-
Lennox Hearth T150C - page 1
EPA CERTIFIED CATALYTIC FREESTANDING WOODSTOVE MODEL T150C P/N 775008M, Rev. Q, 05/02 THIS APPLIANCE MUST BE INSTALLED BY A QUALIFIED TECHNICIAN. READ MANUAL THOROUGHLY BEFORE INSTALLATION. RETAIN THESE INSTRUCTIONS FOR FUTURE REFERENCE INSTALLATION AND OPERATION MANUAL Ce manuel d'installation est disponible en francais, simplement en faire l ...
-
Lennox Hearth T150C - page 2
IMPORTA NT WA RNINGS CA UTION: PLEASE REA D THIS ENT IRE MANUA L BEFORE YOU INST A LL AND USE YOUR NEW ROOM HEA T ER. FOR YOUR SAFETY, FOLLOW T HE INSTALLA TION, OPERA T ION AND MAINTENA NCE INST RUC- TION S EXA CT LY, WITHO UT DEVIATION. FAILURE TO FOL LOW T HESE INSTRUCT IONS M A Y RESULT IN PROPERTY DA M A GE, BODILY INJURY, OR EVEN DEA TH. IF T ...
-
Lennox Hearth T150C - page 3
PAGE 3 TA BLE OF CONTENTS Important W arnings ................................................ 2 Test ing/Listing, EPA, Using this Manual ................. 3 Planning Your Installation ...................................... 4-7 Installation .......................................................... 7-11 Product Features and Controls ............... ...
-
Lennox Hearth T150C - page 4
PLA NNING YOUR INSTA LLATION PAGE 4 QUESTIONS T O A SK LOCAL BUILDING OFFICIA L A corr ect installation is critical and im perative f or r educ- ing fire hazards and perilous conditions that can arise when w ood burning appliances are im properly installed. The ins taller m ust follow all of the manuf acturer s’ in- structi ons. The ins tallation ...
-
Lennox Hearth T150C - page 5
PLA NNING YOUR INSTA LLATION PAGE 5 FLOOR PROTECTION This appliance requires ½" (13 m m) m inimum non- com bustible floor protection designed f or solid fuel burn- ing appliances having a therm al c onductivity of k = .84 BTU in/f t or equivalent. If the f loor protection is to be stone, tile, brick , etc., it m ust be m ortared or grouted to ...
-
Lennox Hearth T150C - page 6
PLA NNING YOUR INSTA LLATION PAGE 6 SELECTING A L OCA TION The design of your home and where you place y our stove will determine its value as a source of heat. A woodstove depends prim arily on air circulation (convec- tion) to dispers e its heat, and therefor e, a central loca- tion is often bes t. There ar e other practical c onsidera- tions, wh ...
-
Lennox Hearth T150C - page 7
PLA NNING YOUR INSTALLA TION INSTA LLATION PAGE 7 REDUCED MASONRY STRUCT URE CLEA RANCE (ALCOVE) Your stove can be installed in a m asonr y structur e with reduced clearances if the structur e was built to National Building Code for f ireplaces and c himneys (UBC 37). The firebox of the masonry structur e mus t be of ade- quate size to allow a mini ...
-
Lennox Hearth T150C - page 8
INSTA LLATION PAGE 8 TY PES OF CHIM NEYS The c himney is a vital part of your st ove installation. A properly built m asonry chimney or a properly installed factor y built chimney will assure a consis tent draft under a variety of w eather conditions (a sm oking s tove is usu- ally caused by a chim ney problem ). The s tove f lue size is 6 inches ( ...
-
Lennox Hearth T150C - page 9
INSTA LLATION PAGE 9 CHIMNEY HEIGHT REQUIREM ENTS The c himney must ex tend 3 feet (914 m m ) above the level of roof penetration and a m inimum of 2 feet (610 mm ) higher than any r oof surf ace within 10 feet (305 c m) (see below). Check with y our local building off icials for any additional requirem ents f or y our area. Due to prevailing winds ...
