Русский dropdown-ico

Инструкция обслуживания Monessen Hearth BWBC400

80 страниц 2.49 mb
Скачать

Перейти на страницу of 80

Summary
  • Monessen Hearth BWBC400 - page 1

    BWB400, BWB400I, BWBC400 AND BWBC400I W OOD B URNING F IREPLACES I NST ALLA TION , O PERA TION AND M AINTENANCE M ANUAL O NL Y M ODELS DYS24/18(N,P)(M,V) U NVENTED G AS L OG S ETS WHICH HA VE BEEN FOUND TO COMPL Y WITH THE S T ANDARD F OR U NVENTED R OOM H EA TERS ANSI Z21.1 1.2, ARE TO BE INST ALLED IN THIS FIREPLACE . 075629 HOOD MUST BE INST ALL ...

  • Monessen Hearth BWBC400 - page 2

    C ONGRA TULA TIONS ! Y ou have chosen the finest wood burning fireplace available. Y our fireplace has been designed for years of heating and viewing enjoyment. Please take time to read this entire manual before installing or operating your fireplace. T ABLE OF C ONTENTS L ISTING AND C ODE A PPROV ALS The instructions contained in this manual provi ...

  • Monessen Hearth BWBC400 - page 3

    2 3 I MPORT ANT I NFORMA TION 1. Read these instructions entirely before beginning any part of the installation. Save these instructions for any future repairs. 2. Use these instructions as a guide during the installation of the fireplace. 3. Be sure these instructions become the property of and are reviewed by all future users of this fireplace to ...

  • Monessen Hearth BWBC400 - page 4

    5 4 O PERA TION G UIDELINES As wood is burned in the fireplace, room air entering the fireplace is circulated around the fireplace firebox. This air circulation protects the firebox from overheating. Air circulation through the fireplace must not be blocked or restricted in any manner . Blocking or restricting air circulation through the fireplace ...

  • Monessen Hearth BWBC400 - page 5

         NOTE: COMBUSTIBLE MATERIALS SHOULD NOT BE INSTALLED BELOW TOP SPACER. NON-COMBU NOTE: COMBUSTIBLE MATERIALS SHOULD NOT BE INSTALLED BELOW TOP SPACER. NON-COMBU STIBLE MATERIALS STIBLE MATERIALS SUCH AS BRICK OR TILE MAY BE USED TO TRIM FACE OF THE FIREPLACE BUT SHOULD NOT C SUCH AS BRICK OR TILE MAY BE USED TO TRIM FACE OF ...

  • Monessen Hearth BWBC400 - page 6

    BWBC400I BWBC400I BWBC400 BWBC400 BWB400I BWB400I BWB400 BWB400 SIDE VIEW SIDE VIEW FRONT VIEW FRONT VIEW TOP VIEW TOP VIEW 21 1/2" 21 1/2" FRAMING FRAMING DIMENSION DIMENSION OUTSIDE AIR OUTSIDE AIR CONNECTOR CONNECTOR CENTERLINE CENTERLINE 38 1/2" 38 1/2" FRAMING FRAMING DIMENSION DIMENSION ...

  • Monessen Hearth BWBC400 - page 7

    F IREPLACE L OCA TION CAUTION: Do not install fireplace over carpeting. This fireplace does not weigh more than large pieces of furniture and can normally be located near a load bearing wall without requiring additional foundations or supports. If however , the fireplace is to be trimmed with a heavy stone or brick facing and hearth extension, be s ...

  • Monessen Hearth BWBC400 - page 8

    Survey the planned location for the fireplace for overhead plumbing or electrical wires, etc., that might complicate the installation or endanger persons installing or cleaning the chimney . Avoid a location where the chimney cap will be near abrupt changes in the roof shape, nearby wall or embankments, under or near trees or above the roof of a si ...

  • Monessen Hearth BWBC400 - page 9

    MULTIPLE STORY INSTALLATION MULTIPLE STORY INSTALLATION ATTIC SPACE ATTIC SPACE SINGLE STORY INSTALLATION WITH SINGLE STORY INSTALLATION WITH 14 1/2" SQUARE HOLE 14 1/2" SQUARE HOLE IN JOIST (1 3/4" AIR  IN JOIST (1 3/4" AIR  SPACE CLEARANCE SPACE CLEARANCE TO COMBUSTIBLES) TO COMBUSTIBLES) 14 1/2" SQUARE? ...

  • Monessen Hearth BWBC400 - page 10

    10 F LOOR P ROTECTION If this fireplace is installed on a combustible floor , the floor area 16 inches in front of, and 8 inches either side of the fireplace opening must be protected by an insulating noncombustible hearth extension. This hearth extension may be either minimum 6-inch thick stone or brick as shown by Figure 10, a H1652 Hearth Extens ...

