-
Suburban OXYGEN THERAPY DOOR 12155-00-DRDRAA - page 1
Owner’s Manual Oxygen Therapy Door Converts standard Regal cage into an oxygen therapy chamber Models to fit most single-door Regal cages Door-mounted thermometer/hygrometer Outside compartment for nebulizer and ice New Model Numbers: 12155-00-DRDRAA, 12155-00-DREP AA, 12155-00-EPDRAA, 12155-00-EPEP AA, 12155-00-EPFNAA, 12155-00-E ...
-
Suburban OXYGEN THERAPY DOOR 12155-00-DRDRAA - page 2
© Copyright 2006 by Suburban Surgical Co., Inc. All rights reserved. No part of this document may be reproduced or utilized in any form or by any means, electronic or mechanical, including photocopying, recording, or by any information storage and retrieval system without written permission. Inquiries should be addressed to Suburban Surgical Co., ...
-
Suburban OXYGEN THERAPY DOOR 12155-00-DRDRAA - page 3
Form No. 702703 Rev . E August, 2006 i Owner’s Manual - Oxygen Therapy Door Table of Contents Chapter 1 - General Information ................................................................. 1 Introduction ............................................................................................................................... .1 About this ...
-
Suburban OXYGEN THERAPY DOOR 12155-00-DRDRAA - page 4
ii SSCI - Suburban Surgical Company , Inc. Table of Contents Cleaning Instructions ................................................................................................................. 16 Introduction .................................................................................................................. 16 Stainless Steel Cle ...
-
Suburban OXYGEN THERAPY DOOR 12155-00-DRDRAA - page 5
Form No. 702703 Rev . E August, 2006 1 Owner’s Manual - Oxygen Therapy Door Introduction The SSCI Oxygen Therapy Door transforms your standard Regal cage into an oxygen therapy chamber . The clear door features a continuous-flow nebulizer with .25 in (.635 cm) inner diameter x .062 in (.16 cm) thick tubing to deliver a regulated flow of medicated ...
-
Suburban OXYGEN THERAPY DOOR 12155-00-DRDRAA - page 6
2 SSCI - Suburban Surgical Company , Inc. Chapter 1 - General Information W ARNINGS Information and Safety Notices Throughout this manual you will find text under the headings Note: and W ARNING: . Under the Note: headings, you will be given additional information pertinent to the subject discussed in that paragraph or step. Example: Push the oxyge ...
-
Suburban OXYGEN THERAPY DOOR 12155-00-DRDRAA - page 7
Form No. 702703 Rev . E August, 2006 3 Owner’s Manual - Oxygen Therapy Door Care and Cleaning of St ainless S teel Introduction Stainless steel is steel alloyed with chromium to make it highly resistant to stain, rust and corrosion. Note: This does NOT mean that stainless steel will never rust or corrode. Science has not yet developed a steel whi ...
-
Suburban OXYGEN THERAPY DOOR 12155-00-DRDRAA - page 8
4 SSCI - Suburban Surgical Company , Inc. Chapter 1 - General Information Cleaning Requirements Effect on W arranty Safety The large selection of brands and combinations of chemicals available for deodorizing, disinfecting and sanitizing is staggering. Select one or more agents for use in your facility only after weighing all the benefits claimed b ...
-
Suburban OXYGEN THERAPY DOOR 12155-00-DRDRAA - page 9
Form No. 702703 Rev . E August, 2006 5 Owner’s Manual - Oxygen Therapy Door SSCI Cont act Information Contact SSCI Customer Service by mail, telephone or fax. The department is available from 8:30am to 5:00pm, Central T ime, Monday through Friday . Closed holidays. Address: Suburban Surgical Co., Inc. 275 T welfth S treet Wheeling, Illinois 60090 ...
-
Suburban OXYGEN THERAPY DOOR 12155-00-DRDRAA - page 10
6 SSCI - Suburban Surgical Company , Inc. Chapter 1 - General Information Comment s: ...
-
Suburban OXYGEN THERAPY DOOR 12155-00-DRDRAA - page 11
Form No. 702703 Rev . E August, 2006 7 Owner’s Manual - Oxygen Therapy Door Unp acking and Inspection If the shipping container appears damaged in any way , contact the shipping company immediately . Save all damaged packing materials to assist in proving liability for damage. Carefully inspect your Oxygen Therapy Door while you unpack it. If dam ...
