-
Alto-Shaam 3DN - page 1
MN-28645 • 08/08 P R I N T E D I N U . S . A . D r a w e r W a r m e r s E l e c t r i c M A N U A L o r E L E C T R O N I C C O N T R O L M o d e l s : 5 0 0 - 1 D , 1 D N 5 0 0 - 2 D , 2 D N 5 0 0 - 3 D , 3 D N • I N S T A L L A T I O N • O P E R AT I O N • M A I N T E N A N C E W164 N9221 W ater Street • P .O. Box 450 • Menomonee Fal ...
-
Alto-Shaam 3DN - page 2
Drawer Warmer Installation/Operation/Service Manual • 1 . D E L I V E R Y This Alto-Shaam appliance has been thoroughly tested and inspected to insur e only the highest quality unit is provided. Upon r eceipt, check for any possible shipping damage and report it at once to the delivering carrier . See T ransportation Damage and Claims section loc ...
-
Alto-Shaam 3DN - page 3
Drawer Warmer Installation/Operation/Service Manual • 2 . 1 . T h i s a p p l i a n c e i s i n t e n d e d t o c o o k , h o l d o r p r o c e s s f o o d s f o r t h e p u r p o s e o f h u m a n c o n s u m p t i o n . N o o t h e r u s e f o r t h i s a p p l i a n c e i s a u t h o r i z e d o r r e c o m m e n d e d . 2 . T h i s a p p l i ...
-
Alto-Shaam 3DN - page 4
Drawer Warmer Installation/Operation/Service Manual • 3 . 1 . The cabinet, complete with unattached items and a c c e s s o r i e s , m a y b e d e l i v e r e d i n o n e o r m o r e packages. Check to ensur e all accessories ordered h a v e b e e n r e c e i v e d . 2 . This appliance is designed for the purpose of maintaining hot food at a tem ...
-
Alto-Shaam 3DN - page 5
Drawer Warmer Installation/Operation/Service Manual • 4 . I N S T A L L A T I O N 500-1D 500-2D 500-3D 1-1 1/16" (42mm) C L 24-3/8" (618mm) 40-1/16" (1018mm) 22-13/16" (579mm) 11 -3/4" (298mm) 19" (482mm) 26-1/8" (663mm) ELECTRICAL CONNECTION ELECTRICAL CONNECTION HI-LO Switch available only on 500 -1D and 50 0 ...
-
Alto-Shaam 3DN - page 6
Drawer Warmer Installation/Operation/Service Manual • 5 . I N S T A L L A T I O N Exterior Dimensions - 500-1DN, 500-2DN, 500-3DN N 500-1DN 500-2DN 500-3DN 1-1 1/16" (42mm) C L 16-7/16" (418mm) 50-7/8" (1291mm) 2 8-1/8" (714mm) 11 -1 1/16" (296mm) 18-7/8" (479mm) 26-3/16" (663mm) ELECTRICAL CONNECTION ELECTRICAL ...
-
Alto-Shaam 3DN - page 7
Drawer Warmer Installation/Operation/Service Manual • 6 . I N S T A L L A T I O N Manual Control, 120V Unit Manual Control, 208-240V , 230V Units Drawer Bearing Drawer Rail Stud & Nut Ther mostat Knob T emperature Gauge High Limit Switch Heat Indicator Light Panel Overlay Panel Overlay Drawer Assembly Electronic Contr ol Panel Overlay ...
-
Alto-Shaam 3DN - page 8
1 . An identification tag is permanently mounted on t h e c a b i n e t . 2 . Plug cabinet into a properly gr ounded receptacle ONL Y , positioning the unit so the power supply cord is easily accessible in case of an emer gency . Arcing will occur when connecting or disconnecting the unit unless all controls ar e in the “OFF” position. 3 . If n ...
-
Alto-Shaam 3DN - page 9
This appliance is intended for use in commercial establishments where all operators ar e familiar with the purpose, limitations, and associated hazards of this appliance. Operating instructions and warnings must be read and understood by all operators and users. 1 . M a k e s u r e t h e u n i t i s c o n n e c t e d t o t h e appropriate power sou ...