  • Monessen Hearth BWBC400 - page 11

    The ability of insulating material to retard the transfer of heat may be expressed as either Thermal Conduc- tance (C), Thermal Conductivity (K), or Thermal Resistance (R). The mathematical relationship of these values and the formulas for converting one value to another is as follows: C=K divided by the material thickness (Example C = .43 divided ...

  • Monessen Hearth BWBC400 - page 12

    12 F IREPLACE C OMPONENTS F IGURE 13 FA2 FAN KIT FA2 FAN KIT S48, S36, S18, AND S12 S48, S36, S18, AND S12 CHIMNEY FLUE SECTIONS CHIMNEY FLUE SECTIONS SE30 30 SE30 30 ˚ ELBOW ELBOW SCS  SCS  CHIMNEY CHIMNEY SUPPORT SUPPORT SCF36A OR SCF36AI SCF36A OR SCF36AI FIREPLACE FIREPLACE 403 OR 603 DUCT 403 OR 603 DUCT CONNE ...

  • Monessen Hearth BWBC400 - page 13

    F IREPLACE C OMPONENTS SF36A SF36AI SCF36A SCF36AI GD36PB GD36B SCS SE30 612 1212  SC SF SCL SQ8 SF30 H1652 AK4 AK6 FP4U FP6U 403 603 FA2  JB1  S8 LFSQT  SPC H36  R3672 R4884 CF8 VFK  S48 S36 S18 S12  MODEL MODEL   ...

  • Monessen Hearth BWBC400 - page 14

    F IREPLACE I NST ALLA TION 14 L OCA TION S ELECTION Unpack and check the fireplace and chimney for damage. If any items have been damaged, report this to your Monessen Hearth Systems dealer . Before beginning the installation, be sure you have the proper parts in sufficient quantity . Refer to the Parts Diagram and List section of this manual for p ...

  • Monessen Hearth BWBC400 - page 15

    C HIMNEY I NST ALLA TION 15 1. Lay out, cut and frame openings through all ceilings and the roof at the point where the chimney will pass through. Unless the chimney is to be offset, the point where the center line of the chimney will pass through the ceiling and roof can be determined with a plumb line as shown by Figure 15. The fireplace should b ...

  • Monessen Hearth BWBC400 - page 16

    IMAGINARY IMAGINARY CENTER POINT CENTER POINT ACTUAL ACTUAL CENTER POINT CENTER POINT CENTERLINE  CENTERLINE  OF CHIMNEY OF CHIMNEY PLUMB BOB PLUMB BOB PLUMB LINE PLUMB LINE "S" SERIES DOUBLE "S" SERIES DOUBLE WALL CHIMNEY WALL CHIMNEY  14 1/2" x 14 1/2" 14 1/2" x 14 1/2"? ...

  • Monessen Hearth BWBC400 - page 17

    C HIMNEY O FFSET I NST ALLA TION 17 30∞ ELBOW 8-PENNY NAILS PER STRAP. AROUND THE ELBOW WITH TO FRAMING MEMBER A MINIMUM OF TWO (2) STRAPS MUST BE NAILED ALL FOUR SUPPORT FLUE PIPE INLET AIR PIPE SURROUNDING STRUCTURE. BE NAILED SECURELY TO THE ON TOP OF THE FIREPLACE SHOULD ELBOWS NOT INSTALLED DIRECTLY THE SUPPORT STRAPS OF ALL F IGURE 18 3. Th ...

  • Monessen Hearth BWBC400 - page 18

      CONTINUE CHIMNEY TO PROPER CONTINUE CHIMNEY TO PROPER HEIGHT AND INSTALL ROUND HEIGHT AND INSTALL ROUND CHIMNEY CAP OR CHIMNEY CHIMNEY CAP OR CHIMNEY HOUSING. HOUSING. FASTEN SUPPORT STRAPS SECURELY FASTEN SUPPORT STRAPS SECURELY ROOF ROOF FLASHING FLASHING STORM COLLAR STORM COLLAR NOTE: TWO ELBOWS NOTE: TWO ELBOWS MAY BE ...

  • Monessen Hearth BWBC400 - page 19

    C HIMNEY C AP I NST ALLA TION 19 M ODEL SC C HIMNEY C AP S PECIAL N OTE : The proper height as previously explained is important to assure proper draft and safety . The chimney cap extends the flue outlet four inches above the top of the last section of chimney . This should be kept in mind when determining the proper height for the chimney . The c ...

