines that a small child is present in a forward-facing child restraint that is installed according to the manufacturer’ s instructions, • the system determines that a small child is present in a booster seat, • a front passenger takes his/her weight off of the seat for a period of time, • a child or a small person occup ...

  • Ford 2006 Five Hundred - page 126

    • T urn the vehicle off and ask the person to place the seatback in the full upright position. • Have the person sit upright in the seat, centered on the seat cushion, with the person’ s legs comfortably extended. • Restart the vehicle and have the person remain in this position for about two minutes. This will allow the system to detect th ...

  • Ford 2006 Five Hundred - page 127

    passenger seat, the passenger airbag will be disabled. Even though the passenger airbag is disabled, the ⬙ pass airbag off ⬙ lamp may or may not be illuminated according to the table below . Objects Pass Airbag Off Indicator Light Passenger Airbag Small (i.e. 3 ring binder , small purse, bottled water) Unlit Disabled Medium (i.e. heavy briefcas ...

  • Ford 2006 Five Hundred - page 128

    In case there is a problem with the front passenger sensing system, the airbag readiness lamp in the instrument cluster will stay lit. If the airbag readiness lamp is lit, do the following: The driver and/or adult passengers should check for any objects that may be lodged underneath the front passenger seat or cargo interfering with the seat. If ob ...

  • Ford 2006 Five Hundred - page 129

    A difficulty with the system is indicated by one or more of the following: • The readiness light (same light for front and side airbag system) will either flash or stay lit. • The readiness light will not illuminate immediately after ignition is turned on. • A series of five beeps will be heard. The tone pattern will repeat periodically until ...

  • Ford 2006 Five Hundred - page 130

    automotive safety experts known as the Side Airbag T echnical W orking Group. These recommended testing procedures help reduce the risk of injuries related to the deployment of side airbags. The side airbag system consists of the following: • An inflatable nylon bag (airbag) with a gas generator concealed behind the outboard bolster of the driver ...

  • Ford 2006 Five Hundred - page 131

    Several air bag system components get hot after inflation. Do not touch them after inflation. If the side airbag has deployed, the airbag will not function again. The side airbag system (including the seat) must be inspected and serviced by an authorized dealer . If the airbag is not replaced, the unrepaired area will increase the risk of injury in ...

  • Ford 2006 Five Hundred - page 132

    All occupants of the vehicle including the driver should always wear their safety belts even when an airbag SRS and Safety Canopy 娂 system is provided. T o reduce risk of injury , do not obstruct or place objects in the deployment path of the inflatable Safety Canopy 娂 . How does the Safety Canopy 姟 system work? The design and development of ...

  • Ford 2006 Five Hundred - page 133

    The Safety Canopy 娂 system, in combination with seat belts, can help reduce the risk of severe injuries in the event of a significant side impact collision or rollover event. Children 12 years old and under should always be properly restrained in the second row seats. The Safety Canopy 娂 will not interfere with children restrained using a prope ...

  • Ford 2006 Five Hundred - page 134

    If the Safety Canopy 娂 system has deployed, the Safety Canopy 娂 will not function again unless replaced. The Safety Canopy 娂 system (including the A, B, and C pillar trim) must be inspected and serviced by an authorized dealer . If the Safety Canopy 娂 is not replaced, the unrepaired area will increase the risk of injury in a collision. Dete ...

  • Ford 2006 Five Hundred - page 135

    must put them in safety seats made especially for children. Many states require that children use approved booster seats until they are eight years old. Check your local and state or provincial laws for specific requirements regarding the safety of children in your vehicle. When possible, always place children under age 12 in the rear seat of your ...

  • Ford 2006 Five Hundred - page 136

    bend comfortably . Booster seats also may make the shoulder belt fit better and more comfortably , but make sure that the belt is approximately centered on the shoulder . When children should use booster seats Children need to use booster seats from the time they outgrow the toddler seat until they are big enough for the vehicle seat and lap/should ...

  • Ford 2006 Five Hundred - page 137

    • Those with a high back. If, with a backless booster seat, you cannot find a seating position that adequately supports your child’ s head, a high back booster seat would be a better choice. Either type can be used at any seating position equipped with lap/shoulder belts if your child is over 40 lb. (18 kg). Children and booster seats vary wide ...

  • Ford 2006 Five Hundred - page 138

    Move a child to a different seating location if the shoulder belt does not stay positioned on the shoulder during use. Follow all instructions provided by the manufacturer of the booster seat. Never put the shoulder belt under a child’ s arm or behind the back because it eliminates the protection for the upper part of the body and may increase th ...

  • Ford 2006 Five Hundred - page 139

    • Place seat back in upright position. • Put the safety belt in the automatic locking mode. Refer to Automatic locking mode. • LA TCH lower anchors are recommended for use by children up to 48 lb (22 kg) in a child restraint. T op tether anchors can be used for children up to 60 lb (27 kg) in a child restraint, and to provide upper torso rest ...

  • Ford 2006 Five Hundred - page 140

    1. Position the child safety seat in a seat with a combination lap and shoulder belt. 2. Pull down on the shoulder belt and then grasp the shoulder belt and lap belt together . 3. While holding the shoulder and lap belt portions together , route the tongue through the child seat according to the child seat manufacturer’ s instructions. Be sure th ...

  • Ford 2006 Five Hundred - page 141

    4. Insert the belt tongue into the proper buckle (the buckle closest to the direction the tongue is coming from) for that seating position until you hear a snap and feel the latch engage. Make sure the tongue is latched securely by pulling on it. 5. T o put the retractor in the automatic locking mode, grasp the shoulder portion of the belt and pull ...

  • Ford 2006 Five Hundred - page 142

    8. Allow the safety belt to retract to remove any slack in the belt. 9. Before placing the child in the seat, forcibly move the seat forward and back to make sure the seat is securely held in place. T o check this, grab the seat at the belt path and attempt to move it side to side and forward. There should be no more than one inch of movement for p ...

  • Ford 2006 Five Hundred - page 143

    2. Route the child safety seat tether strap over the back of the seat. For vehicles with adjustable head restraints, route the tether strap under the head restraint and between the head restraint posts, otherwise route the tether strap over the top of the seatback. 3. Locate the correct anchor for the selected seating position. 4. Open the tether a ...

  • Ford 2006 Five Hundred - page 144

    Attaching safety seats with LA TCH (Lower Anchors and T ethers for Children) attachments for child seat anchors Some child safety seats have two rigid or webbing mounted attachments that connect to two anchors at certain seating positions in your vehicle. This type of child seat eliminates the need to use seat belts to attach the child seat. For fo ...

  • Ford 2006 Five Hundred - page 145

    Attach LA TCH lower attachments of the child seat only to the anchors shown. If you install a child seat with rigid LA TCH attachments, do not tighten the tether strap enough to lift the child seat off the vehicle seat cushion when the child is seated in it. Keep the tether strap just snug without lifting the front of the child seat. Keeping the ch ...

