Инструкция обслуживания Hearth and Home Technologies LCOR-HVB-CE

44 страниц 3.02 mb
Скачать

Перейти на страницу of 44

Summary
  • Hearth and Home Technologies LCOR-HVB-CE - page 1

    Heat & Glo • PIER/ST/L&RCOR-HVB-CE • 2068-900 Rev . H • 6/07 1 - Do not store or use gasoline or other flam- mable vapors and liquids in the vicinity of this or any other appliance. - What to do if you smell gas • Do not try to light any appliance. • Do not touch any electrical switch. • Do not use any phone in your building. ? ...

  • Hearth and Home Technologies LCOR-HVB-CE - page 2

    Heat & Glo • PIER/ST/L&RCOR-HVB-CE • 2068-900 Rev . H • 6/07 2 These units MUST use one of the flue systems described in the Installing the Fireplace section of the Installers Guide . NO OTHER flue systems or components MA Y BE USED . This gas fireplace and flue assembly MUST flue directly to the outside and MUST NEVER be attached to ...

  • Hearth and Home Technologies LCOR-HVB-CE - page 3

    Heat & Glo • PIER/ST/L&RCOR-HVB-CE • 2068-900 Rev . H • 6/07 3 T able of Content s Safety and W arning Information .................................................. 2 Service Parts List ......................................................................... 4 Section 1: Approvals and Regulations .................................... ...

  • Hearth and Home Technologies LCOR-HVB-CE - page 4

    Heat & Glo • PIER/ST/L&RCOR-HVB-CE • 2068-900 Rev . H • 6/07 4 * Part number list on following page. 5 Log Assembly Service Parts Diagram Service Parts List PIER-HVB-CE Beginning Manufacturing Date: 6-04 Ending Manufacturing Date: ______ 2 1 3 4 8 6 7 9 ...

  • Hearth and Home Technologies LCOR-HVB-CE - page 5

    Heat & Glo • PIER/ST/L&RCOR-HVB-CE • 2068-900 Rev . H • 6/07 5 (NG , LP) Exploded Part s Diagram IMPORT ANT : THIS IS DA TED INFORMA TION. The most current information is located on your dealers VIP site. When ordering, supply serial and model numbers to ensure correct service parts. IT E M CO M M O N P A RT SER IA L # P A RT NUM BER ...

  • Hearth and Home Technologies LCOR-HVB-CE - page 6

    Heat & Glo • PIER/ST/L&RCOR-HVB-CE • 2068-900 Rev . H • 6/07 6 Service Parts Diagram Service Parts ST -HVB-CE Beginning Manufacturing Date: 6-04 Ending Manufacturing Date: ______ * Part number list on following page. 4 Log Assembly 2 3 1 6 5 7 ...

  • Hearth and Home Technologies LCOR-HVB-CE - page 7

    Heat & Glo • PIER/ST/L&RCOR-HVB-CE • 2068-900 Rev . H • 6/07 7 (NG , LP) Exploded Part s Diagram IMPORT ANT : THIS IS DA TED INFORMA TION. The most current information is located on your dealers VIP site. When ordering, supply serial and model numbers to ensure correct service parts. ST -HVB-CE IT E M CO M M O N P A RT SER IA L # P A ...

  • Hearth and Home Technologies LCOR-HVB-CE - page 8

    Heat & Glo • PIER/ST/L&RCOR-HVB-CE • 2068-900 Rev . H • 6/07 8 * Part number list on following page. 5 Log Assembly Service Parts Diagram Service Parts LCOR-HVB-CE Beginning M anufacturing Date: 6-04 Ending Manufacturing Date: ______ 8 2 3 4 6 7 1 9 ...

  • Hearth and Home Technologies LCOR-HVB-CE - page 9

    Heat & Glo • PIER/ST/L&RCOR-HVB-CE • 2068-900 Rev . H • 6/07 9 (NG , LP) Exploded Part s Diagram IMPORT ANT : THIS IS DA TED INFORMA TION. The most current information is located on your dealers VIP site. When ordering, supply serial and model numbers to ensure correct service parts. LCOR-HVB-CE IT E M CO M M O N P A RT SE R IA L # P ...