  • Monessen Hearth BWBC400 - page 20

    C HIMNEY H EIGHT AND O FFSET C HARTS 20 17 26 1/2 31 3/4 36 41 1/4 47 1/4 50 3/4 57 3/4 62 67 3/4 72 1/2 77 1/2 82 88 92 1/4 98 1/2 102 3/4 107 3/4 113 1/4 118 1/4 122 1/2 128 3/4 133 139 1/4 143 1/2 148 1/2 154 159 163 1/4 169 1/2 173 3/4 180 184 1/4 ...

  • Monessen Hearth BWBC400 - page 21

    C HIMNEY C AP C HASE I NST ALLA TION 21 The preinstalled chimney sections should be no more than 10 inches below the top of the chase. The installation should be planned so that either a two-foot or three-foot chimney section will be used for the top section. This is necessary to ensure complete engagement of the inlet air telescope and chimney cap ...

  • Monessen Hearth BWBC400 - page 22

    O UTSIDE C OMBUSTION A IR P RECAUTIONS AND R ECOMMENDA TIONS N OTE : The use of outside air for combustion is optional unless required by building codes. It is only necessary to supply outside combustion air to one side of the fireplace. Use the model AK4 combustion air kit. 22 STEP 1: SECURE OUTSIDE AIR STARTING COLLAR TO LEFT SIDE OF STEP 1: S ...

  • Monessen Hearth BWBC400 - page 23

    O UTSIDE C OMBUSTION A IR P RECAUTIONS & R ECOMMENDA TIONS 23 O UTSIDE C OMBUSTION A IR R ECOMMENDA TIONS ( CONTINUED ) 1. Extremely long runs and numerous turns in the duct leading from the fireplace to the combustion air assembly should be avoided. These conditions will increase the resistance to the free flow of air through the duct. Refer t ...

  • Monessen Hearth BWBC400 - page 24

    C OMBUSTION A IR A SSEMBL Y M ODEL AK-4 C OMBUSTION A IR A SSEMBL Y 1. Remove the cover plate from the 4-inch outlet opening location on the left or right outside of the fireplace. DO NOT remove the cover if the outside air will not be connected. 2. Place the insulation ring between the AK-4 starting collar and fireplace wall and place the starting ...

  • Monessen Hearth BWBC400 - page 25

    25 G AS A PPLIANCE I NST ALLA TION C AUTION : If an unvented gas appliance is installed in the fireplace, the gas appliance must only be operated with the fireplace glass door fully open (if included). Only unvented gas log set which have been found to comply with the standard for unvented room heaters, ANSI/IAS/AGA Z21.1 1.2, are to be installed i ...

  • Monessen Hearth BWBC400 - page 26

    G AS A PPLIANCE I NST ALLA TION Do not allow the trim materials to extend closer than 3/8 inch to the vertical edges of the firebox opening if you plan to equip the fireplace with glass doors. The face of your fireplace may be left exposed or trimmed. If trim is installed, be sure it is fastened securely to the face of the fireplace. Any crack betw ...

  • Monessen Hearth BWBC400 - page 27

    27 FINISH WALL FRAMING 1/4" INSTALLATION OF NON-COMBUSTIBLE FACING MATERIALS TO THE FRONT FACE OF THE FIREPLACE COMBUSTIBLE FRAMING COMBUSTIBLE FRAMING MEMBERS FACING MATERIAL MEMBERS FACING MATERIAL TO TOP OF SPACERS. TO TOP OF SPACERS. CAUTION: CAUTION: DO NOT COVER  DO NOT COVER  OR RESTRICT SIDE VENT  OR RESTRICT ...

  • Monessen Hearth BWBC400 - page 28

    G LASS D OOR I NST ALLA TION AND F AN A CCESSOR Y F AN A CCESSOR Y The model BWBC400 and BWBC400I Fireplaces may be equipped with a Model F A2 fan accessory . If the fireplace is to be equipped with the F A2 fan at anytime, the JB1 junction box assembly must be installed on the fireplace as shown by Figures 32 and 33 during the installation of the ...

  • Monessen Hearth BWBC400 - page 29

    F IREPLACE O PERA TION W ARNING : If a decorative gas appliance is used in the fireplace the fireplace damper must be fixed in an open position. (See additional operation information in section titled “Operation Guidelines”.) A DV ANT AGES OF A W OOD B URNING F IREPLACE These are the practical, ecological advantages of wood as a fuel. Also to b ...

  • Monessen Hearth BWBC400 - page 30

    F IREPLACE O PERA TION A F EW W ORDS OF C AUTION Beware of burning certain material in your fireplace. Among these are plastics, poison ivy twigs and stems, and chemically treated woods such as discarded poles and railroad ties. These not only create air pollution, but can induce extreme irritation for some individuals. Use hemlock, spruce, juniper ...