-
Suburban OXYGEN THERAPY DOOR 12155-00-DRDRAA - page 12
8 SSCI - Suburban Surgical Company , Inc. Chapter 2 - Installation and Setup 1. W ith a 1/4 in. or smaller punch and a small hammer , remove both hinge pins from the cage door (Figures 2 and 3). 2. Remove the door from the cage. 3. Open the door and, on the rear of the gauge, pull the tape marked “ REMOVE TO ST ART ” from the battery compartmen ...
-
Suburban OXYGEN THERAPY DOOR 12155-00-DRDRAA - page 13
Form No. 702703 Rev . E August, 2006 9 Owner’s Manual - Oxygen Therapy Door 6. On the nebulizer extension, squeeze the two ends of the cotter pin together and remove the pin from the extension (Figure 6). 7. Open the oxygen therapy door . 8 . Place the nebulizer in the ice tray with the extension through the opening in the door (Figures 5, 6, and ...
-
Suburban OXYGEN THERAPY DOOR 12155-00-DRDRAA - page 14
10 SSCI - Suburban Surgical Company , Inc. Chapter 2 - Installation and Setup Comment s: ...
-
Suburban OXYGEN THERAPY DOOR 12155-00-DRDRAA - page 15
Form No. 702703 Rev . E August, 2006 11 Owner’s Manual - Oxygen Therapy Door Door and Latch Door Seals The door has flexible rubber seal strips (Figure 8) on all four sides to prevent the escape of oxygen. The corners are open to help distribute the oxygen uniformly , and allow for the escape of carbon dioxide. The door is held closed by a self-a ...
-
Suburban OXYGEN THERAPY DOOR 12155-00-DRDRAA - page 16
12 SSCI - Suburban Surgical Company , Inc. Chapter 3 - Operating and Cleaning Ice T ray The ice tray can be used for ice baths, warm water , warm chemical packs - whatever your current treatment requires. The tray cannot be easily removed from the door if the nebulizer is in place. Therefore, a valve is provided on the bottom of the tray to facilit ...
-
Suburban OXYGEN THERAPY DOOR 12155-00-DRDRAA - page 17
Form No. 702703 Rev . E August, 2006 13 Owner’s Manual - Oxygen Therapy Door Maximum/Minimum T emperature and Humidity Recording As the gauge operates, it records the maximum and minimum temperatures and humidities reached since the last time the Clear Button was pressed. Use a small, pointed instrument, or an unbent paper clip, to press the Max ...
-
Suburban OXYGEN THERAPY DOOR 12155-00-DRDRAA - page 18
14 SSCI - Suburban Surgical Company , Inc. Chapter 3 - Operating and Cleaning Using the Nebulizer W e at SSCI are not licensed veterinarians. Please use your experience, and refer to professional literature for advice on proper dosages and usage of medications, and appropriate concentrations of oxygen. Note: The nebulizer is designed for single pat ...
-
Suburban OXYGEN THERAPY DOOR 12155-00-DRDRAA - page 19
Form No. 702703 Rev . F May , 2009 15 Owner’s Manual - Oxygen Therapy Door Oxygen Concentration Control 4. At the oxygen source, set the oxygen flow to 10 liters per minute or higher if more flow is needed. 5. Refer to Oxygen Concentration Contr ol below to set desired oxygen concentration. Note: For questions concerning the use of the nebulizer ...
-
Suburban OXYGEN THERAPY DOOR 12155-00-DRDRAA - page 20
16 SSCI - Suburban Surgical Company , Inc. Chapter 3 - Operating and Cleaning Cleaning Instructions Y ou will no doubt want to clean your oxygen door and cages whenever they become dirty or saturated with waste fluids. Maintaining high standards of sanitation will be an important priority for your facility . Ordinary deposits of waste and fluids ca ...
-
Suburban OXYGEN THERAPY DOOR 12155-00-DRDRAA - page 21
Form No. 702703 Rev . E August, 2006 17 Owner’s Manual - Oxygen Therapy Door Replacement Part s T able 2 lists the replacement parts available for the Oxygen Therapy Door . For parts not listed below , contact SSCI Customer Service at (800) 323-7366. Refer to Parts Or dering Procedur e on Page 18 . Warning: Oxygen is a highly combustible gas. A v ...
