English dropdown-ico

Manual Vulcan-Hart VCRH12

20 pages 0.61 mb
Download

Go to site of 20

Summary
  • Vulcan-Hart VCRH12 - page 1

    ITW Food Equipment Group, LLC 3600 North Point Blvd. Baltimore, MA 21222 RETAIN THIS MANUAL FOR FUTURE USE FORM F- 38308 ( 04-10) INSTALLATION & OPERATION MANUAL FOR Medium Duty Gas Hotplates MODELS VCRH12 VCRH24 VCRH36 www.vulcanhart.com MODELS WCRH12 WCRH24 WCRH36 www.wolfrange.com VCRH36 ...

  • Vulcan-Hart VCRH12 - page 2

    - 2 - IMPORTANT FOR YOUR SAFETY THIS MANUAL HAS BEEN PREPARED FOR PERSONNEL QUALIFIED TO INSTALL GA S EQUIPMENT , WHO SHOU LD PERFORM THE INITIAL FIELD START-UP AND ADJUSTMENTS OF THE EQUIPMENT COVERED BY THIS MANUAL. POST IN A PROMINENT LOCATION THE INSTRUCTIONS TO BE FOLLOWED IN THE EVENT THE SMELL OF GAS IS DETECTED . THIS INFO RMATION CAN BE OB ...

  • Vulcan-Hart VCRH12 - page 3

    - 3 - INSTALLATION, OPERATION AND CARE OF MEDIUM DUTY GAS HOTPL ATES GENERAL Gas Counterto p Hotplates are designed for comm ercial use only and fea ture fast, efficie nt gas heat. Each bur ner is controlled by an ad justable gas valv e. Cast grates and b urners are easily remove d for cleaning wh en cool. Model Number Of Burners BTU/hr Input Ratin ...

  • Vulcan-Hart VCRH12 - page 4

    - 4 - INSTALLATION CODES AND STANDARD S The hotplate must be instal led in accord ance with: In the United Stat es of America: 1. State and local codes. 2. National Fu el Gas Code, ANSI-Z 223.1/NFPA #54 (latest edition ). This shall include but not be limited to : NFPA #54 Sectio n 10.3.5.2 for Venting. Copies may be ob tained from The Ame rican Ga ...

  • Vulcan-Hart VCRH12 - page 5

    - 5 - GAS CONNECTIONS Gas supply c onnections an d any pipe joint c ompound must be resistant to th e action o f propane gases. Purge the su pply line to clea n out any dust, di rt, or any foreign matter before con necting the line to the unit. Codes requi re that a gas shut-off valve be installed in the gas line ahea d of the appliance. The ga s s ...

  • Vulcan-Hart VCRH12 - page 6

    - 6 - The minimum supp ly pressure (upstre am of the regulator) should be 7- 9” W.C. for natura l gas and 11-12” W. C. for propane gas. At no time shoul d the hotplate be con nected to supply pressure greater than ½ psig (3.45 kPa) or 14” W.C. PROPANE GAS CONVERSION This hotplate is shipped fr om the factory eq uipped with fixed burner orifi ...

  • Vulcan-Hart VCRH12 - page 7

    - 7 - OPERATION The hotpl ate and it s parts ar e hot. Use ca re when op erating, cleaning or ser vicing t he hotplate. CONTROLS There is one pilot fo r every two burners. The hotplate is equ ipped with standing, unmonitored pilots . Gas will flow from the pilots as soon as the main gas supp ly to the unit is turne d on. See p ilot lighting pro ced ...

  • Vulcan-Hart VCRH12 - page 8

    - 8 - PILOT ADJUSTME NT Using a fla thead screwdri ver, turn the s lotted hex-he ad pilot ad justment sc rew clockwise to decreas e the flame, and co unterclo ckwise to increa se the flame. See Fig. 6. CLEANI NG Grates may be immersed in commercial cle aning compound overnight. In the mornin g, rinse with hot water to remove any residues of clea ni ...

  • Vulcan-Hart VCRH12 - page 9

    - 9 - MAINTENANCE The hotplat e and its parts are hot. Use care when opera ting, cleaning or ser vicing t he hotplate. LUBRICATION All valves must be checked and lubricated peri odically. Check w ith your service ag ency for details. VENT SYSTEM At least twice a year the ex haust hood (ven ting system) sho uld be examined and cleaned. SERVICE Conta ...

  • Vulcan-Hart VCRH12 - page 10

    - 10 - TROUBLESHOOTIN G Burner does not come on A. Problem with gas va lve. (Call for ser vice). when the control knob is B. Pilot burner not lit. turned on C. Low gas pressure. (Call for service) Too much heat A. Burner valves adjusted too high B . F a u l t y v e n t i l a t i o n C. Overrated gas pressure D. Improperly adjusted burner Uneven hea ...

  • Vulcan-Hart VCRH12 - page 11

    ITW Food Equipment Group, LLC 3600 North Point Blvd. Baltimore, MA 21222 GARDER CE MANUAL POUR UNE UTILISATION FUTURE FORMULAIRE F-38308 (04-10 ) MANUEL D’INSTALLATION ET D’EMPLOI POUR Plaques de cuisson au gaz à fonction moyenne MODÈLES VCRH12 VCRH24 VCRH36 www.vulcanhart.com MODÈLES WCRH12 WCRH24 WCRH36 www.wolfrange.com VCRH36 ...

