Русский dropdown-ico

Инструкция обслуживания Unified Brands HY-6E(CE)

34 страниц 2.89 mb
Скачать

Перейти на страницу of 34

Summary
  • Unified Brands HY-6E(CE) - page 1

    This manual provides information for: H Y - 6 E ( C E ) H Y P E R S T E A M ™ A T M O S P H E R I C C O N V E C T I O N S T E A M E R I N T E R N A T I O N A L · Self-Contained · Electric Heated · Capacity: 6 Steamer Pans (305 x 508 x 64mm) OPERA TOR MANUAL & SERVICE MANUAL IMPORT ANT INFORMA TION, KEEP FOR OPERA TOR P AR T NUMBER 128717, ...

  • Unified Brands HY-6E(CE) - page 2

    2 OM/SM-HY -6E(CE) OM/SM-HY-6E(CE) 2 IMPORT ANT — RE AD FIRS T — IMPO RTANT THESE APPLIANCES MUST BE INSTALLED BY A COMPETENT PERSON IN CONFORMITY WITH THE INSTALLATION AND SERVICING INSTRUCTIONS AND NATIONAL REG ULATIONS IN FORCE AT THE TIME. PARTICULAR ATTENTION MUST BE PAID TO THE FOLLOWING: I. E. E. REGULA TIONS FOR ELECTR ICAL INSTALLATI O ...

  • Unified Brands HY-6E(CE) - page 3

    OM/SM-HY -6E(CE) 3 OM/SM-HY-6E(CE) 3 WARNING: WHEN YOU OPEN THE DOOR, STA Y AWAY FROM STEAM COMING OUT OF THE UNIT. STEAM CA N CAUSE B URNS. WARNING: BEFORE CLEANING THE OUTSIDE OF THE STEAMER, DISCONNECT THE ELECTRIC POWER SUPPLY. KEEP WATER AND CLEANING SOLUTIONS OUT OF CONTROLS AND ELECTRICAL COMPONENTS. NEV ER HOSE OR STEAM CLEAN ANY PAR T OF T ...

  • Unified Brands HY-6E(CE) - page 4

    4 OM/SM-HY -6E(CE) OM/SM-HY-6E(CE) 4 Table of Conten ts 1 . 0 E Q U I P M E N T D E S C R I P T I O N ............................................. 5 2 . 0 I N S P E C T I O N A N D U N P A C K I N G .......................................... 5 3.0 WATER CO NDITIONING/ REQUIREMENT S . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ...

  • Unified Brands HY-6E(CE) - page 5

    OM/SM-HY -6E(CE) 5 OM/SM-HY-6E(CE) 5 The HY-6E (CE) has two independent cavities, each w ith its own base-moun ted steam generator. (New model shown). The unit will be delivered in a heav y carton, strapped to a wooden skid. 1.0 - Equipment Description Your Groen HY-6E (C E) HyPerSteam Convect ion Steamer is designed to giv e years of service. It h ...

  • Unified Brands HY-6E(CE) - page 6

    6 OM/SM-HY -6E(CE) OM/SM-HY-6E(CE) 6 The BPST Connection on the right rear side of the steamer. 3.0 - Water Conditioning It is essential to supply the steam generator with water that will not form s cale. Even though the steam generator is engineered to minimize scale formation, scale development depends on the hardness of your water and the number ...

  • Unified Brands HY-6E(CE) - page 7

    OM/SM-HY -6E(CE) 7 OM/SM-HY-6E(CE) 7 4.0 - Installation and Start-Up WARNING THE UNIT M UST BE INSTALLED BY PERSONNEL WHO ARE QUA LIFIED TO W ORK WITH E LECTRICITY AND PLUMBIN G. IMPROPER INSTALLATION CAN CAUSE INJURY TO PERSONNEL AND/OR DAMAGE TO THE EQUIPMENT. THE UNIT M UST BE INSTALLED IN ACCORDANCE WITH APPLICABLE CODES. CAUTION DO NOT INSTALL ...