  • Ford 2006 Five Hundred - page 146

    INFORMA TION ABOUT UNIFORM TIRE QUALITY GRADING New vehicles are fitted with tires that have a rating on them called T ire Quality Grades. The Quality grades can be found where applicable on the tire sidewall between tread shoulder and maximum section width. For example: • T readwear 200 T raction AA T emperature A These T ire Quality Grades are ...

  • Ford 2006 Five Hundred - page 147

    The traction grade assigned to this tire is based on straight-ahead braking traction tests, and does not include acceleration, cornering, hydroplaning or peak traction characteristics. T emperature A B C The temperature grades are A (the highest), B and C, representing the tire’ s resistance to the generation of heat and its ability to dissipate ...

  • Ford 2006 Five Hundred - page 148

    Increasing the inflation pressure beyond this pressure will not increase the tire’ s load carrying capability . • kPa: Kilopascal, a metric unit of air pressure. • PSI: Pounds per square inch, a standard unit of air pressure. • Cold inflation pressure: The tire pressure when the vehicle has been stationary and out of direct sunlight for an ...

  • Ford 2006 Five Hundred - page 149

    gauges may be inaccurate. Ford Motor Company recommends the use of a digital or dial-type tire pressure gauge rather than a stick-type tire pressure gauge. Use the recommended cold inflation pressure for optimum tire performance and wear . Under -inflation or over -inflation may cause uneven treadwear patterns. Under -inflation is the most common c ...

  • Ford 2006 Five Hundred - page 150

    T o check the pressure in your tire(s): 1. Make sure the tires are cool, meaning they are not hot from driving even a mile. Note: If you have to drive a distance to get air for your tire(s), check and record the tire pressure first and add the appropriate air pressure when you get to the pump. It is normal for tires to heat up and the air pressure ...

  • Ford 2006 Five Hundred - page 151

    internal damage to the tire is suspected, have the tire demounted and inspected in case it needs to be repaired or replaced. For your safety , tires that are damaged or show signs of excessive wear should not be used because they are more likely to blow out or fail. Tire wear When the tread is worn down to 1/16th of an inch (2 mm), tires must be re ...

  • Ford 2006 Five Hundred - page 152

    U.S. DOT T ire Identification Number (TIN): This begins with the letters “DOT” and indicates that the tire meets all federal standards. The next two numbers or letters are the plant code designating where it was manufactured, the next two are the tire size code and the last four numbers represent the week and year the tire was built. For exampl ...

  • Ford 2006 Five Hundred - page 153

    Tire and wheel alignment A bad jolt from hitting a curb or pothole can cause the front end of your vehicle to become misaligned or cause damage to your tires. If your vehicle seems to pull to one side when you’re driving, the wheels may be out of alignment. Have an authorized dealer check the wheel alignment periodically . Wheel misalignment in t ...

  • Ford 2006 Five Hundred - page 154

    • Rear Wheel Drive (RWD) vehicles/Four Wheel Drive (4WD)/ All Wheel Drive (A WD) vehicles (front tires at top of diagram) Sometimes irregular tire wear can be corrected by rotating the tires. Note: If your tires show uneven wear ask an authorized dealer to check for and correct any wheel misalignment, tire imbalance or mechanical problem involved ...

  • Ford 2006 Five Hundred - page 155

    Only use replacement tires and wheels that are the same size and type (such as P-metric versus L T -metric or all-season versus all-terrain) as those originally provided by Ford. Use of any tire or wheel not recommended by Ford can affect the safety and performance of your vehicle, which could result in an increased risk of loss of vehicle control, ...

  • Ford 2006 Five Hundred - page 156

    2. 215: Indicates the nominal width of the tire in millimeters from sidewall edge to sidewall edge. In general, the larger the number , the wider the tire. 3. 65: Indicates the aspect ratio which gives the tire’ s ratio of height to width. 4. R: Indicates a “radial” type tire. 5. 15: Indicates the wheel or rim diameter in inches. If you chang ...

  • Ford 2006 Five Hundred - page 157

    Letter rating Speed rating - mph (km/h) Y 186 mph (299 km/h) Note: For tires with a maximum speed capability over 149 mph (240 km/h), tire manufacturers sometimes use the letters ZR. For those with a maximum speed capability over 186 mph (299 km/h), tire manufacturers always use the letters ZR. 8. U.S. DOT T ire Identification Number (TIN): This be ...

  • Ford 2006 Five Hundred - page 158

    • T emperature: The temperature grades are A (the highest), B and C, representing the tire’ s resistance to the generation of heat and its ability to dissipate heat when tested under controlled conditions on a specified indoor laboratory test wheel. 13. Maximum Permissible Inflation Pressure: Indicates the tire manufacturers’ maximum permissi ...

  • Ford 2006 Five Hundred - page 159

    Information on “T” type tires “T” type tires have some additional information beyond those of “P” type tires; these differences are described below: T145/80D16 is an example of a tire size. Note: The temporary tire size for your vehicle may be different from this example. 1. T: Indicates a type of tire, designated by the T ire and Rim A ...

  • Ford 2006 Five Hundred - page 160

    The tires on your vehicle have all weather treads to provide traction in rain and snow . However , in some climates, you may need to use snow tires and chains. Follow these guidelines when using snow tires and chains: • Use only SAE class “S” cables or equivalent on the front axle for P215/60R17 equipped vehicles. SAE class “S” chains or ...

  • Ford 2006 Five Hundred - page 161

    V ehicle Curb W eight – is the weight of your new vehicle when you picked it up from your authorized dealer plus any aftermarket equipment. Payload – is the combined weight of cargo and passengers that the vehicle is carrying. The maximum payload for your vehicle can be found on the T ire Label on the B-Pillar or the edge of the driver’ s doo ...

  • Ford 2006 Five Hundred - page 162

    Example only: Cargo W eight – includes all weight added to the Base Curb W eight, including cargo and optional equipment. When towing, trailer tongue load or king pin weight is also part of cargo weight. 2006 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus) Tires, Wheels and Loading 162 ...

  • Ford 2006 Five Hundred - page 163

    GA W (Gross Axle W eight) – is the total weight placed on each axle (front and rear) – including vehicle curb weight and all payload. GA WR (Gross Axle W eight Rating) – is the maximum allowable weight that can be carried by a single axle (front or rear). These numbers are shown on the Safety Compliance Certification Label located on the B-Pi ...

  • Ford 2006 Five Hundred - page 164

    GVWR (Gross V ehicle W eight Rating) – is the maximum allowable weight of the fully loaded vehicle (including all options, equipment, passengers and cargo). The GVWR is shown on the Safety Compliance Certification Label located on the B-Pillar or the edge of the driver’ s door . The GVW must never exceed the GVWR. Exceeding the Safety Complianc ...

