Русский dropdown-ico

Инструкция обслуживания Hoshizaki DMC-750BWF

34 страниц 0.34 mb
Скачать

Перейти на страницу of 34

Summary
  • Hoshizaki DMC-750BWF - page 1

    INSTRUCTION MANUAL ISSUED: APRIL 13, 1998 CUBELET ICE DISPENSER R eliability is a beautiful thing TM REVISED: NOV . 18, 2003 DCM-500BAF DCM-500BWF DCM-750BAF DCM-750BWF ...

  • Hoshizaki DMC-750BWF - page 2

    2 HOSHIZAKI provides this manual primarily to assist qualified service technicians in the installation, maintenance and service of the ice dispenser. Should the reader have any questions or concerns which have not been satisfactorily addressed, please call or write to the HOSHIZAKI Technical Support Department for assistance. Only qualified service ...

  • Hoshizaki DMC-750BWF - page 3

    3 • Please review this manual. It should be read carefully before the ice dispenser is in- stalled and operated. Only qualified service technicians should install, service and main- tain the ice dispenser. This manual should be made available to the technician prior to installation, service or maintenance. • Keep this manual with the ice dispen ...

  • Hoshizaki DMC-750BWF - page 4

    4 MODEL NUMBER MODEL NUMBER MODEL NUMBER MODEL NUMBER MODEL NUMBER SERIAL NUMBER SERIAL NUMBER SERIAL NUMBER SERIAL NUMBER SERIAL NUMBER AC SUPPLY VOLTAGE AC SUPPLY VOLTAGE AC SUPPLY VOLTAGE AC SUPPLY VOLTAGE AC SUPPLY VOLTAGE COMPRESSOR COMPRESSOR COMPRESSOR COMPRESSOR COMPRESSOR GEAR MOTOR GEAR MOTOR GEAR MOTOR GEAR MOTOR GEAR MOTOR FAN MOTOR FAN ...

  • Hoshizaki DMC-750BWF - page 5

    5 We reserve the right to make changes in specifications and design without prior notice. MODEL NUMBER MODEL NUMBER MODEL NUMBER MODEL NUMBER MODEL NUMBER SERIAL NUMBER SERIAL NUMBER SERIAL NUMBER SERIAL NUMBER SERIAL NUMBER AC SUPPLY VOLTAGE AC SUPPLY VOLTAGE AC SUPPLY VOLTAGE AC SUPPLY VOLTAGE AC SUPPLY VOLTAGE COMPRESSOR COMPRESSOR COMPRESSOR CO ...

  • Hoshizaki DMC-750BWF - page 6

    6 MODEL NUMBER MODEL NUMBER MODEL NUMBER MODEL NUMBER MODEL NUMBER SERIAL NUMBER SERIAL NUMBER SERIAL NUMBER SERIAL NUMBER SERIAL NUMBER AC SUPPLY VOLTAGE AC SUPPLY VOLTAGE AC SUPPLY VOLTAGE AC SUPPLY VOLTAGE AC SUPPLY VOLTAGE COMPRESSOR COMPRESSOR COMPRESSOR COMPRESSOR COMPRESSOR GEAR MOTOR GEAR MOTOR GEAR MOTOR GEAR MOTOR GEAR MOTOR FAN MOTOR FAN ...

  • Hoshizaki DMC-750BWF - page 7

    7 See the Nameplate for electrical and refrigeration specifications. This Nameplate is located on the upper part of the Left Side Panel. [d] DCM-750BWF (Water-cooled) [d] DCM-750BWF (Water-cooled) [d] DCM-750BWF (Water-cooled) [d] DCM-750BWF (Water-cooled) [d] DCM-750BWF (Water-cooled) MODEL NUMBER MODEL NUMBER MODEL NUMBER MODEL NUMBER MODEL NUMBE ...

  • Hoshizaki DMC-750BWF - page 8

    8 Unit: inch (mm.) 2. DIMENSIONS/CONNECTIONS 2. DIMENSIONS/CONNECTIONS 2. DIMENSIONS/CONNECTIONS 2. DIMENSIONS/CONNECTIONS 2. DIMENSIONS/CONNECTIONS [a] DCM-500BAF [a] DCM-500BAF [a] DCM-500BAF [a] DCM-500BAF [a] DCM-500BAF ...

