English dropdown-ico

Manual Lincoln Electric Impinger Conveyorized Oven 3255

20 pages 0.42 mb
Download

Go to site of 20

Summary
  • Lincoln Electric Impinger Conveyorized Oven 3255 - page 1

    Lincoln Foodservice Products, LLC 1111 North Hadley Road Fort Wayne, Indiana 46804 United States of America Technical Suppor t Hotline: ( 800) 678-951 1 Telephone: (260) 459-8200 www.lincolnfp. com operator manual This document includes : • Safety Notices • Spe cific atio ns • Installation Instructions • Operating Instructi ons • Cleaning ...

  • Lincoln Electric Impinger Conveyorized Oven 3255 - page 2

    Impinger 3255 – Operator Manual 2 IMPORTANT WARNING AND SAFETY INFORMATION · Obtain from your local gas provider and post in a prom inent location instructio ns to be followed in the event gas odors are detected. · It is required that the oven be placed under a ventilati on hood to provide for adequate air supply and ventilation. · Minimum cle ...

  • Lincoln Electric Impinger Conveyorized Oven 3255 - page 3

    Impinger 3255 – Operator Manual 3 PURCHASER’S RESPONSIBILITY It is the responsibilit y of the purchaser: 1. To see that the gas and electric service s for the oven are installed on site in accordance with the manufacturers specification. 2. To unload, uncrate, and install the oven in its proper location; in accordance with this installation / o ...

  • Lincoln Electric Impinger Conveyorized Oven 3255 - page 4

    Impinger 3255 – Operator Manual 4 ***NOTE: For proper operation, the gas valve requires a nominal inlet pressure of 7 inches H 2 O column for natural gas and 11 inche s of H 2 O column for L.P. gas. A minimum inlet pressure of 1.0 inch of H 2 O above the manifold setting (NAT. manifold 3.5” H 2 O, L.P. manifold 10” H 2 O) must be maintained w ...

  • Lincoln Electric Impinger Conveyorized Oven 3255 - page 5

    Impinger 3255 – Operator Manual 5 EXTERIOR DIMENSIONS ...

  • Lincoln Electric Impinger Conveyorized Oven 3255 - page 6

    Impinger 3255 – Operator Manual 6 SPACING The oven must have 6 inches (152 mm) of clearance from combustible surfaces. In case other equi pment is located on the right side of oven, a minimum clearan ce of 24 inches (609 mm) is required from that equipment. FOR ALL OVENS: A 24-inch (609 mm ) clearance at the rear of the oven must be obtai nable f ...

  • Lincoln Electric Impinger Conveyorized Oven 3255 - page 7

    Impinger 3255 – Operator Manual 7 CANOPY VENTILATION RECOMMENDATIONS – DOUBLE DECK OR SINGLE UNIT * AFF = Above Finished Floor SMOKE CANDLE TEST – VENTILATION SYSTEM VERIFICATION OVEN SET-UP FOR THIS TEST: 1. This test is to be done on the bottom oven of a multiple oven system, or a single oven. 2. The conveyor must be off. 3. The oven temper ...

  • Lincoln Electric Impinger Conveyorized Oven 3255 - page 8

    Impinger 3255 – Operator Manual 8 UNLOADING When the oven arrives it should consist of: 1. A crate containing oven body, c onveyor, fingers, crumb pans, and pan stops. (Some mod els may have the conveyor pac ked separately.) 2. A package containing the stand and top. It is recommended that you have a material-handlin g device available to unload. ...

  • Lincoln Electric Impinger Conveyorized Oven 3255 - page 9

    Impinger 3255 – Operator Manual 9 CODE REFERENCE GAS CODE REFERENCE Safe and satisfactory operation of this ov en depends to a great extent upon its proper in stallation, and it should be installed, as applicable in accordance wit h the Natio nal Fuel Gas Codes, ANSI Z223.1/NFPA 54, latest versi on, Manufacturers’ installation Instructions a nd ...

  • Lincoln Electric Impinger Conveyorized Oven 3255 - page 10

    Impinger 3255 – Operator Manual 10 STAND AND FINGER ASSEMBLY 4. Before installing the retaining brackets in the oven(s), be sure all of the packing material is removed from the plenum shroud. Install the finger retaining brackets by placing them upside down and hooking the retaining pin as shown above. 5. Rotate the finger brackets until the notc ...

  • Lincoln Electric Impinger Conveyorized Oven 3255 - page 11

    Impinger 3255 – Operator Manual 11 FINGER HOUSING BAFFLE PLATE ADJUSTEMENTS The finger housing has a b affle mounted inside to balance t he air flow to the rear and front of the oven. If the product is cooking more or less in the rear of the oven than in the front, it is possible the finger housing baffle need s to be adjusted. If it is deemed ne ...

  • Lincoln Electric Impinger Conveyorized Oven 3255 - page 12

    Impinger 3255 – Operator Manual 12 PROGRAMMING OVEN START-UP INSTRUCTIONS 1. Turn oven on. After the oven is turned on it is in cooking mode. To set the time and tempe rature you must be in programming mode. 2. To get to program mode, press and hol d the time and temperature buttons for approx imately 6 seconds. While pressing the buttons the di ...

