-
Hearth and Home Technologies BODBAY - page 1
SA VE THESE INSTRUCTIONS www .quadrare.com This manual contains instructions for Installation, Operation & Maintenance. Please read this entire manual before you install and use your new room heater . Failure to follow instructions may result in property damage, bodily injury , or even death. BODEGA BA Y WOOD INSERT Advanced Combustion T ech ...
-
Hearth and Home Technologies BODBAY - page 2
BODEGA BA Y WOOD INSERT Page 2 August 20, 2008 R 435-1320B and Welcome to the Quadra-Fire Family ! H earth & Home T echnologies welcomes you to our tradition of excellence! In choosing a Quadra-Fire appliance, you have our assurance of commitment to quality , durability , and perfor - mance. This commitment begins with our research of the marke ...
-
Hearth and Home Technologies BODBAY - page 3
Page 3 August 20, 2008 BODEGA BA Y WOOD INSERT R 435-1320B SAFETY & OVER VIEW OF APPLIANCE Location & Sample of Serial Number Label ----------- 2 Dimensions ----------------------------------------------------- 4 Minimum Clearances to Combustibles ------------------ 4 Listings ---------------------------------------------------------- 5 Chi ...
-
Hearth and Home Technologies BODBAY - page 4
BODEGA BA Y WOOD INSERT Page 4 August 20, 2008 R 435-1320B DIMENSIONS T OP VIEW SIDE VIEW FRONT VIEW SERIAL NUMBER LABEL LOCA TION: ON BEADED CHAIN, LEFT SIDE BEHIND OUTER SKIN Hearth Extension A B C D F E Insert SideW all Maximum Mantel Depth - 10" (254mm) Fascia or T rim Mantel Thermal Protection USA & Canada USA CANADA A Sidewall to Sto ...
-
Hearth and Home Technologies BODBAY - page 5
Page 5 August 20, 2008 BODEGA BA Y WOOD INSERT R 435-1320B A VOID FIRE: T o ensure that insulation or any other combustible material does not contact the chimney , a chimney inside the house must have at least 2 inches (51mm) of air space clearance around the chimney . A chimney outside the house must have at least 1 inch (25mm) clearance to the co ...
-
Hearth and Home Technologies BODBAY - page 6
BODEGA BA Y WOOD INSERT Page 6 August 20, 2008 R 435-1320B IF INST ALLING THIS MODEL T O A MASONRY CHIMNEY , AL W A YS BE SURE THE CHIMNEY IS IN GOOD CONDITION AND THA T IT MEETS THE MINIMUM ST ANDARDS OF THE NA TIONAL FIRE PROTECTION ASSOCIA TION (NFP A) ST ANDARD 21 1. A F ACTOR Y BUIL T CHIMNEY MUST BE 6 INCH (152mm) UL 103 HT AND ULC S629. THIS ...
-
Hearth and Home Technologies BODBAY - page 7
Page 7 August 20, 2008 BODEGA BA Y WOOD INSERT R 435-1320B Floor Ceiling Caulk Floor (second Story) Non-Combustible Firestopping Material Minimum 1 inch (25mm) clearance from exterior chimney to sheathing Firestopping 2 inch (51mm) A chimney must be the required height above the roof or other obstruction for safety and for proper draft oper - ation ...
-
Hearth and Home Technologies BODBAY - page 8
BODEGA BA Y WOOD INSERT Page 8 August 20, 2008 R 435-1320B 1. An outside air inlet must be provided for combustion and must remain clear of leaves, debris, ice and/or snow . It must be unrestricted while unit is in use to prevent room air starvation which can cause smoke spillage and an inability to maintain a re. Smoke spillage can also set off ...
