Русский dropdown-ico

Инструкция обслуживания Hoshizaki MODULAR CRESCENT CUBER KML-450MWH

22 страниц 0.65 mb
Скачать

Перейти на страницу of 22

Summary
  • Hoshizaki MODULAR CRESCENT CUBER KML-450MWH - page 1

    ISSUED: HOSHIZAKI MODULAR CRESCENT CUBER INSTR UCTION MANU AL FEB. 21, 2001 MODELS KML-450MAH KML-450MWH REVISED: SEPT . 24, 2001 TM ...

  • Hoshizaki MODULAR CRESCENT CUBER KML-450MWH - page 2

    2 HOSHIZAKI AMERICA, INC. 618 Highway 74 South Peachtree City , GA 30269 Attn: HOSHIZAKI T echnical Support Department Phone: 1-800-233-1940 T echnical Service (770) 487-2331 Fax: (770) 487-3360 NO TE: T o expedite assistance, all correspondence/communication MUST include the follo wing information: • Model Number • Serial Number • Complete a ...

  • Hoshizaki MODULAR CRESCENT CUBER KML-450MWH - page 3

    3 • Please review this manual. It should be read carefully before the icemaker is installed and operated. Only qualified service technicians should install, service and maintain the icemaker. This manual should be made available to the technician prior to installation, maintenance or service. • Keep this manual with the icemaker for future refe ...

  • Hoshizaki MODULAR CRESCENT CUBER KML-450MWH - page 4

    4 I. SPECIFICA TIONS 1. NAMEPLA TE RA TING [a] KML-450MAH (Air-cooled) See the Nameplate for electrical and refrigeration speci- fications. This Nameplate is located on the upper right hand side of the rear panel. Since this Nameplate is located on the rear panel of the icemaker, it cannot be read when the back of the icemaker is against a wall or ...

  • Hoshizaki MODULAR CRESCENT CUBER KML-450MWH - page 5

    5 [b] KML-450MWH (Water-cooled) See the Nameplate for electrical and refrigeration speci- fications. This Nameplate is located on the upper right hand side of rear panel. Since this Nameplate is located on the rear panel of the icemaker, it cannot be read when the back of the icemaker is against a wall or against another piece of kitchen equipment. ...

  • Hoshizaki MODULAR CRESCENT CUBER KML-450MWH - page 6

    6 2. DIMENSIONS/CONNECTIONS [a] KML-450MAH Unit: inches (mm.) ...

  • Hoshizaki MODULAR CRESCENT CUBER KML-450MWH - page 7

    7 [b] KML-450MWH Unit: inches (mm.) ...

  • Hoshizaki MODULAR CRESCENT CUBER KML-450MWH - page 8

    8 II. INST ALLA TION AND OPERA TING INSTR UCTIONS 1. CHECKS BEFORE INST ALLA TION IMPORT ANT Remove shipping carton, tape(s) and packing. If packing material is left in the icemaker, it will not work properly. 1) Remove the panels to prevent damage when installing the icemaker. See “2. HOW TO REMOVE PANELS.” 2) Remove the package containing the ...

  • Hoshizaki MODULAR CRESCENT CUBER KML-450MWH - page 9

    9 2. HOW TO REMOVE PANELS - See Fig. 1 a) Front Panel ......... Remove the screw. Lift up and pull toward you. b) Top Panel ............ Lift its front up slightly, push away, and then lift off. c) Side Panel (R) ..... Remove the screw. Pull slightly toward you, and lift off. d) Insulation Panel ... Lift up slightly, and pull toward you. 3. LOCA TI ...

  • Hoshizaki MODULAR CRESCENT CUBER KML-450MWH - page 10

    10 4. SET UP 1) Unpack the Storage Bin, and attach the four adjustable legs provided (bin accessory) to the bottom of the Storage Bin. 2) Position the Storage Bin in the selected permanent position. 3) Place the icemaker on the top of the Storage Bin. 4) Secure the icemaker to the Storage Bin, by using the two Universal Braces and the two bolts pro ...

  • Hoshizaki MODULAR CRESCENT CUBER KML-450MWH - page 11

    11 6. W A TER SUPPL Y AND DRAIN CONNECTIONS - See Fig. 4 IMPORT ANT Do not operate the icemaker when the water supply is OFF, or if the pressure is below 10 PSIG. Do not run the icemaker until the proper water pressure is reached. • Water supply inlet is 1/2" female pipe thread (FPT). Note: On water-cooled model, two water supply inlets are ...