-
Lennox Hearth T150C - page 10
INSTA LLATION PAGE 10 RESIDENTIAL INSTA LLATION DIA G RA M ...
-
Lennox Hearth T150C - page 11
INSTA LLATION Combustible Wall Chimney Connector Pass-Throughs NOT ES: 1. Connectors to a masonry chimney, excepting method B, shall extend in one conti nuous section through the wall pass-through sy stem and the chimney w all, to but not past the inner f lue liner face. 2. A chimney connector shall not pass through an attic or roof space, closet o ...
-
Lennox Hearth T150C - page 12
PRODUCT FEA TURES A ND CONTROLS PAGE 12 PRIMARY A IR CONT ROL The prim ary combus tion air delivery is controlled by the Prim ary Air Control Assem bly (The contr ol knob is lo- cated above the fuel door ). The heat output can be con- trolled by sliding the handle to a higher or lower heat output setting (See Care and O peration Section – Pri- ma ...
-
Lennox Hearth T150C - page 13
CA RE A ND OPERATION PAGE 13 FUEL DOOR CA UT ION: WHEN OPENING THE DOOR, DO NOT EX- TEND IT BEYOND IT S NORMAL TRA VEL. OVEREX- TENDING T HE DOOR TO A FURTHER OPEN POSITION CA N PUT EXCESSIVE STRESS ON HING E A R EA O F DOOR A ND HINGE PINS AND MA Y RESULT IN BREAK- AG E . DOOR OPERA TION The door handle as sem bly opens and secur ely latches the f ...
-
Lennox Hearth T150C - page 14
CA RE A ND OPERATION PAGE 14 BREA K -IN PERIOD Your stove finish is a high temperature paint that r equires time and tem peratur e to com pletely cure. W e rec om- mend that you ventilate the house during the initial bur ns. The paint em its non-tox ic odors dur ing this process . KEEP YOUR HOUSE W ELL VENTIL A T ED DURING THE CURING PROCESS TO PRE ...
-
Lennox Hearth T150C - page 15
CA RE A ND OPERATION PAGE 15 Refueling * 1. O pen the dam per by pas s control by pulling it toward y ou. 2. Set the pr imar y air control s et to high. 3. O pen the door approxim ately 1/2 inch (13 m m) , then wait for about thirty seconds. Open the door and add wood, then close the door. 4. If the optional temperatur e probe is used wait for a re ...
-
Lennox Hearth T150C - page 16
FUEL PAGE 16 BURN RECOMM ENDED FUEL This appliance is approved for use with untreated natural dry w ood only (s ee Important W arnings , page 2, #8). Burning m aterials other than natural wood will s horten the life of the catalytic com bustor. Do not bur n particleboard or pressed logs us ing bonding agents as they can produce conditions that will ...
-
Lennox Hearth T150C - page 17
MA INTE NA NCE PAGE 17 SMALL A REA PA INT T OUCH-UP The s tove body is painted with a quality high- temper ature stove paint. Use only m odel T SPK-B Stove Paint, Catalog # 70K99. Do not touch-up y our stove with any other paint. Using one small piece of 320 grit s and paper and lightly sand the blemish so that the edges are “f eathered” or sm ...
-
Lennox Hearth T150C - page 18
MA INTE NA NCE PAGE 18 CREOSOTE FORMATION A ND NEED FOR RE- MOV A L What is Creo sote - W hen wood is burned slowly , it produces tar and other organic vapors, which com bine with expelled mois ture to form cr eosote. The creosote vapors condense in the relatively cool chimney flue of a slow-burning fire. As a result, cr eosote residue acc u- mu la ...
-
Lennox Hearth T150C - page 19
MA INTE NA NCE PAGE 19 CA T A LYTIC COM BUSTOR Your stove has been designed with a c ataly tic c ombus - tor, which will improve the overall ef ficienc y of your stove. Rem oving the com bustors for cleaning, ins pec- tion and reinstallation s hould be done at least onc e a y ear. Cleaning the com bustors helps reduc e buildup of ash and retarding ...