  • Ford 2006 Five Hundred - page 165

    mandatory options, no cargo (internal or external), a tongue load of 10–15% (conventional trailer) or king pin weight of 15–25% (fifth wheel trailer), and driver only (150 lb. [68 kg]). Consult your authorized dealer (or the RV and T railer T owing Guide provided by your authorized dealer) for more detailed information. Do not exceed the GVWR o ...

  • Ford 2006 Five Hundred - page 166

    capacity to carry you, 4 of your friends and all the golf bags? Y ou and four friends average 220 lb. (99 kg) each and the golf bags weigh approximately 30 lb. (13.5 kg) each. The calculation would be: 1400 – (5 x 220) – (5 x 30) = 1400 – 1100 – 150 = 150 lb. Y es, you have enough load capacity in your vehicle to transport four friends and ...

  • Ford 2006 Five Hundred - page 167

    T owing trailers beyond the maximum recommended gross trailer weight exceeds the limit of the vehicle and could result in engine damage, transmission damage, structural damage, loss of vehicle control, vehicle rollover and personal injury . Preparing to tow Use the proper equipment for towing a trailer and make sure it is properly attached to your ...

  • Ford 2006 Five Hundred - page 168

    authorized dealer or trailer rental agency for proper instructions and equipment for hooking up trailer lamps. Driving while you tow When towing a trailer: • T urn off the speed control. The speed control may shut off automatically when you are towing on long, steep grades. • Consult your local motor vehicle speed regulations for towing a trail ...

  • Ford 2006 Five Hundred - page 169

    In case of roadside emergency with a disabled vehicle, please refer to the Wrecker towing section in the Driving chapter . These guidelines are designed to ensure that your transmission is not damaged due to insufficient lubrication. Front Wheel Drive (FWD) vehicles: Do not tow your Front Wheel Drive vehicle with the front drive wheels on the groun ...

  • Ford 2006 Five Hundred - page 170

    STARTING Positions of the ignition 1. LOCK, locks the automatic transaxle gearshift lever and allows key removal. This position also shuts the engine and all electrical accessories off without locking the steering wheel. T o lock the steering wheel, remove the key then turn the steering wheel. 2. ACC, allows the electrical accessories such as the r ...

  • Ford 2006 Five Hundred - page 171

    Do not park, idle, or drive your vehicle in dry grass or other dry ground cover . The emission system heats up the engine compartment and exhaust system, which can start a fire. Do not start your vehicle in a closed garage or in other enclosed areas. Exhaust fumes can be toxic. Always open the garage door before you start the engine. See Guarding a ...

  • Ford 2006 Five Hundred - page 172

    • Make sure the gearshift lever is in P (Park). 3. T urn the key to 3 (RUN) without turning the key to 4 (ST ART). Some warning lights will briefly illuminate. See W arning lights and chimes in the Instrument Cluster chapter for more information regarding the warning lights. Starting the engine 1. T urn the key to 3 (RUN) without turning the key ...

  • Ford 2006 Five Hundred - page 173

    Guarding against exhaust fumes Carbon monoxide is present in exhaust fumes. T ake precautions to avoid its dangerous effects. If you smell exhaust fumes inside your vehicle, have your dealer inspect your vehicle immediately . Do not drive if you smell exhaust fumes. Important ventilating information If the engine is idling while the vehicle is stop ...

  • Ford 2006 Five Hundred - page 174

    keeping the brakes from locking. Noise from the ABS pump motor and brake pedal pulsation may be observed during ABS braking and the brake pedal may suddenly travel a little farther as soon as ABS braking is done and normal brake operation resumes. These are normal characteristics of the ABS and should be no reason for concern. Using ABS When hard b ...

  • Ford 2006 Five Hundred - page 175

    The BRAKE warning lamp in the instrument cluster illuminates and remains illuminated (when the ignition is turned ON) until the parking brake is released. Always set the parking brake fully and make sure that the gearshift is securely latched in P (Park). The parking brake is not recommended to stop a moving vehicle. However , if the normal brakes ...

  • Ford 2006 Five Hundred - page 176

    The T raction Control 娂 system will allow your vehicle to make better use of available traction on slippery surfaces. The system is a driver aid which makes your vehicle easier to handle primarily on snow and ice covered roads. During T raction Control 娂 operation the engine will not “rev-up” when you push further on the accelerator . This ...

  • Ford 2006 Five Hundred - page 177

    If the power steering system breaks down (or if the engine is turned off), you can steer the vehicle manually , but it takes more effort. If the steering wanders or pulls, check for: • an improperly inflated tire • uneven tire wear • loose or worn suspension components • loose or worn steering components • improper steering alignment AUTO ...

  • Ford 2006 Five Hundred - page 178

    3. Locate the white plastic cover at the front driver side of the gearshift lever . Locate the screw which attaches this cover and remove using a screwdriver . Remove the cover by tilting forward while pulling up and out of the gearshift assembly . 4. Locate the silver button in the driver side front area of the gearshift assembly . Press and hold ...

  • Ford 2006 Five Hundred - page 179

    decreasing engine RPM which causes a slight energy loss as the gears change. The gear changes can be felt by the driver . W ith the CVT , there is no energy transfer loss from shifting because there is no gear shifting up or down. Acceleration up to vehicle operating speed is smooth and continuous; uninterrupted by gear shifting. The same holds tru ...

  • Ford 2006 Five Hundred - page 180

    R (Reverse) W ith the gearshift lever in R (Reverse), the vehicle will move backward. Always come to a complete stop before shifting into and out of R (Reverse). N (Neutral) W ith the gearshift lever in N (Neutral), the vehicle can be started and is free to roll. Hold the brake pedal down while in this position. D (Drive) The normal driving positio ...

  • Ford 2006 Five Hundred - page 181

    • Move the gearshift lever and securely latch it in P (Park) Always set the parking brake fully and make sure the gearshift is latched in P (Park). T urn the ignition to the LOCK position and remove the key whenever you leave your vehicle. R (Reverse) W ith the gearshift lever in R (Reverse), the vehicle will move backward. Always come to a compl ...

  • Ford 2006 Five Hundred - page 182

    This system is not designed to prevent contact with small or moving objects. The system is designed to provide a warning to assist the driver in detecting large stationary objects to avoid damaging the vehicle. The system may not detect smaller objects, particularly those close to the ground. Certain add-on devices such as large trailer hitches, bi ...

  • Ford 2006 Five Hundred - page 183

    indicator light on the control will illuminate when the system is turned off. If the indicator light illuminates when the RSS is not turned off, it may indicate a failure in the RSS. Keep the RSS sensors (located on the rear bumper/fascia) free from snow , ice and large accumulations of dirt (do not clean the sensors with sharp objects). If the sen ...