  • Hoshizaki MODULAR CRESCENT CUBER KML-450MWH - page 12

    12 Fig. 4 KML-450MWH KML-450MAH ...

  • Hoshizaki MODULAR CRESCENT CUBER KML-450MWH - page 13

    13 7. FINAL CHECK LIST 1) Is the icemaker level? 2) Is the icemaker in a site where the ambient temperature is within +45°F to +100°F and the water temperature within +45°F to +90°F all year around? 3) Is there at least 6" clearance at sides, rear and top of the icemaker for maintenance or service? 4) Have all shipping carton, tapes and pa ...

  • Hoshizaki MODULAR CRESCENT CUBER KML-450MWH - page 14

    14 8. ST AR T UP CAUTION 1. All parts are factory-adjusted. Improper adjustments may result in failure. 2. If the unit is turned off, wait for at least 3 minutes before restarting the icemaker to prevent damage to the Compressor. 3. Do not operate the unit in the “WASH” position without water in the Water Tank. This will cause damage to the Wat ...

  • Hoshizaki MODULAR CRESCENT CUBER KML-450MWH - page 15

    15 Note: The Bin Switch will only shut down the unit at the end of a harvest or within the first 5 minutes of the freeze cycle. To shut the unit down outside of this time period turn the control switch to “OFF”. 8) Replace the Bin Control Cover. 9) Move the Control Switch to the “Service” position. Then move the Service Switch to the “Dra ...

  • Hoshizaki MODULAR CRESCENT CUBER KML-450MWH - page 16

    16 9. PREP ARING THE ICEMAKER FOR LONG ST ORA GE CA UTION When shutting off the icemaker for an extended time, drain out all water from the water line and remove the ice from the Storage Bin. The Storage Bin should be cleaned and dried. Drain the icemaker to prevent damage to the water supply line at sub-freezing temperatures, using air or carbon d ...

  • Hoshizaki MODULAR CRESCENT CUBER KML-450MWH - page 17

    17 [2] Remove the water from the potable water supply line: 1) Turn off the power supply and remove the Front Panel. 2) Move the Control Switch, on the Control Box, to the “OFF” position. 3) Wait 3 minutes. 4) Close the Potable Water Supply Line Shut-off Valve and open the Potable Water Supply Line Drain Valve. See Fig. 4. 5) Allow the line to ...

  • Hoshizaki MODULAR CRESCENT CUBER KML-450MWH - page 18

    18 III. CLEANING AND MAINTENANCE INSTR UCTIONS 1. CLEANING INSTR UCTIONS W ARNING 1. HOSHIZAKI recommends cleaning this unit at least once a year. More frequent cleaning, however, may be required in some existing water conditions. 2. To prevent injury to individuals and damage to the icemaker, do not use ammonia type cleaners. 3. Always wear liquid ...

  • Hoshizaki MODULAR CRESCENT CUBER KML-450MWH - page 19

    19 10) Move the Service Switch to the “WASH” position. 11) Replace the Insulation Panel and the Front Panel in their correct positions. 12) Turn on the power supply and start the washing process. 13) Turn off the power supply after 30 minutes. 14) Remove the Front Panel. 15) Move the Service Switch to the “DRAIN” position. 16) Replace the F ...

  • Hoshizaki MODULAR CRESCENT CUBER KML-450MWH - page 20

    20 Note: If you do not sanitize the icemaker, go to step 14) in “SANITIZING PROCEDURE.” [b] SANITIZING PROCEDURE - Following Cleaning Procedure 1) Dilute IMS-II Sanitizer or a 5.25% Sodium Hypochlorite solution with water (Add 1.0 fl. oz. to 2 gal. of water). Note: IMS-II Sanitizer, Part #SA0004, is available through your Hoshizaki Dealer. 2) R ...

  • Hoshizaki MODULAR CRESCENT CUBER KML-450MWH - page 21

    21 2. MAINTENANCE IMPORT ANT This icemaker must be maintained individually, referring to the instruction manual and labels provided with the icemaker. 1) Stainless Steel Exterior To prevent corrosion, wipe the exterior occasionally with a clean and soft cloth. Use a damp cloth containing a neutral cleaner to wipe off oil or dirt build up. 2) Storag ...