-
Alto-Shaam 3DN - page 10
1. Dual wattage control. The one and two drawer , 120V war mers are provided with a HIGH/LOW power switch. Use the HIGH position at 1000 watts for meats, potatoes, and vegetables — use the LOW position at 500 watts for breads and rolls. 2. Preheat at 200°F (93°C) for 30 minutes. W h e n t h e t h e r m o s t a t i s t u r n e d c l o c k w i s ...
-
Alto-Shaam 3DN - page 11
Drawer Warmer Installation/Operation/Service Manual • 1 0 . O P E R A T I O N - ELECT RONIC CONTROL POWER INDICA TOR LIGHT UP / DOWN A RROWS ON / OFF POWER KEY LOCK INDICA TOR L ED DISPLA Y H EA T INDICA TOR L IGHT ON/OFF KEY Press the on/off key once and the power indicator light will illuminate. Press and hold the on/off key until the LED displ ...
-
Alto-Shaam 3DN - page 12
Drawer Warmer Installation/Operation/Service Manual • 1 1 . O P E R A T I O N Chefs, cooks and other specialized food service personnel employ varied methods of cooking. Proper holding temperatures for a specific food product must be based on the moisture content of the product, product density, volume, and proper serving temperatures. Safe holdi ...
-
Alto-Shaam 3DN - page 13
Drawer Warmer Installation/Operation/Service Manual • 1 2 . P R O T E C T I N G S TA I N L E S S S T E E L S U R FA C E S I t i s i m p o r t a n t t o g u a r d a g a i n s t c o r r o s i o n i n t h e c a r e o f s tainless steel surfaces. H a r s h , c o r r o s i v e , o r i nappropriate chemicals can c o m p l e t e l y d e s t r o y t h e ...
-
Alto-Shaam 3DN - page 14
Drawer Warmer Installation/Operation/Service Manual • 1 3 . 1 . Disconnect unit from power source, and let cool. 2 . Remove, cover or wrap, and refrigerate food. 3 . Remove drawer pans and clean separately. The drawer assembly is completely removable. Remove from the cabinet and clean to prevent a build-up of food residue from inter fering with t ...
-
Alto-Shaam 3DN - page 15
S A N I T A T I O N Food flavor and aroma ar e usually so closely related that it is dif ficult, if not impossible, to separate them. There is also an important, i nseparable relationship between cleanliness and food flavor . Cleanliness, top operating efficiency , and appearance of equipment contribute considerably to savory , appetizing foods. Go ...
-
Alto-Shaam 3DN - page 16
Drawer Warmer Installation/Operation/Service Manual • 1 5 . MANUAL CONTROL THERMOST A T and HEA T LIGHT SEQUENCE Whenever the ther mostat is tur ned “ON,” the heat indicator light will indicate the power ON/OFF condition of the heating cable, and consequently, the cycling of the cabinet as it maintains the dialed cavity temperature. If the li ...
-
Alto-Shaam 3DN - page 17
Drawer Warmer Installation/Operation/Service Manual • 1 6 . S E R V I C E TROUBLE SHOOTING • ELECTRONIC CONTROL Error C ode D escription/ Results Possible Cause S ervice Required E-10 Air Sensor Fault (shorted) Inoperative Oven Air sensor is shorted. Air sensor is defective. Air sensor is open or has connection failure. Need air sensor test. Se ...
-
Alto-Shaam 3DN - page 18
Drawer Warmer Installation/Operation/Service Manual • 1 7 . P art D escription Q ty 5 00-1D Q ty 5 00-2D Q ty 5 00-3D Manual or Electronic Contr ol • Wide Drawer Warmers Air T unnel 1 1002672 1 1002672 1 1002672 Cable Replacement Kit (CB-3044) 1 4874 1 4874 1 4874 Casing Bottom 1 1002400 1 1002400 1 1002400 Casing T op 1 1002403 1 1002403 1 100 ...
