Русский dropdown-ico

Инструкция обслуживания LG Electronics LRMM1430SW

48 страниц 1.69 mb
Скачать

Перейти на страницу of 48

Summary
  • LG Electronics LRMM1430SW - page 1

    MICROW A VE OVEN SER VICE MANUAL MODEL : LRMM1430SW LRMM1430SB CAUTION BEFORE SERVICING THE UNIT , READ THE SAFETY PRECAUTIONS IN THIS MANUAL. website http://www.lgservice.com ...

  • LG Electronics LRMM1430SW - page 2

    -1- CAUTION W ARNING T O SER VICE TECHNICIANS PRECAUTIONS T O BE OBSER VED BEFORE AND DURING SER VICING T O A VOID POSSIBLE EXPOSURE T O EXCESSIVE MICROW A VE ENERGY a. Do not operate or allow the oven to be operated with the door open. b. Make the following safety checks on all ovens to be serviced before activating the magnetron or other microwav ...

  • LG Electronics LRMM1430SW - page 3

    FOREWORD Read this Manual carefully. Failure to adhere to or observe the information in this Manual may result in exposing yourself to the Microwave Energy normally contained within the oven cavity. MECHANICAL SERVICE INFORMATION T ABLE OF CONTENTS 1. Adjustment Procedures ............................................................................ ...

  • LG Electronics LRMM1430SW - page 4

    -3- 1. ADJUSTMENT PROCEDURES To avoid possible exposure to microwave energy leakage, adjust the door latches and interlock switches, using the following procedure. ONLY AUTHORIZED SERVICE PERSONNEL SHOULD MAKE THIS ADJUSTMENT. The Interlock Monitor and Primary Interlock Switch acts as the final safety switch protecting the user from microwave energ ...

  • LG Electronics LRMM1430SW - page 5

    -4- LA TCH BOARD PRIMARY INTERLOCK SWITCH LA TCH LA TCH BOARD (A) (B) 0-1/64" 0-1/64" DOOR LA TCH SECONDARY INTERLOCK SWITCH MONITOR INTERLOCK SWITCH Figure 1-a Figure 1-b ...

  • LG Electronics LRMM1430SW - page 6

    2. PRECAUTIONS ON INST ALLA TION (Figure 2) A. Plug the power supply cord into a 120 V AC, 60 Hz, single-phase power source with a capacity of at least 20 amperes. B. Since the unit weights about 38 lbs., be sure to place it on a sturdy and flat surface. C. Avoid placing the unit in a location where there is direct heat or splashing water. D. Place ...

  • LG Electronics LRMM1430SW - page 7

    SPECIFICA TIONS Rated Power Consumption 1250W maximum Output 1200W maximum ( * IEC 60705 Rating standard) Adjustable 0W through 1200W, 10 steps Frequency 2,450 MHz 50 MHz Power Supply 120V 12V AC, 60Hz Rated Current 11 Amp. Magnetron Cooling Forced Air Cooling Microwave Stirring Turntable Rectification Rectification Voltage Doubler Half-Wave (Inver ...

  • LG Electronics LRMM1430SW - page 8

    6. OVERALL CIRCUIT DIAGRAM A. SCHEMA TIC DIAGRAM -7- Figure 3 ...

  • LG Electronics LRMM1430SW - page 9

    B. MA TRIX CIRCUIT FOR TOUCH KEY BOARD -8- Figure 4 ...

  • LG Electronics LRMM1430SW - page 10

    7. OPERA TING PROCEDURES A. CONTROL P ANEL Figure 5. -9- 1. Display. The Display includes a clock and indicators that tell you time of day, cooking time settings, and cooking functions selected. 2. Sensor Touch. This pad allows you to cook most of your favorite foods without having to select cooking times and power levels. 3. Homemade Bakery. Homem ...