-
Hearth and Home Technologies BODBAY - page 9
Page 9 August 20, 2008 BODEGA BA Y WOOD INSERT R 435-1320B MASONR Y FIREPLACE USING DIRECT -CONNECT METHOD Refer to: Clearances to Combustibles on page 4, Canadian Installation Requirements on page 1 1, Hearth Requirements on page 4 and Zero Clearance Adjustable Support Kit on page 15. Figure 9A - Installation Into Masonry Fireplace Direct Connect ...
-
Hearth and Home Technologies BODBAY - page 10
BODEGA BA Y WOOD INSERT Page 10 August 20, 2008 R 435-1320B F ACT OR Y BUIL T ZERO CLEARANCE FIREPLACE (USA INST ALLA T ONS ONL Y) Listed Liner Mantel SEAL DAMPER AREA OR FACE SEAL Figure 10A - Installation Into A Factory-Built Zero Clearance Fireplace The following modications of factory built replaces are permissible: 1) removal of damper; ...
-
Hearth and Home Technologies BODBAY - page 11
Page 1 1 August 20, 2008 BODEGA BA Y WOOD INSERT R 435-1320B INST ALLA TION IN CANADA MASONR Y and HEA T -CIRCULA TING (INST ALLA TIONS INTO F ACTORY -BUIL T FIREPLACES ARE PROHIBITED IN CANADA) Whether installed in a masonry or heat-circulating replace, this replace insert must be installed with a continuous chim - ney liner of six inch (152 ...
-
Hearth and Home Technologies BODBAY - page 12
BODEGA BA Y WOOD INSERT Page 12 August 20, 2008 R 435-1320B SECURING LINER T O CHIMNEY RING There are 2 options to secure the liner to the chimney ring: (See Figure 12A). Option One: If there is enough room on the top of the insert to work, hand bend the two tabs upward 90°. Secure the liner with the supplied hex head bolts 1/4- 20-3/4. Option T w ...
-
Hearth and Home Technologies BODBAY - page 13
Page 13 August 20, 2008 BODEGA BA Y WOOD INSERT R 435-1320B 1. Remove contents from box being careful not to scratch or damage trim pieces. 2. Lay the panel set face down on protective covering to prevent scratching the painted surface. 3. Secure panel set together with screws provided. See Figure 13A 4. T o assemble the trim, attach the 2 side tri ...
-
Hearth and Home Technologies BODBAY - page 14
BODEGA BA Y WOOD INSERT Page 14 August 20, 2008 R 435-1320B BLOWER CORD LOCA TION Remove Bolt Remove Bolt Figure 14A Figure 14C Figure 14D Figure 14B - Right Side Location Black Red White Snap Disc Blower Control Box with Switch Cooling Fan Black Operating the Blower Control Box with Switch 1. The blower will turn on/off automatically when set to A ...
-
Hearth and Home Technologies BODBAY - page 15
Page 15 August 20, 2008 BODEGA BA Y WOOD INSERT R 435-1320B ZERO CLEARANCE ADJUST ABLE TRIM SUPPORT , 2” to 10” Part No. 841-0990, size 9”d x 45”w and Part No. ADJSPT -12, size 12”d x 50”w Included in Kit: ( 1) T rim T op, (1) T rim Front, (2) T rim Sides, Double-Sided T ape (already installed) T ools Needed: Phillips Head Screwdriver , ...
-
Hearth and Home Technologies BODBAY - page 16
BODEGA BA Y WOOD INSERT Page 16 August 20, 2008 R 435-1320B WOOD SELECTION AND STORAGE Burn only dry seasoned wood. Dry , well-seasoned wood will not only minimize the chance of creosote formation but will give you the most efcient heat output. Even dry wood contains at least 15% moisture by weight and should be burned hot enough to keep the chi ...
-
Hearth and Home Technologies BODBAY - page 17
Page 17 August 20, 2008 BODEGA BA Y WOOD INSERT R 435-1320B BURN RA TES ST ARTING FIRE : Open both controls (push in) completely . After a wood load has been burning on high for 5 to 15 minutes or longer for very large pieces, close the Start-Up Air Control (bottom rod) by pulling it out. HIGH: Leave the Primary Air Control fully open (top rod). It ...
