-
Trane SCIH - page 1
SXIH-S VX0 1B-EN Installation, Operation, and Maintenance Int egr al Air -Cooled Self-Contained Unit Model SCIH “ AO ” and later design sequence September 2007 ...
-
Trane SCIH - page 2
© 20 07 American Standard All rights reserved SXIH-SVX0 1B-EN general information About This Manual Literature Change History Use this manual for Integral Air-Cooled units, model SCIH. This is the second issue of this manual, which includes the addition of the accessory model number and instructions on how to convert the unit to a horizontal disch ...
-
Trane SCIH - page 3
SXIH-SVX0 1B-EN 3 contents Cross reference to related publications: • Integral Air-Cooled Self-Contained Product Catalog, PKG-PRC009-EN Installation ……………………………………………………………2 general information ……………………………………………2 pre-installation considerations …………………? ...
-
Trane SCIH - page 4
4 SXIH-SVX0 1B-EN Installation general information Int egral Air -Cooled Model Number Descr iption Following is a complete description of the integral air -cooled unit model number . Eac h digit in the model number has a correspo nding code that identifies specific unit options. S C I H 0 7 5 3 1 A 0 10100 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 Dig ...
-
Trane SCIH - page 5
SXIH-SVX0 1B-EN 5 Installation general information Accessory Model Number Description Following is a complete description of the integral air -cooled accessory model number . Eac h digit in the model number has a corresponding code that identifies specific unit options. P V I H A A 1 1 1 A0 A 0 1 1 1 2 3 4 5 6 7 8 9 10 11 12 13 14 Digit 1 - Parts/A ...
-
Trane SCIH - page 6
6 SXIH-SVX0 1B-EN Installation general information General Information The integral air -cooled unit, model SCIH, is a high ef ficiency , ver tical air cooled air conditioner . Units have either front or top disc harge configuration options and easy service access. Unit construction is heavy gage steel with a baked enamel finish. A vailable unit vo ...
-
Trane SCIH - page 7
SXIH-SVX0 1B-EN 7 Installation pre-installation considerations Installation Pre-Installation Considerations Checklist The following checklist gives an overview of the recommended pre-installation considerations. Follow the procedures in this section to ensure installation is complete and adequate for proper unit operation. V erify this c hec klist ...
-
Trane SCIH - page 8
8 SXIH-SVX0 1B-EN CONDENSER COIL FORKLIFT ACCESS 2.76 74.80 24.90 A BC 15.43 D 18.86 E 2.76 74.80 24.90 34.25 0.75 CONDENSER RETURN RETURN AIR SIDE ACCESS SIDE ACCESS SUPPL Y AIR SUPPL Y AIR CONDENSER DISCHARGE 31.50 13.64 2.74 dimensions and weights Installation Model SCIH 5 & 7 .5-t on units SCIH Unit Dimensions & W eights, in-lbs. Ship. ...
-
Trane SCIH - page 9
SXIH-SVX0 1B-EN 9 dimensions and weights Installation SCIH Component Overview back of unit inlet filter frame airflow vent airflow airflow low ambient damper outlet water coil supply airflow supply airflow ...
-
Trane SCIH - page 10
10 SXIH-SVX0 1B-EN dimensions and weights Installation SCIH A ccessor ies A C B Low Ambient Damper SCIH Low Ambient Damper Dimensions & Weight, in-lbs. Unit Size A B C Weight 5 & 7.5 ton 19 1 / 8 7 7 / 8 11 20 10 & 15 ton 52 3 / 4 7 7 / 8 11 40 A C B SCIH Plenum Dimensions & Weight, in-lbs. Unit Size A B C Grill Size (W x H) W eight ...
-
Trane SCIH - page 11
SXIH-SVX0 1B-EN 11 Installation dimensions and weights 2. Coil connections are mirror -image and can be mounted with either left or right-hand connections. 3.239 OD CONNECTION CONNECTION OD A B SCIH Hot W ater Coil Dimensions & Weight, in-lbs. Unit W et Coil Dry Coil Size A B Weight Wei gh t 5 T o n 38 1 / 2 33 1 / 16 49 39 7 .5 T on 52 1 / 2 4 ...
-
Trane SCIH - page 12
12 SXIH-SVX0 1B-EN Installation mechanical requirements Ductw or k Consider ations Install all air ducts according to the National Fire Protection Association standards for the “Installation of Air Conditioning and V entilation Systems other than R esidence T ype (NFP A 90A) and R esidence T ype W arm Air Heating and Air Conditioning Systems (NFP ...
-
Trane SCIH - page 13
SXIH-SVX0 1B-EN 13 Installation electrical requirements W ARNING Ground Wire! All field-installed wiring must be completed by qualified per sonnel. All field-installed wiring must comply with NEC and applicable local codes. Failure to follow this instruction could result in death or serious injury . W ARNING Grounding Required! Follow proper local ...
-
Trane SCIH - page 14
14 SXIH-SVX0 1B-EN electrical requirements Installation T able I-ER-2. Int egral Air -Cooled Oversized Motor Electr ical Data Condenser Evaporator Unit Compressor Fan Motor Fan Motor Size V oltage R L A L R A H p FL A H p FL A M C A M F S 5.0 208-230/60/3 1 9.3 135.0 2.0 5.81 1 .5 4.42 34.4 50 460/60/3 8.2 6 1 .8 2.63 2.00 14.9 20 575/60/3 6.6 4 9. ...
-
Trane SCIH - page 15
SXIH-SVX0 1B-EN 15 Installation Installation Procedure Installation Checklist The checklist listed below is a summary of the steps required to successfully install an integral air-cooled unit. This checklist is intended to acquaint the installing personnel with what is required in the installation process. It does not replace the detailed instructi ...