  • Unified Brands HY-6E(CE) - page 8

    8 OM/SM-HY -6E(CE) OM/SM-HY-6E(CE) 8 Leave an air gap between the hose and the building drain, and don’t allow water traps in the hose. WARNING TO AVOID DAM AGE OR INJURY , FOLLOW THE ELE CTRICAL SCH EMATIC EXAC TLY WHEN CONN ECTING THE UNIT. HY-6E (CE) HyPerSteam™ convection steamers operate at 400 Volts (Three Phase) or 230 Volts (One Phase). ...

  • Unified Brands HY-6E(CE) - page 9

    OM/SM-HY -6E(CE) 9 OM/SM-HY-6E(CE) 9 5.0 - Operation WARNING AN Y POT ENTIAL USER O F T HE EQUIPMENT SHOULD BE TRAINED IN SAFE AN D CORR ECT OPERAT ING PROCEDURES. 5.1 Controls Operator controls are on the front right of the unit. The control panel has the following touch pads and indicator ligh ts. (Your contro ls may have eith er words or the sym ...

  • Unified Brands HY-6E(CE) - page 10

    10 OM/SM-HY -6E(CE) OM/SM-HY-6E(CE) 10 5.2.5 Open the door. Remove the pans from the steamer, using hot pads or oven mitts to protect your hands from the hot pans. 5.2.6 To shut down the unit, press the ON switch/pad to OFF. The steam generator will automatically drain. ...

  • Unified Brands HY-6E(CE) - page 11

    OM/SM-HY -6E(CE) 11 OM/SM-HY-6E(CE) 11 6.0 - Cleaning To keep your HY-6E Steamer in proper working condition/o rder, use the following proced ure to clean the unit. This regular cleaning will reduce the effort required to clean the steam generators and cavities. 6.1 Suggested Tools 1. Mild detergen t 2. Stainless steel exterior cleaner such as Zepp ...

  • Unified Brands HY-6E(CE) - page 12

    12 OM/SM-HY -6E(CE) OM/SM-HY-6E(CE) 12 The process for de-liming your HY-6E (CE) Steamer is simple, tool-less and quick. 6.2.2 Steam Generator and Cooking Chamber The steamer cavity and steam generator may be cleaned s eparately . When cleaning is scheduled, or if theSERVICE light is on, follow these simple de- liming instructions. REMEMBER: DON’ ...

  • Unified Brands HY-6E(CE) - page 13

    OM/SM-HY -6E(CE) 13 OM/SM-HY-6E(CE) 13 7.0 - Maintenance The HY-6E Steamer is designed for minimum maintenance, and no user adjustments should be necessary. Certain parts may need replacement after prolonged use. If there is a need for service, only Groen per sonnel or author ized Groen representatives should perform the work. Alwa ys supply wat er ...

  • Unified Brands HY-6E(CE) - page 14

    14 OM/SM-HY -6E(CE) OM/SM-HY-6E(CE) 14 9.0 - Parts List 9.1 External Cabinet and Sheet Metal Key Description Part No. Key Description Part No. 1 Lower Side Panels 125899 9a Door Pin Lock Nut 003823 2 Lower Front Pa nel 125898 10 Timer Knob 123100 3 Adjustable Table Leg 042505 11 Mylar Overla y Plate 123128 4 Door 094150 12 Vent Pipe 096855 5 Door H ...

  • Unified Brands HY-6E(CE) - page 15

    OM/SM-HY -6E(CE) 15 OM/SM-HY-6E(CE) 15 9.0 - Parts List 9.2 Cavity Control Section Key Description Part No. Key Description Part No. 1 Top Cover Clip 123150 8 x 1-3/8” Hose Clamp 127525 2 Timer 100983 9 Fan Motor 096740 3 x Door Switch 096857 10 Motor Capacitor 096813 4 Ready Thermostat 088865 11 Cover, Control Pa nel 119806 5 Steam Port 088874 1 ...