  • Ford 2006 Five Hundred - page 184

    Basic operating principles • Drive slower in strong crosswinds which can affect the normal steering characteristics of your vehicle. • Be extremely careful when driving on pavement made slippery by loose sand, water , gravel, snow or ice. If your vehicle goes off the edge of the pavement • If your vehicle goes off the edge of the pavement, sl ...

  • Ford 2006 Five Hundred - page 185

    If the parking brake is fully released, but the brake warning lamp remains illuminated, the brakes may not be working properly . See your authorized dealer . Do not spin the wheels at over 35 mph (56 km/h). The tires may fail and injure a passenger or bystander . Emergency maneuvers • In an unavoidable emergency situation where a sudden sharp tur ...

  • Ford 2006 Five Hundred - page 186

    gear and drive steadily through the terrain. Apply the accelerator slowly and avoid spinning the wheels. If your vehicle is equipped with a 6–speed transmission: When driving at slow speeds in deep sand under high outside temperatures, use L (Low) gear when possible. L (Low) gear operation will maximize the engine and transmission cooling capabil ...

  • Ford 2006 Five Hundred - page 187

    “T read Lightly” is an educational program designed to increase public awareness of land-use regulations and responsibilities in our nations wilderness areas. Ford Motor Company joins the U.S. Forest Service and the Bureau of Land Management in encouraging you to help preserve our national forest and other public and private lands by “treadin ...

  • Ford 2006 Five Hundred - page 188

    Driving on snow and ice Note: Excessive tire slippage can cause transaxle damage. A WD vehicles have advantages over 2WD vehicles in snow and ice but can skid like any other vehicle. Should you start to slide while driving on snowy or icy roads, turn the steering wheel in the direction of the slide until you regain control. A void sudden applicatio ...

  • Ford 2006 Five Hundred - page 189

    DRIVING THROUGH WATER If driving through deep or standing water is unavoidable, proceed very slowly especially when the depth is not known. Never drive through water that is higher than the bottom of the wheel rims (for cars) or the bottom of the hubs (for trucks). When driving through water , traction or brake capability may be limited. Also, wate ...

  • Ford 2006 Five Hundred - page 190

    ROADSIDE ASSISTANCE Getting roadside assistance T o fully assist you should you have a vehicle concern, Ford Motor Company offers a complimentary roadside assistance program. This program is separate from the New V ehicle Limited W arranty . The service is available: • 24–hours, seven days a week • for the New V ehicle Limited W arranty perio ...

  • Ford 2006 Five Hundred - page 191

    U.S. Ford or Mercury vehicle customers who require roadside assistance, call 1–800–241–3673; Lincoln vehicle customers call 1–800–521–4140. Canadian customers who require roadside assistance, call 1–800–665–2006. If you need to arrange roadside assistance for yourself, Ford Motor Company will reimburse a reasonable amount. T o obt ...

  • Ford 2006 Five Hundred - page 192

    The fuel pump shut-off switch is located in the front passenger footwell area in the right upper corner . T o reset the switch: 1. T urn the ignition OFF . 2. Check the fuel system for leaks. 3. If no leaks are apparent, reset the switch by pushing in on the reset button. 4. T urn the ignition ON. 5. W ait a few seconds and return the key to OFF . ...

  • Ford 2006 Five Hundred - page 193

    Standard fuse amperage rating and color COLOR Fuse rating Mini fuses Standard fuses Maxi fuses Cartridge maxi fuses Fuse link cartridge 5A T an T an — — — 7.5A Brown Brown — — — 10A Red Red — — — 15A Blue Blue — — — 20A Y ellow Y ellow Y ellow Blue Blue 25A Natural Natural — — — 30A Green Green Green Pink Pink 40A — ...

  • Ford 2006 Five Hundred - page 194

    The fuses are coded as follows. Fuse/Relay Location Fuse Amp Rating Passenger Compartment Fuse Panel Description F1 20A High beams F2 15A Interior lamps (Courtesy and demand lamps), Delayed accessory (Power windows and moonroof) F3 25A Access/Security (Power door lock actuators, Decklid lock actuator , Decklid solenoid) F4 15A Adjustable pedal swit ...

  • Ford 2006 Five Hundred - page 195

    Fuse/Relay Location Fuse Amp Rating Passenger Compartment Fuse Panel Description F17 30A Rear defroster F18 10A PCM relay coil, Shifter Brake-Shift Interlock (BSI), Passive Anti-Theft System (P A TS) module, Fuel relay coil, Brake lamps, Center High-Mounted Stop Lamp (CHMSL) F19 10A Anti-lock Brake System (ABS)/T raction control module, All Wheel D ...

  • Ford 2006 Five Hundred - page 196

    If the battery has been disconnected and reconnected, refer to the Battery section of the Maintenance and Specifications chapter . The high-current fuses are coded as follows: Fuse/Relay Location Fuse Amp Rating Power Distribution Box Description 1 80A* SJB, SJB fuses 1, 2, 3, 4, 5, 8 and 12 2 — Not used 3 30A* Front wiper , Front washer 4 — No ...

  • Ford 2006 Five Hundred - page 197

    Fuse/Relay Location Fuse Amp Rating Power Distribution Box Description 13 — Not used 14 — Not used 15 15A** T raction Control Module (TCM) 16 20A** Power point (Console) 17 10A** Alternator 18 40A* Logic feed to SJB, SJB solid state devices 19 — Not used 20 40A* Rear defroster 21 30A* Power seat motors (passenger) 22 30A* Heated seat modules ...

  • Ford 2006 Five Hundred - page 198

    Fuse/Relay Location Fuse Amp Rating Power Distribution Box Description 40 1A Diode A/C clutch 41 1 ⁄ 2 ISO relay Fog lamps 42 — Not used 43 1 ⁄ 2 ISO relay A/C clutch 44 1 ⁄ 2 ISO relay Fuel pump driver module, Fuel pump 45 — Not used 46 5A** Heated Positive Crankcase V entilation (PCV) valve 47 — Not used 48 10A** TCM, EVMV , Canister ...

  • Ford 2006 Five Hundred - page 199

    The use of tire sealants is not recommended and may damage your tires. Dissimilar spare tire/wheel information Failure to follow these guidelines could result in an increased risk of loss of vehicle control, injury or death. If you have a dissimilar spare tire/wheel, then it is intended for temporary use only . This means that if you need to use it ...

  • Ford 2006 Five Hundred - page 200

    • Ground clearance and parking at curbs • W inter weather driving capability • W et weather driving capability For vehicles equipped with 4WD, it is not recommended that the vehicle be operated in 4WD modes with a temporary emergency spare tire. If 4WD operation is necessary , do not operate above speeds of 10 mph (16 km/h) or for distances a ...

  • Ford 2006 Five Hundred - page 201

    Removing the spare tire and jack 1. Lift the trunk cargo cover , and remove the wing nut that secures the spare tire by turning it counterclockwise. 2. Lift and remove the spare tire from the trunk. 3. Remove the second wing nut that secures the jack retention bracket by turning it counterclockwise, remove the jack kit from the vehicle. 4. Remove t ...