  • Hearth and Home Technologies LCOR-HVB-CE - page 10

    Heat & Glo • PIER/ST/L&RCOR-HVB-CE • 2068-900 Rev . H • 6/07 10 * Part number list on following page. 5 Log Assembly Service Parts Diagram Service Parts RCOR-HVB-CE Beginning M anufacturing Date: 6-04 Ending Manufacturing Date: ______ 1 3 2 4 6 7 8 11 10 9 12 ...

  • Hearth and Home Technologies LCOR-HVB-CE - page 11

    Heat & Glo • PIER/ST/L&RCOR-HVB-CE • 2068-900 Rev . H • 6/07 11 (NG , LP) Exploded Part s Diagram IMPORT ANT : THIS IS DA TED INFORMA TION. The most current information is located on your dealers VIP site. When ordering, supply serial and model numbers to ensure correct service parts. RCOR-HVB-CE IT E M CO M M O N P A RT SER IA L # P ...

  • Hearth and Home Technologies LCOR-HVB-CE - page 12

    Heat & Glo • PIER/ST/L&RCOR-HVB-CE • 2068-900 Rev . H • 6/07 12 V alve Assembly Service Parts Beginning M anufacturing Date: 6-04 Ending Manufacturing Date: ______ Standing Pilot V alve Assembly IT E M DESCRIP TI O N SERI A L # P A RT NUM BER 1 S hu t Off V a lv e A ssem b ly 302-330A 2 ON / O F F Wire Assem bl y 060-521A 3S I T V a l ...

  • Hearth and Home Technologies LCOR-HVB-CE - page 13

    Heat & Glo • PIER/ST/L&RCOR-HVB-CE • 2068-900 Rev . H • 6/07 13 Appliance Certification The Heat & Glo fireplace models discussed in this Installers Guide have been tested to certification standards and listed by the applicable laboratories. Certification MODELS: PIER-HV B-CE, S T - H V B-CE , LCOR-HV B-CE, RCOR-HV B-CE LABORA TOR ...

  • Hearth and Home Technologies LCOR-HVB-CE - page 14

    Heat & Glo • PIER/ST/L&RCOR-HVB-CE • 2068-900 Rev . H • 6/07 14 Figure 1. Diagram of the PIER-HVB-CE REAR FLUE CO LLAR S EL ECT RI CA L ACCE S S GA S L I NE ACCE S S GA S CO NT RO LS & LABE LS TOP STAN DOFF S TO P FLUE COLL ARS 5-14 (133m m) 12 (306mm) 1/ 2 (13m m) (2) 42- 5/8 (108 2mm ) 42 (1 06 7mm) 17 -15 /16 (456mm) 32- 1/8 (8 ...

  • Hearth and Home Technologies LCOR-HVB-CE - page 15

    Heat & Glo • PIER/ST/L&RCOR-HVB-CE • 2068-900 Rev . H • 6/07 15 Figure 2. Diagram of the ST -HVB-CE RE AR FLUE COL LARS ELECTRIC AL ACCE SS GAS LINE ACCE SS GAS CO NTR OLS & LA BELS TOP ST ANDO FFS TOP F LUE COL LAR S 5-14 (133mm) 12 (306mm) 1/2 (13 mm) (4) 46-5/8 (1 18 3mm) 42 (1 0 67 mm) 32-5 /16 (820m m) 21 (53 3mm ) 36-3/16 (9 ...

  • Hearth and Home Technologies LCOR-HVB-CE - page 16

    Heat & Glo • PIER/ST/L&RCOR-HVB-CE • 2068-900 Rev . H • 6/07 16 Figure 3. Diagram of the LCOR-HVB-CE and RCOR-HVB-CE 5-14 (1 33mm) 12 (3 06mm) 1/ 2 (13 mm) (4 ) 42-5 /8 (1 082mm ) 42 (1 067mm ) 17-1 5/16 (456 mm ) 32-1 /8 (816 mm ) 2-5/ 16 (58 mm) 7-1/ 4 (1 84mm) 10 (2 54mm) 4-3/ 4 (1 21mm) E L ECT RI CAL AC CE S S GAS LIN E AC CE SS ...

  • Hearth and Home Technologies LCOR-HVB-CE - page 17

    Heat & Glo • PIER/ST/L&RCOR-HVB-CE • 2068-900 Rev . H • 6/07 17 3 Inst alling the Fireplace Step 1. Locating the Fireplace The diagram below shows space and clearance require- ments for locating a fireplace within a room. Minimum Clearances from the Fireplace to Combustible Materials Figure 4. Fireplace Dimensions and Locations Cleara ...