  • Unified Brands HY-6E(CE) - page 16

    16 OM/SM-HY -6E(CE) OM/SM-HY-6E(CE) 16 9.0 - Parts List 9.3 Steamer Base Section Key Description Part No. Key Description Part No. 1 Terminal Block 096810 7 Control Transformer 120/208/240 Volt Pri. 24 Vo lt Sec. 150VA 121716 2 Fuse Block 096809 3 Fuse 20 Amp 071849 8 Hi-Heat Contactor 119811 4 Water Level Prob es 070178 9 Harnesses (see pg 21) 5 H ...

  • Unified Brands HY-6E(CE) - page 17

    OM/SM-HY -6E(CE) 17 OM/SM-HY-6E(CE) 17 9.0 - Parts List 9.4 Steamer Base - Rear View Key Description Part No. Key Description Part No. 1 Outer Steam Generator 096719 12 Drain Box 096791 2 Inner Steam Generator 096719 13 Drain Box Flap 099213 3 Top Steam Ho se 099952 14 Drain Box Cov er 096792 4 Bottom Ste am Hose 099951 15 Top Cavity Drain Hose 088 ...

  • Unified Brands HY-6E(CE) - page 18

    18 OM/SM-HY -6E(CE) OM/SM-HY-6E(CE) 18 9.0 - Parts List 9.5 Steamer Motor and Controls Key Description Part No. Key Description Part No. 1 Fan Motor 096740 7 Timer Knob 123100 2 Motor Mounting Plate 094134 8 Door Switch 096857 3 Motor Shaft Seal 09686 8 9 Steam Port Kit* 118102 4 Motor Insulator 094135 10 -Ready Thermostat 08 8865 5 Fan 096790 11 - ...

  • Unified Brands HY-6E(CE) - page 19

    OM/SM-HY -6E(CE) 19 OM/SM-HY-6E(CE) 19 9.0 - Parts List 9.6 Steamer Generator Individual Parts Key Description New Key Description New 1 Steam Generator We ldmen t 096887 9 Top St eam Hose 099953 2 Right Steam Gen. Insulatio n* 096896 10 Sink Drain Hose 099915 3 Left Steam Gen. Insulation* 096770 11 Water In let Hose 096772 4 Safety V alve 106392 1 ...

  • Unified Brands HY-6E(CE) - page 20

    20 OM/SM-HY -6E(CE) OM/SM-HY-6E(CE) 20 9.0 - Parts List 9.7 Steamer Individual Parts Key Description Part No. Key Description Part No. 1 Heater Element, 240V 121706 7 Water Inlet Valve 3-way 090827 2 Heater Element, Gasket 042366 8 Control Transformer 120/208/240 Volt Pri. 24 Volt Se c. 150VA 121716 3 High Limit Thermostat 122009 4 Thermo stat Clam ...

  • Unified Brands HY-6E(CE) - page 21

    OM/SM-HY -6E(CE) 21 OM/SM-HY-6E(CE) 21 10 - Service Information: The following procedures a re based upon having access to the stea mer on all four si des. If the steamer is installed betwe en other appliances and there is not enough room on the s ides for acce ss, the steame r mu st t hen be pulled ou t f rom i ts position to gain proper access. C ...

  • Unified Brands HY-6E(CE) - page 22

    22 OM/SM-HY -6E(CE) OM/SM-HY-6E(CE) 22 5. Attach new drain valve to valve bracket. Pull silicone hose through drain valve and loosely install h ose clamps over both ends of the hose. Be sure silicone hose is properly aligned and does not have any kinks, bends and/or twists. 6. Position the valve over the valve mounting threaded studs and connect bo ...

  • Unified Brands HY-6E(CE) - page 23

    OM/SM-HY -6E(CE) 23 OM/SM-HY-6E(CE) 23 2. Lift the cover of the drain box. The re are no fasteners holding the cover on the d rain box. 3. Tip the cover and note ther e is a circular hole in the middle and the spray nozzle (with a hex head) is in the center of the hole. 4. W ith a sock et wrench, turn the spray nozzle in the counter-clockwise direc ...