  • Monessen Hearth BWBC400 - page 31

    M AINTENANCE AND S AFETY F UEL S T ORAGE W ood can be dried suf ficiently for burning within a few weeks if protected form rain in a low humidity area. It is far better to cut wood and allow it to dry for a year . In all cases, the wood should be stacked so that both ends of the sticks are exposed to the air and protected from rain. The drier the w ...

  • Monessen Hearth BWBC400 - page 32

    F IREPLACE M AINTENANCE At the end of each heating season or when the fireplace will not be in use for an extended time, the ashes should be removed and the hearth area should be swept as clean as is practical. The slow absorption of moisture into the ashes over a long period of time could cause a condition which would be corrosive to the metal fir ...

  • Monessen Hearth BWBC400 - page 33

    20. Do build fires of moderate intensity in the fireplace for the first three fires to allow materials to adjust and cure before being subjected to the intense heat of a large fire. DONT’S 1. Don’t allow other installations or operation considerations to take priority over safety considerations. 2. Don’t attempt to use the fireplace until the ...

  • Monessen Hearth BWBC400 - page 34

    34 P ARTS D IAGRAM AND L IST All repair part orders should be placed through your local dealer . T o ensure prompt and accurate service, please provide the following information when placing a repair part order: Model number of your Appliance, Part Name, Part Number , and Quantity of parts needed. PART NUMBER  076418 031867 070940 03187 ...

  • Monessen Hearth BWBC400 - page 35

    35 P ARTS D IAGRAM AND L IST All repair part orders should be placed through your local dealer . T o ensure prompt and accurate service, please provide the following information when placing a repair part order: Model number of your Appliance, Part Name, Part Number , and Quantity of parts needed. 1 2 6 5 4 9 8 7 3 PART NAME PART NAME UPPER G ...

  • Monessen Hearth BWBC400 - page 36

    36 L IMITED W ARRANTY FACTORY-BUILT FIREPLACE AND COMPONENTS ( EXCEPT BLOWERS ) W HAT IS COVERED AND FOR HOW LONG •F IVE -Y EAR C OVERAGE - For five years from the date this fireplace and components are first purchased for use, Monessen Hearth Systems will, at its option, repair or replace any defective part of this fireplace or components, or re ...

  • Monessen Hearth BWBC400 - page 37

    37 Y OUR D UTIES This fireplace must be installed by a qualified installer according to your local building codes and installation instructions and operated according to the owner’s instructions. You must keep an invoice, canceled check or payment record to verify the purchase date of the fireplace. I F Y OU H AVE A PROBLEM W ITH Y OUR F IREPLACE ...

  • Monessen Hearth BWBC400 - page 38

    38 N OTES This page intentionally left blank. 53D9031. Rev 1 03/03 ...

  • Monessen Hearth BWBC400 - page 39

    N OTES 39 This page intentionally left blank. 53D9031. Rev 1 03/03 ...

  • Monessen Hearth BWBC400 - page 40

    A TTENTION A PPLIANCE I NST ALLER P LEASE RETURN THESE O PERA TING AND I NST ALLA TION I NSTRUCTIONS TO THE C ONSUMER . 53D9031. Rev 1 03/03 ...

  • Monessen Hearth BWBC400 - page 41

    BWB500, BWB500I, BWBC500 AND BWBC500I R ESIDENTIAL F IREPLACES I NST ALLA TION , O PERA TION AND M AINTENANCE M ANUAL O NL Y U NVENTED G AS L OG S ETS WHICH HA VE BEEN FOUND TO COMPL Y WITH THE S T ANDARD F OR U NVENTED R OOM H EA TERS ANSI Z21.1 1.2 ARE TO BE INST ALLED IN THESE FIREPLACES . W HEN AN APPROVED ANSI Z21.1 1.2 UNVENTED ROOM HEA TER I ...

  • Monessen Hearth BWBC400 - page 42

    2 L ISTING AND C ODE A PPROV ALS The instructions contained in this manual provide the information necessary to install this fireplace in accordance with Underwriter ’s Laboratories requirements and in compliance with the National Fire Protection Association Standard No. 21 1. Some codes may require the fireplace and chimney be electrically groun ...

  • Monessen Hearth BWBC400 - page 43

    3 1. Read these instructions entirely before beginning any part of the installation. Save these instructions for any future repairs. 2. Use these instructions as a guide during the installation of the fireplace. 3. Be sure these instructions become the property of and are reviewed by all future users of this fireplace to encourage proper operation ...

  • Monessen Hearth BWBC400 - page 44

    4 5 O PERA TION G UIDELINES As wood is burned in the fireplace, room air enters the lower louvered panel of models BWBC500 and BWBC500I, or the bottom/side vents on models BWB500 and BWB500I circulates around the firebox. This air circulation cools the firebox and must not be blocked or restricted in any manner . Blocking the air flow can cause a f ...