  • LG Electronics LRMM1430SW - page 11

    B. PANEL INSTRUCTIONS (Figure 5) The entire operation is done by simple touch control pads. (1) Display Window Numbers and letters explained in Figure 5 are shown in the display window (Vacuum Fluorescent Tube). (a) The Time in four digits (12-hour indication): 00 Hour 00 Minute. (b) Cooking Time of Day in four digits 00 Minutes 00 Seconds. (c) Pow ...

  • LG Electronics LRMM1430SW - page 12

    C. EASY USE CHART (1) CLOCK 1. Touch STOP/CLEAR. 2. Touch CLOCK. 3. Touch numbers for correct time of day. 4. Touch CLOCK. (2) “HI-POWER” COOKING 1. Touch STOP/CLEAR. 2. Touch COOK TIME. 3. Touch numbers for desired cooking time. 4. Touch START. (3) “MULTI-STAGE” COOKING 1. Touch STOP/CLEAR. 2. Touch COOK TIME. 3. Touch numbers for cooking ...

  • LG Electronics LRMM1430SW - page 13

    8. PROCEDURE FOR MEASURING MICROW A VE ENERGY LEAKAGE A. CAUTIONS (1) Be sure to check a microwave emission prior to servicing the oven if the oven is operative prior to servicing. (2) The service personnel should inform the manufacturer, importer, or assembler of any certified oven unit found to have a microwave emission level in excess of 5mW/cm. ...

  • LG Electronics LRMM1430SW - page 14

    D. MEASUREMENT WITH A FULLY ASSEMBLED OVEN (1) After all components, including the outer panels, are fully assembled, measure for microwave energy leakage around the door viewing window, the exhaust opening and air inlet openings. (2) Microwave energy leakage must not exceed the values prescribed below. NOTES: Leakage with the outer panels removed ...

  • LG Electronics LRMM1430SW - page 15

    -14- 9. DISASSEMBL Y INSTRUCTIONS IMPORTANT NOTES: UNIT MUST BE DISCONNECTED FROM ELECTRICAL OUTLET WHEN MAKING REPAIRS, RE-PLACEMENTS, ADJUSTMENTS AND CONTINUITY CHECKS. WAIT AT LEAST ONE MINUTE, UNTIL THE HIGH VOLTAGE CAPACITOR IN THE HIGH VOLTAGE POWER SUPPLY HAS FULLY DISCHARGED. THE CAPACITOR SHOULD BE DISCHARGED BY USING INSULATED WIRE - I.E. ...

  • LG Electronics LRMM1430SW - page 16

    C. REMOVING CONTROL CIRCUIT BOARD (Figure 10) (1) Remove out case. (2) Remove door assembly. (3) Unfasten two screws. (4) Lift up and pull out control panel assembly carefully from the cavity. (5) Remove door frame. (6) Remove the F.P.C connector from the terminal socket. (7) Unfasten two screws which tighen the circuit board. (8) Remove control ci ...

  • LG Electronics LRMM1430SW - page 17

    -16- E. AIR GUIDE REMOVAL (Figure 12) (1) Separate cavity and base plate. (2) Unfasten the screws which hold the air guide in the base plate. (3) Unfasten the air guide from hook. F. POWER BOARD AND INVERTER MODULE AND SUCTION GUIDE (Figure 12) (1) Separate cavity and base plate. (2) Remove air guide. (3) Unfasten the screws. (4) Lift up the power ...

  • LG Electronics LRMM1430SW - page 18

    -17- H. MAGNETRON REMOVAL (1) Disconnect the leadwire from the magnetron. (2) Carefully remove the mounting screws holding the magnetron at the waveguide. (3) Remove the magnetron from the waveguide. NOTE: 1. When removing the magnetron, make sure its dome does not hit any adjacent parts, or it may be damaged. 2. When replacing the magnetron, be su ...