  • Ford 2006 Five Hundred - page 202

    T o help prevent the vehicle from moving when you change a tire, be sure to place the transaxle in P (Park), set the parking brake and block (in both directions) the wheel that is diagonally opposite (other side and end of the vehicle) to the tire being changed. If the vehicle slips off the jack, you or someone else could be seriously injured. 2. P ...

  • Ford 2006 Five Hundred - page 203

    4. Put the jack in the jack notch next to the tire you are changing. T urn the jack handle clockwise until the wheel is completely off the ground. 5. Remove the lug nuts with the lug wrench. 6. Replace the flat tire with the spare tire, making sure the valve stem is facing outward. Reinstall the lug nuts until the wheel is snug against the hub. Do ...

  • Ford 2006 Five Hundred - page 204

    Stowing the tire and jack 1. Fully collapse the jack, fold the lug wrench socket into the handle and place the jack and wrench into the felt bag as shown. T ake care to position the jack as shown to ensure that the locating holes in the jack base can be placed on the locating tabs of the jack mounting bracket in the spare tire tub. 2. Securely clos ...

  • Ford 2006 Five Hundred - page 205

    If you are stowing the temporary spare tire, place the tire over the jack and secure it with the large wing nut. WHEEL LUG NUT TORQUE SPECIFICATIONS Retighten the lug nuts to the specified torque at 100 miles (160 km) after any wheel disturbance (tire rotation, changing a flat tire, wheel removal, etc.). Bolt size Wheel lug nut torque* lb.ft. N • ...

  • Ford 2006 Five Hundred - page 206

    Do not attempt to push-start your vehicle. Automatic transmissions do not have push-start capability; doing so may damage the catalytic converter . Preparing your vehicle When the battery is disconnected or a new battery is installed, the transmission must relearn its shift strategy . As a result, the transmission may have firm and/or soft shifts. ...

  • Ford 2006 Five Hundred - page 207

    2. Connect the other end of the positive (+) cable to the positive (+) terminal of the assisting battery . 3. Connect the negative (-) cable to the negative (-) terminal of the assisting battery . + – + – + – + – 2006 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus) Roadside Emergencies 207 ...

  • Ford 2006 Five Hundred - page 208

    4. Make the final connection of the negative (-) cable to an exposed metal part of the stalled vehicle’ s engine, away from the battery and the carburetor/fuel injection system. Do not use fuel lines, engine rocker covers or the intake manifold as grounding points. Do not connect the end of the second cable to the negative (-) terminal of the bat ...

  • Ford 2006 Five Hundred - page 209

    Removing the jumper cables Remove the jumper cables in the reverse order that they were connected. 1. Remove the jumper cable from the ground metal surface. Note: In the illustrations, lightning bolts are used to designate the assisting (boosting) battery . 2. Remove the jumper cable on the negative (-) connection of the booster vehicle’ s batter ...

  • Ford 2006 Five Hundred - page 210

    3. Remove the jumper cable from the positive (+) terminal of the booster vehicle’ s battery . 4. Remove the jumper cable from the positive (+) terminal of the disabled vehicle’ s battery . After the disabled vehicle has been started and the jumper cables removed, allow it to idle for several minutes so the engine computer can relearn its idle c ...

  • Ford 2006 Five Hundred - page 211

    WRECKER TOWING If you need to have your vehicle towed, contact a professional towing service or , if you are a member of a roadside assistance program, your roadside assistance service provider . It is recommended that your vehicle be towed with a wheel lift or flatbed equipment. Do not tow with a slingbelt. Ford Motor Company has not approved a sl ...

  • Ford 2006 Five Hundred - page 212

    In case of a roadside emergency with a disabled vehicle (without access to wheel dollies, flatbed transport vehicle or a car hauling trailer) your vehicle can be flat towed (all wheels on the ground) only under the following conditions: • The ambient temperature is above 32°F (0°C) • Place the automatic transaxle in N (Neutral). • DO NOT ex ...

  • Ford 2006 Five Hundred - page 213

    GETTING THE SERVICES YOU NEED At home Y ou must take your Ford vehicle to an authorized dealer for warranty repairs. While any authorized dealer handling your vehicle line will provide warranty service, we recommend you return to your selling authorized dealer who wants to ensure your continued satisfaction. Please note that certain warranty repair ...

  • Ford 2006 Five Hundred - page 214

    In Canada: Customer Relationship Centre Ford Motor Company of Canada, Limited P .O. Box 2000 Oakville, Ontario L6J 5E4 1-800-565-3673 (FORD) www .ford.ca If you own a Lincoln vehicle and are away from home when your vehicle needs service, or if you need more help than the authorized dealer could provide, after following the steps described above, c ...

  • Ford 2006 Five Hundred - page 215

    In some states (in the U.S.) you must directly notify Ford in writing before pursuing remedies under your state’ s warranty laws. Ford is also allowed a final repair attempt in some states. In the United States, a warranty dispute must be submitted to the Dispute Settlement Board before taking action under the Magnuson-Moss W arranty Act, or to t ...

  • Ford 2006 Five Hundred - page 216

    THE BETTER BUSINESS BUREAU (BBB) AUTO LINE PROGRAM (U.S. ONLY) Y our satisfaction is important to Ford Motor Company and to your dealer . Experience has shown that our customers have been very successful in achieving satisfaction by following the three-step procedure outlined on the front page of the W arranty Guide. However , if your warranty conc ...

  • Ford 2006 Five Hundred - page 217

    authorized dealer to resolve a factory-related vehicle service concern have been unsatisfactory , Ford of Canada participates in an impartial third party mediation/arbitration program administered by the Canadian Motor V ehicle Arbitration Plan (CAMV AP). The CAMV AP program is a straight-forward and relatively speedy alternative to resolve a disag ...

  • Ford 2006 Five Hundred - page 218

    GETTING ASSIST ANCE OUTSIDE THE U.S. AND CANADA Before exporting your vehicle to a foreign country , contact the appropriate foreign embassy or consulate. These officials can inform you of local vehicle registration regulations and where to find unleaded fuel. If you cannot find unleaded fuel or can only get fuel with an anti-knock index lower than ...

  • Ford 2006 Five Hundred - page 219

    For a free publication catalog, order toll free: 1-800-782-4356 Monday-Friday 8:00 a.m. - 6:00 p.m. EST Helm, Incorporated can also be reached by their website: www .helminc.com. (Items in this catalog may be purchased by credit card, check or money order .) Obtaining a French owner ’ s guide French Owner’ s Guides can be obtained from your aut ...