-
Hearth and Home Technologies BODBAY - page 18
BODEGA BA Y WOOD INSERT Page 18 August 20, 2008 R 435-1320B AIR QUALITY AND YOUR QUADRA-FIRE INSERT In recent years there has been an increasing concern about the quality of our air . Much of the blame for poor air quality has been placed on the burning of wood for home heating. In order to improve this situation we at Quadra-Fire have developed cl ...
-
Hearth and Home Technologies BODBAY - page 19
Page 19 August 20, 2008 BODEGA BA Y WOOD INSERT R 435-1320B MAINTENANCE CARE AND CLEANING OF PLA TED SURF ACES IMPORT ANT : Y ou must clean all the ngerprints and oils from the plated surfaces before ring the insert for the rst time. Use warm soapy water and a soft rag, glass cleaner and a paper towel, or vinegar and a paper towel to remov ...
-
Hearth and Home Technologies BODBAY - page 20
BODEGA BA Y WOOD INSERT Page 20 August 20, 2008 R 435-1320B 1 1 2 2 3 4 4 4 4 4 4 4 4 4 4 6 6 4 4 5 2 6-1/8" 2-1/4" 5 5 Allen wrench on retainer bolt First tube has larger holes BRICK REPLACEMENT INSTRUCTIONS P ART 832-3500 The rebox of your insert is lined with high quality re - brick which has exceptional insulating properties. Th ...
-
Hearth and Home Technologies BODBAY - page 21
Page 21 August 20, 2008 BODEGA BA Y WOOD INSERT R 435-1320B EXPLODED VIEW 1 10 2 3 4 5 6 7 8 9 1 1 12 13 14 15 16 17 18 24 19 20 21 22 23 Item Part Name 1 Strain Relief Bushing 2 Speed Control (Rheostat) 3 Snap Disc 4 Airwash 5 Outside Air Cover Plate 6 Fiberboard Bafe 7 Ceramic Blanket 8 Manifold T ubes #2, #3, #4 Item Part Name 9 Wire Access P ...
-
Hearth and Home Technologies BODBAY - page 22
BODEGA BA Y WOOD INSERT Page 22 August 20, 2008 R 435-1320B SER VICE P ARTS DC-BB-GD Door Crown, Gold DC-BB-NL Door Crown, Nickel SP-BB3044-GD Panel & Gold T rim Set, Small, 30-1/2”h x 44-5/8”w SP-BB3044-NL Panel & Nickel T rim Set, Small, 30-1/2”h x 44-5/8”w SP-BB3450-GD Panel & Gold T rim Set, Large, 34”h x 50-1/2”w SP-BB3 ...
-
Hearth and Home Technologies BODBAY - page 23
Page 23 August 20, 2008 BODEGA BA Y WOOD INSERT R 435-1320B W arranty Policy LIMITED LIFETIME W ARRANTY The Hearth & Home T echnologies limited Lifetime Warranty guarantees that the following components will work as designed for the lifetime of the stove or Hearth & Home T echnologies will repair or replace them. These items include but are ...
-
Hearth and Home Technologies BODBAY - page 24
Page 24 August 20, 2008 435-1320B R • Do NOT discard this manual. • Important operating and maintenance instructions included. • Read, understand and follow these instruci- tons for safe installation and operation. • Leave this manual with party responsible for use and operation. CAUTION This product may be covered by one or more of the fol ...
У вас вопрос, касающийся Hearth and Home Technologies BODBAY?
Воспользуйтесь формуляром, находящимся ниже
Если с помощью найденной инструкции Вы не решили свою проблему с Hearth and Home Technologies BODBAY, задайте вопрос, заполнив следующий формуляр. Если у какого то из пользователей была похожая проблема с Hearth and Home Technologies BODBAY со всей вероятностью он захочет поделиться методом ее решения.