  • Hoshizaki DMC-750BWF - page 9

    9 Unit: inch (mm.) [b] DCM-500BWF [b] DCM-500BWF [b] DCM-500BWF [b] DCM-500BWF [b] DCM-500BWF ...

  • Hoshizaki DMC-750BWF - page 10

    10 Unit: inch (mm.) [c] DCM-750BAF [c] DCM-750BAF [c] DCM-750BAF [c] DCM-750BAF [c] DCM-750BAF ...

  • Hoshizaki DMC-750BWF - page 11

    11 Unit: inch (mm.) [d] DCM-750BWF [d] DCM-750BWF [d] DCM-750BWF [d] DCM-750BWF [d] DCM-750BWF ...

  • Hoshizaki DMC-750BWF - page 12

    12 II. GENERAL INFORMATION II. GENERAL INFORMATION II. GENERAL INFORMATION II. GENERAL INFORMATION II. GENERAL INFORMATION 1. CONSTRUCTION 1. CONSTRUCTION 1. CONSTRUCTION 1. CONSTRUCTION 1. CONSTRUCTION Hoshizaki Cubelet Ice Dispensers, models DCM-500BAF, DCM-500BWF, DCM-750BAF and DCM-750BWF include Water Supply, Freezer, Condensing, Storage, Disp ...

  • Hoshizaki DMC-750BWF - page 13

    13 2. OPERATION - How it works 2. OPERATION - How it works 2. OPERATION - How it works 2. OPERATION - How it works 2. OPERATION - How it works Water flows from a potable water source through the Water Supply Line Shut-off Valve, enters at the water inlet fitting and on to the Water Supply Assembly. The water supply functions to maintain a constant ...

  • Hoshizaki DMC-750BWF - page 14

    14 III. INSTALLATION AND OPERATING INSTRUCTIONS III. INSTALLATION AND OPERATING INSTRUCTIONS III. INSTALLATION AND OPERATING INSTRUCTIONS III. INSTALLATION AND OPERATING INSTRUCTIONS III. INSTALLATION AND OPERATING INSTRUCTIONS 1. CHECKS BEFORE INSTALLATION 1. CHECKS BEFORE INSTALLATION 1. CHECKS BEFORE INSTALLATION 1. CHECKS BEFORE INSTALLATION 1. ...

  • Hoshizaki DMC-750BWF - page 15

    15 3. LOCATION 3. LOCATION 3. LOCATION 3. LOCATION 3. LOCATION WARNING WARNING WARNING WARNING WARNING This ice dispenser is not intended for outdoor use. Normal operating ambient temperature should be within +45°F to +100°F; normal operating water temperature should be within +45°C to +90°C. Operation of the ice dispenser, for extended periods ...

  • Hoshizaki DMC-750BWF - page 16

    16 Fig. 3 Fig. 3 Fig. 3 Fig. 3 Fig. 3 5. CABINET STAND 5. CABINET STAND 5. CABINET STAND 5. CABINET STAND 5. CABINET STAND When placing the ice dispenser on the Cabinet Stand: 1) Attach four adjustable legs to the Cabinet Stand. (Cabinet Stand accessory) 2) Remove the protective plastic film from the panels. 3) Remove the Front Panel by lifting up ...

  • Hoshizaki DMC-750BWF - page 17

    17 Fig. 4 Fig. 4 Fig. 4 Fig. 4 Fig. 4 DIMENSIONS WITH DCM-500BAF ON SD-450 Unit: inch (mm.) ...

  • Hoshizaki DMC-750BWF - page 18

    18 DIMENSIONS WITH DCM-750BAF ON SD-700 Unit: inch (mm.) Fig. 5 Fig. 5 Fig. 5 Fig. 5 Fig. 5 ...

  • Hoshizaki DMC-750BWF - page 19

    19 Fig. 6 Fig. 6 Fig. 6 Fig. 6 Fig. 6 6. ELECTRICAL CONNECTION - See Fig. 6 6. ELECTRICAL CONNECTION - See Fig. 6 6. ELECTRICAL CONNECTION - See Fig. 6 6. ELECTRICAL CONNECTION - See Fig. 6 6. ELECTRICAL CONNECTION - See Fig. 6 WARNING WARNING WARNING WARNING WARNING This ice dispenser requires a ground that meets the national and local electrical ...

  • Hoshizaki DMC-750BWF - page 20

    20 7. WATER SUPPLY AND DRAIN CONNECTIONS - See Fig. 7 and 8 7. WATER SUPPLY AND DRAIN CONNECTIONS - See Fig. 7 and 8 7. WATER SUPPLY AND DRAIN CONNECTIONS - See Fig. 7 and 8 7. WATER SUPPLY AND DRAIN CONNECTIONS - See Fig. 7 and 8 7. WATER SUPPLY AND DRAIN CONNECTIONS - See Fig. 7 and 8 • Water supply inlet is 1/2" female pipe thread (FPT). ...