  • Monessen Hearth BWBC400 - page 45

    5      NOTE: COMBUSTIBLE MATERIALS SHOULD NOT BE INSTALLED BELOW TOP SPACER. NON-COMBU NOTE: COMBUSTIBLE MATERIALS SHOULD NOT BE INSTALLED BELOW TOP SPACER. NON-COMBU STIBLE MATERIALS SUCH AS BRICK OR TILE MAY BE USED TO TRIM FACE OF THE FIREPLACE BUT SHOULD NOT C SUCH AS BRICK OR TILE MAY BE USED TO TRIM FACE OF THE FIREPLACE BUT ...

  • Monessen Hearth BWBC400 - page 46

    6 BWBC500I BWBC500I BWBC500 BWBC500 BWB500I BWB500I BWB500 BWB500 SIDE VIEW SIDE VIEW FRONT VIEW FRONT VIEW TOP VIEW TOP VIEW 21 1/2" 21 1/2" FRAMING FRAMING DIMENSION DIMENSION OUTSIDE AIR OUTSIDE AIR CONNECTOR CONNECTOR CENTERLINE CENTERLINE 44 1/2" 44 1/2" FRAMING FRAMING DIMENSION DIMENSIO ...

  • Monessen Hearth BWBC400 - page 47

    7 F IREPLACE L OCA TION CAUTION: Do not install fireplace over carpeting. This fireplace does not weigh more than large pieces of furniture and can normally be located near a load bearing wall without requiring additional foundations or supports. If however , the fireplace is to be trimmed with a heavy stone or brick facing and hearth extension, be ...

  • Monessen Hearth BWBC400 - page 48

    8 Survey the planned location for the fireplace for overhead plumbing or electrical wires, etc., that might complicate the installation or endanger persons installing or cleaning the chimney . Avoid a location where the chimney cap will be near abrupt changes in the roof shape, nearby wall or embankments, under or near trees or above the roof of a ...

  • Monessen Hearth BWBC400 - page 49

    9 MULTIPLE STORY INSTALLATION MULTIPLE STORY INSTALLATION ATTIC SPACE ATTIC SPACE SINGLE STORY INSTALLATION WITH SINGLE STORY INSTALLATION WITH 14 1/2" SQUARE HOLE 14 1/2" SQUARE HOLE IN JOIST (1 3/4" AIR  IN JOIST (1 3/4" AIR  SPACE CLEARANCE SPACE CLEARANCE TO COMBUSTIBLES) TO COMBUSTIBLES) 14 1/2" SQUAR ...

  • Monessen Hearth BWBC400 - page 50

    10 F LOOR P ROTECTION If this fireplace is installed on a combustible floor , the floor area 20 inches in front of, and 12 inches either side of the fireplace opening must be protected by an insulating noncombustible hearth extension. This hearth extension may be either minimum 6-inch thick stone or brick as shown by Figure 10, an H2066 Hearth Exte ...

  • Monessen Hearth BWBC400 - page 51

    11 43 3/4" 20" 21 13/16" 44" SAFETY STRIP 9 1/2" 7 1/8" 3" X 36" ( MIN. ) 21 3/8" FLOOR LEVEL 5" 9 5/8" (MIN.) 66" (MIN.) GAS OPENING JUNCTION BOX OPENING HEARTH EXTENSION F LOOR P ROTECTION With either type hearth extension minor shifting of the supporting floor or expansion and contracti ...

  • Monessen Hearth BWBC400 - page 52

    12 SF FI RESTOP SPACER H2066 HEARTH EXTENSION KIT AK4 COMBUSTION AIR ASSEMBLY 612-1212 FLASHING 403 DUCT CONNECTOR SE30 30∞ ELBOW FP-4-U UNINSULATED FLEX PIPE SC ROUND CHIMNEY CAP FA2 FAN ASSEMBLY SF42A/SF42AI GD42B OR GD42PB GLASS DOOR KIT SCF42A/SCF42AI SCS CHIMNEY SUPPORT CF8 CHIMNEY CAP Must use with VFK S36 S48 S18 S12 F IREPLACE C OMPONENTS ...

  • Monessen Hearth BWBC400 - page 53

    13 F IREPLACE C OMPONENTS SF42A SF42A SF42AI SF42AI SCF42A SCF42A SCF42AI SCF42AI S48 S48 S36 S36 S18 S18 S12 S12 SE30 SE30 SCS SCS SC SC SCL SCL SQL8 SQL8 612 612 1212 1212  SF SF SF-30 SF-30 FP-4-U FP-4-U 403 403 AK4 AK4 GD42 ...

  • Monessen Hearth BWBC400 - page 54

    14 F IREPLACE I NST ALLA TION L OCA TION S ELECTION Unpack and check the fireplace and chimney for damage. If any items have been damaged, report this to your dealer . Before beginning the installation, be sure you have the proper parts in sufficient quantity . Refer to the Parts Diagram and List section of this manual for proper identification of ...