  • Lincoln Electric Impinger Conveyorized Oven 3255 - page 13

    Impinger 3255 – Operator Manual 13 INFORMATION ON USE OF OVEN As explained in “Concepts,” the Impinger ® oven fun ctions by directing high velo city streams of heated air directly on the food products. Because air is the heat source, it is effective even on sensitive foods. Compared to conventional ovens and ev en convection ovens, the cooki ...

  • Lincoln Electric Impinger Conveyorized Oven 3255 - page 14

    Impinger 3255 – Operator Manual 14 CLEANING INSTRUCTIONS DAILY 1. Clean exterior surfaces of the ov en by wiping it down with a mild de ter gent and clean water, or a commercial stainless cleaner. 2. Clean crumb pans and gua rds by washing with a m ild detergent solution and rinsing with cl ean water. 3. Clean the interior by sweeping up all loos ...

  • Lincoln Electric Impinger Conveyorized Oven 3255 - page 15

    Impinger 3255 – Operator Manual 15 FINGER REMOVAL AND DI SASSEMBLY FOR CLEANING 1. Open door and remove upper finge rs. Note any particular placement of fingers that you may have, such a s fully closed, half-closed, or fully open, columnating pl ates. 2. Remove conveyor and then remove bottom fingers. 3. For finger disassembly, see “Stand an d ...

  • Lincoln Electric Impinger Conveyorized Oven 3255 - page 16

    Impinger 3255 – Operator Manual 16 CONCEPTS The Impinger ® Conveyor Oven produc ed by Lincoln Foodservice Products, LLC utilizes a revolutionary cooki ng concept called “AIR IMPINGEMENT.” It provides exceptional baked food produ ct quality in far less time than conventional devices on the market. The “AIR IMPINGEMENT” system direct s a h ...

  • Lincoln Electric Impinger Conveyorized Oven 3255 - page 17

    Impinger 3255 – Operator Manual 17 CAUTION – HOT SURFACE CLOCK, TIME SWITCH, TIMER TRANSFORMER DANGEROUS VOLTAGE EQUIPOTENTIALITY GROUND PROTECTIVE EARTH GROUND EARTH GROU ND CHANGE FUSES FUSE POWER OFF POWER ON DISCONNECT POWER TEMPERATURE, HEAT CONVEYOR FAN BRENNER HEAT CYCLE READY, TIMER INDICATOR RESET HIGH TEMPERATURE, HEAT APPENDIX A – ...

  • Lincoln Electric Impinger Conveyorized Oven 3255 - page 18

    Impinger 3255 – Operator Manual 18 APPENDIX A – LABEL DEFINITIONS (CONT’D) AMPS VOLTS KILOWATTS / HR TYPE OF GAS AC ½ COOK TIME SERVICE ACCESSIBILITY, PROVIDE MINIMUM REAR AND SIDE CLEARANCE ORIFICE – MAIN ORIFICE – LOW FIRE ...

  • Lincoln Electric Impinger Conveyorized Oven 3255 - page 19

    Impinger 3255 – Operator Manual 19 LIMITED W ARRANTY FO R COMMERCI AL PRODUCTS LIMITED W ARRANTY Lincoln Foodse rvice Products, LLC (“Li ncoln”) warrants this produ ct to be free from defects in material and workmanship for a period of one (1) ye ar from the date of purchase. During the warranty period, Lincoln shall, at Lincoln’s option, r ...

  • Lincoln Electric Impinger Conveyorized Oven 3255 - page 20

    Impinger 3255 – Operator Manual 20 ...

Manufacturer Lincoln Electric Category Convection Oven

Documents that we receive from a manufacturer of a Lincoln Electric Impinger Conveyorized Oven 3255 can be divided into several groups. They are, among others:
- Lincoln Electric technical drawings
- Impinger Conveyorized Oven 3255 manuals
- Lincoln Electric product data sheets
- information booklets
- or energy labels Lincoln Electric Impinger Conveyorized Oven 3255
All of them are important, but the most important information from the point of view of use of the device are in the user manual Lincoln Electric Impinger Conveyorized Oven 3255.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Lincoln Electric Impinger Conveyorized Oven 3255, service manual, brief instructions and user manuals Lincoln Electric Impinger Conveyorized Oven 3255. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Lincoln Electric Impinger Conveyorized Oven 3255.

Similar manuals

A complete manual for the device Lincoln Electric Impinger Conveyorized Oven 3255, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Lincoln Electric Impinger Conveyorized Oven 3255 by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Lincoln Electric Impinger Conveyorized Oven 3255.

A complete Lincoln Electric manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Lincoln Electric Impinger Conveyorized Oven 3255 - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Lincoln Electric Impinger Conveyorized Oven 3255, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Lincoln Electric Impinger Conveyorized Oven 3255, that we can find in the current document
3. Tips how to use the basic functions of the device Lincoln Electric Impinger Conveyorized Oven 3255 - which should help us in our first steps of using Lincoln Electric Impinger Conveyorized Oven 3255
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Lincoln Electric Impinger Conveyorized Oven 3255
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Lincoln Electric Impinger Conveyorized Oven 3255 in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Lincoln Electric Impinger Conveyorized Oven 3255?

Use the form below

If you did not solve your problem by using a manual Lincoln Electric Impinger Conveyorized Oven 3255, ask a question using the form below. If a user had a similar problem with Lincoln Electric Impinger Conveyorized Oven 3255 it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)