-
Trane SCIH - page 16
16 SXIH-SVX0 1B-EN Installation Installation Procedure CIRC. #1 CIRC. #1 CIRC. #2 CIRC. #2 LIQUID LINE CIRCUIT #1 CONDENSER FAN DISCHARGE PANEL 1" HOLE (FIELD OPERATION) DETAIL "A" S ELF-DRILLING SCREW 3/16" X 5/8" PROVIDED SOFT GASKET PROVIDED Low Ambient Damper Installation Reference Figure I-IP-2 and follow the procedure ...
-
Trane SCIH - page 17
SXIH-SVX0 1B-EN 17 Installation Installation Procedure Figure I-IP-3. Hydronic coil installation Hydronic Coil Installation Reference Figure I-IP-3 and follow the procedure below to install the hydronic coil. 1. Remove the front grill, filters, two upper frame screws, and two lower frame screws. 2. Install the hydronic coil in the space previously ...
-
Trane SCIH - page 18
18 SXIH-SVX0 1B-EN Installation Installation Procedure Plenum Installation Reference Figure I-IP-4 and follow the procedure below to install the plenum. 1. Before installing the plenum, ensure the evaporator fan is in the discharge position. If not, see the fan discharge conversion procedure on page 16. 2. Apply the soft gasket material provided co ...
-
Trane SCIH - page 19
SXIH-SVX0 1B-EN 19 Installation Pre-Startup Requirements Pre-Startup Checklist Complete this checklist after installing the unit to verify all recommended installation procedures are complete before unit startup. This does not replace the detailed instructions in the appropriate sections of this manual. Always read the entire section carefully to b ...
-
Trane SCIH - page 20
20 SXIH-SVX0 1B-EN Unit Start up Pr ocedur es W ARNING Hazardous voltage! Disconnect all electric power , including remote disconnects before servicing. F ollow proper loc kout/ tagout procedures to ensure the power can not be inadvertently energized. Failure to disconnect power before servicing could result in death or serious injury. 1 . Chec k a ...
-
Trane SCIH - page 21
SXIH-SVX0 1B-EN 21 Operation Sequence of Operation Sequence of Operation The thermostat controls the unit operation. It has both manual and automatic switches so the thermostat maintains desired comfort levels. The fan switch allows manual selection of the fan speed using the On or Auto setting. With the switch set in the On position, the evaporato ...
-
Trane SCIH - page 22
22 SXIH-SVX0 1B-EN Maintenance general information T able M-GI-1 . Int egral Air -Cooled General Data Nominal T ons 5 7 . 5 10 1 5 ARI capacity - btu/h 60,600 91,000 121,900 177 ,20 0 (S)EER 1 0.47 1 1 0.36 1 0.38 9.76 R22 c harge/circuit (lbs.) 9. 2 14.3 9.3 1 1 .7 Shipping weight – lbs. 9 0 8 10 8 7 1495 1897 Operating weight – lbs. 8 4 8 10 ...
-
Trane SCIH - page 23
SXIH-SVX0 1B-EN 23 Maintenance maintenance procedures Maint enance Procedur es Before beginning any maintenance procedures heed all warnings and cautions. WARNING Hazardous voltage! Disconnect all electric power , including remote disconnects before servicing. F ollow proper loc kout/ tagout procedures to ensure the power can not be inadvertently e ...
-
Trane SCIH - page 24
24 SXIH-SVX0 1B-EN Maintenance maintenance procedures • T o assist in reducing power generation emissions, always attempt to improve equipment performance with improved maintenance and operations that will help conserve energy resources. Refr iger ant Leak T esting WARNING Confined space hazard! Do not work in confined spaces where sufficient qua ...
-
Trane SCIH - page 25
SXIH-SVX0 1B-EN 25 Maintenance maintenance procedures CA UTION Compressor damage! Do not use a Meg ohm meter or apply power to the winding of a compressor while it is under a deep vacuum. This may damage the motor windings. WARNING Hazardous pressure! If heat is required to raise the refrigerant pressure during refrigerant removal, use only warm wa ...
-
Trane SCIH - page 26
26 SXIH-SVX0 1B-EN Maintenance periodic checklists P er iodic Checklists Monthly Checklist The following checklist provides the recommended maintenance schedule to keep the unit running efficiently . WARNING Hazardous voltage! Disconnect all electric power , including remote disconnects before servicing. F ollow proper loc kout/ tagout procedures t ...
-
Trane SCIH - page 27
SXIH-SVX0 1B-EN 27 Maintenance maintenance pr ocedures W ARNING Hazardous voltage! Disconnect all electric power , including remote disconnects before servicing. Follow proper loc kout/tagout procedures to ensure the power can not be inadvertently energized. Failure to disconnect power before servicing could result in death or serious injury. Probl ...
-
Trane SCIH - page 28
28 SXIH-SVX0 1B-EN Maintenance maintenance procedures W ARNING Hazardous voltage! Disconnect all electric power , including remote disconnects before servicing. Follow proper loc kout/tagout procedures to ensure the power can not be inadvertently energized. Failure to disconnect power before servicing could result in death or serious injury. Proble ...
-
Trane SCIH - page 29
T rane A business of American Standard Companies www.trane.com For more information, contact your local T rane office or e-mail us at comfort@trane.com Literature Order Number Date Supersedes T rane has a policy of continuous product and product data improvement a nd reserves the right to c hange design and specifications without notice. SXIH-SVX0 ...
У вас вопрос, касающийся Trane SCIH?
Воспользуйтесь формуляром, находящимся ниже
Если с помощью найденной инструкции Вы не решили свою проблему с Trane SCIH, задайте вопрос, заполнив следующий формуляр. Если у какого то из пользователей была похожая проблема с Trane SCIH со всей вероятностью он захочет поделиться методом ее решения.