-
Alto-Shaam 3DN - page 19
Drawer Warmer Installation/Operation/Service Manual • 1 8 . P art D escription Q ty 5 00-1D N Q ty 5 00-2D N Q ty 5 00-3DN M anual o r E lectronic C ontr ol • Narrow D rawer W armers Air T unnel 1 1002672 1 1002672 1 1002672 Cable Replacement Kit (CB-3044) 1 4874 1 4874 1 4874 Casing Bottom 1 1002794 1 1002794 1 1002794 Casing T op 1 1002798 1 ...
-
Alto-Shaam 3DN - page 20
Drawer Warmer Installation/Operation/Service Manual • 1 9 . S E R V I C E 500-3D • Manual control • top r emoved INSULA TION IN -2003 THERMOST A T TT -3057 TT-33626 THERMOMETER TH -33713 INDICA TOR LIGHT LI -3027 LI -3025 LI -3951 TERMINAL BLOCK BK -3019 WIRING DIAGRAM HEA TING ELEMENT CONNECTIONS AIR TUNNEL 1002672 ( EXHAUST F AN INSIDE ) F ...
-
Alto-Shaam 3DN - page 21
Drawer Warmer Installation/Operation/Service Manual • 2 0 . S E R V I C E 500-3D • Electronic contr ol • top r emoved • 230V INSULA TION IN -2003 CONTROL #5000876 WITHOUT SCI • CONTROL #5000877 WITH SCI ELECTRIC CORD CD -3232, CD -33840, CD -3922 BREAKER SWITCH SW -33487 RELA Y RL -33558 BEEPER BP -3567 POWER SUPPL Y BA -33554 SENSOR WIRE ...
-
Alto-Shaam 3DN - page 22
Drawer Warmer Installation/Operation/Service Manual • 2 1 . 500-3D Interior BEARINGS THERMOMETER CAPILLAR Y THERMOST A T CAPILLAR Y HEA T ELEMENT CABLE CB -3044 INSULA TION IN -2003 S E R V I C E 500-3D Heat Cable W rap D A N G E R D I S C O N N E C T U N I T F R O M P O W E R S O U R C E B E F O R E C L E A N I N G O R S E R V I C I N G . ...
-
Alto-Shaam 3DN - page 23
Drawer Warmer Installation/Operation/Service Manual • 2 2 . ...
-
Alto-Shaam 3DN - page 24
Drawer Warmer Installation/Operation/Service Manual • 2 3 . ...
-
Alto-Shaam 3DN - page 25
Drawer Warmer Installation/Operation/Service Manual • 2 4 . ...
-
Alto-Shaam 3DN - page 26
Drawer Warmer Installation/Operation/Service Manual • 2 5 . ...
-
Alto-Shaam 3DN - page 27
Drawer Warmer Installation/Operation/Service Manual • 2 6 . ...
-
Alto-Shaam 3DN - page 28
Drawer Warmer Installation/Operation/Service Manual • 2 7 . ...
-
Alto-Shaam 3DN - page 29
Drawer Warmer Installation/Operation/Service Manual • 2 8 . ...
-
Alto-Shaam 3DN - page 30
Drawer Warmer Installation/Operation/Service Manual • 2 9 . ...
-
Alto-Shaam 3DN - page 31
Drawer Warmer Installation/Operation/Service Manual • 3 0 . ...
-
Alto-Shaam 3DN - page 32
Drawer Warmer Installation/Operation/Service Manual • 3 1 . ...
-
Alto-Shaam 3DN - page 33
All Alto-Shaam equipment is sold F .O.B. shipping point, and when accepted by the carrier , such shipments become the property of the consignee. Should damage occur in shipment, it is a matter between the carrier and the consignee. In such cases, the carrier is assumed to be responsible for the safe delivery of the merchandise, unless negligence ca ...
Do you have a question concerning Alto-Shaam 3DN?
Use the form below
If you did not solve your problem by using a manual Alto-Shaam 3DN, ask a question using the form below. If a user had a similar problem with Alto-Shaam 3DN it is likely that he will want to share the way to solve it.