  • Hearth and Home Technologies LCOR-HVB-CE - page 18

    Heat & Glo • PIER/ST/L&RCOR-HVB-CE • 2068-900 Rev . H • 6/07 18 Framing should be constructed of 51mm x 102mm (2” x 4”) lumber or heavier . Model A B C D E PIER-HVB-CE 107 (42-1/8) 108 (42-1/2) 58 (23) 91 (35-3/4) 122 (48) ST -HVB-CE 121 (47-5/8) 108 (42-1/2) 58 (23) 91 (35-3/4) 122 (48) L&RCOR-HVB-CE 107 (42-1/8) 108 (42-1/2) ...

  • Hearth and Home Technologies LCOR-HVB-CE - page 19

    Heat & Glo • PIER/ST/L&RCOR-HVB-CE • 2068-900 Rev . H • 6/07 19 NOTE: PIPES OVERLAP 32mm (1-1/4”) A T EACH JOINT . Figure 6. DVP-Series Direct Flue Component Specifications (127mm (5”) inner pipe / 203mm (8”) outer pipe) D V P 9 0 S T 320 mm (12-9/16 in.) 286mm (11- 1/ 4 i n . ) 185mm (7-1/4 i n.) 32mm (1-1/ 4 in.) TYP 18m m (1/ ...

  • Hearth and Home Technologies LCOR-HVB-CE - page 20

    Heat & Glo • PIER/ST/L&RCOR-HVB-CE • 2068-900 Rev . H • 6/07 20 Figure 7. Flue System Component s and T ermination Kits Step 3. Installing the Flue System A. Flue System Approvals These models are approved to use DVP series direct flue pipe components and terminations (see Figures 6 and 7). Approved flue system components are labeled ...

  • Hearth and Home Technologies LCOR-HVB-CE - page 21

    Heat & Glo • PIER/ST/L&RCOR-HVB-CE • 2068-900 Rev . H • 6/07 21 Figure 8 STRAIGHT OUT HORIZONT A L FLUEING H Max. Run 610 mm (24 in.) Figure 9. V CAP H STRAIGHT UP VERTICAL FLUEING V (FT .) 12.2M MAX. (40 FT .) ...

  • Hearth and Home Technologies LCOR-HVB-CE - page 22

    Heat & Glo • PIER/ST/L&RCOR-HVB-CE • 2068-900 Rev . H • 6/07 22 Figure 1 1. Flueing with One 90° Elbow Figure 10. Flueing with One 90° Elbow V H H V NA TURAL GAS - FLUEING WITH ONE 90° ELBOW V (FT . ) H (FT .) 1' MIN. (305mm) 3' MAX. (914mm) 2' MIN. (610mm) 6' MAX. (1.83m) 3' MIN. (914mm) 9' MAX. (2.7m ...

  • Hearth and Home Technologies LCOR-HVB-CE - page 23

    Heat & Glo • PIER/ST/L&RCOR-HVB-CE • 2068-900 Rev . H • 6/07 23 Figure 12. Flueing with T wo 90° Elbows H 1 H V V V 1 H NA TURAL GAS FLUEING WITH TWO 90° ELBOWS V (FT .) H + H 1 (FT .) 1' MIN. (305mm) 3' MAX. (914mm) 2' MIN. (610mm) 6' MAX. (1.83m) 3' MIN. (914mm) 9' MAX. (2.7m) 4' MIN. (1.22m) 12& ...

  • Hearth and Home Technologies LCOR-HVB-CE - page 24

    Heat & Glo • PIER/ST/L&RCOR-HVB-CE • 2068-900 Rev . H • 6/07 24 Figure 13. Flueing with T wo 90° Elbows Figure 14. Flueing with T wo 90° Elbows H 1 V H V H H 1 NA TURAL GAS FLUEING WITH TWO 90° ELBOWS V (FT .) H + H 1 (FT .) 1' MIN. (305mm) 3' MAX. (914mm) 2' MIN. (610mm) 6' MAX. (1.83m) 3' MIN. (914mm) 9&a ...