  • Ford 2006 Five Hundred - page 220

    W ASHING THE EXTERIOR W ash your vehicle regularly with cool or lukewarm water and a neutral pH shampoo, such as Motorcraft Detail W ash (ZC-3–A), which is available from your authorized dealer . • Never use strong household detergents or soap, such as dish washing or laundry liquid. These products can discolor and spot painted surfaces. • Ne ...

  • Ford 2006 Five Hundred - page 221

    • Remove particles such as bird droppings, tree sap, insect deposits, tar spots, road salt and industrial fallout before repairing paint chips. • Always read the instructions before using the products. ALUMINUM WHEELS AND WHEEL COVERS Aluminum wheels and wheel covers are coated with a clearcoat paint finish. In order to maintain their shine: ? ...

  • Ford 2006 Five Hundred - page 222

    • 3.0L Duratec engine • Never wash or rinse the engine while it is running; water in the running engine may cause internal damage. PLASTIC (NON-PAINTED) EXTERIOR PARTS Use only approved products to clean plastic parts. These products are available from your authorized dealer . • For routine cleaning, use Motorcraft Detail W ash (ZC-3–A). ? ...

  • Ford 2006 Five Hundred - page 223

    • The wiper blades can be cleaned with isopropyl (rubbing) alcohol or Motorcraft Premium W indshield W asher Concentrate (ZC-32–A), available from your authorized dealer . This washer fluid contains special solution in addition to alcohol which helps to remove the hot wax deposited on the wiper blade and windshield from automated car wash facil ...

  • Ford 2006 Five Hundred - page 224

    • Remove light stains and soil with Motorcraft Professional Strength Carpet & Upholstery Cleaner (ZC-54). • If grease or tar is present on the material, spot-clean the area first with Motorcraft Spot and Stain Remover (ZC-14). • If a ring forms on the fabric after spot cleaning, clean the entire area immediately (but do not oversaturate) ...

  • Ford 2006 Five Hundred - page 225

    quality products have been specifically engineered to fulfill your automotive needs; they are custom designed to complement the style and appearance of your vehicle. Each product is made from high quality materials that meet or exceed rigid specifications. For best results, use the following products or products of equivalent quality: Motorcraft Bu ...

  • Ford 2006 Five Hundred - page 226

    SERVICE RECOMMENDATIONS T o help you service your vehicle: • W e highlight do-it-yourself items in the engine compartment for easy location. • W e provide scheduled maintenance information which makes tracking routine service easy . If your vehicle requires professional service, your authorized dealer can provide the necessary parts and service ...

  • Ford 2006 Five Hundred - page 227

    OPENING THE HOOD 1. Inside the vehicle, pull the hood release handle located under the bottom of the instrument panel near the steering column. 2. Go to the front of the vehicle and release the auxiliary latch that is located under the front center of the hood. 3. Lift the hood and support it with the prop rod. Lift the prop rod by the sleeve and n ...

  • Ford 2006 Five Hundred - page 228

    IDENTIFYING COMPONENTS IN THE ENGINE COMPARTMENT 3.0L DOHC V6 DURATEC ENGINE 1. Engine coolant reservoir 2. Power steering fluid reservoir 3. Engine coolant bleed plug 4. Brake fluid reservoir 5. Battery 6. Power distribution box 7. Air filter assembly 8. 6–speed automatic transmission fluid dipstick (if equipped) 9. Engine oil dipstick 10. Engin ...

  • Ford 2006 Five Hundred - page 229

    WINDSHIELD WASHER FLUID Add fluid to fill the reservoir if the level is low . In very cold weather , do not fill the reservoir completely . Only use a washer fluid that meets Ford specification WSB-M8B16–A2. Do not use any special washer fluid such as windshield water repellent type fluid or bug wash. They may cause squeaking, chatter noise, stre ...

  • Ford 2006 Five Hundred - page 230

    T o prolong the life of the wiper blades, it is highly recommended to scrape off the ice on the windshield before turning on the wipers. The layer of ice has many sharp edges and can damage the micro edge of the wiper rubber element. ENGINE OIL Checking the engine oil Refer to the scheduled maintenance information for the appropriate intervals for ...

  • Ford 2006 Five Hundred - page 231

    • If the oil level is within this range, the oil level is acceptable. DO NOT ADD OIL. • If the oil level is below this mark, engine oil must be added to raise the level within the normal operating range. • If required, add engine oil to the engine. Refer to Adding engine oil in this chapter . • Do not overfill the engine with oil. Oil level ...

  • Ford 2006 Five Hundred - page 232

    4. Install the indicator and ensure it is fully seated. 5. Fully install the engine oil filler cap by turning the filler cap clockwise until it stops. T o avoid possible oil loss, DO NOT operate the vehicle with the engine oil level indicator and/or the engine oil filler cap removed. Engine oil and filter recommendations Look for this certification ...

  • Ford 2006 Five Hundred - page 233

    BATTERY Y our vehicle is equipped with a Motorcraft maintenance-free battery which normally does not require additional water during its life of service. However , for severe usage or in high temperature climates, check the battery electrolyte level. Refer to scheduled maintenance information for the service interval schedules. Keep the electrolyte ...

  • Ford 2006 Five Hundred - page 234

    When lifting a plastic-cased battery , excessive pressure on the end walls could cause acid to flow through the vent caps, resulting in personal injury and/or damage to the vehicle or battery . Lift the battery with a battery carrier or with your hands on opposite corners. Keep batteries out of reach of children. Batteries contain sulfuric acid. A ...

  • Ford 2006 Five Hundred - page 235

    • Always dispose of automotive batteries in a responsible manner . Follow your local authorized standards for disposal. Call your local authorized recycling center to find out more about recycling automotive batteries. ENGINE COOLANT Checking engine coolant The concentration and level of engine coolant should be checked at the intervals listed in ...

  • Ford 2006 Five Hundred - page 236

    When the engine is cold, check the level of the engine coolant in the reservoir . • The engine coolant should be at the “FULL COLD” level or within the “COLD FILL RANGE” as listed on the engine coolant reservoir (depending upon application). • Refer to scheduled maintenance information for service interval schedules. • Be sure to read ...

  • Ford 2006 Five Hundred - page 237

    Do not add engine coolant when the engine is hot. Steam and scalding liquids released from a hot cooling system can burn you badly . Also, you can be burned if you spill coolant on hot engine parts. Do not put engine coolant in the windshield washer fluid container . If sprayed on the windshield, engine coolant could make it difficult to see throug ...

  • Ford 2006 Five Hundred - page 238

    1. Before you begin, turn the engine off and let it cool. 2. When the engine is cool, wrap a thick cloth around the coolant pressure relief cap on the coolant reservoir (an opaque plastic bottle). Slowly turn cap counterclockwise (left) until pressure begins to release. 3. Step back while the pressure releases. 4. When you are sure that all the pre ...