  • Vulcan-Hart VCRH12 - page 12

    - 2 - Une installation, un ajustement, une modification, un service ou un entretien inapproprié peut causer du dommage matériel, une blessure ou la mort. Li re minutieusement les instructions d’installation, d’ emploi et d’entretien avant d’installer ou de se servi r cet équipement. IMPORTANT POUR VOTRE SÉCURITÉ CE MANUEL A ÉTÉ CONÇ ...

  • Vulcan-Hart VCRH12 - page 13

    - 3 - INSTALLATION, EMPLOI ET ENTRETIEN DES PLAQUES DE CUISSON AU GAZ À FONCTION MOYENNE GENERAL Les plaques de cuisson au gaz de comptoir sont conçues à des fins commerciales seulement et offrent une chaleur au gaz rapide, efficace. Chaque brû leur est contrôlé par une soupape à gaz réglable . Les grilles moulé es et les brû leurs s’en ...

  • Vulcan-Hart VCRH12 - page 14

    - 4 - CODES ET NORMES D’INSTALLATION La plaque de cuisson do it être inst allée confor mément à : Aux États-Unis d'Amérique : 1. Codes locaux e t d’état. 2. National Fuel Gas Code, ANSI-Z223.1/NFPA N o 54 (dernière édition). Cela doit comprendre sans être limité à : NFPA N o 54 Section 10 .3.5.2 pour la ventilation. Vous pouvez ...

  • Vulcan-Hart VCRH12 - page 15

    - 5 - CONNEXIONS DU GAZ Toutes les conn exions et toute pâte à joints doiven t résister à l’action du gaz propane. Vider la conduite d’alimen tation pour la nettoyer de toute poussière, saleté ou tout autre corps étranger avant de la connecter à l’appareil. Les codes e xigent qu’un robine t d’arrêt du gaz so it installé dans la ...

  • Vulcan-Hart VCRH12 - page 16

    - 6 - La pression d'alimen tation minimum (en amont du régulateur) de vrait être de 18 à 23 cm CE pour le gaz nature l et de 28 à 30 cm CE pour le gaz propane. La plaque de cuisson ne devrait à aucun moment être connectée à une pression d’al imentation supérieure à ½ psi (3,45 kPa) ou 36 cm CE. CONVERSION DU GAZ PROPANE Cette plaq ...

  • Vulcan-Hart VCRH12 - page 17

    - 7 - EMPLOI La plaque de cuisson et se s pièces sont chaudes. Fa ites attention lorsque vous employez, nettoyez ou entretenez la plaque de cuiss on. COMMANDES Il y a une veilleuse d’allumage pour deux brûleurs. La plaq ue de cuisson est munie de veilleuses d’allumage permanentes non contrôlées. Le gaz circulera à partir des veilleuses dè ...

  • Vulcan-Hart VCRH12 - page 18

    - 8 - RÉGLAGE DE LA VEILLEUSE D’ ALLUMAGE À l’aide d’un tourne vis à tête plate, tournez la vis à tête hexagona le fendue de régla ge de la veilleuse d’allumage dans le sens des aiguilles d'une montre po ur diminuer la flamme et dans le sens contraire des aig uilles d'une montre pour augmenter la flamme. Voir Fig. 6. NETTOY ...

  • Vulcan-Hart VCRH12 - page 19

    - 9 - ENTRETIEN La plaque de cuisson et se s pièces sont chaudes. Fa ites attention lorsque vous employez, nettoyez ou entretenez la plaque de cuiss on. LUBRIFICAT ION On doit vérifier e t lubrifier tou tes les soupapes régulière ment. Contactez votre service à la clientèle pour de plus amples dé tails. SYSTÈME DE VENTILATION La hotte à é ...

  • Vulcan-Hart VCRH12 - page 20

    - 10 - DÉPANNAGE Le brûleur ne s’ouvre p as lorsque le bouton de De commande est ouvert A. C’est un problème avec la soupape à gaz (Contactez le servic e à la client èle). B. La veilleuse du brûleur n’est pas a llumée C. La pression du gaz est basse.(Con tactez le service à la clientèle). Trop de chaleur A. Les soupapes de s brûleu ...

Manufacturer Vulcan-Hart Category Food Warmer

Documents that we receive from a manufacturer of a Vulcan-Hart VCRH12 can be divided into several groups. They are, among others:
- Vulcan-Hart technical drawings
- VCRH12 manuals
- Vulcan-Hart product data sheets
- information booklets
- or energy labels Vulcan-Hart VCRH12
All of them are important, but the most important information from the point of view of use of the device are in the user manual Vulcan-Hart VCRH12.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Vulcan-Hart VCRH12, service manual, brief instructions and user manuals Vulcan-Hart VCRH12. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Vulcan-Hart VCRH12.

Similar manuals

A complete manual for the device Vulcan-Hart VCRH12, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Vulcan-Hart VCRH12 by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Vulcan-Hart VCRH12.

A complete Vulcan-Hart manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Vulcan-Hart VCRH12 - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Vulcan-Hart VCRH12, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Vulcan-Hart VCRH12, that we can find in the current document
3. Tips how to use the basic functions of the device Vulcan-Hart VCRH12 - which should help us in our first steps of using Vulcan-Hart VCRH12
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Vulcan-Hart VCRH12
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Vulcan-Hart VCRH12 in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Vulcan-Hart VCRH12?

Use the form below

If you did not solve your problem by using a manual Vulcan-Hart VCRH12, ask a question using the form below. If a user had a similar problem with Vulcan-Hart VCRH12 it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)