  • Monessen Hearth BWBC400 - page 55

    15 C HIMNEY I NST ALLA TION 1. Lay out, cut and frame openings through all ceilings and the roof at the point where the chimney will pass through. Unless the chimney is to be offset, the point where the center line of the chimney will pass through the ceiling and roof can be determined with a plumb line as shown by Figure 15. The fireplace should b ...

  • Monessen Hearth BWBC400 - page 56

    16 IMAGINARY IMAGINARY CENTER POINT CENTER POINT ACTUAL ACTUAL CENTER POINT CENTER POINT CENTERLINE  CENTERLINE  OF CHIMNEY OF CHIMNEY PLUMB BOB PLUMB BOB PLUMB LINE PLUMB LINE "S" SERIES DOUBLE "S" SERIES DOUBLE WALL CHIMNEY WALL CHIMNEY  14 1/2" x 14 1/2" 14 1/2" x 14 1/2" ...

  • Monessen Hearth BWBC400 - page 57

    17 C HIMNEY O FFSET I NST ALLA TION E LBOW I NST ALLA TION The following are important points that should be observed when installing elbows on the fireplace: 1. The support straps of all elbows not installed directly on top of the fireplace should be nailed securely to the surrounding structure. This allows the support strap to carry the weight of ...

  • Monessen Hearth BWBC400 - page 58

    18   CONTINUE CHIMNEY TO PROPER CONTINUE CHIMNEY TO PROPER HEIGHT AND INSTALL ROUND HEIGHT AND INSTALL ROUND CHIMNEY CAP OR CHIMNEY CHIMNEY CAP OR CHIMNEY HOUSING. HOUSING. FASTEN SUPPORT STRAPS SECURELY FASTEN SUPPORT STRAPS SECURELY ROOF ROOF FLASHING FLASHING STORM COLLAR STORM COLLAR NOTE: TWO ELBOWS NOTE: TWO ELBOWS MAY ...

  • Monessen Hearth BWBC400 - page 59

    19 C HIMNEY C AP I NST ALLA TION M ODEL SC C HIMNEY C AP S PECIAL N OTE : The proper height as previously explained is important to assure proper draft and safety . The chimney cap extends the flue outlet four inches above the top of the last section of chimney . This should be kept in mind when determining the proper height for the chimney . The c ...

  • Monessen Hearth BWBC400 - page 60

    20 1 0 1 1 0 2 1 0 2 1 0 2 1 3 2 1 3 2 1 3 2 4 3 2 4 3 2 4 3 5 4 3 5 4 3 5 4 6 5 4 6 5 4 6 5 7 6 5 7 6 5 7 6 8 36" 1 0 0 1 0 0 2 0 1 2 0 1 3 0 2 3 1 2 0 1 3 0 2 3 1 2 0 1 3 0 2 3 1 2 0 1 3 0 2 3 1 2 0 1 3 0 2 3 1 2 0 1 3 0 2 3 1 2 0 18" 0 1 0 1 0 1 0 1 0 1 0 1 0 1 0 1 0 1 0 1 0 1 0 1 0 1 0 1 0 1 0 1 0 1 0 1 0 1 0 1 0 1 0 1 0 0 0 1 0 1 0 1 ...

  • Monessen Hearth BWBC400 - page 61

    21 C HIMNEY C AP C HASE I NST ALLA TION The preinstalled chimney sections should be no more than 10 inches below the top of the chase. The installation should be planned so that either an 18-inch or 36-inch chimney section will be used for the top section. This is necessary to ensure complete engagement of the inlet air telescope and chimney cap in ...

  • Monessen Hearth BWBC400 - page 62

    22 O UTSIDE C OMBUSTION A IR P RECAUTIONS & R ECOMMENDA TIONS N OTE : The use of outside air for combustion is optional unless required by building codes. It is only necessary to supply outside combustion air to one side of the fireplace. Use the model AK4 combustion air kit. STEP 1: SECURE OUTSIDE AIR STARTING COLLAR TO LEFT SIDE OF STEP 1: ...

  • Monessen Hearth BWBC400 - page 63

    23 O UTSIDE C OMBUSTION A IR P RECAUTIONS & R ECOMMENDA TIONS O UTSIDE C OMBUSTION A IR R ECOMMENDA TIONS ( CONTINUED ) 1. Extremely long runs and numerous turns in the duct leading from the fireplace to the combustion air assembly should be avoided. These conditions will increase the resistance to the free flow of air through the duct. Refer t ...