  • Hearth and Home Technologies LCOR-HVB-CE - page 25

    Heat & Glo • PIER/ST/L&RCOR-HVB-CE • 2068-900 Rev . H • 6/07 25 Figure 15. Flueing with three 90° elbows H H 1 H 2 V H V H 1 V 1 NA TURAL GAS FLUEING WITH THREE 90° ELBOWS V + V 1 (FT .) H + H 1 + H 2 (FT . ) 1' MIN. (305mm) 3' MAX. (914mm) 2' MIN. (610mm) 6' MAX. (1.83m) 3' MIN. (914mm) 9' MAX. (2.7m) ...

  • Hearth and Home Technologies LCOR-HVB-CE - page 26

    Heat & Glo • PIER/ST/L&RCOR-HVB-CE • 2068-900 Rev . H • 6/07 26 Figure 16. Flueing with three 90° elbows V H H 1 V 1 V H H 1 V 1 NA TURAL GAS FLUEING WITH THREE 90° ELBOWS V + V 1 (FT .) H + H 1 (FT .) 1' MIN. (305mm) 3' MAX. (914mm) 2' MIN. (610mm) 6' MAX. (1.83m) 3' MIN. (914mm) 9' MAX. (2.7m) 4' ...

  • Hearth and Home Technologies LCOR-HVB-CE - page 27

    Heat & Glo • PIER/ST/L&RCOR-HVB-CE • 2068-900 Rev . H • 6/07 27 1. Attach the First Flue Component to the Starting Collars T o attach the first flue component to the starting collars of the fireplace: • Slide the first flue section onto the unit and push in until they snap lock in position. • Rotate this section to the desired pos ...

  • Hearth and Home Technologies LCOR-HVB-CE - page 28

    Heat & Glo • PIER/ST/L&RCOR-HVB-CE • 2068-900 Rev . H • 6/07 28 4. Install Firestops For Horizontal Runs - Firestops are REQUIRED on both sides of a combustible wall through which the flue passes. NOTE: Model DVP-TRAP does not need an exterior firestop on an exterior combustible wall. The firestop is built into the cap. T o install fi ...

  • Hearth and Home Technologies LCOR-HVB-CE - page 29

    Heat & Glo • PIER/ST/L&RCOR-HVB-CE • 2068-900 Rev . H • 6/07 29 Figure 22. Ceiling Firestop (Ceiling Side) If the area above the ceiling is NOT an attic, position and secure the ceiling firestop on the ceiling side of the previously cut and framed hole. If the area above the ceiling IS an attic, position and secure the firestop on top ...

  • Hearth and Home Technologies LCOR-HVB-CE - page 30

    Heat & Glo • PIER/ST/L&RCOR-HVB-CE • 2068-900 Rev . H • 6/07 30 For V ertical T erminations - T o locate the flue and install the flue sections: • Locate and mark the flue centerpoint on the underside of the roof, and drive a nail through the centerpoint. • Make the outline of the roof hole around the centerpoint nail. • The siz ...

  • Hearth and Home Technologies LCOR-HVB-CE - page 31

    Heat & Glo • PIER/ST/L&RCOR-HVB-CE • 2068-900 Rev . H • 6/07 31 V = VENT TERMINAL X = AIR SUPPL Y INLET = AREA WHERE TERMINAL IS NOT PERMITTED Figure 26 V ent T ermination Minimum Clearances L = 2.1 M ...................... clearance above paved side- walk or a paved driveway lo- cated on public property M * = 50.8 cm ................ ...

  • Hearth and Home Technologies LCOR-HVB-CE - page 32

    Heat & Glo • PIER/ST/L&RCOR-HVB-CE • 2068-900 Rev . H • 6/07 32 Step 4. Positioning, Leveling, and Securing the Fireplace • Place the fireplace into position. • Level the fireplace from side to side and from front to back. • Shim the fireplace with non-combustible material, such as sheet met al, as necessary . • Secure the fir ...

  • Hearth and Home Technologies LCOR-HVB-CE - page 33

    Heat & Glo • PIER/ST/L&RCOR-HVB-CE • 2068-900 Rev . H • 6/07 33 • Insert insulation from the outside of the fireplace and pack the insulation tightly to totally seal between the pipe and the outer casing. • At the gas line access hole the gap between the supply piping and gas access hole can be plugged with non- combustible insula ...