  • Hoshizaki MODULAR CRESCENT CUBER KML-450MWH - page 22

    22 91A1BE10B HOSHIZAKI HOSHIZAKI AMERICA, INC. 618 HIGHW A Y 74 SOUTH PEA CHTREE CITY , GA 30269 U .S.A. PHONE: 770-487-2331 ...

Производитель Hoshizaki Категория Ice Maker

Документы, которые мы получаем от производителя устройства Hoshizaki MODULAR CRESCENT CUBER KML-450MWH мы можем разделить на несколько групп. Это в частности:
- технические чертежи Hoshizaki
- инструкции обслуживания MODULAR CRESCENT CUBER KML-450MWH
- паспорта изделия Hoshizaki
- информационные брошюры
- энергетические этикетки Hoshizaki MODULAR CRESCENT CUBER KML-450MWH
Все из них важны, однако самую важную информацию с точки зрения пользователя мы найдем в инструкции обслуживания Hoshizaki MODULAR CRESCENT CUBER KML-450MWH.

Группа документов, определяемая как инструкции обслуживания, делится также на более подробные типы, такие как: Инструкции монтажа Hoshizaki MODULAR CRESCENT CUBER KML-450MWH, инструкции обслуживания, короткие инструкции или инструкции пользователя Hoshizaki MODULAR CRESCENT CUBER KML-450MWH. В зависимости от потребностей, Вам необходимо поискать требуемый документ. На нашем сайте Вы можете просмотреть самую популярную инструкцию использования изделия Hoshizaki MODULAR CRESCENT CUBER KML-450MWH.

Похожие инструкции обслуживания

Полная инструкция обслуживания устройства Hoshizaki MODULAR CRESCENT CUBER KML-450MWH, как должна выглядеть?
Инструкция обслуживания, определяемая также как пособие пользователя, или просто "руководство" - это технический документ, цель которого заключается в использовании Hoshizaki MODULAR CRESCENT CUBER KML-450MWH пользователями. Инструкции пишет, как правило технический писатель, языком, доступным для всех пользователей Hoshizaki MODULAR CRESCENT CUBER KML-450MWH.

Полная инструкция обслуживания Hoshizaki, должна заключать несколько основных элементов. Часть из них менее важная, как например: обложка / титульный лист или авторские страницы. Однако остальная часть, должна дать нам важную с точки зрения пользователя информацию.

1. Вступление и рекомендации, как пользоваться инструкцией Hoshizaki MODULAR CRESCENT CUBER KML-450MWH - В начале каждой инструкции, необходимо найти указания, как пользоваться данным пособием. Здесь должна находится информация, касающаяся местонахождения содержания Hoshizaki MODULAR CRESCENT CUBER KML-450MWH, FAQ и самых распространенных проблем - то есть мест, которые чаще всего ищут пользователи в каждой инструкции обслуживания
2. Содержание - индекс всех советов, касающихся Hoshizaki MODULAR CRESCENT CUBER KML-450MWH, которое найдем в данном документе
3. Советы по использованию основных функций устройства Hoshizaki MODULAR CRESCENT CUBER KML-450MWH - которые должны облегчить нам первые шаги во время использования Hoshizaki MODULAR CRESCENT CUBER KML-450MWH
4. Troubleshooting - систематизированный ряд действия, который поможет нам диагностировать а в дальнейшем очередность решения важнейших проблем Hoshizaki MODULAR CRESCENT CUBER KML-450MWH
5. FAQ - чаще всего задаваемые вопросы
6. Контактные данные Информация о том, где искать контактные данные производителя / сервисного центра Hoshizaki MODULAR CRESCENT CUBER KML-450MWH в данной стране, если самостоятельно не получится решить проблему.

У вас вопрос, касающийся Hoshizaki MODULAR CRESCENT CUBER KML-450MWH?

Воспользуйтесь формуляром, находящимся ниже

Если с помощью найденной инструкции Вы не решили свою проблему с Hoshizaki MODULAR CRESCENT CUBER KML-450MWH, задайте вопрос, заполнив следующий формуляр. Если у какого то из пользователей была похожая проблема с Hoshizaki MODULAR CRESCENT CUBER KML-450MWH со всей вероятностью он захочет поделиться методом ее решения.

Перепишите текст с картинки

Captcha
Новая картинка

Комментарии (0)