  • Monessen Hearth BWBC400 - page 64

    24 C OMBUSTION A IR A SSEMBL Y M ODEL AK4 C OMBUSTION A IR A SSEMBL Y 1. Remove the cover plate from the 4-inch outlet opening location on the left or right outside of the fireplace. DO NOT remove the cover if the outside air will not be connected. 2. Place the insulation ring between the AK4 starting collar and fireplace wall and place the startin ...

  • Monessen Hearth BWBC400 - page 65

    25 G AS A PPLIANCE I NST ALLA TION W ARNING : Improper installation or operation of a gas appliance in this fireplace can allow unburned gas to leak out which will cause a fire or explosion hazard, or the release of poisonous carbon monoxide into the dwelling which can cause serious injury or death to its inhabitants. T o reduce these risks to a mi ...

  • Monessen Hearth BWBC400 - page 66

    26 G AS A PPLIANCE I NST ALLA TION 8. Be sure the gas is turned off at the appliance, then turn the gas on at the cut of f valve and test the gas line connections for leaks with soapy water solution or a liquid leak detector . DO NOT USE A MA TCH OR OTHER FLAME SOURCE T O CHECK FOR GAS LEAKS. If a gas leak is detected, turn the gas off immediately ...

  • Monessen Hearth BWBC400 - page 67

    27 FINISHED WALL FINISHED WALL FRAMING FRAMING 1/4" INSTALLATION OF NON-COMBUSTIBLE FACING MATERIALS TO THE FRONT FACE OF THE FIREPL INSTALLATION OF NON-COMBUSTIBLE FACING MATERIALS TO THE FRONT FACE OF THE FIREPL ACE COMBUSTIBLE FRAMING MEMBERS FACING MATERIAL TO TOP OF SPACERS. CAUTION: DO NOT COVER  OR RESTRICT SIDE VENT  ARE ...

  • Monessen Hearth BWBC400 - page 68

    28 G LASS D OOR I NST ALLA TION AND F AN A CCESSOR Y F AN A SSEMBL Y The model BWBC500 and BWBC500I Fireplaces may be equipped with a accessory fan Model F A2. If the fireplace is to be equipped with this accessory at anytime, the JB1 junction box assembly must be installed on the fireplace as shown by Figures 32 and 33 during the installation of t ...

  • Monessen Hearth BWBC400 - page 69

    29 F IREPLACE O PERA TION W ARNING : If a decorative gas appliance is used in the fireplace the fireplace damper must be fixed in an open position. (See additional operation information in section titled “Operation Guidelines”.) A DV ANT AGES OF A W OOD B URNING F IREPLACE These are the practical, ecological advantages of wood as a fuel. Also t ...

  • Monessen Hearth BWBC400 - page 70

    30 F IREPLACE O PERA TION A F EW W ORDS OF C AUTION Beware of burning certain material in your fireplace. Among these are plastics, poison ivy twigs and stems, and chemically treated woods such as discarded poles and railroad ties. These not only create air pollution, but can induce extreme irritation for some individuals. Use hemlock, spruce, juni ...

  • Monessen Hearth BWBC400 - page 71

    31 M AINTENANCE AND S AFETY F UEL S T ORAGE W ood can be dried suf ficiently for burning within a few weeks if protected form rain in a low humidity area. It is far better to cut wood and allow it to dry for a year . In all cases, the wood should be stacked so that both ends of the sticks are exposed to the air and protected from rain. The drier th ...

  • Monessen Hearth BWBC400 - page 72

    32 F IREPLACE M AINTENANCE At the end of each heating season or when the fireplace will not be in use for an extended time, the ashes should be removed and the hearth area should be swept as clean as is practical. The slow absorption of moisture into the ashes over a long period of time could cause a condition which would be corrosive to the metal ...

  • Monessen Hearth BWBC400 - page 73

    33 20. Do build fires of moderate intensity in the fireplace for the first three fires to allow materials to adjust and cure before being subjected to the intense heat of a large fire. DONT’S 1. Don’t allow other installations or operation considerations to take priority over safety considerations. 2. Don’t attempt to use the fireplace until ...

  • Monessen Hearth BWBC400 - page 74

    34 2 1 3 4 5 6 7 8 R EP AIR P ART D IAGRAMS AND L ISTS All repair part orders should be placed through your local dealer . T o ensure prompt and accurate service, please provide the following information when placing a repair part order: Model number of your Appliance, Part Name, Part Number , and Quantity of parts needed. PART NUMBER 077072 031867 ...

  • Monessen Hearth BWBC400 - page 75

    35 8 7 6 5 4 3 2 1 R EP AIR P ART D IAGRAMS AND L ISTS All repair part orders should be placed through your local dealer . T o ensure prompt and accurate service, please provide the following information when placing a repair part order: Model number of your Appliance, Part Name, Part Number , and Quantity of parts needed. PART NAME UPPER GRILLE PN ...