  • Unified Brands HY-6E(CE) - page 24

    24 OM/SM-HY -6E(CE) OM/SM-HY-6E(CE) 24 3. Unplug the six terminals for the high heat elements on the heater plate. Note which wires (in the harness) go to which term inals. B oth the terminals and wir es are numbered I to 6. 4. Unplug the set of two pigt ail wires connecting the low heat element to the heater plate. 5. Remove the two 6-32 self-tapp ...

  • Unified Brands HY-6E(CE) - page 25

    OM/SM-HY -6E(CE) 25 OM/SM-HY-6E(CE) 25 10.13 Supply Voltage Terminal Block - P/N 09 6810 Fuse - P/N 096809 Fuse 20 Am p - P/N 071489 1. Turn off the power to the steamer. 2. Remove the cover from the electrical compartment. 3. The ter minal block is locate d on the back wall of the electrical compartment. 4. Using a flat blade screwdriver, disconne ...

  • Unified Brands HY-6E(CE) - page 26

    26 OM/SM-HY -6E(CE) OM/SM-HY-6E(CE) 26 corresponding hole punched into the front panel. This hole may be seen from the inside of the c ompartment only when the timer is rem oved. To Install: 6. Fit the timer in place ma king sure that it i s properly placed so that the disk on the timer f its into the punched hole in the front panel. 7. Once the ti ...

  • Unified Brands HY-6E(CE) - page 27

    OM/SM-HY -6E(CE) 27 OM/SM-HY-6E(CE) 27 13. T he entire a ssembly may now be positioned on the four threaded stud bolts protruding from the cavity wall. Fasten the assembly with the 1/4-20 Keps nuts using a so cket wrench. Make sur e tha t th e gre en ground strap is fastened by one of the Keps nu ts securing the motor. 10.19 Motor Starting Capacito ...

  • Unified Brands HY-6E(CE) - page 28

    28 OM/SM-HY -6E(CE) OM/SM-HY-6E(CE) 28 5. The hose m ay be removed. Be care ful that th e hose clamps do not fall off and get lost. IMPORTANT: Make sure that the correct part (and part number) are being used. The two hoses in the steamer are of differe nt lengths. (See Page 17 for Part Numbers.) To Install: 6. Slide the two hos e clamps onto the ho ...

  • Unified Brands HY-6E(CE) - page 29

    OM/SM-HY -6E(CE) 29 OM/SM-HY-6E(CE) 29 8. Remove screws and U-channel from the door. Take the magnet and block assembly fro m pre sent location and place it at the opposite end of the door channel, with the magnet facing outward from th e door. 9. Remove screws. Remove door handle from cam. 10. Apply NEVER-SEE Z high tem perature (rat ed for 250ºC ...

  • Unified Brands HY-6E(CE) - page 30

    30 OM/SM-HY -6E(CE) OM/SM-HY-6E(CE) 30 1. Turn steamer off and allow it to cool. 2. Remove screws and U-channel from the door. 3. Remove screws, door handle, and cam. 4. Apply a NEVER-SEEZ high temperature compound to the door cam and Locktite 242 to screw threads. 5. Assemble door cam to handle with screws. 6. Be sure door handle is in the DOW N p ...

  • Unified Brands HY-6E(CE) - page 31

    OM/SM-HY -6E(CE) 31 OM/SM-HY-6E(CE) 31 11 - Electrical Schematic ...

  • Unified Brands HY-6E(CE) - page 32

    32 OM/SM-HY -6E(CE) 32 12 - Service Log Model No. Serial No. Date Purchased Purchase Order No. Purchased From Location Date Installed For Service Call Date Maintenance Performed Performed by ...