-
Suburban OXYGEN THERAPY DOOR 12155-00-DRDRAA - page 22
18 SSCI - Suburban Surgical Company , Inc. Chapter 4 - Repairs and Replacements Part s Ordering Procedure Many of the threaded fasteners used on SSCI products are secured with thread adhesive to insure structural integrity . Removing any screw or bolt may be difficult at first. During disassembly , retain all hardware items such as screws, ...
-
Suburban OXYGEN THERAPY DOOR 12155-00-DRDRAA - page 23
Form No. 702703 Rev . E August, 2006 19 Owner’s Manual - Oxygen Therapy Door Procedures Nebulizer Assembly , Complete This is the complete nebulizer assembly including the bottle, cap, regulator , extension, cotter pin, hose barb fitting and oxygen supply hose (Figure 18). T ool Required Needle-nose pliers P/N 212126 Procedure 1. On the nebul ...
-
Suburban OXYGEN THERAPY DOOR 12155-00-DRDRAA - page 24
20 SSCI - Suburban Surgical Company , Inc. Chapter 4 - Repairs and Replacements Nebulizer Oxygen Supply Hose P/N 750492 5. Attach the free end of the nebulizer plastic tubing to a 50 psi wall oxygen outlet or an oxygen cylinder . Note: Y our oxygen supplier is the best source to make these connections for you. The partial nebulizer assembly include ...
-
Suburban OXYGEN THERAPY DOOR 12155-00-DRDRAA - page 25
Form No. 702703 Rev . E August, 2006 21 Owner’s Manual - Oxygen Therapy Door T ools Required 5/8 in. open-end wrench Utility knife Procedure The hose barb fitting connects the oxygen supply hose to the nebulizer (Figure 21). T o replace the fitting: 1 . Pull or cut the oxygen supply hose off the fitting. 2. Hold the white, 4-arm knob on t ...
-
Suburban OXYGEN THERAPY DOOR 12155-00-DRDRAA - page 26
22 SSCI - Suburban Surgical Company , Inc. Chapter 4 - Repairs and Replacements The nebulizer extension is a 2 in. long stainless steel tube that provides a channel for the oxygen from the nebulizer to the interior of the therapy chamber (Figure 18). T o mount a new extension to a new nebulizer cap, use a high quality silicone cement. Make sure the ...
-
Suburban OXYGEN THERAPY DOOR 12155-00-DRDRAA - page 27
Form No. 702703 Rev . E August, 2006 23 Owner’s Manual - Oxygen Therapy Door Removal - New-style Gauge 1. Open the cage door . 2. W ith a Phillips screwdriver and a 3/8 in. wrench, remove the two gauge bracket screws/nuts (Figure 24). 3. Remove the gauge bracket and the gauge from the inside of the oxygen door . Figure 24. Front View of the New-s ...
-
Suburban OXYGEN THERAPY DOOR 12155-00-DRDRAA - page 28
24 SSCI - Suburban Surgical Company , Inc. Chapter 4 - Repairs and Replacements 6. Loosen the gauge bracket nuts and remove the gauge from the door . 7. W ith a 1/16 in. bit, drill two holes in the door at the locations marked in S tep 5 ( Figure 26). This will provide easy access to the buttons on the front of the gauge. 8. Smooth out the outside ...
-
Suburban OXYGEN THERAPY DOOR 12155-00-DRDRAA - page 29
Form No. 702703 Rev . E August, 2006 25 Owner’s Manual - Oxygen Therapy Door Hang the new ice tray on the button hooks provided on the door (Figures 27 and 28). Ice T ray V alve Ice T ray T ools Required Pliers Utility knife Procedure 1. Remove the ice tray from the oxygen therapy door . 2. If tubing is attached to the valve barb fitting, ...
-
Suburban OXYGEN THERAPY DOOR 12155-00-DRDRAA - page 30
26 SSCI - Suburban Surgical Company , Inc. Chapter 4 - Repairs and Replacements The following instructions cover both the seal strip retainers and the seal strips. All seal strip retainers are the same except for length and number of mounting holes. The same is true for all seal strips. Parts Identification T able 3 on Page 27 and T able 4 on Page ...
-
Suburban OXYGEN THERAPY DOOR 12155-00-DRDRAA - page 31
Form No. 702703 Rev . E August, 2006 27 Owner’s Manual - Oxygen Therapy Door 5. If you are replacing the seal strip, hold the new strip in position. 6. Hold the new or existing seal strip retainer in position. 7. Secure the seal strip and retainer to the door with the screws/nuts you removed in S tep 2. 8. Close the door and observe the seal to b ...