  • Monessen Hearth BWBC400 - page 76

    36 L IMITED W ARRANTY FACTORY-BUILT FIREPLACE AND COMPONENTS ( EXCEPT BLOWERS ) W HAT IS COVERED AND FOR HOW LONG •F IVE -Y EAR C OVERAGE - For five years from the date this fireplace and components are first purchased for use, Monessen Hearth Systems will, at its option, repair or replace any defective part of this fireplace or components, or re ...

  • Monessen Hearth BWBC400 - page 77

    37 Y OUR D UTIES This fireplace must be installed by a qualified installer according to your local building codes and installation instructions and operated according to the owner’s instructions. You must keep an invoice, canceled check or payment record to verify the purchase date of the fireplace. I F Y OU H AVE A PROBLEM W ITH Y OUR F IREPLACE ...

  • Monessen Hearth BWBC400 - page 78

    38 T HIS P AGE INTENTIONALL Y LEFT BLANK . 53D9032. Rev 1 03/03 ...

  • Monessen Hearth BWBC400 - page 79

    39 T HIS P AGE INTENTIONALL Y LEFT BLANK . 53D9032. Rev 1 03/03 ...

  • Monessen Hearth BWBC400 - page 80

    53D9032. R EV 1 03/03 A TTENTION A PPLIANCE I NST ALLER P LEASE R ETURN T HIS O PERA TING AND I NST ALLA TION I NSTRUCTIONS T O T HE C ONSUMER . ...

Производитель Monessen Hearth Категория Fire Pit

Документы, которые мы получаем от производителя устройства Monessen Hearth BWBC400 мы можем разделить на несколько групп. Это в частности:
- технические чертежи Monessen Hearth
- инструкции обслуживания BWBC400
- паспорта изделия Monessen Hearth
- информационные брошюры
- энергетические этикетки Monessen Hearth BWBC400
Все из них важны, однако самую важную информацию с точки зрения пользователя мы найдем в инструкции обслуживания Monessen Hearth BWBC400.

Группа документов, определяемая как инструкции обслуживания, делится также на более подробные типы, такие как: Инструкции монтажа Monessen Hearth BWBC400, инструкции обслуживания, короткие инструкции или инструкции пользователя Monessen Hearth BWBC400. В зависимости от потребностей, Вам необходимо поискать требуемый документ. На нашем сайте Вы можете просмотреть самую популярную инструкцию использования изделия Monessen Hearth BWBC400.

Похожие инструкции обслуживания

Полная инструкция обслуживания устройства Monessen Hearth BWBC400, как должна выглядеть?
Инструкция обслуживания, определяемая также как пособие пользователя, или просто "руководство" - это технический документ, цель которого заключается в использовании Monessen Hearth BWBC400 пользователями. Инструкции пишет, как правило технический писатель, языком, доступным для всех пользователей Monessen Hearth BWBC400.

Полная инструкция обслуживания Monessen Hearth, должна заключать несколько основных элементов. Часть из них менее важная, как например: обложка / титульный лист или авторские страницы. Однако остальная часть, должна дать нам важную с точки зрения пользователя информацию.

1. Вступление и рекомендации, как пользоваться инструкцией Monessen Hearth BWBC400 - В начале каждой инструкции, необходимо найти указания, как пользоваться данным пособием. Здесь должна находится информация, касающаяся местонахождения содержания Monessen Hearth BWBC400, FAQ и самых распространенных проблем - то есть мест, которые чаще всего ищут пользователи в каждой инструкции обслуживания
2. Содержание - индекс всех советов, касающихся Monessen Hearth BWBC400, которое найдем в данном документе
3. Советы по использованию основных функций устройства Monessen Hearth BWBC400 - которые должны облегчить нам первые шаги во время использования Monessen Hearth BWBC400
4. Troubleshooting - систематизированный ряд действия, который поможет нам диагностировать а в дальнейшем очередность решения важнейших проблем Monessen Hearth BWBC400
5. FAQ - чаще всего задаваемые вопросы
6. Контактные данные Информация о том, где искать контактные данные производителя / сервисного центра Monessen Hearth BWBC400 в данной стране, если самостоятельно не получится решить проблему.

У вас вопрос, касающийся Monessen Hearth BWBC400?

Воспользуйтесь формуляром, находящимся ниже

Если с помощью найденной инструкции Вы не решили свою проблему с Monessen Hearth BWBC400, задайте вопрос, заполнив следующий формуляр. Если у какого то из пользователей была похожая проблема с Monessen Hearth BWBC400 со всей вероятностью он захочет поделиться методом ее решения.

Перепишите текст с картинки

Captcha
Новая картинка

Комментарии (0)