  • Hearth and Home Technologies LCOR-HVB-CE - page 34

    Heat & Glo • PIER/ST/L&RCOR-HVB-CE • 2068-900 Rev . H • 6/07 34 Step 9. Finishing Figure 30 shows the minimum vertical and corresponding maximum horizontal dimensions of fireplace mantels or other combustible projections above the top front edge of the fireplace. See Figures 4 and 5 for other fireplace clearances. Only non-combustible ...

  • Hearth and Home Technologies LCOR-HVB-CE - page 35

    Heat & Glo • PIER/ST/L&RCOR-HVB-CE • 2068-900 Rev . H • 6/07 35 Inst alling the T rim Combustible materials may be brought up to the specified clearances on the side and top front edges of the fireplace, but MUST NEVER overlap onto the front face. The joints between the finished wall and the fireplace top and sides can only be sealed ...

  • Hearth and Home Technologies LCOR-HVB-CE - page 36

    Heat & Glo • PIER/ST/L&RCOR-HVB-CE • 2068-900 Rev . H • 6/07 36 LOG #1 (SRV2068-700): Place log #1 behind grate tabs on the second and third grate bars on the left rear corner . Position so that the bottom grooves fit over bars and the log is snug against the grate t abs. LOG #2 (SRV2068-701): Locate log #2 in left front corner of the ...

  • Hearth and Home Technologies LCOR-HVB-CE - page 37

    Heat & Glo • PIER/ST/L&RCOR-HVB-CE • 2068-900 Rev . H • 6/07 37 LOG #4 (SRV2068-703): Place log #4 in the right rear corner of the log grate using bottom grooves for placement. Align log #4 by using the grate corner and rear cross bar as stops. LOG #5 (SRV2068-703): Place log #5 on top of flat spot on log #1 and against the inside of ...

  • Hearth and Home Technologies LCOR-HVB-CE - page 38

    Heat & Glo • PIER/ST/L&RCOR-HVB-CE • 2068-900 Rev . H • 6/07 38 CAUTION: Logs are fragile. Carefully remove the logs from the packaging. Logs #4 and #5 are the same log. See Service Parts pages for individual assembly photos. Only for Model: LCOR-HVB-CE 1 2 3 4 5 6 T ABS LOG #1 (SRV2068-700): Place log #1 in front of grate tabs on the ...

  • Hearth and Home Technologies LCOR-HVB-CE - page 39

    Heat & Glo • PIER/ST/L&RCOR-HVB-CE • 2068-900 Rev . H • 6/07 39 LOG #3 (SRV2068-702): Position log #3 across the first, second and third grate bars and pull towards the front against the grate tabs on bars one and three. 3 LOG #4 (SRV2068-703): Place log #4 in the left front corner of the log grate using bottom grooves for placement. ...

  • Hearth and Home Technologies LCOR-HVB-CE - page 40

    Heat & Glo • PIER/ST/L&RCOR-HVB-CE • 2068-900 Rev . H • 6/07 40 LOG #6 (SRV582-705): Position log #6 on top of the groove in log #3 with the forked end resting on the grate assembly as shown. 6 ...

  • Hearth and Home Technologies LCOR-HVB-CE - page 41

    Heat & Glo • PIER/ST/L&RCOR-HVB-CE • 2068-900 Rev . H • 6/07 41 Placing the Ember Material Ember material is shipped with this gas fireplace. T o place the ember material: S tep 1 1. Before Lighting the Fireplace Before lighting the fireplace, be sure to do the following: ! Step 12. Lighting the Fireplace Y ou’ve reviewed all safety ...

  • Hearth and Home Technologies LCOR-HVB-CE - page 42

    Heat & Glo • PIER/ST/L&RCOR-HVB-CE • 2068-900 Rev . H • 6/07 42 4 Maint aining and Servicing Y our Fireplace Fireplace Maintenance Although the frequency of your appliance servicing and main- tenance will depend on use and the type of installation, you should have a qualified service technician perform an appli- ance check-up at the b ...

  • Hearth and Home Technologies LCOR-HVB-CE - page 43

    Heat & Glo • PIER/ST/L&RCOR-HVB-CE • 2068-900 Rev . H • 6/07 43 5 T roubleshooting With proper installation, operation, and maintenance the gas fireplace will provide years of trouble-free service. If you do experience a problem, this trouble shooting guide will assist a qualified service person in the diagnosis of a problem and the c ...