  • Hoshizaki DMC-750BWF - page 21

    21 Fig. 7 Fig. 7 Fig. 7 Fig. 7 Fig. 7 Air Cooled Model Fig. 8 Fig. 8 Fig. 8 Fig. 8 Fig. 8 Water Cooled Model ...

  • Hoshizaki DMC-750BWF - page 22

    22 8. FINAL CHECK LIST 8. FINAL CHECK LIST 8. FINAL CHECK LIST 8. FINAL CHECK LIST 8. FINAL CHECK LIST 1) Is the ice dispenser level? 2) Is the ice dispenser in a site where the ambient temperature is within +45°F to +100°F all year around? 3) Is there at least a 6" clearance around the icemaker for maintenance or service? 4) Have all shippi ...

  • Hoshizaki DMC-750BWF - page 23

    23 9. START UP - See Fig. 9 9. START UP - See Fig. 9 9. START UP - See Fig. 9 9. START UP - See Fig. 9 9. START UP - See Fig. 9 WARNING WARNING WARNING WARNING WARNING 1. All parts are factory-adjusted. Improper adjustments may result in failure. 2. If the unit is turned off, wait for at least 3 minutes before restarting the ice dispenser to preven ...

  • Hoshizaki DMC-750BWF - page 24

    24 11) Check if there is any abnormal noise from the Compressor, Fan Motor or Gear Motor(s) after 30 minutes of running. 12) Move the Dispense Mode Switch, located at the bottom of the Middle Front Panel, to the “PORTION” or “CONTINUOUS” position. 13) Press the Push Button to dispense ice, and the dispensing mechanism will operate. 14) Pres ...

  • Hoshizaki DMC-750BWF - page 25

    25 Note: When shipped, the Portion Control is set at the minimum dispensing time (0.6 sec.) Model DCM-500BAF, BWF . . . . . . . . . . . . about 0.72 oz. DCM-750BAF, BWF . . . . . . . . . . . . about 0.84 oz. IMPORTANT IMPORTANT IMPORTANT IMPORTANT IMPORTANT Leaving ice in long storage may result in the formation of an ice block or bridge due to wet ...

  • Hoshizaki DMC-750BWF - page 26

    26 11. PREPARING THE ICEMAKER FOR LONG STORAGE - See Fig. 11 11. PREPARING THE ICEMAKER FOR LONG STORAGE - See Fig. 11 11. PREPARING THE ICEMAKER FOR LONG STORAGE - See Fig. 11 11. PREPARING THE ICEMAKER FOR LONG STORAGE - See Fig. 11 11. PREPARING THE ICEMAKER FOR LONG STORAGE - See Fig. 11 and 12 and 12 and 12 and 12 and 12 WARNING WARNING WARNIN ...

  • Hoshizaki DMC-750BWF - page 27

    27 IMPORTANT IMPORTANT IMPORTANT IMPORTANT IMPORTANT Before operating the dispenser next time, check that the Water Supply Line Drain Valve is closed, and open the Water Supply Line Shut-off Valve. Note: When shutting off the ice dispenser at sub-freezing temperatures, run the ice dispenser with the Water Supply Line Shut-off Valve closed, and blow ...

  • Hoshizaki DMC-750BWF - page 28

    28 V. CLEANING AND MAINTENANCE INSTRUCTIONS V. CLEANING AND MAINTENANCE INSTRUCTIONS V. CLEANING AND MAINTENANCE INSTRUCTIONS V. CLEANING AND MAINTENANCE INSTRUCTIONS V. CLEANING AND MAINTENANCE INSTRUCTIONS IMPORTANT IMPORTANT IMPORTANT IMPORTANT IMPORTANT Ensure all components, fasteners and thumbscrews are securely in place after any maintenance ...

  • Hoshizaki DMC-750BWF - page 29

    29 8) Wait for 10 minutes before starting the icemaking process. Then turn on the Power Switch and move the Control Switch to the “ICE” position. Run the ice dispenser until it stops automatically. Note: This ice dispenser will not run without the Front Panel. Replace the Top Panel and the Front Panel. 9) Repeat Step 5). 10) Pour water into the ...

  • Hoshizaki DMC-750BWF - page 30

    30 [b] STORAGE BIN - Following Cleaning Procedures for Water System [b] STORAGE BIN - Following Cleaning Procedures for Water System [b] STORAGE BIN - Following Cleaning Procedures for Water System [b] STORAGE BIN - Following Cleaning Procedures for Water System [b] STORAGE BIN - Following Cleaning Procedures for Water System 1) Remove the Front Co ...

  • Hoshizaki DMC-750BWF - page 31

    31 7) Immerse the parts removed in the above steps 2) through 6) in the cleaning and sanitizing solution for about 15 minutes each. 8) Rinse these parts thoroughly with clean water. 9) Wipe thoroughly the Shutter located above the Ice Dispensing Spout. 10) Reassemble the Bin Control Bracket Assembly. 11) Place the Dispensing Auger and Agitator, Bin ...