  • LG Electronics LRMM1430SW - page 19

    J . FAN MOTOR ASSEMBLY REMOVAL ( 1) Separate cavity and base plate. ( 2) Remove air and suction guide.. ( 3) Remove the two screws holding the fan motor ASSEMBLY to the suction guide ASSEMBLY . ( 4) Disconnect the wires and unfasten the screws. ( 5) Pull out the Fan motor from the suction guide. K. INTERLOCK SYSTEM (1) INTERLOCK MECHANISM The door ...

  • LG Electronics LRMM1430SW - page 20

    -19- A. PRIMARY INTERLOCK SWITCH TEST When the door release button is depressed slowly with the door closed, an audible click should be heard at the same time or successively at intervals. When the button is released slowly, the latches should activate the switches with an audible click . If the latches do not activate the switches when the door is ...

  • LG Electronics LRMM1430SW - page 21

    -20- CAUTIONS 1. DISCONNECT THE POWER SUPPLY CORD FROM THE OUTLET WHENEVER REMOVING THE OUTER CASE FROM THE UNIT. PROCEED WITH THE TEST ONLY AFTER DISCHARGING THE HIGH VOLTAGE CAPACITOR AND REMOVING THE LEAD WIRES FROM THE INVERTER MODULE. 2. ALL OPERATIONAL CHECKS WITH MICROWAVE ENERGY MUST BE DONE WITH A LOAD (1 LITER OF WATER IN CONTAINER) IN TH ...

  • LG Electronics LRMM1430SW - page 22

    -21- COMPONENTS TEST PROCEDURE RESULTS SENSOR Normal: Approximately BK-RD: 5.2 Kohms RD-WH: 2.1 Kohms BK-WH: 2.1 Kohms Abnormal: Infinite or several *Sensor cooking condition 1. Oven should be plugged in at least 5 minutes before sensor cooking. 2. Room temperature should not exceed 95 ˚ F. 3. Be sure the exterior of the cooking container and the ...

  • LG Electronics LRMM1430SW - page 23

    -22- COMPONENTS TEST PROCEDURE RESULTS RELAY FAN MOTOR (Wire leads removed) TURNTABLE MOTOR (Wire leads removed) Check for continuity of relay with an ohm-meter. (Remove lead wires from relay and operate the unit.) Measure the resistance. (Ohm-meter scale: R x 100) Measure the resistance. (Ohm-meter scale: R x 1000) Normal: Approx. ON: 0 ohm OFF: ? ...

  • LG Electronics LRMM1430SW - page 24

    -23- B. CHECKOUT PROCEDURES (1) CHECKOUT PROCEDURES FOR FUSE BLOWING CAUTION: REPLACE BLOWN FUSE WITH 20 AMPERE FUSE. Fuse blows immediately after the door is closed. Fuse blows immediately after the door is opened. Fuse blows when the door is closed and START key is touched. Improper operation of the primary interlock, secondary interlock switches ...

  • LG Electronics LRMM1430SW - page 25

    -24- (2) CHECKOUT PROCEDURES FOR RELAY - PROBLEM (A) - FAN motor and oven lamp turn on without touching START key when the door is closed. Remove the mate connector of I/O CON from the circuit board does the unit still operate? GOOD GOOD Replace the circuit board - PROBLEM (B) - FAN motor and oven lamp turn on When the door is closed and START key ...

  • LG Electronics LRMM1430SW - page 26

    (3) CHECKOUT PROCEDURES FOR CIRCUIT BOARD The following symptoms indicate a defective circuit board. (1) Check the input current. If the input current is more than 20A, check the magnetron and wiring. If the input current is less than 0.5 A, there is no input to the inverter. (2) The start function fails to operate but the interlock switches, the d ...

  • LG Electronics LRMM1430SW - page 27

    -26- C. TROUBLE SHOOTING WHEN YOU GET A COMPLAINT FROM YOUR CUSTOMER, EVALUATE THE COMPLAINT CAREFULLY. IF THE FOLLOWING SYMPTOMS APPLY, PLEASE INSTRUCT THE CUSTOMER IN THE PROPER USE OF THE MICROWAVE OVEN. THIS CAN ELIMINATE AN UNNECESSARY SERVICE CALL. CAUTIONS 1. Check grounding before checking for trouble. 2. Be careful of the Inverter. 3. When ...