  • Unified Brands HY-6E(CE) - page 33

    OM/SM-HY -6E(CE) 33 33 Limited Warranty To Commercial Purchasers* (for Areas Outside of the U.S. and Canada) Groen Foodservice Equipment ("Groen Equipment") has been skillfully manufactured, carefully inspected and packaged to meet rigid standards of excellence. Groen warrants its Equipment to be free from defects in material and workmans ...

  • Unified Brands HY-6E(CE) - page 34

    10 5 5 Me n d el l Da v i s D r i ve • Ja c k so n M S 3 9 27 2 88 8 - 99 4 - 76 3 6 • 6 0 1- 3 7 2- 3 9 03 • Fa x 8 88 - 8 64 - 7 63 6 gr oe n .c o m P AR T NUMBER 128717, REV . B (4/06) ...

Производитель Unified Brands Категория Electric Steamer

Документы, которые мы получаем от производителя устройства Unified Brands HY-6E(CE) мы можем разделить на несколько групп. Это в частности:
- технические чертежи Unified Brands
- инструкции обслуживания HY-6E(CE)
- паспорта изделия Unified Brands
- информационные брошюры
- энергетические этикетки Unified Brands HY-6E(CE)
Все из них важны, однако самую важную информацию с точки зрения пользователя мы найдем в инструкции обслуживания Unified Brands HY-6E(CE).

Группа документов, определяемая как инструкции обслуживания, делится также на более подробные типы, такие как: Инструкции монтажа Unified Brands HY-6E(CE), инструкции обслуживания, короткие инструкции или инструкции пользователя Unified Brands HY-6E(CE). В зависимости от потребностей, Вам необходимо поискать требуемый документ. На нашем сайте Вы можете просмотреть самую популярную инструкцию использования изделия Unified Brands HY-6E(CE).

Похожие инструкции обслуживания

Полная инструкция обслуживания устройства Unified Brands HY-6E(CE), как должна выглядеть?
Инструкция обслуживания, определяемая также как пособие пользователя, или просто "руководство" - это технический документ, цель которого заключается в использовании Unified Brands HY-6E(CE) пользователями. Инструкции пишет, как правило технический писатель, языком, доступным для всех пользователей Unified Brands HY-6E(CE).

Полная инструкция обслуживания Unified Brands, должна заключать несколько основных элементов. Часть из них менее важная, как например: обложка / титульный лист или авторские страницы. Однако остальная часть, должна дать нам важную с точки зрения пользователя информацию.

1. Вступление и рекомендации, как пользоваться инструкцией Unified Brands HY-6E(CE) - В начале каждой инструкции, необходимо найти указания, как пользоваться данным пособием. Здесь должна находится информация, касающаяся местонахождения содержания Unified Brands HY-6E(CE), FAQ и самых распространенных проблем - то есть мест, которые чаще всего ищут пользователи в каждой инструкции обслуживания
2. Содержание - индекс всех советов, касающихся Unified Brands HY-6E(CE), которое найдем в данном документе
3. Советы по использованию основных функций устройства Unified Brands HY-6E(CE) - которые должны облегчить нам первые шаги во время использования Unified Brands HY-6E(CE)
4. Troubleshooting - систематизированный ряд действия, который поможет нам диагностировать а в дальнейшем очередность решения важнейших проблем Unified Brands HY-6E(CE)
5. FAQ - чаще всего задаваемые вопросы
6. Контактные данные Информация о том, где искать контактные данные производителя / сервисного центра Unified Brands HY-6E(CE) в данной стране, если самостоятельно не получится решить проблему.

У вас вопрос, касающийся Unified Brands HY-6E(CE)?

Воспользуйтесь формуляром, находящимся ниже

Если с помощью найденной инструкции Вы не решили свою проблему с Unified Brands HY-6E(CE), задайте вопрос, заполнив следующий формуляр. Если у какого то из пользователей была похожая проблема с Unified Brands HY-6E(CE) со всей вероятностью он захочет поделиться методом ее решения.

Перепишите текст с картинки

Captcha
Новая картинка

Комментарии (0)