-
Suburban OXYGEN THERAPY DOOR 12155-00-DRDRAA - page 32
28 SSCI - Suburban Surgical Company , Inc. Chapter 4 - Repairs and Replacements T able 4. Seal Strip Part Numbers l e d o M r o o D s n o i s n e m i D r o o D N / P p i r t S l a e S y t i t n a u Q A A R D R D - 0 0 - 5 5 1 2 1 : N / P w e N 1 - 3 6 5 2 0 1 : N / P d l O H . n i 4 2 x W . n i 4 2 H m c 6 9 . 0 6 x W m c 6 9 . 0 6 0 1 9 0 5 7 s e ...
-
Suburban OXYGEN THERAPY DOOR 12155-00-DRDRAA - page 33
Form No. 702703 Rev . E August, 2006 29 Owner’s Manual - Oxygen Therapy Door General The following procedures will help you fix most of the problems that you might encounter with the Oxygen Therapy Door . If necessary , please feel free to call SSCI Customer Service at (800) 323-7366. Our experienced T echnical Support personnel will be glad to h ...
-
Suburban OXYGEN THERAPY DOOR 12155-00-DRDRAA - page 34
30 SSCI - Suburban Surgical Company , Inc. Chapter 5 - Troubleshooting Returning the Oxygen Therapy Door for Rep airs RMA Numbers If your door should require return to SSCI for repairs, discuss the problem with one of our Customer Service Representatives. Obtain an RMA number (Return Merchandise Authorization) from him before shipping the unit back ...
-
Suburban OXYGEN THERAPY DOOR 12155-00-DRDRAA - page 35
Form No. 702703 Rev . E August, 2006 31 Owner’s Manual - Oxygen Therapy Door There is no oxygen flow into the cage. First: Make sure that the oxygen supply is turned on at the source and that your oxygen supply tank is not empty . Second: Make sure the oxygen therapy door is properly closed and latched and not allowing oxygen to escape. Third: Ma ...
-
Suburban OXYGEN THERAPY DOOR 12155-00-DRDRAA - page 36
32 SSCI - Suburban Surgical Company , Inc. Chapter 5 - Troubleshooting There is excessive oxygen leakage from the cage. Note: Some oxygen leakage is normal. The corners of the cage are left open to help distribute the oxygen in the cage uniformly and to allow for the escape of carbon dioxide. If you feel that the amount of leakage is excessive, per ...
-
Suburban OXYGEN THERAPY DOOR 12155-00-DRDRAA - page 37
Form No. 702703 Rev . E August, 2006 33 Owner’s Manual - Oxygen Therapy Door The door does not close or latch correctly . The latch brackets are probably out of adjustment. Refer to Latch Adjustment on Page 1 1 . Remedial Action ...
-
Suburban OXYGEN THERAPY DOOR 12155-00-DRDRAA - page 38
34 SSCI - Suburban Surgical Company , Inc. Chapter 5 - Troubleshooting One or both of the gauges does not read correctly . Remedial Action One or both of the gauges is defective. The gauges are not repairable and must be replaced. Call SSCI and order a new gauge assembl y , P/N 854 771 . Refer to Page 22 for replacement procedures. ...
-
Suburban OXYGEN THERAPY DOOR 12155-00-DRDRAA - page 39
Inside back cover This page left blank intentionally . ...
-
Suburban OXYGEN THERAPY DOOR 12155-00-DRDRAA - page 40
Form No. 702703 Rev . E 08/06 Suburban Surgical Comp any , Inc. 275 T welf th S treet Wheeling, IL 60090 Phone: (847) 537-9320 Fax: (847) 537-9061 T oll Free: (800) 323-7366 Web: www .suburbansurgical.com SSCI For more information on SSCI’s fine line of products and accessories, talk to your SSCI sales representative. ...
У вас вопрос, касающийся Suburban OXYGEN THERAPY DOOR 12155-00-DRDRAA?
Воспользуйтесь формуляром, находящимся ниже
Если с помощью найденной инструкции Вы не решили свою проблему с Suburban OXYGEN THERAPY DOOR 12155-00-DRDRAA, задайте вопрос, заполнив следующий формуляр. Если у какого то из пользователей была похожая проблема с Suburban OXYGEN THERAPY DOOR 12155-00-DRDRAA со всей вероятностью он захочет поделиться методом ее решения.