  • LG Electronics LRMM1430SW - page 28

    -27- 1. Incomplete segments. • Segment missing. • Partial segment missing. • Digit flickering (NOTE: Slight flickering is normal.) 2. Colon does not turn on or blink. 3. A distinct change in the brightness of one or more numbers in display. 4. One or more digits in the display are not lighting. 5. Display indicates a number different from one ...

  • LG Electronics LRMM1430SW - page 29

    -28- CONDITION CHECK RESULT CAUSE REMEDY 1. Fuse blows. Continuity. No continuity. Continuity. Shorted contact at the primary switch. Replace fuse, primary, monitor switches, and RELAY of P.C.B Assembly. No continuity. Normal. Defective control PCB. Replace Inverter. Fuse blows again Defective Inverter. Replace control PCB. Malfunction of the monit ...

  • LG Electronics LRMM1430SW - page 30

    -29- CONDITION CHECK RESULT CAUSE REMEDY 1. Setting time does not count down when touching START pad. 2. Fan motor or oven lamp do not turn on. No continuity. Continuity. Continuity Defective Power PCB assembly. Loose connection. Replace Power PCB assembly. Connect them tightly. No continuity Abnormal Check fan motor. Defective fan motor. Replace f ...

  • LG Electronics LRMM1430SW - page 31

    -30- CONDITION CHECK RESULT CAUSE REMEDY No microwave oscillation. No continuity. Continuity. Defective PCB assembly. Replace PCB assembly. Disconnect the wire leads from relay and check continuity of relay. ( O perate the unit) Replace Inverter and Magnetron. Output is full power when you set lower power level. Abnormal. Defective PCB assembly. Re ...

  • LG Electronics LRMM1430SW - page 32

    -31- INTRODUCTION EXPLODED VIEW ...

  • LG Electronics LRMM1430SW - page 33

    -32- DOOR P ARTS 14970A 14026A WTP002 13806A 13213A 13552A 13536A 13581A 268711 WTP002 23506A 13551A 15006A ...

  • LG Electronics LRMM1430SW - page 34

    -33- CONTROLLER P ARTS 268711 WTP002 23506A 13551A ...

  • LG Electronics LRMM1430SW - page 35

    -34- OVEN CA VITY P ARTS 33112U WTT022 :Model LRMM 1430SW :Model LRMM 1430SB W107 33390G 35889A WSZ185 36549S WTP013 33052A 13806F 647781 ...

  • LG Electronics LRMM1430SW - page 36

    -35- LA TCH BOARD P ARTS WSZ085 43500A 466001 43501A 466003 466001 ...

  • LG Electronics LRMM1430SW - page 37

    -36- OVEN INTERIOR P ARTS WTT028 WTT021 54974T 56501A 56930V 56912B 43500A 56324A WSZ002 ...

  • LG Electronics LRMM1430SW - page 38

    -37- BASE PLA TE P ARTS 35264A 568772 568771 56549F 56851H 56201A 50FZZA 54980A 43501A 65006B 63302A WTT021 WTT028 WTT034 WSZ002 268712 WTT028 WTT028 WTT028 55900A 54974S 55238A 568711 56411A ...

  • LG Electronics LRMM1430SW - page 39

    -38- REPLACEMENT P AR TS LIST LOC. NO. *01 3828W5A3194 MANUAL,OWNERS R *02 3828W5S3066 MANUAL,SERVICE R *10 3890W3W376B BOX,WHITE R 13213A 3213W0A008B DOOR FRAME ASSEMBLY R 13536A 3536W1A002A SEAL TAPE S 13552A 3552W0A009A CHOKE COVER R 13581A 3581W0A077B DOOR ASSEMBLY R 13806F 3806W1A062A DECO,FRONT R 14026A 4026W1A025A LATCH R 14970A 4970WRA001C ...