  • Ford 2006 Five Hundred - page 239

    8. Add coolant/water mixture through the thermostat housing opening until full at housing opening. 9. Install the thermostat housing bleed plug. Install metal pin by pushing into the slot. After any coolant has been added, check the coolant concentration, refer to Checking engine coolant section. If the concentration is not 50/50 (protection to – ...

  • Ford 2006 Five Hundred - page 240

    If you have to add more than 1.0 quart (1.0 liter) of engine coolant per month, have your authorized dealer check the engine cooling system. Y our cooling system may have a leak. Operating an engine with a low level of coolant can result in engine overheating and possible engine damage. Recycled engine coolant Ford Motor Company does NOT recommend ...

  • Ford 2006 Five Hundred - page 241

    • Decreased engine coolant concentrations below 40% will decrease the freeze protection characteristics of the engine coolant and may cause engine damage. • Refer to the chart on the coolant container to ensure the coolant concentration in your vehicle will provide adequate protection at the temperatures in which you drive. V ehicles driven yea ...

  • Ford 2006 Five Hundred - page 242

    Observe the following guidelines when handling automotive fuel: • Extinguish all smoking materials and any open flames before refueling your vehicle. • Always turn off the vehicle before refueling. • Automotive fuels can be harmful or fatal if swallowed. Fuel such as gasoline is highly toxic and if swallowed can cause death or permanent injur ...

  • Ford 2006 Five Hundred - page 243

    Refueling Fuel vapor burns violently and a fuel fire can cause severe injuries. T o help avoid injuries to you and others: • Read and follow all the instructions on the pump island; • T urn off your engine when you are refueling; • Do not smoke if you are near fuel or refueling your vehicle; • Keep sparks, flames and smoking materials away ...

  • Ford 2006 Five Hundred - page 244

    If you must replace the fuel filler cap, replace it with a fuel filler cap that is designed for your vehicle. The customer warranty may be void for any damage to the fuel tank or fuel system if the correct genuine Ford or Motorcraft fuel filler cap is not used. The fuel system may be under pressure. If the fuel filler cap is venting vapor or if you ...

  • Ford 2006 Five Hundred - page 245

    Octane recommendations Y our vehicle is designed to use “Regular” unleaded gasoline with pump (R+M)/2 octane rating of 87. W e do not recommend the use of gasolines labeled as “Regular” that are sold with octane ratings of 86 or lower in high altitude areas. Do not be concerned if your engine sometimes knocks lightly . However , if it knock ...

  • Ford 2006 Five Hundred - page 246

    • The indicator may come on. For more information on the “Check Engine” or the “Service engine soon” indicator , refer to W arning lights and chimes in the Instrument Cluster chapter . ESSENTIALS OF GOOD FUEL ECONOMY Measuring techniques Y our best source of information about actual fuel economy is you, the driver . Y ou must gather infor ...

  • Ford 2006 Five Hundred - page 247

    • Have the vehicle loading and distribution the same every time. Y our results will be most accurate if your filling method is consistent. Calculating fuel economy 1. Fill the fuel tank completely and record the initial odometer reading (in miles or kilometers). 2. Each time you fill the tank, record the amount of fuel added (in gallons or liters ...

  • Ford 2006 Five Hundred - page 248

    • Revving the engine before turning it off may reduce fuel economy . • Using the air conditioner or defroster may reduce fuel economy . • Y ou may want to turn off the speed control in hilly terrain if unnecessary shifting between third and fourth gear occurs. Unnecessary shifting of this type could result in reduced fuel economy . • W armi ...

  • Ford 2006 Five Hundred - page 249

    • Close windows for high speed driving. EP A window sticker Every new vehicle should have the EP A window sticker . Contact your authorized dealer if the window sticker is not supplied with your vehicle. The EP A window sticker should be your guide for the fuel economy comparisons with other vehicles. It is important to note the box in the lower ...

  • Ford 2006 Five Hundred - page 250

    Exhaust leaks may result in entry of harmful and potentially lethal fumes into the passenger compartment. Do not make any unauthorized changes to your vehicle or engine. By law , vehicle owners and anyone who manufactures, repairs, services, sells, leases, trades vehicles, or supervises a fleet of vehicles are not permitted to intentionally remove ...

  • Ford 2006 Five Hundred - page 251

    the description in the W arning lights and chimes section of the Instrument Cluster chapter . Y our vehicle may not pass the I/M test with the indicator on. If the vehicle’ s powertrain system or its battery has just been serviced, the on-board diagnostics system is reset to a “not ready for I/M test” condition. T o ready the on-board diagnos ...

  • Ford 2006 Five Hundred - page 252

    BRAKE FLUID The fluid level will drop slowly as the brakes wear , and will rise when the brake components are replaced. Fluid levels between the “MIN” and “MAX” lines are within the normal operating range; there is no need to add fluid. If the fluid levels are outside of the normal operating range the performance of your brake system could ...

  • Ford 2006 Five Hundred - page 253

    If your transaxle does not engage normally , do not attempt to drive. The vehicle should be towed to your authorized dealer for evaluation. Checking 6–speed automatic transmission fluid (if equipped) Refer to your scheduled maintenance information for scheduled intervals for fluid checks and changes. Y our transaxle does not consume fluid. Howeve ...

  • Ford 2006 Five Hundred - page 254

    Checking automatic transmission fluid at cool temperature (32°F-81°F [17°C-27°C]) If a fluid check is necessary at a low fluid temperature (32°F-81°F [17°C-27°C]), perform the check using the cold range on the dipstick. However , the fluid must be re-checked at the proper fluid temperature. Low fluid level Do not drive the vehicle if the fl ...

  • Ford 2006 Five Hundred - page 255

    If an overfill occurs, excess fluid should be removed by an authorized dealer . An overfill condition of transmission fluid may cause shift and/or engagement concerns and/or possible damage. Do not use supplemental transmission fluid additives, treatments or cleaning agents. The use of these materials may affect transmission operation and result in ...

  • Ford 2006 Five Hundred - page 256

    REFILL CAPACITIES Fluid Ford Part Name Application Capacity Brake fluid Motorcraft High Performance DOT 3 Motor V ehicle Brake Fluid All Between MAX and MIN on reservoir Engine coolant 1 Motorcraft Premium Gold Engine Coolant (yellow-colored) 3.0L engine 11.6 quarts (11.0L) Engine oil (includes filter change) 2 Motorcraft SAE 5W -20 Premium Synthet ...

  • Ford 2006 Five Hundred - page 257

    Fluid Ford Part Name Application Capacity Automatic transaxle Motorcraft Continuously V ariable Chain T ype T ransmission Fluid 3 CVT automatic transaxle 10.0 quarts (9.5L) 4 Premium Automatic T ransmission Fluid 3 6–speed automatic transaxle 7.4 quarts (7.0L) 4 Rear Axle Lubricant Motorcraft SAE 80W -90 Premium Rear Axle Lubricant A WD 1.5 pints ...