-
Lennox Hearth T150C - page 20
TROUBLESHOOTING PAGE 20 SMO KES OUT FUEL DOO R WHEN OPEN ( see ✸ ✸ ✸ ✸ ) 1. The pr imar y air control is closed. 2. The c himney is too cool. Set the prim ary air c ontrol on "HIGH" with the by pass dam per contr ol "OPEN" for a f ew minutes bef ore opening the fuel door . 3. Exces s creosote will not only restrict your ...
-
Lennox Hearth T150C - page 21
TROUBLESHOOTING PAGE 21 CA TALYST SUBSTRATE CRA CKING 1. Normal operation, as long as com bustor re- mains intact. If crack ing causes large pieces to fall out, replac e com bustor. 2. Mis handling or abuse. Handle with care. 3. W arped housing (s ee Overfiring Damage on this page). CA TALYST SUBSTRATE 1. Extr eme therm al s hock. Com bustor is bei ...
-
Lennox Hearth T150C - page 22
SPECIFICA TIONS: Model T150C PAGE 22 A pproximate Up to ~1800 sq. f t. Heat Capacity Up to ~550 sq. M Maximu m Burn Rate 49,027 BTU EPA BTU Range 6500 / 35,300 BTU Emissions Rate (grams/hr.) 4.1 Efficiency Rating 72% Outside A ir Provision No Maximum Log Length 22" (559 mm) Firebox Size ( cubic feet) 2.5 c.f. ( 762 cu. mm) Stove Back t o Flue ...
-
Lennox Hearth T150C - page 23
REPLA CEMENT PA RTS FOR MODEL: T150C PAGE 23 Part No. Model Descriptio n Door Parts C15220 Door Assem bly, Cast (Handle Included) 27M83 Gask et Kit, 1/2" Medium Rope 26M23 Gask et Kit, Side W indow 1/8" Ly therm ⊗ 27M81 Gask et Kit, Door Glass Channel 18280 Glass, Door 9 5/8 X 14 1/4" (Glass gask et not included) 18281 Glass, Side ...
-
Lennox Hearth T150C - page 24
COMPONEN T DIA GRA MS: T150C PAGE 24 FIREBRICK (1 ¼” thick) Part Qty Dimen sions FB-1 9 9 x 4 ¼” Reg ular Top View Showing Brick Installed CA T A LYTIC COM BUSTOR Sys tem Components ...
-
Lennox Hearth T150C - page 25
OPTIONA L A CCESSORIES: T150C Note: Inst all and use accessories per in structions p rovided w ith th e accessory kit. PAGE 25 Catalog # M odel Description Notes 14M36 BK- T15 Blower Kit Includes Dial- A- Tem p for Vari able Speed Control 14M21 SSK Stove Stat Kit Therm ally Con- trols Blower 14M34 M K T 1 5 - GRY M a r b l e S e t - G r a y Accent ...
-
Lennox Hearth T150C - page 26
SA FETY/LISTING LA BEL PAGE 26 ...
-
Lennox Hearth T150C - page 27
EPA LAB EL Page 27 ...
-
Lennox Hearth T150C - page 28
Page 28 OWNERSHIP RECORDS Dealer’s Nam e: Dealer’s Addres s: City : State: Zip Code: Serial Num ber: Date of Purc hase: Date Installed: Notes: SERVICE A ND M AINTENA NCE LOG Service Servic e Service Date Tec hnician Description ...
-
Lennox Hearth T150C - page 29
1110 West Taft A venue Orange, CA 92865 ...
У вас вопрос, касающийся Lennox Hearth T150C?
Воспользуйтесь формуляром, находящимся ниже
Если с помощью найденной инструкции Вы не решили свою проблему с Lennox Hearth T150C, задайте вопрос, заполнив следующий формуляр. Если у какого то из пользователей была похожая проблема с Lennox Hearth T150C со всей вероятностью он захочет поделиться методом ее решения.