  • LG Electronics LRMM1430SW - page 40

    -39- LOC. NO. WTP002 1TPL0302018 SCREW TAPPING,PAN HEAD R WTP013 1TPL0402418 SCREW TAPPING,PAN HEAD R WTT021 1TTL0402418 SCREW TAPPING,TRUSS HEAD R WTT028 1TTL0402818 SCREW TAPPING,TRUSS HEAD R WTT034 1TTL0403418 SCREW TAPPING,TRUSS HEAD R PART NO. DESCRIPTION SVC ALTER R,S: SERVICE PARTS ...

  • LG Electronics LRMM1430SW - page 41

    -40- LOC. NO. *01 3828W5A3340 MANUAL,OWNERS R *02 3828W5S3192 MANUAL,SERVICE R *10 3890W3W377A BOX,WHITE R 13213A 3213W0A008C DOOR FRAME ASSEMBLY R 13352A 3352W1A144A FRONT SCREEN S 13536A 3536W1A002A SEAL TAPE S 13552A 3552W0A009A CHOKE COVER R 13581A 3581W0A077E DOOR ASSEMBLY R 13720D 3720W0D308A PANEL,DOOR R 13806F 3806W1A062B DECO,FRONT R 14026 ...

  • LG Electronics LRMM1430SW - page 42

    -41- LOC. NO. WTP002 1TPL0302018 SCREW TAPPING,PAN HEAD R WTP013 1TPL0402418 SCREW TAPPING,PAN HEAD R WTT021 1TTL0402418 SCREW TAPPING,TRUSS HEAD R WTT022 1TTL0402422 SCREW TAPPING,TRUSS HEAD R WTT028 1TTL0402818 SCREW TAPPING,TRUSS HEAD R WTT034 1TTL0403418 SCREW TAPPING,TRUSS HEAD R PART NO. DESCRIPTION SVC ALTER R,S: SERVICE PARTS ...

  • LG Electronics LRMM1430SW - page 43

    -42- SCHEMA TIC DIAGRAM OF P .C.B ...

  • LG Electronics LRMM1430SW - page 44

    -43- PRINTED CIRCUIT BOARD KEY PCB MAIN PCB ...

  • LG Electronics LRMM1430SW - page 45

    -44- P .C.B. P AR TS LIST LOC. PART NO. DESCRIPTION SPECIFICATION SVC ALTER NO. AR1 0RZ1503G610 RESISTOR,DRAWING 150KOHM 1/4W 5% 3216 BULK 8 PIN R BZ1 6908W3YA01C BUZZER TFM-57 CW NINGBO EAST PIEZO 2048HZ 70D R 6908W3YA01A C01 0CK1040K948 CAPACITOR,FIXED CERAMIC(HIGH DIELECTRIC) 0.1UF D 50V 80%,-20% F(Y5V) TA26 R C02 0CE2276K618 CAPACITOR,FIXED ELE ...

  • LG Electronics LRMM1430SW - page 46

    -45- LOC. PART NO. DESCRIPTION SPECIFICATION SVC ALTER NO. D61 0DD414809AA DIODE,SWITCHING 1N4148 ROHM TP26 DO35 100V 450MA 2A 3NS R D90 0DD414809AB DIODE 1N4148M PYUNG CHANG TP26 DO34 60V 0.5A 0 R D91 0DD414809AB DIODE 1N4148M PYUNG CHANG TP26 DO34 60V 0.5A 0 R D92 0DD414809AB DIODE 1N4148M PYUNG CHANG TP26 DO34 60V 0.5A 0 R D93 0DD414809AB DIODE ...