  • Hearth and Home Technologies LCOR-HVB-CE - page 44

    Heat & Glo • PIER/ST/L&RCOR-HVB-CE • 2068-900 Rev . H • 6/07 44 Sym pt om Po ssi b l e C ause Correct ive A cti on 4. Fr equ en t pil ot ou tage pr oblem . a. P i lot fl ame m ay be t oo h i gh or t oo low , or bl owin g (h igh ), cau sin g pi lot safet y t o drop ou t. Clean an d adj u st t h e pi lot f lame f or max i mu m f l ame i ...

Производитель Hearth and Home Technologies Категория Indoor Fireplace

Документы, которые мы получаем от производителя устройства Hearth and Home Technologies LCOR-HVB-CE мы можем разделить на несколько групп. Это в частности:
- технические чертежи Hearth and Home Technologies
- инструкции обслуживания LCOR-HVB-CE
- паспорта изделия Hearth and Home Technologies
- информационные брошюры
- энергетические этикетки Hearth and Home Technologies LCOR-HVB-CE
Все из них важны, однако самую важную информацию с точки зрения пользователя мы найдем в инструкции обслуживания Hearth and Home Technologies LCOR-HVB-CE.

Группа документов, определяемая как инструкции обслуживания, делится также на более подробные типы, такие как: Инструкции монтажа Hearth and Home Technologies LCOR-HVB-CE, инструкции обслуживания, короткие инструкции или инструкции пользователя Hearth and Home Technologies LCOR-HVB-CE. В зависимости от потребностей, Вам необходимо поискать требуемый документ. На нашем сайте Вы можете просмотреть самую популярную инструкцию использования изделия Hearth and Home Technologies LCOR-HVB-CE.

Похожие инструкции обслуживания

Полная инструкция обслуживания устройства Hearth and Home Technologies LCOR-HVB-CE, как должна выглядеть?
Инструкция обслуживания, определяемая также как пособие пользователя, или просто "руководство" - это технический документ, цель которого заключается в использовании Hearth and Home Technologies LCOR-HVB-CE пользователями. Инструкции пишет, как правило технический писатель, языком, доступным для всех пользователей Hearth and Home Technologies LCOR-HVB-CE.

Полная инструкция обслуживания Hearth and Home Technologies, должна заключать несколько основных элементов. Часть из них менее важная, как например: обложка / титульный лист или авторские страницы. Однако остальная часть, должна дать нам важную с точки зрения пользователя информацию.

1. Вступление и рекомендации, как пользоваться инструкцией Hearth and Home Technologies LCOR-HVB-CE - В начале каждой инструкции, необходимо найти указания, как пользоваться данным пособием. Здесь должна находится информация, касающаяся местонахождения содержания Hearth and Home Technologies LCOR-HVB-CE, FAQ и самых распространенных проблем - то есть мест, которые чаще всего ищут пользователи в каждой инструкции обслуживания
2. Содержание - индекс всех советов, касающихся Hearth and Home Technologies LCOR-HVB-CE, которое найдем в данном документе
3. Советы по использованию основных функций устройства Hearth and Home Technologies LCOR-HVB-CE - которые должны облегчить нам первые шаги во время использования Hearth and Home Technologies LCOR-HVB-CE
4. Troubleshooting - систематизированный ряд действия, который поможет нам диагностировать а в дальнейшем очередность решения важнейших проблем Hearth and Home Technologies LCOR-HVB-CE
5. FAQ - чаще всего задаваемые вопросы
6. Контактные данные Информация о том, где искать контактные данные производителя / сервисного центра Hearth and Home Technologies LCOR-HVB-CE в данной стране, если самостоятельно не получится решить проблему.

У вас вопрос, касающийся Hearth and Home Technologies LCOR-HVB-CE?

Воспользуйтесь формуляром, находящимся ниже

Если с помощью найденной инструкции Вы не решили свою проблему с Hearth and Home Technologies LCOR-HVB-CE, задайте вопрос, заполнив следующий формуляр. Если у какого то из пользователей была похожая проблема с Hearth and Home Technologies LCOR-HVB-CE со всей вероятностью он захочет поделиться методом ее решения.

Перепишите текст с картинки

Комментарии (0)