  • Hoshizaki DMC-750BWF - page 32

    32 2. MAINTENANCE 2. MAINTENANCE 2. MAINTENANCE 2. MAINTENANCE 2. MAINTENANCE IMPORTANT IMPORTANT IMPORTANT IMPORTANT IMPORTANT 1. This ice dispenser must be maintained individually, referring to the instruction manual and labels provided with the ice dispenser. 2. To obtain optimum performance of this ice dispenser, the following consumable parts ...

  • Hoshizaki DMC-750BWF - page 33

    33 3) Air Filter (Air-cooled model only) - See Fig. 17. A plastic mesh air filter removes dirt or dust from the air and keeps the Condenser from getting clogged. As the filter becomes clogged, the ice dispenser’s performance will be reduced. Check the filter at least twice a month. When clogged, use warm water and a neutral cleaner to wash the fi ...

  • Hoshizaki DMC-750BWF - page 34

    HOSHIZAKI HOSHIZAKI AMERICA, INC. HOSHIZAKI AMERICA, INC. HOSHIZAKI AMERICA, INC. HOSHIZAKI AMERICA, INC. HOSHIZAKI AMERICA, INC. 618 HIGHWAY 74 SOUTH 618 HIGHWAY 74 SOUTH 618 HIGHWAY 74 SOUTH 618 HIGHWAY 74 SOUTH 618 HIGHWAY 74 SOUTH PEACHTREE CITY, GA 30269 PEACHTREE CITY, GA 30269 PEACHTREE CITY, GA 30269 PEACHTREE CITY, GA 30269 PEACHTREE CITY, ...

Производитель Hoshizaki Категория Ice Maker

Документы, которые мы получаем от производителя устройства Hoshizaki DMC-750BWF мы можем разделить на несколько групп. Это в частности:
- технические чертежи Hoshizaki
- инструкции обслуживания DMC-750BWF
- паспорта изделия Hoshizaki
- информационные брошюры
- энергетические этикетки Hoshizaki DMC-750BWF
Все из них важны, однако самую важную информацию с точки зрения пользователя мы найдем в инструкции обслуживания Hoshizaki DMC-750BWF.

Группа документов, определяемая как инструкции обслуживания, делится также на более подробные типы, такие как: Инструкции монтажа Hoshizaki DMC-750BWF, инструкции обслуживания, короткие инструкции или инструкции пользователя Hoshizaki DMC-750BWF. В зависимости от потребностей, Вам необходимо поискать требуемый документ. На нашем сайте Вы можете просмотреть самую популярную инструкцию использования изделия Hoshizaki DMC-750BWF.

Похожие инструкции обслуживания

Полная инструкция обслуживания устройства Hoshizaki DMC-750BWF, как должна выглядеть?
Инструкция обслуживания, определяемая также как пособие пользователя, или просто "руководство" - это технический документ, цель которого заключается в использовании Hoshizaki DMC-750BWF пользователями. Инструкции пишет, как правило технический писатель, языком, доступным для всех пользователей Hoshizaki DMC-750BWF.

Полная инструкция обслуживания Hoshizaki, должна заключать несколько основных элементов. Часть из них менее важная, как например: обложка / титульный лист или авторские страницы. Однако остальная часть, должна дать нам важную с точки зрения пользователя информацию.

1. Вступление и рекомендации, как пользоваться инструкцией Hoshizaki DMC-750BWF - В начале каждой инструкции, необходимо найти указания, как пользоваться данным пособием. Здесь должна находится информация, касающаяся местонахождения содержания Hoshizaki DMC-750BWF, FAQ и самых распространенных проблем - то есть мест, которые чаще всего ищут пользователи в каждой инструкции обслуживания
2. Содержание - индекс всех советов, касающихся Hoshizaki DMC-750BWF, которое найдем в данном документе
3. Советы по использованию основных функций устройства Hoshizaki DMC-750BWF - которые должны облегчить нам первые шаги во время использования Hoshizaki DMC-750BWF
4. Troubleshooting - систематизированный ряд действия, который поможет нам диагностировать а в дальнейшем очередность решения важнейших проблем Hoshizaki DMC-750BWF
5. FAQ - чаще всего задаваемые вопросы
6. Контактные данные Информация о том, где искать контактные данные производителя / сервисного центра Hoshizaki DMC-750BWF в данной стране, если самостоятельно не получится решить проблему.

У вас вопрос, касающийся Hoshizaki DMC-750BWF?

Воспользуйтесь формуляром, находящимся ниже

Если с помощью найденной инструкции Вы не решили свою проблему с Hoshizaki DMC-750BWF, задайте вопрос, заполнив следующий формуляр. Если у какого то из пользователей была похожая проблема с Hoshizaki DMC-750BWF со всей вероятностью он захочет поделиться методом ее решения.

Перепишите текст с картинки

Captcha
Новая картинка

Комментарии (0)