  • LG Electronics LRMM1430SW - page 47

    -46- LOC. PART NO. DESCRIPTION SPECIFICATION SVC ALTER NO. R38 0RD5601G608 RESISTOR,FIXED CARBON FILM 5.6K OHM 1/4 W 5% TA26 R R39 0RD1002F608 RESISTOR,FIXED CARBON FILM 10K OHM 1/6 W 5% TA26 R R45 0RD4702F608 RESISTOR,FIXED CARBON FILM 47K OHM 1/6 W 5% TA26 R R46 0RD3302F608 RESISTOR,FIXED CARBON FILM 33K OHM 1/6 W 5% TA26 R R47 0RD1001F608 RESIST ...

  • LG Electronics LRMM1430SW - page 48

    P/NO : 3828W5S3066 May , 2003 Printed in Korea ...

Производитель LG Electronics Категория Microwave Oven

Документы, которые мы получаем от производителя устройства LG Electronics LRMM1430SW мы можем разделить на несколько групп. Это в частности:
- технические чертежи LG Electronics
- инструкции обслуживания LRMM1430SW
- паспорта изделия LG Electronics
- информационные брошюры
- энергетические этикетки LG Electronics LRMM1430SW
Все из них важны, однако самую важную информацию с точки зрения пользователя мы найдем в инструкции обслуживания LG Electronics LRMM1430SW.

Группа документов, определяемая как инструкции обслуживания, делится также на более подробные типы, такие как: Инструкции монтажа LG Electronics LRMM1430SW, инструкции обслуживания, короткие инструкции или инструкции пользователя LG Electronics LRMM1430SW. В зависимости от потребностей, Вам необходимо поискать требуемый документ. На нашем сайте Вы можете просмотреть самую популярную инструкцию использования изделия LG Electronics LRMM1430SW.

Похожие инструкции обслуживания

Полная инструкция обслуживания устройства LG Electronics LRMM1430SW, как должна выглядеть?
Инструкция обслуживания, определяемая также как пособие пользователя, или просто "руководство" - это технический документ, цель которого заключается в использовании LG Electronics LRMM1430SW пользователями. Инструкции пишет, как правило технический писатель, языком, доступным для всех пользователей LG Electronics LRMM1430SW.

Полная инструкция обслуживания LG Electronics, должна заключать несколько основных элементов. Часть из них менее важная, как например: обложка / титульный лист или авторские страницы. Однако остальная часть, должна дать нам важную с точки зрения пользователя информацию.

1. Вступление и рекомендации, как пользоваться инструкцией LG Electronics LRMM1430SW - В начале каждой инструкции, необходимо найти указания, как пользоваться данным пособием. Здесь должна находится информация, касающаяся местонахождения содержания LG Electronics LRMM1430SW, FAQ и самых распространенных проблем - то есть мест, которые чаще всего ищут пользователи в каждой инструкции обслуживания
2. Содержание - индекс всех советов, касающихся LG Electronics LRMM1430SW, которое найдем в данном документе
3. Советы по использованию основных функций устройства LG Electronics LRMM1430SW - которые должны облегчить нам первые шаги во время использования LG Electronics LRMM1430SW
4. Troubleshooting - систематизированный ряд действия, который поможет нам диагностировать а в дальнейшем очередность решения важнейших проблем LG Electronics LRMM1430SW
5. FAQ - чаще всего задаваемые вопросы
6. Контактные данные Информация о том, где искать контактные данные производителя / сервисного центра LG Electronics LRMM1430SW в данной стране, если самостоятельно не получится решить проблему.

У вас вопрос, касающийся LG Electronics LRMM1430SW?

Воспользуйтесь формуляром, находящимся ниже

Если с помощью найденной инструкции Вы не решили свою проблему с LG Electronics LRMM1430SW, задайте вопрос, заполнив следующий формуляр. Если у какого то из пользователей была похожая проблема с LG Electronics LRMM1430SW со всей вероятностью он захочет поделиться методом ее решения.

Перепишите текст с картинки

Captcha
Новая картинка

Комментарии (0)