  • Ford 2006 Five Hundred - page 258

    4 Approximate dry fill capacity . Actual amount may vary during fluid changes. LUBRICANT SPECIFICATIONS Items Ford Part Name or equivalent Ford Part Number Ford Specification Brake fluid Motorcraft High Performance DOT 3 Motor V ehicle Brake Fluid PM-1 ESA-M6C25-A Door latch, hood latch, auxiliary hood latch, seat tracks, trunk and liftgate latches ...

  • Ford 2006 Five Hundred - page 259

    Items Ford Part Name or equivalent Ford Part Number Ford Specification Coupler fluid V olvo T ransmission Oil, Clutch 1161641 — Power T ransfer Unit Motorcraft SAE 75W -90 Fuel Efficient High Performance Rear Axle Lubricant XY -75W -90–QFEHP — Engine oil Motorcraft SAE 5W -20 Premium Synthetic Blend Motor Oil (US) Motorcraft SAE 5W -20 Super ...

  • Ford 2006 Five Hundred - page 260

    ENGINE DATA Engine 3.0L-DOHC V6 engine Displacement 183 cubic inches Required fuel 87 octane Firing order 1–4–2–5–3–6 Spark plug gap (0.052–0.056 inch) 1.32–1.42 mm Ignition system Coil on plug Compression ratio 10.0:1 ENGINE DRIVEBELT ROUTING • 3.0L V6 Engine V EHICLE DIMENSIONS V ehicle dimensions Inches (mm) (1) Overall length 20 ...

  • Ford 2006 Five Hundred - page 261

    5 2 3 2006 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus) Maintenance and Specifications 261 ...

  • Ford 2006 Five Hundred - page 262

    IDENTIFYING YOUR VEHICLE Certification label The National Highway T raffic Safety Administration Regulations require that a Safety Compliance Certification Label be affixed to a vehicle and prescribe where the Safety Compliance Certification Label may be located. The Safety Compliance Certification Label is located on the structure by the trailing ...

  • Ford 2006 Five Hundred - page 263

    The V ehicle Identification Number (VIN) contains the following information: 1. W orld manufacturer identifier 2. Brake type and Gross V ehicle W eight Rating (GVWR) 3. V ehicle line, series, body type 4. Engine type 5. Check digit 6. Model year 7. Assembly plant 8. Production sequence number T RANSMISSION/T RANSAXLE CODE DESIGNATIONS Y ou can find ...

  • Ford 2006 Five Hundred - page 264

    GENUINE FORD ACCESSORIES FOR YOUR VEHICLE A wide selection of Genuine Ford Accessories are available for your vehicle through your local authorized Ford or Ford of Canada dealer . These quality accessories have been specifically engineered to fulfill your automotive needs; they are custom designed to complement the style and aerodynamic appearance ...

  • Ford 2006 Five Hundred - page 265

    Interior style Electrochromic compass/temperature/Homelink options Floor mats Scuff plates Lifestyle Engine block heaters Interior cargo organization and management Smoker’ s pack Peace of mind First aid kits Full vehicle covers Highway safety kits Keyless entry keypads Locking gas cap Mobile-Ease 娂 hands free communication system Remote start ...

  • Ford 2006 Five Hundred - page 266

    • T o avoid interference with other vehicle functions, such as anti-lock braking systems, amateur radio users who install radios and antennas onto their vehicle should not locate the Amateur Radio Antennas in the area of the driver’ s side hood. • Electrical or electronic accessories or components that are added to the vehicle by the authoriz ...

  • Ford 2006 Five Hundred - page 267

    A Accessory delay .......................... 63 Air cleaner filter ....................... 255 Air conditioning ....................42, 44 Airbag supplemental restraint system ................120–121, 129, 131 and child safety seats ............ 122 description .............. 121, 129, 131 disposal .................................... 134 driver ...

  • Ford 2006 Five Hundred - page 268

    waxing ..................................... 220 wheels ...................................... 221 wiper blades ............................ 222 Climate control (see Air conditioning or Heating) ......42, 44 Clock ............................................ 60 Clock adjust 6-CD in dash .............................21 Compass, electronic set zone a ...

  • Ford 2006 Five Hundred - page 269

    specifications .................. 258, 260 Exhaust fumes .......................... 173 F Fluid capacities ......................... 256 Foglamps ..................................... 49 Four -Wheel Drive vehicles driving off road ....................... 183 Fuel ............................................ 241 calculating fuel economy ............ ...

  • Ford 2006 Five Hundred - page 270

    K Keyless entry system ................. 92 autolock ..................................... 94 Keys positions of the ignition ......... 170 L Lamps autolamp system ....................... 48 bulb replacement specifications chart .................. 52 daytime running light ...............50 fog lamps ................................... 49 headlamps . ...

  • Ford 2006 Five Hundred - page 271

    Relays ........................................ 192 Remote entry system ................. 87 illuminated entry ................ 91–92 opening the trunk ..................... 88 Reverse sensing system ........... 181 Roadside assistance .................. 190 S Safety Belt Maintenance ..........119 Safety belts (see Safety restraints) ............ ...

  • Ford 2006 Five Hundred - page 272

    T ransaxle fluid, checking and adding (automatic) ..................... 252–253 fluid, refill capacities .............. 256 lubricant specifications .......... 260 T ransmission ............................. 177 brake-shift interlock (BSI) .... 177 lubricant specifications .......... 258 T runk ........................................... 85 remot ...

Manufacturer Ford Category Automobile

Documents that we receive from a manufacturer of a Ford 2006 Five Hundred can be divided into several groups. They are, among others:
- Ford technical drawings
- 2006 Five Hundred manuals
- Ford product data sheets
- information booklets
- or energy labels Ford 2006 Five Hundred
All of them are important, but the most important information from the point of view of use of the device are in the user manual Ford 2006 Five Hundred.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Ford 2006 Five Hundred, service manual, brief instructions and user manuals Ford 2006 Five Hundred. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Ford 2006 Five Hundred.

Similar manuals

A complete manual for the device Ford 2006 Five Hundred, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Ford 2006 Five Hundred by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Ford 2006 Five Hundred.

A complete Ford manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Ford 2006 Five Hundred - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Ford 2006 Five Hundred, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Ford 2006 Five Hundred, that we can find in the current document
3. Tips how to use the basic functions of the device Ford 2006 Five Hundred - which should help us in our first steps of using Ford 2006 Five Hundred
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Ford 2006 Five Hundred
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Ford 2006 Five Hundred in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Ford 2006 Five Hundred?

Use the form below

If you did not solve your problem by using a manual Ford 2006 Five Hundred, ask a question using the form below. If a user had a similar problem with Ford 2006 Five Hundred it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (1)

teodoro merchant

Tengo una Radio TK8102h conectado a un repetidor, pero cuando Tx no me oyen, y Rx entrecortado. podrian ayudamerme a solucionar el problema?